service DODGE SPRINTER 2008 2.G Workshop Manual

621 *Technical data
Service products and capacities
6
CapacitiesVehicle
Engine with
oil filter
Tank
Cooling
system
Windshield washer /
headlamp cleaning
system
Engine oil
Capacity
Including
reserve fuel
Coolant
1
1 Whenever the coolant is replaced, a concentration of 50% by volume of corrosion inhibitor/antifreeze should be maintained. This provides antifreeze pro-
tection down to -34,6 °F (-37 °C). Do not exceed a concentration of 55% by volume (antifreeze protection down to approximately -49 °F (-45 °C)), as the
heat dissipation properties deteriorate at higher concentrations. Observe the Mercedes-Benz Specifications for Service Products, Sheet 325.
Water with MB windshield
washer fluid
2500 CRD, 3500 CRD
13.21 US qt.
(12.5 l)
25.0 US gal
(100 l)
2
2 Including a reserve of 5.3 US gal (20 l).
5.3 US gal
(20 l)
10.75 US qt.
(10.0 l)
approx. 7.40 US qt. (7.0 l)
2500, 3500
10.04 US qt.
(9.5 l)
25.0 US gal
(100 l)
2
5.3 US gal
(20 l)
7.40 US qt.
(7.0 l)
approx. 7.40 US qt. (7.0 l)
nf_BA.book Page 621 Friday, January 25, 2008 3:53 PM

622 *Technical dataService products and capacities
6
The vehicle will use more fuel than usual
in the following conditions:\4
at very low temperatures
\4
in urban traffic
\4
on short trips
\4
when towing a trailer
\4
when driving with a heavy load
\4
in mountainous terrain
Fuel consumptionEnvironmental note
H
A vehicle’s CO
2 emissions and fuel con-
sumption depend on:
\4efficient use of fuel by the engine
\4the style of driving adopted
\4other non-technical factors such as
environmental influences or road con-
ditions
nf_BA.book Page 622 Friday, January 25, 2008 3:53 PM

634 *Technical dataVehicle identification labels
6
Example incomplete vehicle safety certi-
fication label (Canada vehicles)
2VINExample Engine Compartment
3VIN (embossed on the engine compart-
ment rear bulk)
4Engine number (engraved on gasoline en-
gine)
5Engine number (engraved on diesel en-
gine)
6Emission control information label and
engine oil warning label
1
7Emission control information label (gaso-
line engine) (\2page 380)1. Read and observe the diesel engine oil informa-
tion under “Engine oils” in the“Service pro-
ducts and capacities” section.
nf_BA.book Page 634 Friday, January 25, 2008 3:53 PM

647 Index
Heater
. . . . . . . . . . . . . . . . . 228
–233
air distribution . . . . . . . . . . . . . . 230
airflow . . . . . . . . . . . . . . . . . . . . 230
air-recirculation mode . . . . . . . . 231
control panel . . . . . . . . . . . . . . . 228
defrosting . . . . . . . . . . . . . . . . . 232
fogged-up windows . . . . . . . . . . 231
heating . . . . . . . . . . . . . . . . . . . . 229
see Rear heater . . . . . . . . . . . . . 233
special settings . . . . . . . . . . . . . 231
temperature . . . . . . . . . . . . . . . . 230
ventilation . . . . . . . . . . . . . . . . . 229
Heater booster function
. . . . . . 234
Heater booster system
. . . . . . . 235
Heatingrear window . . . . . . . . . . . . . . . . 214
seat . . . . . . . . . . . . . . . . . . . . . . 122windshield . . . . . . . . . . . . . 213
,223
High-beam headlamps
. . . . 131
,526
changing bulbs . . . . . . . . . . . . . 527
High-pressure cleaners
. . . . . . . 418
Hood
. . . . . . . . . . . . . . . . . . . . . . . 318
Horn
. . . . . . . . . . . . . . . . . . . . . . . . 19
Hydroplaning
. . . . . . . . . . . . . . . 197
I
Identification lamps
. . . . . . . . . . 533
changing bulbs . . . . . . . . . 533
,536
Ignition lock
. . . . . . . . . . . . . . . . 111
Immobilizer
. . . . . . . . . . . . . . . . . . 77
Indicatorvehicles with steering wheel buttons
Service due date . . . . . . . . . . 412vehicles without steering wheel
buttons
service due date . . . . . . . . . . 412
Indicator and warning lampsair cleaner . . . . . . . . . . . . . . . . . 477
brake system . . . . . . . . . . . . . . . 464
braking . . . . . . . . . . . . . . . . . . . 462
engine oil level . . . . . . . . . . . . . 471
seat belt . . . . . . . . . . . . . . . . . . 482
seat belt reminder . . . . . . . . . . . 482
SRS . . . . . . . . . . . . . . . . . . . . . . 469
water separator . . . . . . . . . . . . . 482Indicator lampABS . . . . . . . . . . . . . . . . . . . . . . 466
ASR . . . . . . . . . . . . . . . . . . 462
,465
BAS . . . . . . . . . . . . . . . . . . 462,465
battery charge . . . . . . . . . . . . . . 469
I
nf_BA.book Page 647 Friday, January 25, 2008 3:53 PM

655 Index
fore-and-aft adjustment . . . . . . . 114
heating . . . . . . . . . . . . . . . . . . . . 122
malfunction . . . . . . . . . . . . . . 458
height . . . . . . . . . . . . . . . . . . . . . 115
suspension . . . . . . . . . . . . . . . . 116
suspension lock . . . . . . . . . . . . . 116
swivelling . . . . . . . . . . . . . . . . . . 116
vertical lock . . . . . . . . . . . . . . . . 116Seat belt
. . . . . . . . . . . . . . . . . . . . 36
adjusting height . . . . . . . . . . . . . . 40
cleaning . . . . . . . . . . . . . . . . . . . 425
telltale . . . . . . . . . . . . . . . . . . . . 482
wearing . . . . . . . . . . . . . . . . . . . . 39
Seat heatingswitching on . . . . . . . . . . . . . . . 123Seating capacity
. . . . . . . . . . . . . 354
Securing a load
. . . . . . . . . . . . . . 280
Securing tensioning straps
. . . . 280
Selector leverlock . . . . . . . . . . . . . . . . . . 185
,201
Servicecalling up the due date
vehicles with steering wheel
buttons . . . . . . . . . . . . . . . . . . 413
vehicles without steering
wheel buttons . . . . . . . . . . . . 414
indicator . . . . . . . . . . . . . . . . . . 411Service information
. . . . . . . . . . . . 9
Service lifetires . . . . . . . . . . . . . . . . . . . . . . 349Service products
. . . . . . . . 322
,410
capacities . . . . . . . . . . . . . . . . . 621
coolants, lubricants, etc. . . . . . . 616
diesel . . . . . . . . . . . . . . . . . . . . . 612engine oils . . . . . . . . . . . . . . . . . 606
fuels . . . . . . . . . . . . . . . . . . . . . 610
gasoline . . . . . . . . . . . . . . . . . . . 610
notes . . . . . . . . . . . . . . . . . . . . . 604
windshield washer fluid . . . . . . . 333
Setting the blower speed
. . . . . 220
Setting the date
. . . . . . . . . . . . . 169
vehicles with steering wheel
buttons . . . . . . . . . . . . . . . . . . . 169
vehicles without steering wheel
buttons . . . . . . . . . . . . . . . . . . . 150
Settingsresetting all (vehicles with steering
wheel buttons) . . . . . . . . . . . . . 162Shift rangeautomatic transmission . . . . . . . 204
display . . . . . . . . . . . . . . . . . . . . 202
nf_BA.book Page 655 Friday, January 25, 2008 3:53 PM

659 Index
direction of rotation, spinning . . 351
driving instructions . . . . . . . . . . 195
important guidelines . . . . . . . . . 346
inflation pressure . . . . . . . . 361
,365
information placard . . . . . . . . . . 352
inspection . . . . . . . . . . . . . . . . . 347
load limit information . . . . . . . . . 355
load rating . . . . . . . . .383
,384
,398
loading Information . . . . . . . . . . 352
loading terminology . . . . . . . . . . 393
loading the vehicle . . . . . . . . . . . 351
low tire pressure indicator . . . . . 478
maximum load . . . . . . . . . . . . . . 399
messages in the multifunction
display . . . . . . . . . . . . . . . . . . . . 478
ply composition and material
used . . . . . . . . . . . . . . . . . . . . . . 398problems under/overinflation . . 380
,
382
radial-ply tires . . . . . . . . . . . . . . 345
retreads . . . . . . . . . . . . . . . . . . . 344
rotating . . . . . . . . . . . . . . . 351
,399
seating capacity . . . . . . . . . . . . 354
service life . . . . . . . . . . . . . . . . . 349
sizes . . . . . . . . . . . . . . . . . . . . . 383
speed rating . . . . . . . 199
,386
,398
storing . . . . . . . . . . . . . . . . . . . . 350
temperature . . . . . . . . 363
,364
,627
terminology . . . . . . . . . . . . . . . . 393
TIN . . . . . . . . . . . . . . . . . . . 387,397
Tire Identification Number see TIN
Tire Pressure Monitoring System
(TPMS), (USA only) . . . . . . . . . . 367
TPMS malfunction indicator . . . 478traction . . . . . . . . . . . . . . . 198
,398
tread . . . . . . . . . . . . . . . . . . . . . 398
tread depth . . . . . . . . . . . . 349,405
Treadwear Indicator (TWI) . . . . . 196
Treadwear Indicators . . . . . . . . . 398
valves . . . . . . . . . . . . . . . . . . . . 345
vehicle maximum load on . . . . . 399
wear pattern . . . . . . . . . . . . . . . 401
winter tires . . . . . . . . . . . . . . . . 404
Tongue Weight Ratingsee TWRTopTether
. . . . . . . . . . . . . . . . . . . .64
Tow-away protection
. . . . . . . . . . .78
nf_BA.book Page 659 Friday, January 25, 2008 3:53 PM