coolant level DODGE GRAND CARAVAN 2009 5.G Owners Manual

INSTRUMENT CLUSTER DESCRIPTIONS1. Fuel Gauge
The pointer shows the level of fuel in the fuel tank when
the ignition switch is in the ON position.
2. Fuel Door Reminder
The arrow in this symbol is a reminder that the
Fuel Filler Door is located on the left side of the
vehicle.
3. Temperature Gauge
The temperature gauge shows engine coolant tempera-
ture. Any reading within the normal range indicates that
the engine cooling system is operating satisfactorily. The gauge pointer will likely indicate a higher tempera-
ture when driving in hot weather, up mountain grades,
or when towing a trailer. It should not be allowed to
exceed the upper limits of the normal operating range. CAUTION!
Driving with a hot engine cooling system could
damage your vehicle. If temperature gauge reads
“H“, pull over and stop the vehicle. Idle the vehicle
with the air conditioner turned off until the pointer
drops back into the normal range. If the pointer
remains on the “H”, and you hear continuous chimes,
turn the engine off immediately, and call an autho-
rized dealer for service.240 UNDERSTANDING YOUR INSTRUMENT PANEL

When rear controls are locked by the front system, the
LOCK symbol on the temperature knob is illuminated
and any rear overhead adjustments are ignored.
Rear Mode Control
Auto Mode
The rear system automatically maintains the correct
mode and comfort level desired by the rear seat occu-
pants.
Headliner ModeAir comes from the outlets in the headliner. Each of
these outlets can be individually adjusted to direct
the flow of air. Moving the air vanes of the outlets to one
side will shut off the airflow.
Bi-Level Mode Air comes from both the headliner outlets and the
floor outlets. NOTE:
In many temperature positions, the BI-LEVEL
mode is designed to provide cooler air out of the head-
liner outlets and warmer air from the floor outlets.
Floor Mode Air comes from the floor outlets.
Summer Operation
The engine cooling system in air conditioned vehicles
must be protected with a high-quality antifreeze coolant
to provide proper corrosion protection and to protect
against engine overheating. A solution of 50% ethylene
glycol antifreeze coolant and 50% water is recommended.
Refer to “Maintenance Procedures” in Section 7 of this
manual for proper coolant selection. 322 UNDERSTANDING YOUR INSTRUMENT PANEL

CAUTION!Driving with a hot cooling system could damage
your vehicle. If temperature gauge reads “H”, pull
over and stop the vehicle. Idle the vehicle with the air
conditioner turned off until the pointer drops back
into the normal range. If the pointer remains on the
“H”, turn the engine off immediately, and call for
service.
WARNING!
A hot engine cooling system is dangerous. You or
others could be badly burned by steam or boiling
coolant. You may want to call a service center if your
vehicle overheats. If you decide to look under the
hood yourself, see Section 7, Maintenance, of this
manual. Follow the warnings under the Cooling
System Pressure Cap paragraph.
JACKING AND TIRE CHANGING WARNING!

Getting under a jacked-up vehicle is dangerous.
The vehicle could slip off the jack and fall on you.
You could be crushed. Never get any part of your
body under a vehicle that is on a jack. If you need
to get under a raised vehicle, take it to a service
center where it can be raised on a lift.
The jack is designed to use as a tool for changing
tires only. The jack should not be used to lift the
vehicle for service purposes. The vehicle should
be jacked on a firm level surface only. Avoid ice or
slippery areas. (Continued)
WHAT TO DO IN EMERGENCIES 411 6

Please note that it is the owner’s responsibility to main-
tain the proper level of protection against freezing ac-
cording to the temperatures occurring in the area where
the vehicle is operated.
NOTE:Mixing engine coolant (antifreeze) types will
decrease the life of the engine coolant (antifreeze) and
will require more frequent coolant changes.
Cooling System Pressure Cap
The cap must be fully tightened to prevent the loss of
engine coolant (antifreeze), and to ensure that engine
coolant (antifreeze) will return to the radiator from the
coolant recovery bottle.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces. WARNING!

The warning words “DO NOT OPEN HOT” on
the cooling system pressure cap are a safety pre-
caution. Never add engine coolant (antifreeze)
when the engine is overheated. Do not loosen or
remove the cap to cool an overheated engine. Heat
causes pressure to build up in the cooling system.
To prevent scalding or injury, do not remove the
pressure cap while the system is hot or under
pressure.
Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal of Used Coolant
Used ethylene glycol-based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check
with your local authorities to determine the disposal
454 MAINTAINING YOUR VEHICLE

rules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol-based
engine coolant (antifreeze) in open containers or allow it
to remain in puddles on the ground. If ingested by a
child, contact a physician immediately. Clean up any
ground spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine cold, the level of the engine coolant (antifreeze) in
the coolant recovery bottle should be between the ranges
indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
engine coolant (antifreeze) freeze point or replacing the
engine coolant (antifreeze). Advise your service atten-
dant of this. As long as the engine operating temperature
is satisfactory, the coolant bottle only needs to be checked
once a month.When additional engine coolant (antifreeze) is needed to
maintain the proper level, it should be added to the
coolant bottle. Do not overfill.
Points to Remember
NOTE:
When the vehicle is stopped after a few miles (a
few kilometers) of operation, you may observe vapor
coming from the front of the engine compartment. This is
normally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
Do not overfill the coolant recovery bottle.
Check the engine coolant (antifreeze) freeze point in
the radiator and in the coolant recovery bottle. If
MAINTAINING YOUR VEHICLE 455 7

engine coolant (antifreeze) needs to be added, contents
of the coolant recovery bottle must also be protected
against freezing.
If frequent engine coolant (antifreeze) additions are
required, or if the level in the coolant recovery bottle
does not drop when the engine cools, the cooling
system should be pressure tested for leaks.
Maintain engine coolant (antifreeze) concentration at
50% HOAT engine coolant (antifreeze) (minimum)
and distilled water for proper corrosion protection of
your engine, which contains aluminum components.
Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, also keep the front of
the condenser clean.
Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
Brakes
In order to assure brake system performance, all brake
system components should be inspected periodically.
Refer to the “Maintenance Schedule” in Section 8 for the
proper maintenance intervals.WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You would not have your full
braking capacity in an emergency.
456 MAINTAINING YOUR VEHICLE

FLUIDS AND CAPACITIESU.S.
Metric
Fuel (Approximate) 20 Gallons76 Liters
Engine Oil with Filter
3.3L and 3.8L Engine (SAE 5W-20, API Certified) 5 Quarts4.7 Liters
4.0L Engine (SAE 10W-30, API Certified) 5.5 Quarts5.2 Liters
Cooling System *
3.3L, 3.8L, and 4.0L Engine (MOPARt Engine Coolant/
Antifreeze 5 Year/100,000 Mile Formula) 13.4 Quarts
12.6 Liters
* Includes heater and coolant recovery bottle filled to MAX level. Add 2.9 Qts (2.8 L) if equipped with a rear
heater.
480 MAINTAINING YOUR VEHICLE

Once A Month
Check tire pressure and look for unusual wear or
damage.
Inspect the battery and clean and tighten the terminals
as required.
Check the fluid levels of the coolant reservoir, the
brake master cylinder, the power steering and the
transaxle and add as needed.
Check all lights and other electrical items for correct
operation.At Each Oil Change
Change the engine oil filter.
Inspect the brake hoses and lines. CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
486 MAINTENANCE SCHEDULES
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Compass Calibration . . . . . . . . . . . . . . . . . . 255,261
Compass Variance . . . . . . . . . . . . . . . . . . . . 254,262
Computer, Trip/Travel . . . . . . . . . . . . . . . . . . . . 260
ConnectorUCI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 290
Universal Consumer Interface (UCI) . . . . . . . . . 290
Console . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Console, Floor . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Console, Overhead . . . . . . . . . . . . . . . . . . . . . . . 198
Console, Removable . . . . . . . . . . . . . . . . . . . . . . 226
Contract, Service . . . . . . . . . . . . . . . . . . . . . . . . 505
Coolant Pressure Cap (Radiator Cap) . . . . . . . . . . 454
Cooling System . . . . . . . . . . . . . . . . . . . . . . . . . 451 Adding Coolant (Antifreeze) . . . . . . . . . . . . . . 453
Coolant Capacity . . . . . . . . . . . . . . . . . . . . . . 480
Coolant Level . . . . . . . . . . . . . . . . . . . . . . 451,455
Disposal of Used Coolant . . . . . . . . . . . . . . . . 454
Drain, Flush, and Refill . . . . . . . . . . . . . . . . . . 452
Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . 455 Points to Remember . . . . . . . . . . . . . . . . . . . . 455
Pressure Cap . . . . . . . . . . . . . . . . . . . . . . . . . 454
Radiator Cap . . . . . . . . . . . . . . . . . . . . . . . . . 454
Selection of Coolant (Antifreeze) . . . . . . 452,480,481
Cruise Control (Speed Control) . . . . . . . . . . . . . . 188
Cupholders . . . . . . . . . . . . . . . . . . . . . . . . . 214,466
Customer Assistance . . . . . . . . . . . . . . . . . . . . . 503
Data Recorder, Event . . . . . . . . . . . . . . . . . . . . . . 74
Daytime Running Lights . . . . . . . . . . . . . . . . . . . 181
Dealer Service . . . . . . . . . . . . . . . . . . . . . . . . . . 438
Defroster, Rear Window . . . . . . . . . . . . . . . . . . . 226
Defroster, Windshield . . . . . . . . . . . . . . . . 94,308,318
Diagnostic System, Onboard . . . . . . . . . . . . . . . . 435
Dimmer Control . . . . . . . . . . . . . . . . . . . . . . . . 178
Dipsticks Automatic Transaxle . . . . . . . . . . . . . . . . . . . . 459
Automatic Transmission . . . . . . . . . . . . . . . . . 459
Oil (Engine) . . . . . . . . . . . . . . . . . . . . . . . . . . 439
INDEX 515
10

Power Steering . . . . . . . . . . . . . . . . . . . . . . . . 342
Disabled Vehicle Towing . . . . . . . . . . . . . . . . . . . 427
Disposal Antifreeze (Engine Coolant) . . . . . . . . . . . . . . . 454
Engine Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . 442
Domelight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 177
Door Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Door Locks, Automatic . . . . . . . . . . . . . . . . . . . . 32
Door Opener, Garage . . . . . . . . . . . . . . . . . . . . . 201
Driving On Slippery Surfaces . . . . . . . . . . . . . . . . . . . 339
Through Flowing, Rising, or Shallow Standing
Water . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 340
DVD Player (Video Entertainment System™) . . . . 301
E-85 Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 383
Electric Remote Mirrors . . . . . . . . . . . . . . . . . . . 102
Electrical Power Outlets . . . . . . . . . . . . . . . . . . . 210
Electronic Brake Control System . . . . . . . . . . . . . 347 Brake Assist System . . . . . . . . . . . . . . . . . . . . 348
Electronic Stability Program . . . . . . . . . . . . . . . 349
Electronic Speed Control (Cruise Control) . . . . . . 188
Electronic Stability Program (ESP) . . . . . . . . . . . . 349
Electronic Vehicle Information Center
(EVIC) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 196,256
Emergency, In Case of Hazard Warning Flasher . . . . . . . . . . . . . . . . . 410
Jacking . . . . . . . . . . . . . . . . . . . . . . . . . . . 411,415
Jump Starting . . . . . . . . . . . . . . . . . . . . . . . . . 424
Overheating . . . . . . . . . . . . . . . . . . . . . . . . . . 410
Emission Control System Maintenance . . . . . . 436,484
Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . 433,434 Air Cleaner . . . . . . . . . . . . . . . . . . . . . . . . . . 442
Block Heater . . . . . . . . . . . . . . . . . . . . . . . . . 331
Break-In Recommendations . . . . . . . . . . . . . . . . 91
Checking Oil Level . . . . . . . . . . . . . . . . . . . . . 439
Compartment . . . . . . . . . . . . . . . . . . . . . . 433,434
Coolant (Antifreeze) . . . . . . . . . . . . . . . . . . . . 481
516 INDEX