warning DODGE DURANGO 2005 2.G Owners Manual

WARNING!
The warning words “DO NOT OPEN HOT” on the
coolant pressure cap are a safety precaution. Heat
causes pressure to build up in the cooling system. To
prevent scalding or injury, do not remove the pres-
sure cap when the system is hot or under pressure.
Coolant Level
The coolant bottle system provides a quick visual method
for determining that the coolant level is adequate. With
the engine idling, and warmed to normal operating
temperature, remove the cap from the bottle, remove the
dipstick and wipe the excess coolant from it. Reinsert the
dipstick and remove. Observe the dipstick checking the
holes along the stem for coolant. Check the coolant level
whenever the hood is raised.The radiator normally remains completely full, so there is
no need to remove the pressure cap except checking
coolant freeze point or replacement with new antifreeze
coolant. Your service attendant should be advised of this.
When additional coolant is needed to maintain the
proper level, it should be added to the coolant bottle. Do
not overfill.
Points To Remember
A. Do not overfill the coolant bottle.
B. Check coolant freeze point in the radiator and in the
coolant bottle. If antifreeze needs to be added, contents of
coolant bottle also must be protected against freezing.
C. If frequent coolant additions are required, or if the
level in the coolant bottle does not drop when the engine
cools, the cooling system should be pressure tested for
leaks.
328 MAINTAINING YOUR VEHICLE

Brake Master Cylinders
The fluid level in the master cylinders should be checked
whenever the vehicle is serviced, or immediately if the
brake system warning light is on. If necessary, add fluid
to bring level to the full mark on the side of the reservoir
of the brake master cylinder. Be sure to clean the top of
the master cylinder area before removing the cap. With
disc brakes, fluid level can be expected to fall as the brake
pads wear. Brake fluid level should be checked when
pads are replaced. If the brake fluid level is abnormally
low, check system for leaks.
Refer to Recommended Fluids, Lubricants and Genuine
Parts for correct fluid type.WARNING!
Use of brake fluid that may have a lower initial
boiling point, or is unidentified, as to specifications
may result in sudden brake failure during hard
prolonged braking. You could have an accident.
WARNING!
Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts and the
brake fluid catching on fire.
Use only brake fluid that has been in a tightly closed
container to avoid contamination from foreign matter or
moisture.
MAINTAINING YOUR VEHICLE 331
7

CAUTION!
Do not allow a petroleum-base fluid to contaminate
the brake fluid. Seal damage may result.
Brake Hoses
Inspection should be performed whenever the brake
system is serviced or at intervals specified. Inspect hy-
draulic brake hoses for surface cracking, scuffing or worn
spots. If there is any evidence of cracking, scuffing, or
worn spots, the hose should be replaced immediately!
Eventual deterioration of the hose can take place with
possible burst failure.
WARNING!
Worn brake hoses can burst and cause brake failure.
You could have an accident. If you see any sign of
cracking, scuffing, or worn spots, have the brake
hoses replaced immediately.
Automatic Transmission
Fluid Level Check
Check the fluid level while the transmission is at normal
operating temperature 180°F (82°C). This occurs after at
least 15 miles (24 km) of driving. At normal operating
temperature the fluid cannot be held comfortably be-
tween the fingertips.
To check the automatic transmission fluid level properly,
the following procedure must be used:
332 MAINTAINING YOUR VEHICLE

•If you carry special cargo such as chemicals, fertilizers,
de-icer salt, etc., be sure that such materials are well
packaged and sealed.
•If a lot of driving is done on gravel roads, consider
mud or stone shields behind each wheel.
•Use Mopartouch up paint on scratches as soon as
possible. Your dealer has touch up paint to match the
color of your vehicle.
Interior Care
Use MoparFabric Cleaner to clean fabric upholstery
and carpeting.
Use MoparVinyl Cleaner to clean vinyl upholstery and
trim.
MoparTotal Clean is specifically recommended for
leather upholstery.Your leather upholstery can be best preserved by regular
cleaning with a damp soft cloth. Small particles of dirt
can act as an abrasive and damage the leather upholstery
and should be removed promptly with a damp cloth.
Stubborn soils can be removed easily with a soft cloth
and MoparTotal Clean. Care should be taken to avoid
soaking your leather upholstery with any liquid. Please
do not use polishes, oils, cleaning fluids, solvents, deter-
gents, or ammonia based cleaners to clean your leather
upholstery. Application of a leather conditioner is not
required to maintain the original condition.
WARNING!
Do not use volatile solvents for cleaning purposes.
Many are potentially flammable, and if used in
closed areas they may cause respiratory harm.
MAINTAINING YOUR VEHICLE 339
7

WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
VEHICLE STORAGE
If you are storing your vehicle for more than 21 days, we
recommend that you take the following steps to mini-
mize the drain on your vehicle’s battery:
•Disconnect the Ignition-Off Draw fuse (I.O.D.) fuse
located in the Power Distribution Center (PDC). The
I.O.D. cavity includes a snap-in retainer that allows the
fuse to be disconnected, without removing it from the
fuse block.
•The transfer case should be placed in the 4HI mode
and kept in this position to minimize the battery drain.
•As an alternative to the above steps you may discon-
nect the negative cable from the battery.
SCHEDULE “A” 381
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

ABS (Anti-Lock Brake) System............167,236
Adding Fuel........................262,286
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 316
Air Conditioner Maintenance............198,319
Air Conditioning........................ 197
Air Conditioning, Operating Tips............ 209
Air Conditioning, Rear Zone................ 201
Air Conditioning Refrigerant.............319,320
Air Conditioning System................197,319
Air Filter.............................. 316
Air Pressure, Tires....................249,257
Airbag.............................38,171
Airbag Light............................ 51
Alarm..............................24,167
Alarm, Panic............................ 21
Alignment and Balance................... 256
Alterations/Modifications, Vehicle............. 6
Antenna, Satellite Radio................... 194
Antifreeze (Engine Coolant)...........326,327,357Anti-Lock Brake System (ABS).............. 236
Anti-Lock Warning Light.................. 167
Anti-Theft System.....................24,167
Appearance Care........................ 337
Arming Theft System...................... 25
Auto Unlock, Doors....................... 16
Automatic Dimming Mirror...............74,78
Automatic Door Locks..................... 15
Automatic Headlights.................... 122
Automatic Transaxle...................... 221
Automatic Transmission.............218,221,332
Adding Fluid......................... 333
Fluid and Filter Changes................. 334
Fluid Level Check...................... 332
Fluid Type........................334,360
Gear Ranges.......................... 221
Special Additives...................... 334
Torque Converter...................... 225
Axle Fluid............................. 360
394 INDEX

Axle Lubrication........................ 335
Ball Joints............................. 321
Battery............................... 318
Charging............................ 296
Emergency Starting..................... 296
Gas Caution.......................... 296
Keyless Transmitter Replacement............ 24
Saving Feature (Protection)............... 121
Belts, Drive............................ 315
Belts, Seat.............................. 29
Body Mechanism Lubrication............... 321
B-Pillar Location........................ 244
Brake Fluid............................ 360
Brake System........................236,330
Anti-Lock........................... 236
Disc Brakes.......................... 330
Fluid Check.......................... 331
Hoses.............................. 332Master Cylinder....................... 331
Parking............................. 234
Warning Light.....................167,169
Brakes............................... 236
Brake/Transmission Interlock............... 221
Break-In Recommendations, New Vehicle........ 64
Bulb Replacement....................... 349
Bulbs, Light............................ 348
Calibration, Compass..................... 140
Capacities, Fluid........................ 357
Caps, Filler
Fuel.............................262,263
Oil (Engine).......................... 313
Power Steering........................ 320
Radiator (Coolant Pressure)............... 324
Car Washes............................ 337
Carbon Monoxide Warning............65,144,266
Cargo Management System................. 156
INDEX 395
10

Towing............................. 299
Emission Control System Maintenance......... 362
Emission Related Components.............. 329
Engine
Air Cleaner.......................... 316
Block Heater......................... 220
Break-In Recommendations................ 64
Compartment......................305,306
Coolant (Antifreeze).................326,359
Cooling............................. 324
Exhaust Gas Caution..................65,266
Fails to Start.......................... 219
Flooded, Starting...................... 219
Fuel Requirements..................... 357
Jump Starting......................... 296
Oil ........................... 311,357,359
Oil Filler Cap......................... 313
Oil Selection.......................... 357
Oil Synthetic......................... 314Overheating.......................... 327
Starting............................. 218
Temperature Gauge..................... 164
Entry System, Illuminated.................. 13
Equipment Identification Plate.............. 284
Ethylene Glycol Antifreeze................. 326
Event Data Recorder...................... 52
Exhaust Gas Caution................65,266,324
Exhaust System.......................65,323
Extender, Seat Belt........................ 37
Exterior Lighting........................ 123
Filters
Air Cleaner.......................... 316
Engine Fuel.......................... 316
Engine Oil........................314,359
Engine Oil Disposal.................... 314
Flashers
Hazard Warning....................... 286
398 INDEX

Odometer........................... 168
Speedometer......................... 166
Tachometer.......................... 167
Gear Ranges........................... 221
Glass Cleaning.......................... 340
Grease............................... 336
Gross Axle Weight Rating.................. 269
Gross Cargo Weight...................... 268
GVWR............................268,271
Hands-Free Phone........................ 78
Hazard Warning Flasher................... 286
Headlights............................ 349
Delay.............................. 122
High Beam........................... 126
High Beam/Low Beam Select Switch........ 126
Lights On Reminder.................... 124
Passing............................. 125
Replacing............................ 349Heated Mirrors.......................... 77
Heated Seats........................... 105
Heater............................... 197
Heater, Engine Block..................... 220
High Beam Indicator..................... 165
High Beam/Low Beam Select (Dimmer) Switch . . 126
Hitches
Trailer Towing........................ 275
Homelink Transmitter.................... 142
Hood Release.......................... 118
Hoses................................ 329
Ignition............................... 12
Key ................................. 9
Lock................................ 12
Illuminated Entry........................ 13
Infant Restraint........................54,55
Inflation Pressure Tires.................... 257
Inside Rearview Mirror.................... 74
400 INDEX

Instrument Cluster....................... 164
Instrument Panel and Controls.............. 162
Instrument Panel Lens Cleaning............. 340
Integrated Power Module.................. 347
Interior Appearance Care.................. 339
Interior Fuses.......................... 342
Interior Lighting........................ 121
Interior Lights.......................... 121
Intermittent Wipers...................... 126
Introduction............................. 4
Jack Operation.......................288,291
Jacking Instructions...................... 292
Key, Replacement........................ 10
Key, Sentry.............................. 9
Key-In Reminder......................... 9
Keyless Entry System...................... 19
Keys.................................. 9Knee Bolster............................ 38
Lane Change and Turn Signals.........125,164,350
Lap/Shoulder Belts.....................29,34
LATCH (Lower Anchors and Tether for CHildren) . 57
Liftgate................................ 26
Lights..............................66,120
Airbag............................51,171
Anti-Lock Warning..................... 167
Automatic Headlights................... 122
Back-Up............................. 350
Brake Warning........................ 169
Bulb Replacement...................348,349
Center Mounted Stop................... 355
Courtesy/Reading..................... 136
Cruise.............................. 171
Daytime Running...................... 123
Door Ajar........................... 169
Fog ..........................124,165,356
INDEX 401
10