fuel DODGE JOURNEY 2009 1.G Service Manual

Spark Plugs
Spark plugs must fire properly to assure engine perfor-
mance and emissions control. New plugs should be
installed at the specified mileage. The entire set should be
replaced if there is any malfunction due to a faulty spark
plug. Refer to “Fluids, Lubricants, and Genuine Parts” in
this section for the proper type of spark plug for use in
your vehicle.
Engine Air Cleaner Filter
Refer to the Maintenance Schedule in Section 8 for engine
air cleaner filter service intervals.
NOTE:Be sure to follow the “dusty or off-road condi-
tions” maintenance interval if applicable.
WARNING!
The air induction system (air cleaner, hoses, etc.,) can
provide a measure of protection in the case of engine
backfire. Do not remove the air induction system (air
cleaner, hoses, etc.,) unless such removal is necessary
for repair or maintenance. Make sure that no one is
near the engine compartment before starting the
vehicle with the air induction system (air cleaner,
hoses, etc.,) removed. Failure to do so can result in
serious personal injury.
Catalytic Converter
The catalytic converter requires the use of unleaded fuel
only. Leaded gasoline will destroy the effectiveness of the
catalyst as an emissions control device.
MAINTAINING YOUR VEHICLE 429
7

Fuel System
The Electronic Fuel Injection high-pressure fuel system’s
hoses and fittings have unique material characteristics
that provide adequate sealing and resist attack by dete-
riorated gasoline.
You are urged to use only the manufacturer’s specified
hoses and fittings, or their equivalent in material and
specification, in any fuel system servicing. It is manda-
tory to replace any damaged hoses or fittings that have
been removed during service. Care should be taken with
installing fittings to ensure they are properly installed
and fully connected. See your authorized dealer for
service.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Suggested service intervals can be found in the “Mainte-
nance Schedule” in Section 8.
WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You wouldn’t have your full
braking capacity in an emergency.
Brake and Power Steering Hoses
When servicing the vehicle for scheduled maintenance,
inspect the surface of the hoses and nylon tubing for
evidence of heat and mechanical damage. Hard and
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling suggest deterioration of the rubber. Particu-
lar attention should be made to examining those hose
surfaces nearest to high heat sources, such as the exhaust
manifold.
446 MAINTAINING YOUR VEHICLE

CavityCartridge
Fuse Mini-
Fuse Description
J7 30 Amp Pink —Anti-Lock Brake Sys-
tem (ABS) Valve/
Electronic Stability
Program (ESP)
J8 40 Amp Green —Power Memory Seat -
if equipped
J9 40 Amp Green —Flex Fuel/PZEV Mo-
tor - if equipped
J10 30 Amp Pink —(If Equipped) Head-
lamp Washer Relay-
(BUX), Manual Tun-
ing Valve
J11 30 Amp Pink —(If Equipped) Sway
Bar/Thatchum Secu-
rity (BUX)/Power
Sliding DoorCavity
Cartridge
Fuse Mini-
Fuse Description
J13 60 Amp Yellow —Ignition Off Draw
(IOD) Main
J14 40 Amp Green —Electric Back Light
(EBL)
J15 30 Amp Pink —Rear Blower - if
equipped
J17 40 Amp Green —Starter Solenoid
J18 20 Amp Yellow — NGC (Powertrain
Control Module)/
Transmission Range
J19 60 Amp Yellow —Radiator Fan Motor
J20 30 Amp Pink —Front Windshield
Wiper Hi/Low
J21 20 Amp Blue —Front/Rear Washer
MAINTAINING YOUR VEHICLE 459
7

CavityCartridge
Fuse Mini-
Fuse Description
M25 —20 Amp
Yellow Fuel Pump/Diesel
Lift Pump
M26 —10 Amp
Red Power MIRRORS
Switch/Drivers Win-
dow Switch
M27 —10 Amp
Red Steering Column
Lock, Wireless Igni-
tion Node (WIN)
M28
—10 Amp
Red
NGC (Powertrain
Control Module)/
Transmission Feed
(Batt)
M29 —10 Amp
Red Occupant Classifica-
tion Module (OCM)
M30 —15 Amp
Blue Rear Wiper Module
Module/Power Fold-
ing MirrorCavity
Cartridge
Fuse Mini-
Fuse Description
M31 —20 Amp
Yellow Back-Up Lights
M32 —10 Amp
Red Occupant Restraint
Controller (ORC)
M33 —10 Amp
Red NGC (Powertrain
Control Module) Bat-
tery Feed
M34
—10 Amp
Red
Power Assist Module,
HVAC Module, Head-
lamp Washers, Com-
pass Module - if
equipped, Flashlight -
if equipped
M35 —10 Amp
Red Heated Mirrors - if
equipped
M36 —20 Amp
Yellow Power Outlet #3
(Batt)
MAINTAINING YOUR VEHICLE 463
7

FLUIDS AND CAPACITIES
ComponentU.S.Metric
Fuel (approximate)
Front Wheel Drive (FWD) Models with 2.4 Liter PZEV Engine 18.5 gal70 l
FWD Models without 2.4 Liter PZEV Engine 20.5 gal77.6 l
All-Wheel Drive Models 21.1 gal79.8 l
Engine Oil with Filter
2.4 Liter Engine (SAE 5W-20, API Certified) 4.5 qts4.26 l
2.7 Liter Engine (SAE 5W-20, API Certified) 5.5 qts5.2 l
3.5 Liter Engine (SAE 10W-30, API Certified) 5.5 qts5.2 l
Cooling System *
2.4 Liter Engine and Single- or Dual-Zone Climate Control System
(Mopar Antifreeze/Coolant 5 Year/100,000 Mile Formula) or equiva-
lent 7.9 qts
7.5 l
2.4 Liter Engine and Three-Zone Climate Control System (Mopar
Antifreeze/Coolant 5 Year/100,000 Mile Formula) or equivalent 9.8 qts
9.3 l
472 MAINTAINING YOUR VEHICLE

ComponentFluids, Lubricants, and Genuine Parts
Spark Plugs (2.7L) TE10MCC5 (Gap.050 in [1.27 mm])
Spark Plugs (3.5L) ZFR5LP-13G (Gap.050 in [1.27 mm])
Fuel Selection (2.4L) 87 Octane
Fuel Selection (2.7L) 87 Octane
Fuel Selection (2.7L - EXCEPT CALI-
FORNIA EMISSION STATES) E-85 Ethanol
Fuel Selection (3.5L) 87 to 89 Octane
MAINTAINING YOUR VEHICLE 475
7

At Each Stop for Fuel
•Check the engine oil level. Refer to “Engine Oil” under
“Maintenance Procedures” in Section 7.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery, and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering, and transaxle, and
add as needed.
•Check all lights and other electrical items for correct
operation. At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
480 MAINTENANCE SCHEDULES
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S

About Your Brakes.................... 323,326
ABS (Anti-Lock Brake System) .........215,327,328
Adding Engine Coolant (Antifreeze) .......... 442
Adding Fuel ........................... 372
Adding Rear Washer Fluid ................. 194
Adding Washer Fluid ...............157,194,438
Additives, Fuel ......................... 371
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 429
Air Conditioner Maintenance ............... 433
Air Conditioning ..................... 288,289
Air Conditioning Controls ...............288,289
Air Conditioning Filter .................301,434
Air Conditioning, Operating Tips ............ 302
Air Conditioning Refrigerant .............433,434
Air Conditioning System ..........288,289,293,433
Air Pressure, Tires .................... 213,346
Airbag ................................ 50
Airbag Deployment ..................... 56,60
Airbag Light ..................... 57,63,80,218Airbag Maintenance
....................... 62
Airbag, Side .......................... 52,58
Airbag, Window (Side Curtain) .............52,58
Alarm, Panic ............................ 24
Alarm (Security Alarm) .................18,208
Alarm System (Security Alarm) ............... 18
Alignment and Balance ................... 354
All Wheel Drive (AWD) ................... 319
Alterations/Modifications, Vehicle ............. 7
Antenna, Satellite Radio ................... 272
Antifreeze (Engine Coolant) ...........441,442,472
Disposal ............................ 443
Anti-Lock Brake System (ABS) ............327,328
Anti-Lock Warning Light .............215,328,329
Anti-Theft Security Alarm (Theft Alarm) ........ 18
Anti-Theft System ....................... 208
Appearance Care ........................ 452
Arming Theft System (Security Alarm) ......... 18
Assistance Towing ....................... 106
496 INDEX

Brake Assist System...................... 330
Brake Assist Warning Light ................. 216
Brake Control System, Electronic ............. 328
Brake Fluid ............................ 476
Brake, Parking .......................... 323
Brake System ........................ 326,446
Anti-Lock (ABS) .................... 327,328
Fluid Check ....................... 447,476
Hoses .............................. 446
Master Cylinder ....................... 447
Parking ............................. 323
Warning Light ........................ 217
Brakes ............................. 326,446
Brake/Transaxle Interlock .................. 312
Break-In Recommendations, New Vehicle ........ 77
Brightness, Interior Lights .................. 152
Bulb Replacement ..................... 465,466
Bulbs, Light .......................... 81,465Calibration, Compass
.................. 219,228
Camera, Rear ........................... 92
Capacities, Fluid ........................ 472
Caps, Filler Fuel ................................ 372
Oil (Engine) .................. 418,419,420,427
Radiator (Coolant Pressure) ............... 442
Car Washes ............................ 452
Carbon Monoxide Warning ...............79,372
Cargo Area Cover ....................... 191
Cargo Area Features ...................... 188
Cargo Compartment ...................... 188
Light ............................ 151,188
Luggage Carrier ....................... 196
Cargo Light ............................ 151
Cargo Load Floor ........................ 188
Cargo Management System ................. 188
Rollaway Tonneau Cover ................. 191
Tri-Fold Load Floor ..................... 188
498 INDEX

Cargo Tie-Downs........................ 189
Cargo (Vehicle Loading) ................188,375
Catalytic Converter ...................... 429
CD (Compact Disc) Player ...............234,266
CD (Compact Disc) Player Maintenance ........ 284
Cellular Phone ..................... 93,266,267
Certification Label ....................... 375
Chains, Tire ............................ 355
Changing A Flat Tire ..................... 396
Charging System Light .................... 212
Chart, Tire Sizing ........................ 338
Check Engine Light
(Malfunction Indicator Light) ............... 422
Checking Your Vehicle For Safety ............. 78
Checks, Safety ........................... 78
Child Booster Seat ........................ 67
Child Restraint .................. 65,67,69,73,75
Child Restraint Tether Anchors .............71,73
Child Safety Locks ........................ 32 Clean Air Gasoline
....................... 369
Cleaning Wheels ............................. 454
Windshield Wiper Blades ................. 437
Climate Control ......................... 285
Clock ........................ 236,240,255,267
Coin Holder ........................... 183
Cold Weather Operation ................... 309
Compact Disc (CD) Maintenance ............. 284
Compact Spare Tire ...................... 349
Compass .............................. 227
Compass Calibration .................. 219,228
Compass Variance .................... 219,229
Computer, Trip/Travel .................... 226
Connector UCI ................................ 278
Universal Consumer Interface (UCI) ......... 278
Conserving Fuel ........................ 226
Console, Floor .......................... 183
INDEX 499
10