battery DODGE VIPER 2004 ZB / 2.G Owner's Manual

1. Press the driver's door exterior handle to wake up the
vehicle.
2. If the door does not open (vehicle is armed) press the
remote keyless entry unlock button to unlock the vehicle.
3. Press the driver's door exterior handle again to open
the door.
4. Cycle the Ignition to ON/RUN. If the ignition is NOT
cycled to ON/RUN, then the vehicle will re-enter Battery
Save Mode 45 seconds after the driver's door is closed.
Air Conditioner
Check the air conditioning system operation at the start
of the warm weather season.
NOTE:If air conditioning operation seems to be lower
than expected, check the front of the A/C condenser,
located in front of the radiator for dirt or insect accumu-
lation. Clean with a gentle water spray as required. Frontend fascia protectors may reduce air flow to the con-
denser and radiator, reducing A/C and engine cooling
performance.
WARNING!
The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal injury
or damage to the system, adding refrigerant or any
repair requiring lines to be disconnected should be
done by an experienced repairman.
Refrigerant Recovery and Recycling
The air conditioning system of your vehicle contains
R-134a, a refrigerant that does not deplete the ozone layer
in the upper atmosphere. The manufacturer recommends
that air conditioning service be done by facilities using
refrigerant recycling and recovery equipment that meets
SAE standard J1991.
160 MAINTAINING YOUR VEHICLE

Power Distribution Center
Cavity Fuse Circuits
1 Cartridge Fuse 40
AmpBatt-Relay Contact, High
Blower Motor Module-
ABS Pump Feed
2 Cartridge Fuse 40
AmpABS Pump Feed
3 Cartridge Fuse 30
Amp GreenBattery
4 Cartridge Fuse 20
Amp YellowFused Feed to RS Ampli-
fier or Power Amplifier
5 Cartridge Fuse 30
Amp GreenIgnition Switch (Run &
Accessory)-(Downstream)
6 Cartridge Fuse 40
AmpBatt
7 Cartridge Fuse 30
Amp GreenBatt-Relay Contact, ABS
Pump Motor
8 Cartridge Fuse 30
Amp GreenBatt-Motor, WiperCavity Fuse Circuits
9 Cartridge Fuse 40
AmpBatt-Fuseblock
10 Cartridge Fuse 30
Amp GreenBatt-Switch, Ignition
(Run/Start/Accy)
11 Mini Fuse 20
Amp YellowBatt-Relay Contact, Auto
Shutdown
12 Mini Fuse 20
Amp YellowSecondary Power Outlet
Feed
13 Mini Fuse 15
Amp BlueBatt-Flasher, Hazard
14 Mini Fuse 15
Amp BlueRear 02 Sensor to Heater
Relay
15 Mini Fuse 20
Amp YellowElectric Heated RR. WDO
(EBL)
16, 17 Mini Fuse 20
Amp YellowFused Feed-Cigar Lighter
MAINTAINING YOUR VEHICLE 181
7

Cavity Fuse Circuits
18 Mini Fuse 15
Amp BlueBatt-Locks, Power Door
19 Mini Fuse 15
Amp BlueBatt
20 Mini Fuse 15
Amp BlueFeed-Courtesy, Dome, Vi-
sor, Illuminated Entry,
Reading
21 Mini Fuse 15
Amp BlueFuse Feed to Stop Lamp
Switch
22 Mini Fuse 15
Amp BlueBattery to AC Clutch Re-
lay
23, 24 Mini Fuse 10
Amp RedAirbag, Ignition Run
25-29 ISO RELAY Batt-Relay Contact, High
Blower Motor
30-34 MICRO RELAY Batt-Relay-Starter Contact
to SolenoidCavity Fuse Circuits
35-39 MICRO RELAY Feed-Auto Shutdown Re-
lay Coil
40-44 MICRO RELAY Feed-Horn (From Relay)
45-49 MICRO RELAY Batt-Relay-Headlamps
50-54 MICRO RELAY Relay-A/C Clutch Output
from Relay Contact (B+)
55-59 MICRO RELAY Left/Right Downstream
Oxygen Sensor Output
Feed FR
60, 61 Mini Fuse 15
Amp BlueIgnition Start/Run Relay
Coil
62, 63 Mini Fuse 15
Amp BlueIgnition Start/Run Gauges
64, 65 Mini Fuse 10
Amp RedIgnition Start/Run Airbag
66, 67 Mini Fuse 20
Amp YellowFeed-Ign Run/Acc Wiper
Switch
182 MAINTAINING YOUR VEHICLE

²If the vehicle will be subjected to freezing tempera-
tures, remove the battery and store it in a dry, well
ventilated area or place a trickle charger (1.5 Amp)
with automatic shutdown / overcharge protection
connected to the battery. Do not leave the trickle
charger hooked up to the battery without being
plugged into the 110 AC voltage outlet, because this
will result in further drain on the vehicle's battery. If
the vehicle is not going to be driven in the next 3
weeks, follow the battery recharge procedure in the
Service Manual, then disconnect the battery at the
negative terminal or use the save feature described in
Maintaining your Vehicle section under the Mainte-
nance Procedures sub-section, within Maintenance-
Free Battery.CAUTION!
Use care when disconnecting the remote positive
cable. It is connected to the battery and can short out
to any metal on the vehicle. Always tape or wrap the
exposed cable end to prevent electrical shorts.
²Disconnecting the battery causes the engine control
system to lose memory of some ªlearnedº functions,
unless using the Battery Save feature described in
Maintaining your Vehicle section under the Mainte-
nance Procedures sub-section, within Maintenance-
Free Battery. The engine may run rough when first
started after a battery disconnect until the control
module ªrelearnsº these functions.
184 MAINTAINING YOUR VEHICLE

Check the battery every 4 to 6 weeks to ensure that the
voltage is above 12.40. Voltage will drop more rapidly
in hot temperatures. If battery voltage drops below
12.40, follow the battery recharge procedure in the
Service Manual.
²Check that the radiator coolant level of protection is to
at least -20ÉF (-29ÉC).
²Block the wheels. Do not apply the Parking Brake.
²Make sure that all tires are inflated to the optimum
pressure, (29 PSI).
²Cut blocks of plywood about the same size of the tires.
Cover each block with indoor/outdoor carpeting and
place them between the tires and concrete. This will
prevent tire flat spotting.
²For long term storage, remove the tires and put the
vehicle up on blocks. Stack the tires on plywood and
cover with a tarp to prevent flat spotting.
²Move the wiper blades away from the windshield.
NOTE:To help prevent the battery from discharging
during shorter periods of inactivity, perform the follow-
ing:
1. Make sure that the trunk, hood, doors, windows and
convertible top are completely closed.
2. Make sure that remote transmitter is operating and
that the battery is good.
3. Make sure that the hood, trunk and door switches are
in adjustment. Perform the quick system check which
follows.
Use the remote transmitter to set the alarm. If the alarm
SET light comes on and flashes, the system is operating
properly. If not, there is a problem with a switch or the
system. See your dealer for service.
MAINTAINING YOUR VEHICLE 185
7

Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
²Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
²Check all lights and all other electrical items for correct
operation.At Each Oil Change
²Change the engine oil filter.
²Inspect the exhaust system.
²Inspect the brake hoses.
²Inspect the suspension components.
²Lubricate door hinges and check springs.
²Check the engine coolant level, hoses, and clamps.
²Check power steering fluid level.
²Rotate the tires at each oil change interval shown on
Schedule ªAº 6,000 miles (10 000 km) or every other
interval shown on Schedule ªBº 6,000 miles (10 000
km).
202 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

11786.1............................... 111
1819................................. 109
ABS (Anti-Lock Brake) System............... 75
Accessory Delay, Power..................13,24
Adding Engine Coolant (Antifreeze).......... 168
Adding Fuel........................... 129
Additives, Fuel......................... 129
Adjustable Pedals........................ 66
Aiming Headlights....................... 193
Air Cleaner, Engine...................... 155
Air Conditioning......................90,160
Air Conditioning Refrigerant............... 160
Air Pressure, Tires....................... 117
Airbag................................ 38
Airbag Deployment....................... 42
Airbag Light..........................41,79
Airbag Maintenance....................... 45
Airbag On/Off Switch...................34,43Alarm................................ 19
Alignment and Balance................... 123
Alterations/Modifications, Vehicle............. 7
Antenna............................... 90
Antifreeze Disposal...................... 167
Antifreeze (Engine Coolant)..............167,168
Capacities........................... 195
Anti-Lock Warning Light................... 75
Appearance Care........................ 177
Auto Down Power Windows................ 24
Automatic Door Locks..................... 15
Ball Joints............................. 162
Battery.............................78,156
Gas Caution.......................... 157
Bearings.............................. 177
Belt System, Six Point..................... 31
Belts, Drive............................ 152
Belts, Seat.............................. 26
226 INDEX

Theft Alarm............................ 19
Theft System............................ 19
Tilt Steering Column...................... 65
Tire and Loading Information Placard......... 112
Tire Markings.......................... 108
Tire Safety Information.................... 108
Tires .............................. 116,222
Air Pressure.......................... 116
Alignment........................... 123
Chains.............................. 125
Compact Spare........................ 120
High Speed.......................... 119
Inflation Pressures..................... 117
Load Capacity...................... 112,113
Quality Grading....................... 222
Radial.............................. 120
Replacement......................... 122
Rotation............................. 126
Safety..........................48,108,116Sizes............................... 109
Snow Tires........................... 125
Spinning............................ 121
Storage............................. 126
Tread Wear Indicators................... 122
Towing............................... 139
Disabled Vehicle....................... 139
Trailering............................ 130
Traction.............................. 137
Trailer Towing.......................... 130
Transmission........................... 175
Shifting..........................100,101
Transmitter Battery Service.................. 19
Transmitter Programming................... 18
Transmitter, Remote Keyless Entry............ 19
Transporting Pets........................ 46
Tread Wear Indicators.................... 122
Turn Signals..........................64,75
INDEX 235
10