towing DODGE POWER WAGON 2005 2.G Owner's Guide

•More than 50% of your driving is at sustained high
speeds during hot weather, above 32°C (90°F)
•Trailer towing
•Heavy Loading
•Taxi, Police or delivery service (commercial service)
•Off-road or desert operation
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule“B”of the
Maintenance Schedulessection of this manual.
If none of these apply to you, then change your engine oil
at every interval shown on scheduleAof theMainte-
nance Schedulessection of this manual.
Dusty Conditions
Driving through dust-laden air increases the problems of
keeping abrasive materials out of the engine. Under these
conditions, special attention should be given to the
engine air cleaner, the crankcase inlet air cleaner and the
crankcase ventilation system. Make sure that these units
are clean at all times. This will tend to reduce to a
minimum the amount of abrasive material that may enter
the engine.
Engine Oil Selection
For best performance and maximum protection under all
types of operating conditions, the manufacture only
recommends engine oils that are API certified and meet
the requirements of DaimlerChrysler Material Standard
MS-6395. Use Mopar or an equivalent oil meeting the
specification MS-6395.
358 MAINTAINING YOUR VEHICLE

To minimize the possibility of catalyst damage:
•Do not shut off the engine or interrupt the ignition
when the transmission is in gear and the vehicle is in
motion.
•Do not try to start engine by pushing or towing the
vehicle.
•Do not idle the engine with any spark plug wires
disconnected or removed, such as when diagnostic
testing, or for prolonged periods during very rough
idling or malfunctioning operating conditions.
Emission-Related Components
Positive Crankcase (PCV) Valve
Proper operation of the crankcase ventilation system
requires that the PCV valve be free of sticking or plug-
ging from deposits. Deposits can accumulate in the PCV
valve and passages with increasing mileage. Have the
PCV valve, hoses, and passages checked for proper
operation at the intervals specified. If the valve is
plugged or sticking, replace with a new valve—do not
attempt to clean the old PCV valve!Check the ventila-
tion hoses for indications of damage, weepage or plug-
ging with deposits. Replace if necessary.
Maintenance Free Battery
The top of the maintenance free battery is permanently
sealed. You will never have to add water, nor is periodic
maintenance required.
364 MAINTAINING YOUR VEHICLE

EMISSION CONTROL SYSTEM MAINTENANCE
The“Scheduled”maintenance services, listed inbold
typein this section (Section 8) must be done at the times
or mileages specified to assure the continued proper
functioning of the emission control system. These, and all
other maintenance services included in this manual,
should be done to provide best vehicle performance and
reliability. More frequent maintenance may be needed for
vehicles in severe operating conditions such as dusty
areas and very short trip driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the emis-
sion control devices and systems on your vehicle may be
performed by any automotive repair establishment or
individual using any automotive part which has been
certified pursuant to U.S. EPA or, in the State of Califor-
nia, California Air Resources Board regulations.
MAINTENANCE SCHEDULES
There are two maintenance schedules that show the
requiredservice for your vehicle.
First is Schedule“B”. It is for vehicles that are operated
under the conditions that are listed below and at the
beginning of the schedule.
•Day or night temperatures are below 32°F(0°C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90°F C (32°).
•Trailer towing.
•Snowplowing.
410 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Schedule“B”
Follow schedule“B”if you usually operate your vehicle
under one or more of the following conditions.
•Day or night temperatures are below 32°F(0°C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90°F C (32°).
•Trailer towing.
•Snowplowing.
•Heavy Loading.
•Taxi, police, or delivery service (commercial service).
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule“B”of the
Maintenance Schedulessection of this manual.
NOTE:IfANYof these apply to you then flush and
replace your engine coolant every 102,000 miles (163 000
km) or 60 months, whichever comes first and follow
schedule“B”of theMaintenance Schedulessection of
this manual.
If none of these apply to you, then change your engine oil
at every interval shown on scheduleAof theMainte-
nance Schedulessection of this manual.
SCHEDULE“B”413
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 105,000 108,000 111,000 114,000 117,000 120,000
(Kilometers) (168 000) (173 000) (178 000) (182 000) (187 000) (192 000)
Inspect PCV valve, replace as necessary.**X
Inspect auto tension drive belt and replace if
required.XX
Drain and refill automatic tranmission fluid
and change main sump and spin-on cooler
return filter (if equipped) [545RFE only].X
* This applies only if the vehicle is used for frequent
trailer towing, snowplowing, fleet vehicle or commercial
service.
**This maintenance is recommend, but not required.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE“B”423
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Disc Brakes............................ 376
Disposal
Engine Oil........................... 375
Door Ajar............................. 159
Door Locks............................. 18
Door Opener, Garage..................... 130
Drive Belts............................ 360
Driving
Off-Pavement......................... 224
Off-Road............................ 224
Electric Rear Window Defrost..........88,207,211
Electrical Power Outlets................... 139
Electronic Speed Control................... 118
Emergency Brake........................ 282
Emergency, In Case of
Freeing Vehicle When Stuck............... 347
Hazard Warning Flasher................. 334
Jacking............................. 338Jump Starting......................... 344
Tow Hooks.......................... 347
Towing............................. 348
Emission Control System Maintenance......... 410
Emission Related Components.............. 364
Engine............................... 352
Air Cleaner.......................... 361
Break-In Recommendations................ 70
Compartment Identification............... 352
Coolant (Antifreeze).................374,407
Exhaust Gas Caution.................... 313
Flooded, Starting...................... 268
Fuel Requirements..................... 406
Oil ...........................356,406,407
Oil Filler Cap......................... 359
Oil Selection.......................358,406
Oil Synthetic......................... 359
Temperature Gauge..................... 160
Equipment Identification Plate.............. 332
INDEX 443
10

Gasoline.............................. 307
Gasoline, Reformulated................... 307
Gauges............................... 161
Coolant Temperature.................... 160
Fuel................................ 164
Oil Pressure.......................... 159
Speedometer......................... 159
Tachometer.......................... 158
Voltmeter............................ 158
Gear Ranges........................... 270
Gear Ratios............................. 80
Glass Cleaning.......................... 392
GVWR............................... 315
Hands-Free Phone........................ 90
Hazard Warning Flasher................... 334
Head Restraints......................... 104
Headlights.......................... 111,394
High Beam........................... 115High Beam/Low Beam Select Switch........ 115
Lights On Reminder.................... 113
Passing............................. 114
Switch.............................. 111
Heated Mirrors.....................88,207,211
Heated Seats........................... 107
Heater............................... 203
High Beam/Low Beam Select (Dimmer) Switch . . 115
Hitches
Trailer Towing........................ 321
Hoisting.............................. 343
Homelink Transmitter.................... 130
Hood Release.......................... 108
Hoses................................ 375
Hub Caps............................. 342
Ignition.............................15,266
Key ...............................12,16
Lock..............................15,16
INDEX 445
10

ScheduleB.......................... 413
Malfunction Indicator Light................ 354
Manual, Service......................... 436
Manual Transmission..................275,379
Fluid Level Check...................... 379
Lubricant Selection..................379,408
Mirrors................................ 84
Automatic Dimming..................... 85
Electric Powered....................... 87
Outside.............................. 86
Rearview............................. 84
Trailer Towing......................88,326
Modifications/Alterations, Vehicle............. 7
Mopar Parts.........................356,435
Multi-Function Control Lever............... 113
Noise Control
Maintenance.......................... 384
Tampering Prohibited................384,385Noise Emission Warranty.................. 386
Occupant Restraints....................... 35
Octane Rating, Gasoline................... 307
Odometer..........................163,164
Trip .............................163,164
Off-Pavement Driving.................... 224
Off-Road Driving........................ 224
Oil, Engine.........................356,407
Capacity............................ 406
Change Interval....................... 357
Dipstick............................. 356
Disposal............................ 360
Filter............................360,407
Filter Disposal........................ 360
Identification Logo..................... 359
Materials Added to..................... 360
Pressure Gauge....................... 159
Recommendation...................358,406
448 INDEX

Radiator Cap (Coolant Pressure Cap).......372,375
Radio Operation......................166,183
Radio Remote Controls.................... 197
Radio (Sound Systems)...........166,172,183,189
Ramp Travel Index....................... 225
Rear Axle............................. 378
Rear Wheel Bearings..................... 383
Reclining Front Seats..................... 103
Recommended Fluids, Lubricants and Genuine
Parts............................... 407
Recreational Towing...................... 329
Shifting into Transfer Case Neutral (N)....... 329
Shifting out of Transfer Case Neutral (N)..... 330
Reformulated Gasoline.................... 307
Refrigerant............................ 366
Relays and Flashers...................... 393
Reminder, Seat Belt....................... 45
Remote Keyless Entry..................... 24
Remote Sound System Controls.............. 197Replacement Tires....................... 302
Reporting Safety Defects................... 435
Restraint, Head......................... 104
Restraints, Child.......................59,65
Ride Height............................ 81
Rotation, Tires.......................... 306
Safety Checks Inside Vehicle................. 73
Safety Checks Outside Vehicle............... 74
Safety Defects, Reporting.................. 435
Safety Information, Tire................... 286
Safety Tips............................. 71
Schedule, Maintenance.................... 410
Seat Belt Maintenance.................... 392
Seat Belt Reminder....................... 45
Seat Belts..........................35,36,73
Adjustable Upper Shoulder Anchorage........ 43
And Pregnant Women................... 47
Child Restraint.......................59,70
450 INDEX

Inflation Pressures..................... 296
Jacking............................. 338
Load Capacity.....................291,292
Off-Road............................. 82
Radial.............................. 299
Replacement......................... 302
Rotation............................. 306
Safety...........................286,295
Sizes............................... 287
Snow Tires........................... 305
Spare Tire........................... 337
Spinning............................ 301
Tread Wear Indicators................... 302
Wheel Mounting....................... 338
Wheel Nut Torque..................... 341
Tongue Weight/Trailer Weight.............. 323
Torque Converter Clutch.................. 274
Tow Hooks, Emergency................... 347Towing
Disabled Vehicle....................... 348
Guide.............................. 325
Recreational.......................... 329
Trailering............................ 319
Weight.............................. 325
Traction.............................. 331
Trailer Towing.......................... 318
Hitches............................. 321
Mirrors...........................88,326
Tips ................................ 326
Trailer and Tongue Weight................ 323
Trailer Towing Guide..................... 325
Trailer Weight.......................... 325
Transfer Case........................... 379
Fluid............................... 408
Transmission
Automatic........................270,380
Fluid............................... 408
INDEX 453
10