belt DODGE GRAND CARAVAN 2019 Repair Manual

•It is important that the drain holes in the lower edges of
the doors, rocker panels, and trunk be kept clear and
open.
• If you detect any stone chips or scratches in the paint,
touch them up immediately. The cost of such repairs is
considered the responsibility of the owner.
• If your vehicle is damaged due to a collision or similar
cause that destroys the paint and protective coating,
have your vehicle repaired as soon as possible. The cost
of such repairs is considered the responsibility of the
owner.
• If you carry special cargo such as chemicals, fertilizers,
de-icer salt, etc., be sure that such materials are well
packaged and sealed.
• If a lot of driving is done on gravel roads, consider mud
or stone shields behind each wheel.
• Use Mopar Touch Up Paint on scratches as soon as
possible. An authorized dealer has touch up paint to
match the color of your vehicle.INTERIORS
Seats And Fabric Parts
Use Mopar Total Clean to clean fabric upholstery and
carpeting.
WARNING!
Do not use volatile solvents for cleaning purposes.
Many are potentially flammable, and if used in closed
areas they may cause respiratory harm.
Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical solvents
or abrasive cleaners. This will weaken the fabric. Sun
damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the vehicle
to wash them. Dry with a soft cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.8
SERVICING AND MAINTENANCE 383

WARNING!
A frayed or torn belt could rip apart in a collision and
leave you with no protection. Inspect the belt system
periodically, checking for cuts, frays, or loose parts.
Damaged parts must be replaced immediately. Do not
disassemble or modify the system. Seat belt assemblies
must be replaced after a collision if they have been
damaged (i.e., bent retractor, torn webbing, etc.).
Plastic And Coated Parts
Use Mopar Total Clean to clean vinyl upholstery.
CAUTION!
•Direct contact of air fresheners, insect repellents,
suntan lotions, or hand sanitizers to the plastic,
painted, or decorated surfaces of the interior may
cause permanent damage. Wipe away immediately.
• Damage caused by these type of products may not be
covered by your New Vehicle Limited Warranty.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft cloth. A mild soap solution may be used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
cloth.
2. Dry with a soft cloth.
Glass Surfaces
All glass surfaces should be cleaned on a regular basis with
Mopar Glass Cleaner, or any commercial household-type
glass cleaner. Never use an abrasive type cleaner. Use
caution when cleaning the inside rear window equipped
with electric defrosters or windows equipped with radio
antennas. Do not use scrapers or other sharp instruments
that may scratch the elements.
When cleaning the rear view mirror, spray cleaner on the
towel or cloth that you are using. Do not spray cleaner
directly on the mirror.
384 SERVICING AND MAINTENANCE

Automatic Headlights........................62
Automatic Transmission ..................245, 357
Adding Fluid ....................... .357, 400
Fluid And Filter Change ...................357
Fluid Change .......................... .357
Fluid Level Check .................... .356, 357
Fluid Type ......................... .356, 400
Gear Ranges ........................... .248
Special Additives ........................ .356
Torque Converter ....................... .253
Axle Fluid .............................. .400
Axle Lubrication .......................... .400
Battery .............................. .146, 340
Charging System Light ................... .146
Jump Starting .......................... .324
Keyless Key Fob Replacement ................18
Battery Saver Feature .........................64
Belts, Seat ............................... .235
Body Mechanism Lubrication ..................347
B-Pillar Location .......................... .363
Brake Assist System ........................ .160
Brake Control System, Electronic ................159
Brake Fluid .............................. .400
Brake System ......................... .354, 388Anti-Lock (ABS)
........................ .388
Fluid Check ........................ .355, 400
Parking .............................. .243
Warning Light .......................... .145
Brake/Transmission Interlock ..................246
Bulb Replacement ......................... .287
Bulbs, Light .......................... .237, 287
Calibration Compass ............................. .138
Camera, Rear ............................ .265
Capacities, Fluid .......................... .397
Caps, Filler Oil (Engine) ........................... .339
Power
Steering ......................... .254
Radiator (Coolant Pressure) .................353
Carbon Monoxide Warning ................234, 393
Cargo Vehicle Loading ..........................97
Cargo Area Cover ...........................97
Cargo Compartment .........................97
Luggage Carrier ........................ .122
Car Washes .............................. .382
Cellular Phone ........................ .432, 456
Center High Mounted Stop Light ...............290
12
INDEX 473

Certification Label......................... .268
Chains, Tire ............................. .378
Change Oil Indicator ....................... .135
Changing A Flat Tire .................... .297, 357
Chart, Tire Sizing .......................... .359
Check Engine Light (Malfunction Indicator Light). . . .154
Checking Your Vehicle For Safety ...............234
Checks, Safety ............................ .234
Child Restraint ........................... .210
Child Restraints Booster Seats ........................... .214
Child Seat Installation ................. .226, 228
How To Stow An unused ALR Seat Belt ........224
Infant And Child Restraints .................212
Locating The LATCH Anchorages .............220
Lower Anchors And Tethers For Children .......216
Older Children And Child Restraints ...........213
Seating Positions ........................ .215
Using The Top Tether Anchorage .............231
Clean Air Gasoline ........................ .391
Cleaning Wheels ............................... .377
Climate Control ............................68
Automatic ..............................76
Manual ................................68 Coat Hook
...............................112
Cold Weather Operation ..................... .241
Compact Disc (CD) Maintenance ................463
Compact Spare Tire ........................ .375
Compass ................................ .137
Calibration ............................ .138
Variance .............................. .138
Computer, Trip/Travel ................... .136, 144
Console ................................ .105
Floor ................................ .105
Console, Overhead ........................ .108
Contract, Service .......................... .468
Cooling

Pressure Cap (Radiator Cap) ............353
Cooling System ........................... .350
Adding Coolant (Antifreeze) .................352
Cooling Capacity ........................ .397
Disposal Of Used Coolant ..................353
Drain, Flush, And Refill ................... .351
Inspection ............................. .350
Points To Remember ..................... .353
Pressure Cap ........................... .353
Radiator Cap .......................... .353
Selection Of Coolant (Antifreeze) .......351, 397, 398
Corrosion Protection ....................... .381
Cruise Light ............................. .152
474 INDEX

Head Restraints............................49
Heated Mirrors ......................... .56, 60
Heater, Engine Block ....................... .242
High Beam/Low Beam Select (Dimmer) Switch ......62
Hill Start Assist ........................... .160
Hitches Trailer Towing .......................... .273
HomeLink (Garage Door Opener) ................98
Hood Prop ................................92
Hood Release ..............................92
Hook, Coat ...............................112
Ignition ..................................20
Switch .................................20
Inside Rearview Mirror .......................57
Instrument Cluster ......................... .130
Descriptions ........................ .131, 152
Display .............................. .133
Display Controls ........................ .133
Menu Items ........................... .135
Instrument Panel Lens Cleaning ................384
Integrated Power Module (Fuses) ...............292
Interior And Instrument Lights ..................64
Interior Appearance Care .................... .383
Interior Lights ..............................64 Intermittent Wipers (Delay Wipers)
...............67
Introduction ................................4
Inverter Power ................................119
iPod/USB/MP3 Control ..................... .406
Bluetooth Streaming Audio ..............410, 461
Jack Location ............................ .298
Jack Operation ........................ .297, 357
Jump Starting ............................ .324
Key Fob Arm The Alarm ..........................25
Disarm The Alarm ........................25
Programming Additional Key Fobs ..........20, 24
Key Fob Battery Service (Remote Keyless Entry) .....18
Key Fob Programming (Remote Keyless Entry) ......20
Keys ....................................17
Replacement .............................24
Lane Change And Turn Signals .................61
Lane Change Assist ...................... .61, 64
Lap/Shoulder

Belts ........................ .182
Latches ................................. .237
Hood ..................................92
478 INDEX

Leaks, Fluid............................. .237
Life Of Tires ............................. .371
Liftgate ..................................94
Closing ................................94
Opening ................................94
Light Bulbs .............................. .237
Lights .................................. .237
AirBag ........................ .145, 197, 235
Automatic Headlights ......................62
Back-Up .............................. .289
Battery Saver ............................64
Brake Assist Warning ..................... .165
Brake Warning ......................... .145
Bulb Replacement ....................... .287
Center Mounted Stop ..................... .290
Cruise ............................... .152
Daytime Running ...................... .61, 62
Dimmer Switch, Headlight ................61, 62
Electronic Stability Program(ESP) Indicator ......147
Exterior .............................. .237
Fog ............................... .63, 289
Hazard Warning Flasher ...................286
Headlights .......................... .61, 288
Headlights On Reminder ....................63
High Beam ..............................62 High Beam/Low Beam Select
..............61, 62
Instrument Cluster ........................61
Interior ................................64
License ............................... .290
Lights On Reminder .................... .61, 63
Malfunction Indicator (Check Engine) ..........150
Parade Mode (Daytime Brightness) .............66
Park ............................. .153, 289
Passing ............................. .61, 62
Reading ................................64
Rear Servicing .......................... .289
Rear Tail Lamps ........................ .289
Seat Belt Reminder ...................... .147
Security Alarm ......................... .148
Service ............................... .287
Side

Marker ........................... .289
Traction Control ........................ .165
Turn Signals .................. .61, 152, 237, 289
Warning Instrument Cluster Descriptions . . . .147, 152
Loading Vehicle ........................ .97, 268
Tires................................. .363
Load Leveling System ........................97
Locks Automatic Door ..........................29
Low Tire Pressure System .................... .174
12
INDEX 479

Onboard Diagnostic System...................153
Operating Precautions ...................... .153
Operator Manual Owner’s Manual .......................5,470
Outside Rearview Mirrors ...................56, 58
Overhead Console ......................... .108
Overhead Travel Information Center .............108
Overheating, Engine ....................... .327
Owner ’s Manual (Operator Manual) ...............5
Paint Care ............................... .381
Parking Brake ............................ .243
ParkSense System, Rear ..................... .258
Personal Settings .......................... .139
Pets ................................... .233
Phone, Hands-Free (Uconnect) .................432
Placard, Tire And Loading Information ...........363
Power Brakes ............................... .388
Door Locks ..............................28
Inverter ...............................119
Mirrors ................................59
Outlet (Auxiliary Electrical Outlet) ............115
Seats ..................................45
Steering .............................. .254Vent Windows
...........................89
Power Seats Down .................................46
Forward ................................46
Rearward ...............................46
Up....................................46
Pregnant Women And Seat Belts ................192
Preparation For Jacking ..................... .303
Pretensioners Seat Belts ............................. .192
Programmable Electronic Features ...............139
Radial Ply Tires ........................... .369
Radiator Cap (Coolant Pressure Cap) .............353
Radio Frequency General Information ................. .20, 23, 24
Radio Operation ....................... .404, 456
Radio Remote Controls ..................... .405
Rear Air Conditioning ........................72
Rear

Camera ............................. .265
Rear Cross Path ........................... .172
Rear ParkSense System ..................... .258
Reclining Rear Seats .........................34
Recreational Towing ........................ .281
Reformulated Gasoline ...................... .391
12
INDEX 481

Refrigerant.............................. .345
Release, Hood ..............................92
Reminder, Lights On .........................61
Reminder, Seat Belt ........................ .181
Remote Keyless Entry Arm The Alarm ..........................25
Disarm The Alarm ........................25
Programming Additional Key Fobs ..........20, 24
Remote Starting Exit Remote Start Mode .....................22
Replacement Bulbs ........................ .287
Replacement Keys ...........................24
Replacement Tires ......................... .372
Reporting Safety Defects .................... .469
Restraints, Child .......................... .210
Restraints, Head ............................49
Rocking Vehicle When Stuck ...................329
Roof Luggage Rack ........................ .122
Rotation, Tires ............................ .379
Safety Checks Inside Vehicle ...................235
Safety Checks Outside Vehicle .................237
Safety Defects, Reporting .................... .469
Safety, Exhaust Gas ........................ .234
Safety Information, Tire ..................... .357Safety Tips
.............................. .234
Schedule, Maintenance ...................... .335
Seat Belt Reminder ........................ .147
Seat Belts ............................ .181, 235
Adjustable Shoulder Belt ...................186
Adjustable Upper Shoulder Anchorage .........186
Adjustable Upper Shoulder Belt Anchorage ......186
Automatic Locking Retractor (ALR) ...........193
Child Restraints ........................ .210
Energy Management Feature ................192
Extender .............................. .191
Front Seat ...................... .181, 182, 184
Inspection ............................. .235
Lap/Shoulder Belt Operation ................184
Lap/Shoulder

Belts ...................... .182
Lap/Shoulder Belt Untwisting ...............186
Operating Instructions .................... .184
Pregnant Women ........................ .192
Pretensioners .......................... .192
Rear Seat ............................. .182
Reminder ............................. .181
Seat Belt Extender ....................... .191
Seat Belt Pretensioner .................... .192
Untwisting Procedure .................... .186
Seat Belts Maintenance ...................... .383
482 INDEX

Seats.............................. .32, 46, 48
Adjustment ....................... .32, 33, 46
Heated .................................48
Power .................................45
Rear Folding .............................32
Reclining ...............................34
Seatback Release ..........................33
Stow ‘n Go (Fold in Floor) ...................35
Tilting .............................. .32, 33
Security Alarm ........................... .148
Arm The System ..........................25
Disarm The System ........................25
Selection Of Coolant (Antifreeze) ...............398
Sentry Key Key Programming .........................24
Sentry Key (Immobilizer) ......................23
Sentry Key Replacement ......................24
Service Assistance ......................... .466
Service Contract .......................... .468
Service Manuals .......................... .470
Settings Personal .............................. .139
Shift Lever Override ....................... .328
Shoulder Belts ............................ .182
Side View Mirror Adjustment ...................56 Signals, Turn
.................... .61, 152, 237, 289
Snow Chains (Tire Chains) ....................378
Snow Tires .............................. .374
Spare Tires .................... .301, 374, 375, 376
Spark Plugs ............................. .398
Specifications Fuel (Gasoline) ......................... .398
Oil.................................. .398
Speed Control Accel/Decel ........................... .257
Cancel ............................... .258
Resume .............................. .258
Speed Control (Cruise Control) .................255
Starting ................................ .241
Button .................................20
Cold Weather .......................... .241
Engine Fails To Start ..................... .242
Starting
And Operating ..................... .241
Starting Procedures ........................ .241
Steering Power ............................... .254
Tilt Column .............................55
Wheel, Heated ...........................55
Wheel, Tilt ..............................55
Steering Wheel Audio Controls .................405
12
INDEX 483

Disabled Vehicle........................ .330
Guide ................................ .274
Recreational ........................... .281
Weight ............................... .274
Towing Assistance ......................... .444
Towing Behind A Motorhome ..................281
Traction ................................ .282
Traction Control .......................... .163
Trailer Sway Control (TSC) ....................167
Trailer Towing ............................ .270
Cooling System Tips ..................... .280
Hitches ............................... .273
Minimum Requirements ................... .276
Tips ................................. .279
Trailer And Tongue Weight ..................275
Wiring ............................... .278
Trailer Towing Guide ....................... .274
Trailer Weight ............................ .274
Transfer Case Fluid ................................ .400
Transmission Automatic ......................... .245, 356
Fluid ............................. .356, 400
Maintenance ........................... .356
Transporting Pets ......................... .233Tread Wear Indicators
...................... .370
Turn Signals ....................... .61, 152, 289
Uconnect Advanced Phone Connectivity ...............446
Phone Call Features ...................... .440
Uconnect (Hands-Free Phone) ..................432
Uconnect Phone .......................... .442
Umbrella Holder ...........................110
Uniform Tire Quality Grades ..................379
Universal Garage Door Opener (HomeLink) ........98
Universal Transmitter ........................98
Untwisting Procedure, Seat Belt ................186
USB................................... .406
V
anity Mirrors .............................60
Variance Compass ............................. .138
Vehicle Identification Number (VIN) .............388
Vehicle Loading ....................... .268, 364
Vehicle Modifications/Alterations .................5
Vehicle Storage ......................... .87, 381
Viscosity, Engine Oil ....................... .342
Voice Command Commands ............................ .459
12
INDEX 485