steering DODGE DURANGO 2008 2.G Owner's Guide

WARNING!
Improper towing can lead to an injury accident.
Follow these guidelines to make your trailer towing
as safe as possible:
Make certain that the load is secured in the trailer
and will not shift during travel. When trailering
cargo that is not fully secured, dynamic load shifts
can occur that may be difficult for the driver to
control. You could lose control of your vehicle and
have an accident.
²When hauling cargo or towing a trailer, do not over-
load your vehicle or trailer. Overloading can cause a
loss of control, poor performance or damage to brakes,
axle, engine, transmission, steering, suspension, chas-
sis structure or tires.
²Safety chains must always be used between your
vehicle and trailer. Always connect the chains to the
frame or hook retainers of the vehicle hitch. Cross the
chains under the trailer tongue and allow enough
slack for turning corners.
²Vehicles with trailers should not be parked on a grade.
When parking, apply the parking brake on the tow
vehicle. Put the tow vehicle automatic transmission in
P for Park. With a manual transmission, shift the
transmission into reverse. And with four-wheel-drive
vehicles, make sure the transfer case is not in neutral.
Always, block or9chock9the trailer wheels.
²GCWR must not be exceeded.
²Total weight must be distributed between the tow
vehicle and the trailer such that the following four
ratings are not exceeded:
1. GVWR
354 STARTING AND OPERATING

HAZARD WARNING FLASHER
The flasher switch is on the top of the steering column,
just behind the steering wheel. Press the flasher switch
and all front and rear directional signals will flash
intermittently.
Press the switch a second time to turn off the emergency
flashers.This is an emergency warning system and should not be
used when the vehicle is in motion. Use it when your
vehicle is disabled and is creating a safety hazard for
other motorists.
If it is necessary to leave the vehicle to go for service, the
flasher system will continue to operate with the ignition
key removed and the vehicle locked.
366 WHAT TO DO IN EMERGENCIES

NPower Steering Ð Fluid Check............399
NAir Conditioner Maintenance.............399
NFront Suspension Ball Joints..............400
NDrive Shaft Constant Velocity Joints........401
NBody Lubrication.....................401
NWindshield Wiper Blades................401
NWindshield And Rear Window Washers.....402
NExhaust System......................402
NCooling System.......................403
NEmission Related Components............409
NBrake System........................410
NAutomatic Transmission................411
NTransfer Case........................414NAxles..............................414
NAppearance Care And Protection From
Corrosion...........................415
mFuse Block............................420
NFuses (Interior).......................421
NFuses (Power Distribution Center).........424
NFuses (Integrated Power Module)..........427
mVehicle Storage........................429
mReplacement Light Bulbs.................430
mBulb Replacement......................430
NHeadlights/Parking/Turn Signal..........430
NRear Side Marker, Tail Lights, Turn Signals
And Backup Lights Ð Replacement........432
NLicense Lights........................436
382 MAINTAINING YOUR VEHICLE

Power Steering Ð Fluid Check
Checking the power steering fluid level at a defined
service interval is not required. The fluid should only be
checked if a leak is suspected, abnormal noises are
apparent, and/or the system is not functioning as antici-
pated. Coordinate inspection efforts through a certified
DaimlerChrysler Dealership.9
WARNING!
Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to insure accurate fluid level reading. Do
not overfill. Use only manufacturers recommended
power steering fluid.If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to Fluids, Lubricants, and Genuine Parts
for correct fluid type.
Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an Authorized Dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time.
MAINTAINING YOUR VEHICLE 399
7

Emission Related Components
Fuel System Hoses And Vapor/Vacuum Harnesses
When the vehicle is serviced for scheduled maintenance,
inspect surface of hoses and nylon tubing for evidence of
heat and mechanical damage. Hard and brittle rubber,
cracking, checking, tears, cuts, abrasions, and excessive
swelling suggest deterioration of the rubber. Particular
attention should be given to examining hose surfaces
nearest to high heat sources, such as the exhaust mani-
fold.
Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose clamps and couplings to make sure they
are secure and no leaks are present.
NOTE:Fluids such as oil, power steering fluid, and
brake fluid are used during assembly plant operations to
ease the assembly of hoses to couplings. Therefore, oil
wetness at the hose-coupling area is not necessarily anindication of leakage. Actual dripping of hot fluid when
systems are under pressure (during vehicle operation),
should be noted before hose is replaced based on leakage.
You are urged to use only the manufacturer's specified
hoses and clamps, or their equivalent in material and
specification, in any fuel system servicing. It is manda-
tory to replace all clamps that have been loosened or
removed during service. Care should be taken in install-
ing new clamps to insure they are properly torqued.
Positive Crankcase Ventilation (PCV) Valve
Proper operation of the crankcase ventilation system
requires that the PCV valve be free of sticking or plug-
ging because of deposits. Deposits can accumulate in the
PCV valve and passage with increasing mileage. Have
the PCV valve, hoses, and passages checked for proper
operation at the intervals specified. If the valve is
plugged or sticking, replace with a new valve ±Do not
MAINTAINING YOUR VEHICLE 409
7

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission MopartATF+4, Automatic Transmission Fluid.
Transfer Case MopartATF+4, Automatic Transmission Fluid.
Front Axle SAE 75W-90 Multipurpose Type, GL-5 Gear Lubricant or equivalent.
Rear Axle SAE 75W-140 Synthetic Gear Lubricant or equivalent.
Brake Master Cylinder MopartDOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir MopartATF+4, Automatic Transmission Fluid.
MAINTAINING YOUR VEHICLE 441
7

Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
²Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
²Check all lights and other electrical items for correct
operation.
At Each Oil Change
²Change the engine oil filter.
²Inspect the brake hoses and lines.
²Check the Manual Transmission fluid level.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
NOTE:** Vehicles built with the 4.7L engine are
equipped with sixteen spark plugs, one set is located on
the top of the engine under the coils and the second set is
located on the side of the engine.
The spark plugs located under the coils are a standard
plug and must be change every 30,000 miles (50 000 km)
The spark plugs located on the side of the engine are a
premium plug and must be changed every 102,000 miles
(170 000 km).
446 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Oil (Engine).......................... 393
Power Steering........................ 399
Radiator (Coolant Pressure)............... 406
Car Washes............................ 416
Carbon Monoxide Warning...............75,336
Cargo Management System................. 185
Cargo Organizer....................... 185
Cargo Organizer........................ 185
Cargo (Vehicle Loading)................... 343
Catalytic Converter...................... 396
CD (Compact Disc) Player...............206,236
Cellular Phone..................87,236,237,251
Center High Mounted Stop Light............ 437
Certification Label....................... 343
Charging.............................. 375
Chart, Tire Sizing........................ 306
Child Restraint........................64,65
Child Restraint Tether Anchors.............68,73
Child Seat.............................. 70Circuit Breakers......................... 420
Cleaning
Wheels............................. 417
Climate Control......................... 251
Climate Control, Rear Zone..............255,261
Clock.....................204,207,210,222,237
Compact Disc (CD) Maintenance............. 250
Compact Spare Tire...................... 317
Compass Calibration..................... 166
Compass Variance....................... 167
Connector
UCI ................................ 240
Universal Consumer Interface (UCI)......... 240
Console, Floor.......................181,182
Console, Overhead....................158,159
Contract, Service........................ 454
Coolant Pressure Cap
(Radiator Cap).................384,385,386,406
Cooling System......................... 403
464 INDEX

Adding Coolant (Antifreeze).............. 405
Coolant Capacity...................... 439
Coolant Level......................403,407
Disposal of Used Coolant................ 407
Drain, Flush, and Refill.................. 404
Inspection........................... 407
Points to Remember.................... 407
Pressure Cap......................... 406
Radiator Cap......................... 406
Selection of Coolant (Antifreeze)......404,439,440
Temperature Gauge..................... 193
Cruise Control (Speed Control).............. 149
Cup Holder............................ 181
Customer Assistance..................... 452
Data Recorder, Event...................... 62
Daytime Running Lights................... 141
Dealer Service.......................... 390
Defroster, Rear Window................... 267Defroster, Windshield.............76,254,259,260
Delay (Intermittent) Wipers................. 144
Diagnostic System, Onboard................ 387
Digital Video Disc (DVD) Player..........206,236
Dimmer Switch, Headlight................. 194
Dipsticks
Automatic Transmission................. 411
Oil (Engine).......................... 391
Power Steering........................ 399
Disarming, Theft System................... 19
Disc Brakes............................ 410
Disposal
Antifreeze (Engine Coolant)............... 407
Door Locks............................. 28
Door Locks, Automatic.................... 162
Door Opener, Garage..................... 168
Drive Belts............................ 394
Drive Shaft Universal Joints................ 401
INDEX 465
10

Engine Oil........................... 391
Power Steering........................ 399
Transfer Case......................... 414
Fluids, Lubricants and Genuine Parts.......... 440
Fog Lights..........................141,438
Folding Rear Seat.....................123,126
Four Wheel Drive....................... 281
Operation........................... 281
Four-Way Hazard Flasher.................. 366
Freeing A Stuck Vehicle................... 377
Front Axle (Differential)................... 415
Fuel................................. 332
Filler Cap (Gas Cap).................336,338
Filter............................... 396
Gauge.............................. 193
Octane Rating......................332,440
Requirements......................332,439
Tank Capacity........................ 439
Fuel, Flexible.............See Flexible Fuel VehiclesFuel System Caution..................... 338
Fuses.....................180,420,421,424,427
Garage Door Opener (HomeLinkt) ........... 168
Gas Cap (Fuel Filler Cap)............336,338,388
Gas Gauge (Fuel Gauge)................... 193
Gasoline (Fuel)......................... 332
Gasoline, Reformulated................... 333
Gauges
Coolant Temperature.................... 193
Fuel................................ 193
Odometer.........................196,198
Speedometer......................... 195
Tachometer.......................... 196
Gear Ranges........................... 276
General Information.................16,114,332
Glass Cleaning.......................... 419
Gross Axle Weight Rating...............344,347
Gross Cargo Weight...................... 343
468 INDEX