center console DODGE RAM 2500 DIESEL 2008 3.G User Guide

storage area into separate compartments. Lift the lower
handle on the front of the armrest, and raise the armrest
for access to the lower storage bin. On Quad Cabtand
Mega Cabtmodels the rear of the floor console offers a
power outlet, a tip out bin and a rear air duct (Mega Cabt
Only).
WARNING!
²This armrest is not a seat. Anyone seated on the
armrest could be seriously injured during vehicle
operation, or an accident. Only use the center
seating position when the armrest is fully upright.
²In an accident, the latch may open if the total
weight of the items stored exceeds about 10 lbs (4.5
kg). These items could be thrown about endanger-
ing occupants of the vehicle. Items stored should
not exceed a total of 10 lbs (4.5 kg).
CAUTION!
²Many accessories that can be plugged in draw
power from the vehicle's battery, even when not in
use (i.e., cellular phones, etc.). Eventually, if
plugged in long enough, the vehicle's battery will
discharge sufficiently to degrade battery life
and/or prevent engine starting.
²Accessories that draw higher power (i.e., coolers,
vacuum cleaners, lights, etc.), will degrade the
battery even more quickly. Only use these inter-
mittently and with greater caution.
²After the use of high power draw accessories, or
long periods of the vehicle not being started (with
accessories still plugged in), the vehicle must be
driven a sufficient length of time to allow the
generator to recharge the vehicle's battery.
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 169
3

To achieve these emission standards, your vehicle is
equipped with a state of the art engine and exhaust
system. The engine and exhaust aftertreatment system
work together to achieve the EPA Heavy Duty Diesel
Engine Emissions Standards. These systems are seam-
lessly integrated into your vehicle and managed by the
Cumminst6.7L engine Powertrain Control Module
(PCM). The PCM manages engine combustion to allow
the exhaust system's catalyst to trap and burn Particulate
Matter (PM) pollutants, with no input or interaction on
your part.
Additionally, the overhead console in your vehicle has
the ability to alert you to additional maintenance re-
quired on your truck or engine. Refer to the following
messages that may be displayed on your Electronic
Vehicle Information Center (EVIC):WARNING!
A hot exhaust system can start a fire if you park over
materials that can burn. Such materials might be
grass or leaves coming into contact with your exhaust
system. Do not park or operate your vehicle in areas
where your exhaust system can contact anything that
can burn.
Perform Service
The 6.7L Cumminstengine utilizes a Closed Crankcase
Ventilation (CCV) system, EGR valve and an EGR cooler.
This system filters and recycles gasses produced in the
crankcase during the normal combustion process. ªPer-
form Serviceº will be displayed on the overhead console
of your vehicle if the CCV filter, EGR valve and EGR
cooler are due for required maintenance. The CCV filter is
426 MAINTAINING YOUR VEHICLE

located on the top of the engine valve cover. For addi-
tional information, see your local authorized dealer.
Catalyst Full See Owner Manual
ªCatalyst Full See Owner Manualº will be displayed on
the overhead console of your vehicle if the exhaust
particulate filter reaches 80% of its maximum storage
capacity. Under conditions of exclusive short duration
and low speed driving cycles, your Cumminstengine
and exhaust aftertreatment system may never reach the
conditions required to remove the trapped PM. If this
occurs, ªCatalyst Full See Owner Manualº will be dis-
played on the overhead console in your vehicle. If this
message is displayed you will hear one chime to assist in
alerting you of this condition.
Catalyst Stat::::::::::80%
Catalyst Stat::::::::::80% will replace the message ªCatalyst
Full See Owner Manualº after it is displayed for one
minute. The engine Powertrain Control Module (PCM)will continue to monitor the amount of particulate matter
trapped in the particulate filter. This message indicates
the percentage of the particulate filter capacity that has
been used.
By simply driving your vehicle at highway speeds for as
little as 45 minutes you can remedy the condition in the
particulate filter system and allow your Cumminsten-
gine and exhaust aftertreatment system to remove the
trapped PM and restore the system to normal operating
condition.
Catalyst Stat:::::::::::80%, 90%, 99%
Catalyst Stat:::::::::::80%, 90%, 99% If you are unable to
drive your vehicle under these conditions for an ex-
tended period of time after the initial warning notifica-
tion, the Engine PCM will continue to monitor the
particulate filter and will display the progression of
particulate filter usage (80, 90, 99%) on the EVIC message
center.
MAINTAINING YOUR VEHICLE 427
7

REPLACEMENT LIGHT BULBS
LIGHT BULBS Ð Inside Bulb No.
Overhead Console Lights............... TS212-2
Dome Light............................7679
All of the inside bulbs are brass or glass wedge base.
Aluminum base bulbs are not approved.LIGHT BULBS Ð Outside Bulb No.
Back-Up..............................3057
Center High Mounted Stop Light............. 912
Fog Light...........................9006LL
Headlight (Halogen)...................... H13
Side Marker Bulb....................... W5W
Park & Turn Signal...................3157NAK
Rear License Plate Light.................... 168
Rear Cargo Light......................... 912
Tail & Stop............................3057
Cab Clearance Lights...................... 168
Dual Rear Wheel Sidemarker Light............ 168
Dual Rear Wheel Tailgate ID Lights (3)......... 168
MAINTAINING YOUR VEHICLE 465
7

Radiator (Coolant Pressure)............... 439
Car Washes............................ 455
Carbon Monoxide Warning...............76,181
Cargo Light............................ 133
Cassette Tape and Player Maintenance......... 247
Catalyst Full Message..................... 425
CD (Compact Disc) Player............202,210,224
Cellular Phone.......................... 89
Center High Mounted Stop Light............ 473
Center Lap Belts......................... 45
Center Seat Storage Compartment.........167,168
Certification Label....................... 352
Charge Air Cooler....................... 442
Chart, Tire Sizing........................ 317
Check Engine Light (Malfunction Indicator
Light)................................ 194
Child Restraint........................61,62
Child Restraint Tether Anchors.............65,69
Child Seat............................62,68Cigar Lighter........................... 162
Cleaning
Wheels............................. 457
Climate Control......................... 249
Clock.....................200,204,212,225,239
Closed Crankcase Ventilation (CCV) Filter...... 426
Clutch Linkage Maintenance................ 445
Compact Disc (CD) Maintenance............. 248
Compact Spare Tire...................... 328
Compass Calibration..................... 150
Compass Variance....................... 150
Console, Overhead....................... 142
Contract, Service........................ 499
Coolant Pressure Cap (Radiator Cap).......... 439
Cooling System......................... 436
Adding Coolant (Antifreeze).............. 439
Coolant Capacity...................... 479
Coolant Level...................436,437,440
Disposal of Used Coolant................ 440
508 INDEX