cooling DODGE VIPER 2008 ZB II / 2.G User Guide

service attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle need only
be checked once a month.
When additional coolant is needed to maintain the
proper level, it should be added to the coolant bottle. Do
not overfill.
Points to Remember
NOTE:When the vehicle is stopped after a few miles (a
few kilometers) of operation, you may observe vapor
coming from the front of the engine compartment. This is
normally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot coolant to
enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
²Do not overfill the coolant recovery bottle.
²Check coolant freeze point in the coolant bottle. If
antifreeze needs to be added, contents of the coolant
bottle also must be protected against freezing.
²If frequent coolant additions are required, or if the
level in the coolant recovery bottle does not drop when
the engine cools, the cooling system should be pres-
sure tested for leaks.
²Maintain coolant concentration at 50% HOAT engine
coolant (minimum) and distilled water for proper
corrosion protection of your engine, which contains
aluminum components.
²Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
²Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean, also.
MAINTAINING YOUR VEHICLE 223
7

HEADLIGHT AIMING
The headlights on your new vehicle were aimed at the
factory under a no load setting. A great increase in weight
will change the aiming of the headlights. Therefore, it
may be necessary to readjust the headlights if you
typically carry an excessive amount of weight in the rear
compartment or generally suspect misalignment. In ei-
ther case, see your authorized dealer if the headlights
require adjustment.
FLUIDS AND CAPACITIES
U.S. Metric
Fuel (approximate)
8.4 Liter Engine 16 gal-
lons60.6 li-
ters
Engine Oil-With Filter
8.4 Liter Engine (SAE 0W-40) 10 qts. 9.5 Li-
ters
Cooling System *
8.4 Liter Engine* (Mopart
Antifreeze/Coolant 5 Year/
102,000 Mile Formula) or
equivalent.16 qts. 15 Liters
* Includes heater and coolant recovery bottle filled to
MAX level.
MAINTAINING YOUR VEHICLE 251
7

Carpeting............................. 233
Catalytic Converter...................... 204
CD (Compact Disc) Changer................ 114
CD (Compact Disc) Player...............108,112
Chains, Tire............................ 164
Charging System Light.................... 106
Chart, Tire Sizing........................ 150
Check Engine Light
(Malfunction Indicator Light)............... 196
Checks, Safety........................... 57
Child Restraint....................50,51,52,55
Child Restraint Tether Anchors............... 53
Circuit Breakers......................... 234
Clean Air Gasoline....................... 168
Climate Control......................... 122
Clock................................ 106
Clutch Fluid........................... 228
Compact Disc (CD) Maintenance............. 122
Console............................... 92Console, Floor........................... 92
Contract, Service........................ 279
Converter, Catalytic...................... 204
Convertible............................. 63
Convertible Boot.......................67,72
Convertible Top.......................63,232
Convertible Top Maintenance............... 232
Coolant Pressure Cap (Radiator Cap).......... 221
Cooling System......................... 219
Adding Coolant (Antifreeze).............. 221
Coolant Capacity...................... 251
Coolant Level......................219,222
Disposal of Used Coolant................ 222
Drain, Flush, and Refill.................. 220
Inspection........................... 222
Points to Remember.................... 223
Pressure Cap......................... 221
Radiator Cap......................... 221
Rubber and Plastic Components............ 224
288 INDEX

Compartment......................... 194
Coolant (Antifreeze).................219,252
Cooling..........................104,219
Exhaust Gas Caution................29,57,171
Fails to Start.......................... 135
Flooded, Starting...................... 135
Fuel Requirements..................168,251
Oil ...........................198,251,252
Oil Change Interval.................... 199
Oil Disposal.......................... 201
Oil Filler Cap......................... 200
Oil Filter............................ 201
Oil Selection.......................200,251
Overheating.......................104,176
Engine Oil Viscosity...................200,251
Engine Oil Viscosity Chart................. 200
Ethanol............................... 169
Exhaust Gas Caution..............29,57,171,218
Exhaust System.......................57,218Filters
Air Cleaner.......................... 203
Engine Fuel.......................... 204
Engine Oil........................201,252
Engine Oil Disposal.................... 201
Flashers
Hazard Warning.....................99,176
Turn Signal.........................82,99
Flash-To-Pass........................... 84
Flooded Engine Starting................... 135
Floor Console........................... 92
Fluid Capacities......................... 251
Fluid Leaks............................. 59
Fluid Level Checks
Brake............................226,253
Capacities........................... 251
Clutch Fluid.......................... 228
Cooling System....................... 219
Engine Oil........................... 198
290 INDEX