fuel FIAT 500 2012 2.G Owner's Guide

Engine Oil
Checking Oil Level
To assure proper engine lubrication, the engine oil must
be maintained at the correct level. Check the oil level at
regular intervals, such as every fuel stop. The best time to
check the engine oil level is about five minutes after a
fully warmed engine is shut off. Do not check oil level
before starting the engine after it has sat overnight.
Checking engine oil level when the engine is cold will
give you an incorrect reading.
Checking the oil while the vehicle is on level ground, and
about five minutes after a fully warmed engine is shut
off, will improve the accuracy of the oil level readings.
Maintain the oil level between the range markings on the
dipstick. The safe range is indicated by a crosshatch zone.
Adding 1 qt (1L) of oil when the reading is at the low end
of the indicated range will result in the oil level at the full
end of the indicator range.
CAUTION!
Do not overfill the engine with oil. Overfilling the
engine with oil will cause oil aeration, which can
lead to loss of oil pressure and an increase in oil
temperature. This loss of oil pressure and increased
oil temperature could damage your engine.
Change Engine Oil
The oil change indicator system will remind you that it is
time to take your vehicle in for scheduled maintenance.
Refer to the “Maintenance Schedule” for further informa-
tion.
NOTE: Under no circumstances should oil change
intervals exceed 8,000 miles (13 000 km) or six months,
whichever occurs first.
310 MAINTAINING YOUR VEHICLE

Engine Oil Selection
For best performance and maximum protection for all
engines under all types of operating conditions, the
manufacturer recommends engine oils that are API Cer-
tified and meet the requirements of Chrysler Material
Standard MS-6395.
American Petroleum Institute (API) Engine Oil
Identification Symbol
This symbol means that the oil has
been certified by the American
Petroleum Institute (API). The
manufacturer only recommends
API Certified engine oils.
CAUTION!
Do not use chemical flushes in your engine oil as the
chemicals can damage your engine. Such damage is
not covered by the New Vehicle Limited Warranty.
Engine Oil Viscosity (SAE Grade)
SAE 5W-30 engine oil is recommended for all operating
temperatures. This engine oil improves low temperature
starting and vehicle fuel economy. Your engine oil filler
cap also states the recommended engine oil viscosity
grade for your engine.
Lubricants which do not have both the engine oil certi-
fication mark and the correct SAE viscosity grade num-
ber should not be used.
The engine oil filler cap also shows the recommended
engine oil viscosity for your engine. For information on
7
MAINTAINING YOUR VEHICLE 311

CAUTION!
•The catalytic converter requires the use of un-
leaded fuel only. Leaded gasoline will destroy the
effectiveness of the catalyst as an emissions con-
trol device and may seriously reduce engine per-
formance and cause serious damage to the engine.
•Damage to the catalytic converter can result if your
vehicle is not kept in proper operating condition.
In the event of engine malfunction, particularly
involving engine misfire or other apparent loss of
performance, have your vehicle serviced promptly.
Continued operation of your vehicle with a severe
malfunction could cause the converter to overheat,
resulting in possible damage to the converter and
vehicle.Under normal operating conditions, the catalytic con-
verter will not require maintenance. However, it is im-
portant to keep the engine properly tuned to assure
proper catalyst operation and prevent possible catalyst
damage.
NOTE:
Intentional tampering with emissions control
systems can result in civil penalties being assessed
against you.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe
and abnormal catalyst overheating. If this occurs, stop
the vehicle, turn off the engine and allow it to cool.
Service, including a tune-up to manufacturer’s specifica-
tions, should be obtained immediately.
320 MAINTAINING YOUR VEHICLE

Cavity Maxi Fuse Mini Fuse DescriptionF08 30 Amp Green Blower Motor
F09 10 Amp RedPowertrain
F10 10 Amp RedHorn
F11 15 Amp BluePowertrain
F11 10 Amp
Red Powertrain (Multi-
air – If Equipped)
F14 5 Amp Tan High beam (Shut-
ter)
F15 15 Amp
Blue Cigar Lighter
F16 7.5 Amp
Brown TransmissionCavity Maxi Fuse Mini Fuse Description
F17 25 Amp
White Powertrain (Multi-
air – If Equipped)
F17 15 Amp
Blue Powertrain
F18 15 Amp
Blue Powertrain
F18 5 Amp Tan Powertrain (Multi-
air – If Equipped)
F19 7.5 Amp
Brown Air Conditioning
F20 15 Amp
Blue Heated Seats – If
Equipped
F21 15 Amp
Blue Fuel Pump
F23 20 Amp
Yellow Anti-Lock Brake
Valves
7
MAINTAINING YOUR VEHICLE 341

FLUID CAPACITIES
U.S.Metric
Fuel (Approximate) 10.5 Gallons40 Liters
Engine Oil with Filter
1.4 Liter Engine 4 Quarts4 Liters
Cooling System
1.4 Liter Engine (MOPAR Antifreeze/Engine Coolant
10 Year/152,000 Mile Formula or equivalent) — with Manual
Transmission 4.6 Quarts
4.4 Liters
1.4 Liter Engine (MOPAR Antifreeze/Engine Coolant
10 Year/152,000 Mile Formula or equivalent) — with Auto-
matic Transmission 5.8 Quarts
5.5 Liters
7
MAINTAINING YOUR VEHICLE 347

FLUIDS, LUBRICANTS, AND GENUINE PARTS
Engine
ComponentFluid, Lubricant, or Genuine Part
Engine Coolant MOPARAntifreeze/Coolant 10 Year/152,000 Mile Formula OAT (Or-
ganic Additive Technology) or equivalent meeting the requirements of
Chrysler Material Standard MS-12106.
Engine Oil Use API Certified SAE 5W-30 Engine Oil, meeting the requirements of
Chrysler Material Standard MS-6395. Refer to your engine oil filler cap for
correct SAE grade.
Engine Oil Filter MOPAREngine Oil Filter or equivalent.
Spark Plugs DCPR7E-N-10 (Gap 0.040 in [1.02 mm])
Fuel Selection 87 Octane Acceptable — 91 Octane Recommended
348 MAINTAINING YOUR VEHICLE

At Each Stop For Fuel
•Check the engine oil level about five minutes after a
fully warmed engine is shut off. Checking the oil level
while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when
the level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once A Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of the engine coolant reservoir
and brake master cylinder, and add as needed.
•Check all lights and other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
8
M A I
N T
E
N A
N CE
S
C
H E
D
U L
E
SMAINTENANCE SCHEDULES 353

Adding Engine Coolant (Antifreeze).......... 323
Adding Fuel ........................... 266
Adding Washer Fluid ..................... 318
Additives, Fuel ......................... 263
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 312
Air Conditioner Maintenance ............... 315
Air Conditioning ........................ 190
Air Conditioning Controls ................. 190
Air Conditioning Refrigerant ............... 315
Air Conditioning System .............190,194,315
Air Conditioning, Operating Tips ............ 200
Air Pressure, Tires ....................... 247
Airbag .............................. 40,50
Airbag Deployment ....................... 52
Airbag Light ..................... 48,55,70,135
Airbag Maintenance ....................... 54
Airbag, Side ...................... 44,46,49,50
Airbag, Window (Side Curtain) ...........44,46,50
Alterations/Modifications, Vehicle ............. 7Anti-Lock Brake System (ABS)
.............. 228
Anti-Lock Warning Light .................. 141
Antifreeze (Engine Coolant) ...........322,347,348
Capacities .......................... 347
Disposal ........................... 324
Appearance Care ........................ 330
Automatic Dimming Mirror ................. 81
Automatic Door Locks ..................... 24
Automatic Temperature Control (ATC) ......... 194
Automatic Transaxle ...................... 12
Automatic Transmission ................ 211,329
Adding Fluid ....................... 330
Fluid and Filter Changes ............... 330
Fluid Level Check .................... 330
Fluid Type ......................... 329
Gear Ranges ........................ 213
Special Additives ..................... 330
Autostick ............................. 218
378 INDEX

B-Pillar Location........................ 242
Battery ............................... 313
Jump Starting ....................... 293
Keyless Transmitter Replacement (RKE) ..... 20
Belts, Seat .............................. 69
Body Mechanism Lubrication ............... 316
Brake Assist System ...................... 230
Brake Fluid ............................ 349
Brake System ........................ 228,326
Anti-Lock (ABS) .................. 228,230
Master Cylinder ..................... 327
Parking ........................... 224
Warning Light ....................... 140
Brake, Parking .......................... 224
Brake/Transmission Interlock ............... 212
Brakes ............................... 326
Break-In Recommendations, New Vehicle ........ 67
Bulbs, Light ............................ 72 Capacities, Antifreeze (Engine Coolant)
........ 347
Capacities, Fluid ........................ 347
Caps, Filler Fuel .............................. 266
Oil (Engine) ........................ 311
Car Washes ............................ 331
Carbon Monoxide Warning ...............68,265
Cargo Area Features ...................... 126
CD (Compact Disc) Player ................. 161
Cellular Phone .......................... 189
Chains, Tire ............................ 253
Changing A Flat Tire ..................... 282
Chart, Tire Sizing ........................ 238
Check Engine Light
(Malfunction Indicator Light) .............138,306
Checking Your Vehicle For Safety ............. 68
Checks, Safety ........................... 68
Child Restraint ........................ 57,58
Child Restraint Tether Anchors ............... 61
10
INDEX 379

Engine Oil......................... 312
Door Locks ............................. 22
Door Locks, Automatic .................... 24
Downshifting ........................... 211
Driving On Slippery Surfaces .................. 220
Through Flowing, Rising, or Shallow Standing
Water ............................. 221
Electric Remote Mirrors .................... 82
Electrical Power Outlets ................... 121
Electronic Brake Control System ............. 229
Anti-Lock Brake System ................ 230
Brake Assist System ................... 230
Traction Control System ................ 231
Electronic Speed Control (Cruise Control) ...... 109
Electronic Stability Control (ESC) ............. 232
Electronic Vehicle Information Center (EVIC) .... 144Emergency, In Case of
Hazard Warning Flasher ............... 271
Jacking ............................ 282
Jump Starting ....................... 293
Towing ............................ 299
Emission Control System Maintenance ......... 306
Engine Break-In Recommendations .............. 67
Checking Oil Level ................... 310
Compartment ....................... 305
Cooling ........................... 321
Exhaust Gas Caution ................68,265
Fails to Start ........................ 208
Flooded, Starting ..................... 208
Fuel Requirements .................... 261
Oil ......................... 310,347,348
Oil Change Interval ................... 310
Oil Filler Cap ....................... 311
Oil Filter ........................... 348
10
INDEX 381