window DODGE MAGNUM SRT 2008 1.G Service Manual

•Guard against carbon monoxide with proper mainte-
nance. Have the exhaust system inspected every time
the vehicle is raised. Have any abnormal conditions
repaired promptly. Until repaired, drive with all side
windows fully open.
•Keep the trunk/liftgate closed when driving your
vehicle to prevent carbon monoxide and other poison-
ous exhaust gases from entering the vehicle.
ADDING FUEL
Fuel Filler Cap (Gas Cap)
The gas cap is located behind the fuel filler door on the
left side of the vehicle. Push in on the left side (near the
edge) of the fuel filler door to access the fuel filler cap. If
the gas cap is lost or damaged, be sure the replacement
cap is for use with this vehicle.NOTE:When removing the fuel filler cap, lay the cap
tether in the hook, located on the fuel filler cap door
reinforcement.Fuel Filler Door
STARTING AND OPERATING 341
5

▫Power Steering — Fluid Check............394
▫Front And Rear Suspension Ball Joints......394
▫Steering Linkage......................395
▫Body Lubrication.....................395
▫Wiper Blades........................395
▫Windshield Washers/Rear Window Washer . . . 396
▫Exhaust System......................396
▫Cooling System.......................397
▫Hoses And Vacuum/Vapor Harnesses.......402
▫Fuel System.........................403
▫Brake System........................403
▫Automatic Transmission................406
▫Front And Rear Wheel Bearings...........407▫Appearance Care And Protection
From Corrosion......................408
▫Cleaning The Center Console Cupholders....412

Fuses (Power Distribution Centers)..........413
▫Fuses (Front Power Distribution Center).....413
▫Fuses (Rear Power Distribution Center)......415

Vehicle Storage........................420

Replacement Light Bulbs.................420

Bulb Replacement......................421
▫Low Beam Headlight, High Beam Headlight, And
Park/Turn Light — Models With Halogen
Headlights..........................421
▫Low Beam Headlight, High Beam Headlight, And
Park/Turn Light — Models With High Intensity
Discharge Headlights (HID)..............423
378 MAINTAINING YOUR VEHICLE

Steering Linkage
The tie rod end ball joints should be inspected for
external leakage or damage when other maintenance is
performed.
Body Lubrication
Locks and all body pivot points, including seat tracks,
door hinges, liftgate hinges, and hood hinges, should be
lubricated periodically to assure quiet, easy operation
and to protect against rust and wear. Prior to the appli-
cation of any lubricant, the parts concerned should be
wiped clean to remove dust and grit; after lubricating,
excess oil and grease should be removed. Particular
attention should also be given to hood latching compo-
nents to ensure proper function. When performing other
underhood services, the hood latch, release mechanism,
and safety catch should be cleaned and lubricated.
The external lock cylinders should be lubricated twice a
year, preferably in the Fall and Spring. Apply a smallamount of a high quality lubricant such as MoparLock
Cylinder Lubricant or equivalent directly into the lock
cylinder.
Wiper Blades
Clean the rubber edges of the wiper blades and the
windshield and rear window periodically with a sponge
or soft cloth and a mild nonabrasive cleaner. This will
remove accumulations of salt or road film.
Operation of the wipers on dry glass for long periods
may cause deterioration of the wiper blades. Always use
washer fluid when using the wipers to remove salt or dirt
from a dry windshield or rear window.
Avoid using the wiper blades to remove frost or ice from
the windshield or rear window. Keep the blade rubber
out of contact with petroleum products such as engine
oil, gasoline, etc.
MAINTAINING YOUR VEHICLE 395
7

Windshield Washers/Rear Window Washer
The windshield washer and the rear window washer
share the same fluid reservoir. The fluid reservoir is
located in the front of the engine compartment. Be sure to
check the fluid level in the reservoir at regular intervals.
Fill the reservoir with windshield washer solvent (not
radiator antifreeze) and operate the system for a few
seconds to flush out the residual water.
When refilling the washer fluid reservoir, apply some
washer fluid to a cloth or towel and wipe the wiper
blades clean. This will help blade performance.
To prevent freeze-up of your windshield washer system
in cold weather, select a solution or mixture that meets or
exceeds the temperature range of your climate. This
rating information can be found on most washer fluid
containers.The fluid reservoir will hold 1 gal (4 l) of washer fluid
when the message “Low Washer Fluid” appears in the
Electronic Vehicle Information Center (EVIC).
WARNING!
Commercially available windshield washer solvents
are flammable. They could ignite and burn you. Care
must be exercised when filling or working around
the washer solution.
Exhaust System
The best protection against carbon monoxide entry into
the vehicle body is a properly maintained engine exhaust
system.
Whenever a change is noticed in the sound of the exhaust
system, when exhaust fumes can be detected inside the
vehicle, or when the underside or rear of the vehicle is
396 MAINTAINING YOUR VEHICLE

WARNING!
Do not use volatile solvents for cleaning purposes.
Many are potentially flammable, and if used in
closed areas they may cause respiratory harm.
Cleaning Headlights
Your vehicle has plastic headlights that are lighter and
less susceptible to stone breakage than glass headlights.
Plastic is not as scratch resistant as glass and therefore
different lens cleaning procedures must be followed.
To minimize the possibility of scratching the lenses and
reducing light output, avoid wiping with a dry cloth. To
remove road dirt, wash with a mild soap solution fol-
lowed by rinsing.
Do not use abrasive cleaning components, solvents, steel
wool or other aggressive material to clean the lenses.
Glass Surfaces
All glass surfaces should be cleaned on a regular basis
with MoparGlass Cleaner or any commercial
household-type glass cleaner. Never use an abrasive type
cleaner. Use caution when cleaning the inside rear win-
dow equipped with electric defrosters or the right rear
quarter window equipped with the radio antenna. Do
not use scrapers or other sharp instrument that may
scratch the elements.
When cleaning the rear view mirror, spray cleaner on the
towel or rag that you are using. Do not spray cleaner
directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
MAINTAINING YOUR VEHICLE 411
7

Cavity Car-
tridge
FuseMini-
FuseDescription
34 — — —
35 — 5 Amp
OrangeAntenna Module - if
equipped/Power Mir-
rors
36 — 20 Amp
YellowHands-Free Phone - if
equipped/Video Moni-
tor - if equipped/Radio
37 — 15 Amp
BlueTransmission
38 — 10 Amp
RedCargo Light/Satellite
Receiver (SDARS) Video
- if equipped/Vehicle
Information Module - if
equipped
39 — 10 Amp
RedHeated Mirrors - if
equippedCavity Car-
tridge
FuseMini-
FuseDescription
40 — 5 Amp
OrangeAuto Inside Rearview
Mirror/Heated Seats - if
equipped/Switch Bank
41 — 10 Amp
RedAC Heater Control/
Headlights/Tire Pres-
sure Monitoring - if
equipped
42 30 Amp
Pink— Front Blower Motor
43 30 Amp
Pink— Rear Window Defroster
44 20 Amp
Blue— Amplifier - if equipped/
Sunroof - if equipped
*Cavities 11, 12, and 13 contain self-resetting fuses
(circuit breakers) that are only serviceable by an autho-
rized dealer. The cluster and the driver SEAT switch are
MAINTAINING YOUR VEHICLE 419
7

fused by the 25-amp circuit breaker in cavity 11. The
passenger SEAT switch is fused by the 25-amp circuit
breaker in cavity 12. The door modules, the driver power
WINDOW switch, and the passenger power WINDOW
switch are fused by the 25-amp circuit breaker in cavity
13. If you experience temporary or permanent loss of
these systems, see your authorized dealer for service.
VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days, you may want to take these steps to protect your
battery.
•Disconnect the negative cable from the battery.
•Anytime you store your vehicle, or keep it out of
service (i.e., vacation) for two weeks or more, run the
air conditioning system at idle for about five minutes
in the fresh air and high blower setting. This willensure adequate system lubrication to minimize the
possibility of compressor damage when the system is
started again.
REPLACEMENT LIGHT BULBS
LIGHT BULBS — Interior Bulb Number
Rear Courtesy/Reading Lights.............. W5W
Rear Compartment (Liftgate) Light............ 578
Overhead Console Reading Lights............. 578
Visor Vanity Lights.....................A6220
Glove Box Light......................... 194
Door Courtesy.......................... 562
Shift Indicator Light................. JKLE14140
Optional Door Map Pocket / Cupholder
Lighting........ LED(ServicedatAuthorized Dealer)
NOTE:For lighted switches, see your authorized dealer
for replacement instructions.
420 MAINTAINING YOUR VEHICLE

About Your Brakes....................295,297
ABS (Anti-Lock Brake System)............297,301
Adding Engine Coolant (Antifreeze).......... 399
Adding Fuel........................... 341
Adding Rear Washer Fluid................. 270
Adding Washer Fluid...............135,270,396
Additives, Fuel......................... 339
Adjustable Pedals....................... 137
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 388
Air Conditioner Maintenance............... 392
Air Conditioning.....................258,260
Air Conditioning Controls................. 258
Air Conditioning Filter.................267,393
Air Conditioning, Operating Tips............ 268
Air Conditioning Refrigerant.............392,393
Air Conditioning System.............258,260,392
Air Pressure, Tires....................182,317
Airbag................................ 48
Airbag Deployment..................... 55,58Airbag Light..................... 56,61,76,178
Airbag Maintenance....................... 60
Airbag, Side.......................... 50,56
Airbag, Window (Side Curtain)............. 50,56
Alarm, Panic............................ 22
Alarm (Security Alarm)................. 18,181
Alarm System (Security Alarm)............... 18
Alignment and Balance................... 323
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 243
Antifreeze (Engine Coolant)...........398,399,429
Disposal............................ 401
Anti-Lock Brake System (ABS)............297,301
Anti-Lock Warning Light...............184,299
Anti-Theft Security Alarm (Theft Alarm)........ 18
Anti-Theft System....................... 181
Appearance Care........................ 408
Arming Theft System (Security Alarm)......... 18
Assistance Towing....................... 100
452 INDEX

Audio Systems (Radio).................205,225
Auto Down Power Windows................ 33
Auto Unlock, Doors....................... 29
Auto Up Power Windows.................. 33
Automatic Dimming Mirror................. 83
Automatic Door Locks................... 28,29
Automatic Headlights.................... 127
Automatic Temperature Control (ATC)......... 260
Automatic Transaxle
Special Additives...................... 407
Automatic Transmission.............285,406,407
Adding Fluid......................407,431
Autostick.........................288,290
Fluid and Filter Changes................. 407
Fluid Change......................... 407
Fluid Level Check...................... 406
FluidType ........................... 431
Shifting ............................. 285
Special Additives...................... 407Automatic Transmission Limp Home Mode . . 289,290
Autostick ...........................288,290
AxleFluid ............................. 431
Axle Lubrication (Axle Fluid)............... 431
BallJoints ............................. 394
Battery............................... 390
Emergency Starting..................... 371
Jump Starting......................... 371
Keyless Transmitter Replacement (RKE)....... 23
Location..........................371,391
Bearings.............................. 407
Belts,Drive ............................ 387
Belts, Seat............................ 39,76
Body Mechanism Lubrication............... 395
B-Pillar Location........................ 312
Brake Assist System...................... 302
Brake Control System, Electronic............. 300
Brake Fluid............................ 431
INDEX 453
10

Selection of Coolant (Antifreeze)......398,429,430
Corrosion Protection..................... 408
Cruise Control (Speed Control).............. 138
CruiseLight ........................... 175
CupHolder .........................155,412
Customer Assistance..................... 443
Data Recorder, Event...................... 61
Daytime Brightness, Interior Lights........... 132
Daytime Running Lights................... 129
Dealer Service.......................... 384
Defroster, Rear Window................... 271
Defroster, Windshield................ 76,259,265
Delay (Intermittent) Wipers..............133,269
Diagnostic System, Onboard................ 381
Digital Video Disc (DVD) Player..........205,225
Dimmer Switch, Headlight................. 130
Dipsticks
Oil (Engine).......................... 385Disabled Vehicle Towing................... 375
Disposal
Antifreeze (Engine Coolant)............... 401
Engine Oil........................... 387
Door Locks............................. 27
Door Locks, Automatic.................... 28
Door Opener, Garage..................... 143
DriveBelts ............................ 387
Driving
On Slippery Surfaces.................... 292
Through Flowing, Rising, or Shallow
Standing Water......................... 293
DVD Player (Video Entertainment System)...... 247
Electric Remote Mirrors.................... 85
Electrical Power Outlets................... 153
Electronic Brake Control System............. 300
Electronic Power Distribution Center (Fuses).... 413
Electronic Speed Control (Cruise Control)...... 138
456 INDEX