automatic transmission DODGE JOURNEY 2012 1.G Owner's Guide

WARNING! (Continued)
•To avoid contamination from foreign matter or
moisture, use only new brake fluid or fluid that
has been in a tightly closed container. Keep the
master cylinder reservoir cap secured at all times.
Brake fluid in a open container absorbs moisture
from the air resulting in a lower boiling point.
This may cause it to boil unexpectedly during hard
or prolonged braking, resulting in sudden brake
failure. This could result in a collision.
•Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts, causing
the brake fluid to catch fire. Brake fluid can also
damage painted and vinyl surfaces, care should be
taken to avoid its contact with these surfaces.(Continued)
WARNING! (Continued)
•Do not allow petroleum based fluid to contami-
nate the brake fluid. Brake seal components could
be damaged, causing partial or complete brake
failure. This could result in a collision.
Automatic Transmission
The automatic transmission and differential assembly are
contained within a single housing.
The fluid level in the automatic transmission should be
checked whenever the vehicle is serviced. Operation with
an improper fluid level will greatly reduce the life of the
transmission and the fluid.
7
MAINTAINING YOUR VEHICLE 525

Selection Of Lubricant
It is important that the proper lubricant is used in the
transmission to assure optimum transmission perfor-
mance. Use only manufacturer ’s recommended transmis-
sion fluid. Refer to “Fluids, Lubricants, and Genuine
Parts” in “Maintaining Your Vehicle” for further informa-
tion. It is important that the transmission fluid be main-
tained at the prescribed level using the recommended
fluid. No chemical flushes should be used in any trans-
mission; only the approved lubricant may be used.
Special Additives
Automatic Transmission Fluid (ATF) is an engineered
product and its performance may be impaired by supple-
mental additives. Therefore, do not add any fluid addi-
tives to the transmission. The only exception to this
policy is the use of special dyes to aid in detecting fluid
leaks. In addition, avoid using transmission sealers as
they may adversely affect seals.
CAUTION!
Do not use chemical flushes in your transmission as
the chemicals can damage your transmission compo-
nents. Such damage is not covered by the New
Vehicle Limited Warranty.
Fluid Level Check – 2.4L Engine
Use the following procedure to check the automatic
transmission fluid level properly:
1. Park the vehicle on level ground.
2. Run the engine at curb idle speed for a minimum of
60 seconds.
3. Apply the parking brake fully.
4. Place the shift lever momentarily in each gear position
ending with the lever in PARK.
526 MAINTAINING YOUR VEHICLE

CAUTION! (Continued)
•Dirt and water in the transmission can cause
serious damage. To prevent dirt and water from
entering the transmission after checking or replen-
ishing fluid, make certain that the dipstick cap is
re-seated properly.
Fluid Level Check – 3.6L Engine
The automatic transmission has no dipstick. Your autho-
rized dealer can check your transmission fluid level
using a special service dipstick.
Fluid And Filter Changes
Refer to the “Maintenance Schedule” for the proper
maintenance intervals
In addition, change the fluid and filter if the transmission
is disassembled for any reason.
Rear Drive Assembly (RDA) – AWD Models Only
Lubricant Selection
Use only the manufacturer’s recommended fluid. Refer
to “Fluids, Lubricants, and Genuine Parts” in “Maintain-
ing Your Vehicle” for further information.
Fluid Level Check
Visually inspect the unit at each oil change for leakage. If
leakage is detected, check the fluid level by removing the
fill plug. The fluid level should be maintained between
the bottom of the fill hole to 1/8 in (4 mm) below the fill
hole.
Add fluid, if necessary, to maintain the proper level.
Frequency Of Fluid Change
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
528 MAINTAINING YOUR VEHICLE

Chassis
ComponentFluid, Lubricant, or Genuine Part
Automatic Transmission MOPAR
ATF+4Automatic Transmission Fluid or equivalent licensed
ATF+4 product.
Power Transfer Unit (PTU) MOPARGear Lubricant 75W-90 or equivalent.
Rear Drive Assembly (RDA) MOPAR Gear Lubricant 75W-90 or equivalent.
Brake Master Cylinder MOPAR
DOT 3, SAE J1703 or equivalent should be used. If DOT 3 brake
fluid is not available, then DOT 4 is acceptable. Use only recommended
brake fluids.
Power Steering Reservoir MOPAR
Power Steering Fluid + 4, MOPAR ATF+4Automatic Trans-
mission Fluid or equivalent licensed ATF+4 product.
550 MAINTAINING YOUR VEHICLE

56,000 Miles (91,000 km) or
42 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate the tires, rotate at the first sign of
irregular wear, even if it occurs before
56,000 miles (91 000 km).
Odometer Reading Date
Repair Order #Dealer Code
Signature, Authorized Service Center
64,000 Miles (104,000 km) or 48 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before
64,000 miles (104 000 km).
❏ Replace the spark plugs (2.4L Engine).
❏ Replace the engine air cleaner filter.
❏ Replace the air conditioning filter.
❏ Inspect the brake linings; replace if necessary.
❏ Replace rear drive assembly (RDA) fluid.
❏ Replace power transfer unit (PTU) fluid.
❏ Change the automatic transmission fluid and filter(s) if using your vehicle for any of the
following: police, taxi, fleet, or frequent trailer towing.
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature, Authorized Service Center
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S558 MAINTENANCE SCHEDULES

120,000 Miles (195,000 km) or
90 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate the tires, rotate at the first sign of
irregular wear, even if it occurs before
120,000 miles (195 000 km).
❏ Inspect the CV joints.
❏ Inspect exhaust system.
❏ Change the automatic transmission fluid
and filter(s).
Odometer Reading Date
Repair Order #Dealer Code
Signature, Authorized Service Center
128,000 Miles (208,000 km) or 96 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before
128,000 miles (208 000 km).
❏ Replace the spark plugs (2.4L Engine).
❏ Replace the engine air cleaner filter.
❏ Replace the air conditioning filter.
❏ Inspect the brake linings, replace if necessary.
❏ Replace rear drive assembly (RDA) fluid.
❏ Replace power transfer unit (PTU) fluid.
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature, Authorized Service Center
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S562 MAINTENANCE SCHEDULES

Automatic Oil Change Indicator............. 291
Automatic Temperature Control (ATC) ......... 353
Automatic Transaxle Adding Fluid ....................... 550
Selection Of Lubricant ................. 550
Automatic Transmission ................372,525
Adding Fluid .................... 526,528
Fluid and Filter Changes ............... 528
Fluid Level Check ................. 526,528
Fluid Type ......................... 526
Gear Ranges ..................... 375,383
Special Additives ..................... 526
Autostick ............................. 390
Auxiliary Electrical Outlet (Power Outlet) ...... 242
Auxiliary Power Outlet ................... 242
B-Pillar Location ........................ 414
Back-Up Lights ......................... 544 Battery
............................... 507
Keyless Transmitter Replacement (RKE) ..... 24
Location ........................... 507
Belts, Seat ............................ 46,92
Body Mechanism Lubrication ............... 512
Booster Seat ............................ 78
Brake Assist System ...................... 403
Brake Control System, Electronic ............. 400
Brake Fluid ............................ 550
Brake System ........................ 399,523
Anti-Lock (ABS) ..................... 400
Fluid Check ..................... 524,550
Master Cylinder ..................... 524
Parking ........................... 396
Warning Light ....................... 279
Brake, Parking .......................... 396
Brake/Transmission Interlock ............... 374
Brakes ............................. 399,523
Break-In Recommendations, New Vehicle ........ 89
10
INDEX 579

Delay (Intermittent) Wipers................. 209
Diagnostic System, Onboard ................ 499
Dimmer Switch, Headlight ................. 206
Dipsticks Automatic Transmission .............526,528
Oil (Engine) ........................ 503
Power Steering ...................... 395
Disabled Vehicle Towing ................... 490
Disposal Antifreeze (Engine Coolant) ............. 521
Engine Oil ......................... 506
Door Locks ............................. 29
Door Locks, Automatic .................... 31
Door Opener, Garage ..................... 230
Driving On Slippery Surfaces .................. 392
Through Flowing, Rising, or Shallow
Standing Water ...................... 393
Driving to Achieve Maximum Fuel Economy .... 292E-85 Fuel
............................. 443
Electric Remote Mirrors ................... 103
Electrical Outlet, Auxiliary (Power Outlet) ...... 242
Electrical Power Outlets ................... 242
Electronic Brake Control System ............. 400
Anti-Lock Brake System ................ 400
Brake Assist System ................... 403
Electronic Roll Mitigation ............... 404
Electronic Stability Program ............. 405
Traction Control System ................ 403
Electronic Roll Mitigation (ERM) ............. 404
Electronic Speed Control (Cruise Control) ...... 213
Electronic Stability Program (ESP) ............ 405
Electronic Vehicle Information Center
(EVIC) ............................. 225,282
Emergency, In Case of Freeing Vehicle When Stuck ............. 487
Hazard Warning Flasher ............... 469
Jacking ............................ 471
582 INDEX

Exterior Light Service..................... 542
Exterior Lighting ........................ 202
Exterior Lights ........................ 94,542
Fabric Care ............................ 532
Filler Location Fuel .................... 281,447
Filters Air Cleaner ......................... 506
Air Conditioning .................. 360,510
Engine Oil ....................... 506,549
Engine Oil Disposal ................... 506
Flash-To-Pass ........................... 206
Flashers Hazard Warning ..................... 469
Turn Signal .................... 94,205,276
Flexible Fuel Vehicles Cruising Range ...................... 446
Engine Oil ......................... 446
Fuel Requirements ................. 443,445Maintenance
........................ 447
Replacement Parts .................... 447
Starting ........................... 446
Flooded Engine Starting ................... 371
Floor Console .......................... 251
Fluid Capacities ......................... 548
Fluid Leaks ............................. 94
Fluid Level Checks Automatic Transmission .............526,528
Brake .......................... 524,550
Cooling System ...................... 518
Engine Oil ......................... 503
Power Steering ................... 395,550
Fluid, Brake ........................... 550
Fluids ................................ 549
Fluids, Lubricants and Genuine Parts .......... 549
Fog Light Service ........................ 543
Fog Lights ....................... 204,276,543
Folding Rear Seat ..................... 190,197
584 INDEX

Shoulder Belts........................... 46
Side Airbag ............................. 70
Side View Mirror Adjustment ............... 102
Signals, Turn ................... 94,205,276,544
Slippery Surfaces, Driving On ............... 392
Snow Chains (Tire Chains) ................. 427
Snow Tires ............................ 429
Spare Tire ....................... 422,423,472
Spark Plugs ............................ 549
Specifications Fuel (Gasoline) ...................... 549
Oil ............................ 504,549
Speed Control (Cruise Control) .............. 213
Speedometer ........................... 281
Starting ............................. 25,368
Automatic Transmission ................ 368
Cold Weather ....................... 370
Engine Fails to Start .................. 371
Remote ............................ 25 Starting and Operating
.................... 368
Starting Procedures ...................... 368
Steering Column Controls ..................... 205
Column Lock ....................... 212
Power ............................ 395
Tilt Column ........................ 212
Wheel, Tilt ......................... 212
Steering Wheel Audio Controls .............. 342
Steering Wheel Mounted Sound System
Controls .............................. 342
Storage ............................... 251
Storage, Vehicle ......................... 360
Stuck, Freeing .......................... 487
Sun Roof .............................. 239
Sun Visor Extension ...................... 105
Sunglasses Storage ....................... 228
Sunroof Maintenance ..................... 242
Supplemental Restraint System - Airbag ........ 61
10
INDEX 595