light DODGE VIPER 2006 ZB / 2.G Repair Manual

At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
NOTE:Also inspect the exhaust system if you notice a
change in the sound of the exhaust system, or if the
exhaust fumes can be detected inside the vehicle.
•Inspect the brake hoses.
•Inspect the suspension components.
•Lubricate door hinges and check springs.
•Check the engine coolant level, hoses, and clamps.
•Check power steering fluid level.
228 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Customer Assistance For The Hearing Or Speech
Impaired (TDD/TTY)
To assist customers who have hearing difficulties, the
manufacturer has installed special TDD (Telecommuni-
cation Devices for the Deaf) equipment at its Customer
Center. Any hearing or speech impaired customer who
has access to a TDD or a conventional teletypewriter
(TTY) in the United States can communicate with the
manufacturer by dialing 1–800–380–CHRY.
Service Contract
You may have purchased a service contract for your
vehicle to help protect you from the high cost of unex-
pected repairs after your manufacturer’s new vehicle
limited warranty expires. The manufacturer stands be-
hind only the manufacturer’s Service Contracts. If you
purchased a manufacturer’s Service Contract, you will
receive Plan Provisions and an Owner Identification Card
in the mail within three weeks of your vehicle delivery
date. If you have any questions about your servicecontract, call the manufacturer’s Service Contract Na-
tional Customer Hotline at 1-800-521-9922.
The manufacturer will not stand behind any service
contract that is not the manufacturer’s Service Contract. It
is not responsible for any service contract other than the
manufacturer’s Service Contract. If you purchased a
service contract that is not a manufacturer’s Service
Contract, and you require service after your manufactur-
er’s new vehicle limited warranty expires, please refer to
your contract documents, and contact the person listed in
those documents.
We appreciate that you have made a major investment
when you purchased your new vehicle. Your dealer has
also made a major investment in facilities, tools, and
training to assure that you are absolutely delighted with
your ownership experience. You’ll be pleased with their
sincere efforts to resolve any warranty issues or related
concerns.
244 IF YOU NEED CONSUMER ASSISTANCE

About Your Brakes....................... 125
ABS (Anti-Lock Brake) System............... 91
Accessory Delay, Power..................14,28
Adding Engine Coolant (Antifreeze).......... 192
Adding Fuel........................... 152
Adding Washer Fluid..................... 189
Additives, Fuel......................... 150
Adjustable Pedals........................ 82
Aiming Headlights....................... 219
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 179
Air Conditioner Maintenance............... 184
Air Conditioning..................... 111,184
Air Conditioning Refrigerant............... 185
Air Pressure, Tires....................... 139
Airbag................................ 43
Airbag Deployment....................... 47
Airbag Light..........................46,95
Airbag Maintenance....................... 51
Airbag On/Off Switch...................37,48Alarm System........................... 21
Alignment and Balance................... 145
Alterations/Modifications, Vehicle............. 7
Antenna.............................. 111
Antenna, Satellite Radio................... 110
Antifreeze (Engine Coolant)..............191,220
Capacities........................... 220
Disposal............................ 193
Anti-Lock Warning Light................... 91
Anti-Theft Security Alarm.................. 21
Appearance Care........................ 200
Auto Down Power Windows................ 28
Automatic Door Locks..................... 16
Automatic Transmission
Adding Fluid......................... 222
Fluid Type........................... 222
Ball Joints............................. 186
Battery.............................94,179
250 INDEX

Emergency Starting..................... 158
Gas Caution.......................... 181
Jump Starting......................... 158
Keyless Transmitter Replacement............ 20
Bearings.............................. 200
Belt System, Six Point..................... 35
Belts, Drive............................ 176
Belts, Seat.............................. 29
Body Damage.......................... 201
Body Mechanism Lubrication............186,187
Body Mechanisms....................... 188
Boot, Convertible Top...................61,66
B-Pillar Location........................ 134
Brake, Parking.......................... 124
Brake System........................125,195
Anti-Lock........................... 125
Fluid Check.......................197,222
Hoses.............................. 196
Master Cylinder....................... 197Warning Light......................... 95
Break-In Recommendations, New Vehicle.....52,129
Bulb Replacement....................... 212
Bulbs, Light......................... 211,212
Capacities, Antifreeze (Engine Coolant)........ 220
Capacities, Fluid........................ 220
Capacity, Cargo Weight................... 153
Caps, Filler
Power Steering........................ 185
Radiator (Coolant Pressure)............... 192
Car Washes............................ 202
Carbon Monoxide Warning...............53,151
Cargo Compartment
Capacity............................ 153
Carpeting............................. 202
Catalytic Converter...................... 176
CD Player...........................99,102
CD Player Maintenance................... 110
INDEX 251
10

Chains, Tire............................ 147
Charging System Light..................... 94
Chart, Tire Sizing........................ 131
Check Engine Light (Malfunction Indicator Light) . 170
Checks, Safety........................... 53
Child Restraint........................36,41
Child Restraint Tether Anchors............... 39
Circuit Breakers......................... 203
Clean Air Gasoline....................... 149
Climate Control......................... 111
Clock................................. 97
Compact Disc Maintenance................. 110
Console............................... 68
Console, Floor........................... 68
Contract, Service........................ 244
Converter, Catalytic...................... 176
Convertible............................. 57
Convertible Boot.......................61,66
Convertible Top.......................57,202Convertible Top Maintenance............... 202
Coolant Pressure Cap..................... 192
Cooling System......................... 190
Adding Coolant (Antifreeze).............. 192
Coolant Capacity...................... 220
Coolant Level......................190,193
Disposal of Used Coolant................ 193
Drain, Flush, and Refill.................. 191
Inspection........................... 193
Points to Remember.................... 194
Pressure Cap......................... 192
Radiator Cap......................... 192
Rubber and Plastic Components............ 195
Selection of Coolant (Antifreeze)......191,220,221
Crankcase Emission Control System.......... 178
Customer Assistance..................... 242
Daytime Running Lights................... 78
Dealer Service.......................... 171
252 INDEX

Defroster, Windshield...................... 53
Delay (Intermittent) Wipers................. 85
Diagnostic System, Onboard................ 169
Dimmer Control......................... 77
Dimmer Switch, Headlight.................. 80
Disposal
Antifreeze (Engine Coolant)............... 193
Door Locks............................. 14
Door Locks, Automatic.................... 16
Doors................................. 14
Drive Belts............................ 176
Driving
On Slippery Surfaces.................... 162
Electric Remote Mirrors.................... 70
Emergency Brake........................ 124
Emergency, In Case of
Freeing Vehicle When Stuck............... 163
Hazard Warning Flasher................. 156Jump Starting......................... 158
Overheating.......................... 156
Towing............................. 163
Emission Control System Maintenance......170,226
Engine............................... 168
Break-In Recommendations................ 52
Checking Oil Level..................... 172
Compartment......................... 168
Coolant (Antifreeze).................190,221
Cooling...........................94,190
Exhaust Gas Caution................26,53,151
Fails to Start.......................... 120
Fuel Requirements..................148,220
Oil ...........................172,220,221
Oil Change Interval.................... 173
Oil Disposal.......................... 175
Oil Filter............................ 175
Oil Selection.......................174,220
Overheating........................94,156
INDEX 253
10

Engine Oil Viscosity...................174,220
Engine Oil Viscosity Chart................. 174
Exhaust Gas Caution..............26,53,151,189
Exhaust System......................... 189
Exterior Lights....................... 211,212
Fan .................................. 112
Filters
Air Cleaner.......................... 179
Engine Oil........................... 221
Flashers
Hazard Warning.....................91,156
Turn Signal........................... 91
Flash-To-Pass........................... 80
Floor Console........................... 68
Fluid Capacities......................... 220
Fluid Leaks............................. 54
Fluid Level Checks
Brake............................197,222Capacities........................... 220
Cooling System....................... 190
Engine Oil........................... 172
Manual Transmission................... 199
Power Steering.....................185,222
Fluids................................ 221
Fluids, Lubricants and Genuine Parts.......... 221
Fog Lights.........................78,79,94
Four-Way Hazard Flasher.................. 156
Freeing A Stuck Vehicle................... 163
Fuel................................. 148
Adding............................. 152
Additives............................ 150
Clean Air............................ 149
Gasoline............................ 148
Gauge............................... 97
Octane Rating........................ 221
Requirements......................148,220
Tank Capacity........................ 220
254 INDEX

Fueling............................... 152
Fuses................................ 203
GasCap .............................. 152
Gasoline.............................. 148
Gasoline, Clean Air...................... 149
Gasoline, Reformulated................... 149
Gasoline/Oxygenate Blends................ 149
Gauges................................ 96
Coolant Temperature..................94,96
Fuel................................ 97
Oil Pressure........................... 96
Speedometer.......................... 90
Tachometer........................... 96
Voltmeter............................ 97
General Information...................... 19
Glass Cleaning.......................... 201
Ground Clearance....................... 148Hazard Warning Flasher.................91,156
Headlights............................ 214
Aiming............................. 219
High Beam........................... 80
High Beam/Low Beam Select Switch......... 80
Passing.............................. 80
Switch............................... 78
Time Delay........................... 79
Heater................................ 111
High Beam Indicator...................... 93
Hood Latch Maintenance.................. 188
Hood Release........................... 73
Hoses.............................195,196
Hydraulic Clutch Fluid.................... 198
Ignition
Key ................................. 12
Timing.............................. 178
Wiring System........................ 178
INDEX 255
10

Infant Restraint.......................... 36
Inside Rearview Mirror.................... 69
Instrument Cluster........................ 90
Instrument Panel and Controls............... 89
Instrument Panel Lens Cleaning............. 201
Interior and Instrument Lights..........See Lights
Interior Lighting......................... 76
Interior Lights.........................76,77
Intermittent Wipers....................... 85
Introduction............................. 4
Jump Starting.......................... 158
Key-In Reminder......................... 13
Keyless Entry System...................... 16
Keys................................. 12
Knee Bolster............................ 43
Lap/Shoulder Belts....................... 30LATCH (Lower Anchors and Tether for CHildren) . 38
Latches
Hood.............................73,188
Lead Free Gasoline...................... 148
Liftgate..............................26,76
Light Bulbs......................... 211,212
Lights...............................54,75
Airbag.............................46,95
Anti-Lock Warning...................... 91
Back-Up............................. 76
Brake Warning......................... 95
Bulb Replacement...................... 211
Daytime Running....................... 78
Dimmer Switch, Headlight..............76,80
Engine Temperature Warning.............. 94
Exterior Check......................... 54
Fog .............................78,79,94
Hazard Warning Flasher...............91,156
Headlight Switch....................... 78
256 INDEX

Headlights.........................78,214
High Beam........................... 80
High Beam Indicator.................... 93
Instrument Cluster...................... 78
Interior............................76,77
License............................. 218
Lights On Reminder..................... 78
Malfunction Indicator.................... 92
Map Reading.......................... 75
Oil Pressure........................... 94
Reading.............................. 75
Seat Belt Reminder...................... 93
Service........................... 211,212
Service Engine Soon (Malfunction Indicator).... 92
Turn Signal.......................76,80,91
Loading Vehicle......................... 153
Capacities........................... 153
Tires ............................... 134Locks
Door................................ 14
Low Tire Indicator....................... 145
Low Tire Pressure System.................. 145
Lower Anchors and Tether for CHildren (LATCH) . 38
Lubricants..........................186,187
Lubrication, Body....................... 186
Luggage/Cargo Capacity.................. 153
Maintenance Free Battery.................. 179
Maintenance Schedule.................... 226
Light Duty ScheduleB................. 229
ScheduleA......................... 236
ScheduleB.......................... 229
Malfunction Indicator Light..............92,170
Manual, Service......................... 246
Manual Transmission..................... 122
Shift Speeds.......................... 123
Master Cylinder......................... 197
INDEX 257
10