lock DODGE MONACO 1965 1.G Owners Manual
[x] Cancel search | Manufacturer: DODGE, Model Year: 1965, Model line: MONACO, Model: DODGE MONACO 1965 1.GPages: 46, PDF Size: 8.12 MB
Page 4 of 46
fOR MORE INfORMATION SEND THIS POSTCARD
If you would like more information about the use. care and maintenance of your new Coronet. Dart or Dodge Polara. 880. Monaco, the following Shop Manuals are available . Please check appropri ate box .
o 1965 Dodge Coronet and Dart Combined Technical Service Manual, 81-270-5250
o 1965 Dodge PoIara, 880, Monaco Technical Service Manual, 81-270-5280
(15.00 ElIch , PO&t~id in U.S .A .) . Send check or Please allow 30 money order (no stamps , please) with this card to: days for delivery.
CHIYSlEI COIt'OIATION , DODGE DIVISION, SEIVICE DEPAITMENT
P .O . lOX 1259, DETIOIT , MICHIGAN 41231
You,nam.~ ____________________________________________________________ ___
Addr"I~ ____________________________________________________________ _
City Zone State
Perhaps you have a friend or relative who would like to receive literature about the beautiful new Dart. Dodge Coronet or Dodge PolaTa . 880 . Monaco . If so. please give his name and address and check the appropriate box. You, Deal.,'. Nam. ________________________________ Name ______________________________ __
AddnK.L-_____________________________ Add,~~ __________________________ ___
Oty ____________ ~UM'Ie___Stote Oty ______________ ~ ... e___S tClte ________ _
[J DODGE DAIT 0 DODGE CORONET 0 DODGE POlAIA, 880, MONACO
page I. 14 ~ Closing Controls .......... 15 oar locks ........... 15 r locks ........ 15 ompartment lock. . .. 15 Dr locks.. .......... 15 ontrol .... 16 ow control ......... 16 dow ............... 16
fort and ce Features t adjustment ...... 17 d wipers and washer. 17 partment ........ 17 e steering wheel. . . .. 19
mirrors at adjustment.. .. rake warning signal .. y warning flasher. ... er ..
17 18
18
19 19
19
19
19
s 20 ........... 20
page refueling . ... . . 20 Cool Aire air conditioning 20 radios. . . . 21 rear seat speaker........ . .. 21 reverberator . .. . . 21 remote·control outside mirror. 21 Heater Operation . ..... .. 22 Air Conditioner Operation 23 Station Wagon Features seat storage ...... 26 tailgate and rear window ... . 27 jack and spare tire storage ... 28 Convertible Top-Operation and Maintenance 29 How to Increase Tire life 30 The Safe Way to Change a Wheel 31 Appearance Care . . 32 Service Ti ps .... ... ... 35 Specifications, Capacities & Data license data .. 41 fluid capacities 41 light bulbs 41 light fuses. 41 engine specifications .. 41
1
Page 5 of 46
YOU'LL WANT
TO KNOW
TillS manual Includes oper~tln\~ In
struetlons lor all equipment .'.hether
st'lldMd, optional, or specl;]1 avail
able at tile time tillS r1i.1 11 U.1 I ,'.~S
approved for prlllting. Cilryslrl Cor
poratloll reserves ti'e r',111 10 rmke
(Ilanges 111 deSign and speuflcallolls,
.1nd or, to make additions to or
Illlprovcmcllts III Its produCI ,'.Ii iloul
ImposlIl,
.111\' OIJII,~IIOIlS UpOIl Itself
10 Illslall tile'" all lis produrts
previously nlililuidclured
page Warranty. . . . . . .. . ........ , . 2 Explanation of Warranty. . . . . . .. 3 Service Schedule .... ' ..... , 4 Owner's Required Services Record. . . 6 Let's Get AcqUainted keys. .. ............ ,. 7 manual seat adjustment. . . . .. 7 rear-view mirror. . . .. .. .. . . .. 7 Driver-Centered Instrumentation 8 I nstrument Cluster Details. , 9 Starting the Engine neutral. . .. .,.............. 10 ignition lock. . . . • . . .. 10 parking brake. . . .. ....•.... 10 break-in information ......... 11 Transmission automatic transmission operation and ranges ....... 12 manual transmission operation. 13 Ughts-I nside and Out head light switch ............. 14 interior lights ........ , . , ..... 14 head light beam selector. . . . 14 back-up lights. . . . . . . . . . . . . .. 14 turn signal .. , . . . . . . . . . . . . . .. 14 glove compartment light. . . . .. 14
page trunk light.. .. . .. , .... ,... 14 Opening and Closing Controls hood lock .... " ......... , 15 outside door locks . ,. ., ... 15 inside door locks, .. .,...... 15 luggage compartment lock. . .. 15 power door locks. , .. . . . . . . . .. 15 window control . .. . _ . . .. 16 vent window control.. . . . . . . .. 16 power window. , ... ' . . . . . . 16
Safety, Comfort and Convenience Features power seat adjustment 17 windshield wipers and washer. 17 glove compartment. . . . . . . . . . . 17 adjustable steering whee\. .... 19 sun visors... . . . . .. .. ....... 17 clock .................... 18 seat belts. ...... ... 18 rear view mi rrors .. .. . .. , 19 custom seat adjustment. . , .... 19 parking brake warning signal., 19 emergency warning Hasher. . . 19 ash receiver ................ 19 coat hooks .. .. . .. .. .. .. ... 20 Auto Pilot. ............. , 20
page refueling . . 20 Cool Aire air conditioning 20 radios .. , .... ,.... .. 21 rear seat speaker ............ 21 reverberator . 21 remote-control outside mirror .. 21 Heater Operation . . 22 Air Conditioner Operation . 23 Station Wagon Features seat storage.. .... .... . 26 tailgate and rear window .. .. 27 jack and spare tire storage .... 28 Convertible Top-Operation and Maintenance ... , . . , ., 29 How to Increase Tire Life .... . 30 The Safe Way to Change a WheeL ........... ,.... . .. 31 Appearance Care ... ' . 32 Service Tips, . . . . . . 35 Specifications, Capacities & Data license data , .. , ............ 41 fluid capacities. 41 light bulbs. . . . . . . . 41 lightfuses. . . . . .. .. . 41 engine specifications. 41
Page 6 of 46
2
MANUFACTURER'S PASSENGER CAR WARRANTY
Chrysler Corporation, as manufacturer, warrants each new passenger cor manufactured by it , including all equipment or accessories (except tires) manufactured or supplied by it, to be free from defects in material and workmanship under normal use and service for twelve thousand (12,000) miles of operation or twelve (12) months after delivery to the original purchaser, whichever event occur. Arst.
In addition, Chrysler Corporation warranls the engine block, head and all internal engine parts, waler pump, intake manifold, transmission case and all internal trans· mission parts, torque converter (if so equipped), drive shaft, universal joints, rear axle and differential, and rear wheel bearings of each new passenger cor manufaetur d by il to be free from defects in material and workmanship under normal use and service for fifty thousand (SO,OOO) mile. of operation or five (5) years art r d IIv ry to th original purchaser, whichever event occurs n .. t. A I an expre .. conditi on o f this warranty coverao., ,h. own., II requir . d ,A hav. th. engl"e all changed evolY three m onlhl Or four thoulond mile., w h hev.r "'eI n"t, 'he engi ne all nlt.r repla .d every II and all and Ihe ,arburetor air nlt~ I."ned eyery .1 and r.ploced every Iwo yeu,., "I. , m
ont hl 'h e
owner II requir e d to furnllh a Ch rysl.r Molars Carpora'ion Au'h orl%ed Dealer evidence that the above main'enance leryi,el have b.en performed a nd requel' 'he d ealer to ,ertily on 'he form supplied w ilh the vehicle (I) 'hat h e ha l received lu ch ev idence, a nd
(ii) the c ar'. Ihen ,urrenl odomeler mileage. This addi· tional warranly coverage does no' include or apply to related systems or accessory un lis such as Ignition or etec· trical sys'ems, fuel or cooling systems, engine or transmis· sion controls or linkage, manual gear shift lever and clvld! assembly or any port of the brake assemblies, wheels or tires.
Chrysl r
Corporation's obligation under this warranty i. limit d to r pairing or replacing, at its option, any pori or ports of th pass ng r Car that prove to be defective within the applicable provlJions of this warranty. Service under thl, warranty .hall b p do,m d by any Chrysler Motors arpa,o" II AUlhali. d D 01 r, at the dealer', place of bu,l" ", w,lh I (horllo f r r plae m nl parts or labor.
'" I w""""ty ""Ii II t ",Iply 10 any pass nger car Ihot
hllll h"~ t. II luhl C I I m lU' , n 0110 ne or accident, " .. , I,; ""1' I"'''~''U , C III Iho' Iholt hav b n r paired or 1111 I .1 .",,,.t .. ,,, (IllY I , M 10" Co'poration AUlhar . I, .1 II III , UI "., til to ull ct ad. n II' its
performance and reliabilit
y nor to any repairs or .ervic.
ing required 01 a re.ult of u.ing ports no t sold or opprov d by Chrysler Corporation. AI.o, this warrant y does not apply to paris replacements, mechanic04 adju stments, repoirs 0 1 other servicing normally mode or required as mai ntenanc , such as replacing spark plugs, condensers, igni tion polnh,
filters, etc., or performing wheel alignments, wheel balane ing, brake adjustments, engine lune·ups, cleaning fu I sys tem, etc .
This warranty is the an'y warranty applicable to po. •• ng., carl manufactur.d by Chry sl er Corporation and is .xpress'y in fieu of any warranties otherwise implle " by low (i ncluding, but not limited to, implied Waf ,anties of merchanlability o r fIIness for a partlcula, purpose). Th e re m edies under .his warranty Ihall b. Ihe only r e m edies available to any owner thereol f other perso n, and neither ChrY ller Carparalion, ChrY,'.f Motor. Corporation nor 'he authorhe d sefllng de"I., assumes a ny o.her obligation o r responsibility with respect to the condition of 'he passengor car, an" neither assumes, nor authorizes anyone to assum_ , , any of them, any additiona' liability in canna Ii .. . herewith.
Page 11 of 46
LET'S GET ACQUAINTED
o A WORD ABOUT YOUR KEY
You will find a small metal tag attached to each set of keys. Stamped on this tag is an
identifying number which you should record
so that in the event of loss you can order
dup!icate keys from your dealer or a reputable locksmith. After recording the numbers, the tag should be destroyed. I f you did not
receive a tag with your keys, ask your dealer to give you the numbers.
LET' GET ACQUAINTED
Take your seat behind the wheel and with the aid of this manual we suggest you famil
iarize yourself with the many features bUilt
into your new car.
The first thing you may want to do is adjust
the front seat to your liking and move the rear-view mirror for safe visibility.
e EAT ADJU TMENT (manual).
The adjusting lever, located at the left of the front seat cushion, at your left hand near the
floor, releases the seat so you can slide it forward or backward with your body weight
to the position that's most suitable. It will lock in the new position when the lever is released. See page I7 for adjustment of power seal.
REAR-VIEW MIRROR
The ball-and-socket mounting of this mirror prevents vibration, yet adjusts easily. Its central location enables you to view traffic
conditions with a quick, safe glance.
Page 17 of 46
AUTOMATIC TRANSMISSION '
The pointer on the indicator in the instrument panel cluster indicates the gear range the
transmission is in. (With a Console the
indicator is on the Console panel, located on the floor at the driver's right.) The Selector Lever is mounted on the right side of the
steering column. Pull the lever toward you and move it to the desired gear range. Gear
ranges are as follows:
"P" Parking. Supplements parking brake by
locking the transmission. Engine' can be
started in this range. Never use " P " while
car is in motion. Always apply parking brake while in this range.
"R" Reverse. Place your foot on the brake
pedal before selecting this range. An auto· matic safety control makes it impossible to
shift into Reverse at forward speeds above 10 miles per hour.
"N " Neutral. Use when car is standing at idle for prolonged period with engine running.
12 Engine can be started in this range.
"0 " Drive. For most city and highway driving.
"2" Second. For driving slowly in heavy city
traffic or on mountain roads where more precise speed control is desirable. Use it also when climbing long grades, and for "engine
braking" when descending moderately steep grades.
CAUTION:
To prevent IICes s engine speed do not ex·
ceed 60 miles per hour In this range.
" 1" First. For driving up very steep hills and for "engine braking" at low speeds (25 miles
per hour or less) when going down. In snow,
sand or mud, car can often be moved by alternately moving from Drive and Reverse with the accelerator slightly depressed to
achieve a "rocking motion.
CAUTION:
To prevent excess engine speed do not ex
ceed 40 miles per hour In this range.
Towing. For short distances put transmission in Neutral, but don't exceed 35 mph. For long distances (more than 100 miles), or If the transmiSSion is not operative, the car should be towed with rear wheels off the ground or with the propeller shaft disconnected.
Assist Starting Procedure (Automatic and Manual Transmission). Your battery must contain an adequate charge to provide prompt starting power to the engine. If it does not, it may require "boosting" by transferring power t o it from a fully-charge battery. When this is done the negative cable on the charging battery must be attached only to the negative (- ) post, and positive (+ ) to positive. Each post IS stamped on top. This precaution will prevent possible wiring damage to your car.
Assist starting can also be done by having the car pushed from behind. Make sure the bumpers on both cars align properly. If you have an automatic transmission put the selector lever in "N" (neutral) and when you have been pushed to about 15 mph, turn the ignition key to "On", press the accelerator pedal about half-way down and move the selector lever to "I" (first) gear. When the engine starts shift to "0" (drive) gear.
With a m anual transmission, press the clutch pedal and hold it there; then shift to Second or High gear. When a speed of about 10 mph is reached, press the accelerator pedal, turn the ignition key to "On" and slowly release the clutch pedal and engine should start.
Do not get an assist start by having t h e cal towed as it could be damaged by being thrust forward suddenly when the engine starts.
Page 20 of 46
,
OPENING AND CLOSING CONTROLS
O To Open Hood. Push up release lever under leading edge of hood and push up safety catch located to the right This unlatches hood and it can be lifted easily. To close hood, lower to engage safety catch, then • press down firmly to lock. ~ Outs/de Door Locks. Use key with U square end and insert with notches up. To unlock, turn key toward front of car. To lock, turn it toward rear of car. The key can be removed after turning it back to vertical. Both front doors, if locked before closing, will automatically unlock when shut This feature prevents locking yourself out of the car with the keys inside. ~ Inside Door Locks. Front: Be sure door ~ is securely closed. Push down on button located on window moulding to lock door. To unlock, pull button up or pull door handle backward. Rear: With the rear doors either open or closed, push down on the button located on window moulding to lock door. To unlock, pull button up. Rear door cannot be unlocked by pulling door handle, a safety feature to prevent accidental unlocking by children. A LUIIPII' Compartment. Use key with ~ round end and insert with notches up. To unlock, turn key to right and counter-
balanced lid will raise easily. The lid will lock itself when closed, whether or not the key is in the lock. Always check before closing to be sure keys are not left inside compartment Power Door Locks. All four doors can be locked at one time from either inside or outside the car, by pushing a button or turning a key. From the inside all four doors are locked automatically by pushing the button on either front door window mOUlding. Pulling up either button unlocks all doors. From the outside all four doors can be locked at one time by using the key in the normal manner in either front door. The car is unlocked in the normal manner with the key unlocking only the door it is used on.
15
Page 22 of 46
SAFETY, COMFORT
AND CONVENIENCE FEATURES
O Windshield Wipers. The wiper blades are specially designed to counteract windlift, providing better cleaning and safer visibility. Turn the knob to right to operate wipers. If equipped with optional Variable Speed wipers, turn knob further right to increase speed.
Windshield Washers. Push windshield wiper knob in to spray fluid on windshield. Fluid will spray as long as knob is held in, enabling you to use just the amount needed for a good cleaning job. During very cold weather it might be wise to operate the defroster a few minutes to assure clear vision through the windshield. MoPar All-Weather Windshield Washer Solvent used with water a ids cleaning action, prevents line clogging or freezing of fluid. ~ Glove Compartment. Convenient for ~ maps, sun glasses and other small items. Use key with round end and insert
with notches up_ To lock, turn key to right
Push button to open. In addition to the glove compartment, Monaco models are equipped with a handy package
storage in the console between the bucket seats. To open, simply press the latch button.
Storage can be locked with the round-end key. ~ 6-Way Power Seat Adjustment (Bench ~ Seat). The control at the left of the front seat cushion moves the seat auto· matically in several posit ions for indiviOual comfort. On long drives this feature enables you to change position occasionally for the comfort of you and your passenger. DO NOT put packages or other articles under front seat, since they could be damaged, or cause damage to seat controls. 4-Way Power Seat Adjustment (Bucket Seat) · Two switches at the left of the front seat cushion moves the seat automatically to the desired position. One switch moves the seat forward & backward; the other switch raises or lowers the seat. Sun Visors. Sun glare through the e windshield or front windows can be controlled by tilting or swinging the visor downward or outward. Pull out o f retaining bracket before moving to side. Optional padded safety sun visors are available from your Dealer to protect head and face in case of sudden stops.
Page 24 of 46
Resulting color mav rub off and webbing strength may be affected.
o Adjustable Steering Wheel. Steering wheel can be moved to any of seven different positions. It can be moved away from the lap area when entering or leaving the car. It can be adjusted to suit the comfort of any SIZe driver. Changing the wheel position on long trips helps relieve fatigue. To adjust the wheel, simply hft up the small lever adjacent to the turn signal control, move the wheel up or down, as desired, and release the lever to lock the wheel firmly in place. Wheel position may be changed while driving.
~ Prismatic Day and Night Mirror. Annoy-ing and dangerous headlight glare-back when driving at night can be elimmated by moving the small lever under the mirror, pictured here. o Six-Way Custom Seat Adjustment. Your front seat track can easily be adjusted In a variety of positions by your Dealer or yourself to suit your personal requirements. It will adjust forward or back, up or down and its tilt can be changed to provide maximum comfort. The manual seat movement
lever may still be used to obtain the desired forward or backward positions.
Q Parking Brake Warning S ignal. Red light in parking brake release lever blinks red when engine is running with parking brake on. Prevents unnecessary brake wear.
Emergency Warning Flasher. This flasher system protects you during emergency stops on the highway at night. By pu lIing a switch on the instrument panel, front' and rear directiona I signals flash intermittently to warn on-coming cars in both lanes. Flasher will operate with the ignition off, permitting driver \0 lock car in the event it is necessary to leave for assistance.
41) Ash Receivers and Lighter. Separate ash receivers for driver and passenger are provided on the lower edge of the instrument panel. Pressure on the tab at the rear enables the ash receiver to be removed for cleaning. On some models an ash receiver is Installed on the front seat back lor the convenience of rear seat passengers.
A lighter is located next to the driver's ash receiver. Push in the knob, but don't hold it. When heated, it will pop out automatically. An ash receiver in Monaco models is provided in rear end of Console.
AOJUSTING BOLT
1
Page 26 of 46
-
RADIO
&Ii. Push-Bullon "AM": Ignition sWitch ~ must be at "On" or "Acc" position to operate.
This transistorIZed radio plays the moment you turn the left-hand knob clockwise to "On" posItion. This same knob adjusts the volume. Tone control ring, behind left knob, provides selection of tone quality. Stations can be tuned by pressing the push-buttons fully in or by turning the knob at right.
NOTE: For best reception With this radiO adjust the antenna height to 40".
NOTE: Radios designed for Chrysler Corporation automobiles are Identified by the car name appearing on either the radio dial lens or the control panel.
To Set Push Bullons: Permit radio to warm up for at least 10 minutes with antenna fully extended to recommended height. Pull out a bullon and, using manual tuning knob, carefully tune In a desired station. Press bullon firmly into lock station. This same procedure is used for selling the remaining buttons.
"fM/ AM" Radio: ThiS transistorIZed radio plays the moment you turn the left-hand knob clockWise to "On" posItion. ThiS same knob adjusts the volume. Tone control ring, behind left knob, prOVides selection of tone quality. Stations can be tuned by preSSing the push·buttons fully In or by turning knob at right.
You can enjoy either FM or AM reception by rotating the selector SWitch ring, located behind the tUning' knob at right, to the deSired band of operation.
NOTE: For best FM reception adjust antenna height to 31"; adjust to 40" for AM reception. The FM/AM band indication appears on the radiO dial. When changing bands, the dual purpose of thiS radiO does not permit pushbuttons, already set for AM stations, to be set for FM stations or vice-versa. To obtain maximum pleasure With your FM AM radiO, refer to the booklet entitled "Facts About FM Reception" In the glove compartment.
Rear Seat Radio Speaker (dealer Installed): Equalized full sound reception IS available uSing both front and rear speakers, or either
In and turn the "On-Oft" knob. NOTE: The radio and Reverberator are separately con-
speaker indiVidually by turning the speaker trolled and powered units. Therefore, when fader control, located near the radiO on the the radio IS turned oft the Reverberator Instrument panel. Turning the knob fully to should also be turned oft by pushing the
the left selects front speaker only. Far right control knob "in" .
selects rear speaker. Proper balance"betwee~ 0 Remote-Control Outside Mirror. Mirror can front and rear can be achieved by mixing be adjusted from the driver's seat by a front and rear speakers. Rear speaker IS control located on the door panel just below located under the rear Window. the vent Window. To adjust the mirror, simply
Reverberator-Equipped Rear Seat Speaker: move the control in the direction you want Equalized, full·fidellty reception With "concert the mirror to move. hall" quality is available from your radiO With the use of the Reverberator -Equipped R ear Seat Speaker Unit. The reverberator mechanically delays radiO sound Signals to the rear seat speaker, creating the sound presence heard In large auditOriums.
To operate, pull " out" the "On·Oft" knob, located on the Instrument panel, near the radiO. Push knob "in" to turn off. Because the sound quality of some types of musIc IS Improved more by reverberation than others, the degree of reverberatron can be controlled by rotating the "On-Off" knob. Rotating to the right provides Increased reverberation. To operate the rear seat speaker only, push
Page 32 of 46
Manual Tailgate : To unlock, Insert ignition key and turn handle to left to lower tailgate window, nght to raise.
E) 0 Electrical Tailgate: On the three-seat models, and If so equipped on two seat models, the tailgate window IS electncally controlled by a switch on the mstrument panel and by a key·operated sWitch on outside of the tailgate.
NOTE: Be sure the tailgate window is not open all the way when children r ndmg in the rear area.
A Full illumination of the interior can be .::1 had by using a rear light on the three seat model, along with the dome light. Rear light is located above tailgate window.
o To Open Tailgate: After lowering window, pull up the latch on top edge of tailgate and lower to open. Tailgate is counterbalanced for easy lowering.
NOTE: Be sure the window is fully down before either opening or closing the tailgate. Tailgate must be completely closed to actuate power window switch, is so equipped.
--------------
2 7