belt DODGE GRAND CARAVAN 2010 5.G Workshop Manual

STARTING PROCEDURES
Before starting your vehicle, adjust your seat, adjust the
inside and outside mirrors, fasten your seat belt, and if
present, instruct all other occupants to buckle their seat
belts.
WARNING!
Never leave unattended children alone in a vehicle.
Leaving children in a vehicle is dangerous for a
number of reasons. A child or others could be seri-
ously or fatally injured. Do not leave the key fob in
the ignition switch. A child could operate power
windows, other controls, or move the vehicle.
Automatic Transmission
The shift lever must be in the NEUTRAL or PARK
position before you can start the engine. Press the brake
pedal before shifting into any driving gear.
Normal Starting
1. Do not press the accelerator.
2. Use the Fob with Integrated Key to briefly turn the
ignition switch to the START position and release it as
soon as the starter engages. The starter motor will
continue to run, and it will disengage automatically
when the engine is running.
3. If the engine fails to start, the starter will disengage
automatically in 10 seconds. If this occurs, turn the
ignition switch to the OFF position, wait 10 to 15 seconds,
then repeat the “Normal Starting” procedure (Steps 1–3
above).
NOTE: This vehicle is equipped with a transmission
shift interlocking system. The brake pedal must be
pressed to shift out of PARK.
5
STARTING AND OPERATING 321

CAUTION!
•It is essential when replacing the cables on the
battery that the positive cable is attached to the
positive post and the negative cable is attached to
the negative post. Battery posts are marked posi-
tive (+) and negative (-) and are identified on the
battery case. Cable clamps should be tight on the
terminal posts and free of corrosion.
•If a “fast charger” is used while the battery is in
the vehicle, disconnect both vehicle battery cables
before connecting the charger to the battery. Do
not use a “fast charger” to provide starting voltage.
Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a system
performance check. Drive belt tension should also be
checked at this time.
CAUTION!
Do not use chemical flushes in your air conditioning
system as the chemicals can damage your air condi-
tioning components. Such damage is not covered by
the New Vehicle Limited Warranty.
444 MAINTAINING YOUR VEHICLE

Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft rag. A mild soap solution may be
used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
rag.
2. Dry with a soft tissue.
Seat Belt Maintenance
Do not bleach, dye or clean the seat belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the seat belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the car to
wash them.Replace the seat belts if they appear frayed or worn, or if
the buckles do not work properly.
Cleaning the Instrument Panel Cupholders
Removal
Pull the flexible liner from the cupholder drawer starting
at one edge to ease removal.
Cleaning
The liner is top shelf dishwasher safe, or you may follow
the cleaning procedure below.
Soak the liner in a mixture of medium hot tap water and
one teaspoon of mild liquid dish soap. Let soak for
approximately 30 minutes. After 30 minutes, pull the
liner from the water and dip it back into the water about
six times. This will loosen any remaining debris. Rinse
the liner thoroughly under warm running water. Shake
the excess water from the liner and dry the outer surfaces
with a clean soft cloth.
464 MAINTAINING YOUR VEHICLE

102,000 Miles (170,000 km) or
102 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate tires.
❏ Replace the ignition cables (3.3L and
3.8L engines).
❏ Replace the spark plugs (3.3L, 3.8L,
and 4.0L engines).
❏ Replace the timing belt (4.0L engine).
❏ Flush and replace the engine coolant if
not done at 60 months.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
108,000 Miles (180,000 km) or 108 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the
engine air cleaner filter, replace if necessary.
❏ Replace the air conditioning filter.
❏ Inspect the brake linings, replace if necessary.
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
SMAINTENANCE SCHEDULES 493

114,000 Miles (190,000 km) or
114 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate tires.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
120,000 Miles (200,000 km) or 120 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ Replace the engine air cleaner filter.
❏ Replace the air conditioning filter.
❏ Inspect the brake linings, replace if necessary.
❏ Inspect the CV Joints.
❏ Inspect the exhaust system.
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
❏ Replace accessory drive belt(s).
❏ Change the automatic transmission fluid & filter.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S494 MAINTENANCE SCHEDULES

Automatic Transaxle...................... 324
Adding Fluid ......................... 458
Fluid Level Check ..................... 458
Interlock System ....................... 325
Selection Of Lubricant ................456,479
Shifting ............................. 326
Special Additives ...................... 458
Automatic Transmission ................456,458
Adding Fluid ...................... 457,458
Fluid and Filter Changes ................. 458
Fluid Change ......................... 458
Fluid Level Check ..................... 457
Fluid Type ........................ 456,479
Battery ............................... 443
Jump Starting ......................... 421
Keyless Transmitter Replacement (RKE) ....... 26
Saving Feature (Protection) ............... 160
Belts, Seat ............................. 101 Blind Spot Monitoring
.................... 114
Body Mechanism Lubrication ............... 447
B-Pillar Location ........................ 351
Brake Assist System ...................... 342
Brake Control System, Electronic ............. 341
Brake Fluid ............................ 479
Brake, Parking .......................... 336
Brake System ........................... 454
Fluid Check .......................... 454
Warning Light ........................ 229
Brakes ............................... 454
Brake/Transmission Interlock ............... 325
Break-In Recommendations, New Vehicle ........ 99
Bulb Replacement ....................... 474
Bulbs, Light ......................... 104,473
Calibration, Compass .................. 244,250
Camera, Rear ........................... 181
Capacities, Fluid ........................ 477
10
INDEX 511

Flooded, Starting...................... 322
Fuel Requirements .................. 372,477
Oil ........................... 437,477,478
Oil Change Interval .................... 438
Oil Disposal .......................... 440
Oil Filler Cap ......................... 439
Oil Filter Disposal ..................... 440
Oil Selection ....................... 438,477
Oil Synthetic ......................... 439
Overheating .......................... 406
Starting ............................. 321
Temperature Gauge .................... 227
Enhanced Accident Response Feature .......... 78
Exhaust Gas Caution ................51,100,377
Exhaust System ...................... 100,441
Express Down Windows ................... 22
Extender, Seat Belt ........................ 67
Exterior Folding Mirrors ................... 112
Exterior Lights .......................... 104 Fabric Care
............................ 462
Filler Location Fuel ...................... 227
Filters Air Cleaner .......................... 440
Air Conditioning .................... 316,445
Engine Oil ........................ 440,478
Engine Oil Disposal .................... 440
Flashers Hazard Warning ....................... 406
Turn Signal .................. 104,228,474,475
Flash-To-Pass ........................... 162
Flat Tire Stowage ........................ 418
Flexible Fuel Vehicles Cruising Range ....................... 380
Engine Oil ........................... 380
Fuel Requirements .................. 377,379
Maintenance ......................... 381
Replacement Parts ..................... 381
Starting ............................. 380
10
INDEX 515

Ignition............................... 13
Key ............................... 12,13
Ignition Key Removal ..................... 13
Illuminated Entry ........................ 18
Immobilizer (Sentry Key) ................... 14
Infant Restraint ........................ 87,88
Information Center, Vehicle ................. 244
Inside Rearview Mirror .................... 110
Instrument Cluster .................... 224,227
Instrument Panel and Controls .............. 223
Instrument Panel Cover ................... 462
Instrument Panel Lens Cleaning ............. 464
Integrated Power Module (Fuses) ............ 465
Interior Appearance Care .................. 462
Interior Lights ....................... 155,156
Introduction ............................. 4
Jack Location ........................... 408
Jack Operation .......................... 407 Jump Starting
.......................... 421
Key, Programming ........................ 16
Key, Replacement ........................ 15
Key, Sentry (Immobilizer) ................... 14
Key-In Reminder ......................... 14
Keyless Entry System ...................... 19
Keys ................................. 12
Lane Change Assist ...................... 161
Lap/Shoulder Belts ....................... 54
LATCH
(Lower Anchors and Tether for CHildren) ....... 92
Latches ............................... 104
Hood .............................. 153
Lead Free Gasoline ...................... 372
Leaks, Fluid ........................... 104
Life of Tires ............................ 361
Liftgate ................................ 48
518 INDEX

Light Bulbs............................ 104
Lights ............................. 104,155
Airbag ....................... 76,81,102,237
Alarm .............................. 236
Anti-Lock ........................... 228
Automatic Headlights ................... 157
Back-Up ............................ 475
Battery Saver ......................... 160
Brake Assist Warning ................... 344
Brake Warning ........................ 229
Bulb Replacement ................... 473,474
Center Mounted Stop ................... 476
Daytime Running ...................... 159
Dimmer Switch, Headlight ............... 156
Engine Temperature Warning .............. 235
Exterior ............................. 104
Fog .......................... 160,236,474
Hazard Warning Flasher ................. 406
Headlight Switch ...................... 157 Headlights
........................... 474
Headlights On Reminder ................. 159
High Beam Indicator .................... 228
High Beam/Low Beam Select ............. 161
Illuminated Entry ....................... 18
Interior .......................... 155,156
License ............................. 476
Lights On Reminder .................... 159
Low Fuel ............................ 237
Malfunction Indicator (Check Engine) ........ 234
Oil Pressure .......................... 236
Park ............................ 157,474
Passing ............................. 162
Reading ............................. 184
Rear Servicing ........................ 475
Rear Tail ............................ 475
Seat Belt Reminder ..................... 236
Security Alarm (Theft Alarm) .............. 236
Service ........................... 473,474
10
INDEX 519

Personal Settings........................ 252
Pets, Transporting ........................ 95
Phone, Cellular ......................... 122
Phone, Hands-Free (Uconnect™) ............. 122
Placard, Tire and Loading Information ......... 351
Power Door Locks ........................... 32
Lift Gate ............................. 49
Mirrors ............................. 112
Outlet (Auxiliary Electrical Outlet) .......... 195
Seats ............................... 126
Sliding Door .......................... 42
Steering ............................. 335
Sunroof ............................. 192
Windows ............................. 36
Windows, Express Down ................. 22
Power Steering Fluid ..................... 479
Pregnant Women and Seat Belts .............. 67
Preparation for Jacking .................... 410 Pretensioners
Seat Belts ............................ 61
Programmable Electronic Features ............ 252
Radial Ply Tires ......................... 358
Radiator Cap (Coolant Pressure Cap) .......449,451
Radio Operation ........................ 297
Radio Remote Controls .................... 295
Radio, Satellite (Uconnect studios)........ 288,293
Rear Air Conditioning .................. 304,311
Rear Camera ........................... 181
Rear Cross Path ......................... 120
Rear Heater ............................ 304
Rear Park Sense System ................... 171
Rear Window Defroster ................... 213
Rearview Mirrors ........................ 110
Reclining Front Seats ..................... 124
Recreational Towing ................... 403,427
Reminder, Seat Belt ..................... 65,66
522 INDEX