steering FIAT 500L 2017 2.G Service Manual

If the ignition key is unavailable, or the battery is
discharged, refer to “Gear Selector Override” in this
section for instructions on shifting the transmission out
of PARK in order to move the vehicle.
CAUTION!
•DO NOT flat tow any vehicle equipped with an
automatic transmission. Damage to the drivetrain
will result. If these vehicles require towing, make
sure all drive wheels are OFF the ground.
• Towing this vehicle in violation of the above
requirements can cause severe transmission dam-
age. Damage from improper towing is not covered
under the New Vehicle Limited Warranty.
IGNITION KEY REMOVAL OVERRIDE
This vehicle is equipped with a Key Ignition Park
Interlock which requires the transmission to be in PARK
before the ignition switch can be turned to the LOCK/
OFF (key removal) position. To remove the key manu-
ally, proceed as follows:
1. Firmly apply the parking brake 2. Remove the Allen Key located in the rear cargo area,
in the tool bag (if equipped) or on the left side in the
cargo box.
3. Unlock the steering column, pull the tilt/telescoping control handle down.
4. Pull the steering wheel outward until it is in the end of the travel position, then lock the steering column
in position, push the control handle up until fully
engaged.
5. Using the Allen key, undo the lower steering column cover screws, and remove the lower cover.
Lower Steering Column Screw Locations
6
WHAT TO DO IN EMERGENCIES 293

6. Pull the release tab downwards using one hand andwith the other one remove the key, sliding it out-
wards.
7. Once the key is removed, reinstall the steering col- umn cover.
CAUTION!
It is advisable to contact your authorized dealer to
have the reinstall procedure carried out. If you
would like to proceed in performing the reinstall
(Continued)
CAUTION! (Continued)
procedure special attention must be paid to the
correct coupling of the clips. Otherwise damage to
the cover or noise might be heard due to incorrect
fastening of the lower cover.
CAP-LESS FUEL FILL FUNNEL
The funnel for the Cap-Less Fuel System is located in
the rear cargo area inside the tool bag (if equipped), or
on the left side in the cargo box. If your vehicle is out of
fuel and an auxiliary fuel can is needed, insert the
funnel into the filler neck and proceed to fill the vehicle.
For more information on the Cap-Less Fuel System refer
to “Adding Fuel” in “Starting And Operating ” in this
manual.
ENHANCED ACCIDENT RESPONSE SYSTEM
(EARS)
This vehicle is equipped with an Enhanced Accident
Response System.
Release Tab Location
294 WHAT TO DO IN EMERGENCIES

Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the
fabric. Sun damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the
vehicle to wash them. Dry with a soft cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
NOTE:If the belts retract slowly, inspect the upper
turning loop for soiling. If soiling is present, clean with
a wet soft cloth until all residue is removed.
WARNING!
A frayed or torn belt could rip apart in a collision
and leave you with no protection. Inspect the belt
system periodically, checking for cuts, frays, or
loose parts. Damaged parts must be replaced imme-
diately. Do not disassemble or modify the system.
Seat belt assemblies must be replaced after a colli-
sion if they have been damaged (i.e., bent retractor,
torn webbing, etc.).
FUSES
WARNING!
• When replacing a blown fuse, always use an
appropriate replacement fuse with the same amp
rating as the original fuse. Never replace a fuse
with another fuse of higher amp rating. Never
replace a blown fuse with metal wires or any
other material. Failure to use proper fuses may
result in serious personal injury, fire and/or prop-
erty damage.
• Before replacing a fuse, make sure that the igni-
tion is off and that all the other services are
switched off and/or disengaged.
• If the replaced fuse blows again, contact an au-
thorized dealer.
• If a general protection fuse for safety systems (air
bag system, braking system), power unit systems
(engine system, gearbox system) or steering sys-
tem blows, contact an authorized dealer.
7
MAINTAINING YOUR VEHICLE 327

Underhood Fuses
The Front Distribution Unit is located on the right side
of the engine compartment, next to the battery. To
access the fuses, push the release tabs and remove the
cover.The ID number of the electrical component correspond-
ing to each fuse can be found on the back of the cover.
Cavity
Maxi Fuse Mini Fuse Description
F01 70 Amp Tan –Body Controller
F02 60 Amp Blue –Body Controller Rear Distribution Unit
F03 20 Amp Yellow –Ignition Switch
F04 40 Amp Orange –Anti-Lock Brake Pump
F05 70 Amp Tan –Electric Power Steering
Front Distribution Unit
328 MAINTAINING YOUR VEHICLE

Power Steering Fluid..................... .342
Pregnant Women And Seat Belts ..............33
Preparation For Jacking ....................281
Pretensioners Seat Belts .............................33
Radial Ply Tires ........................ .251
Radio Frequency General Information ..................14, 18
Radio Operation ........................ .194
Rear Camera .......................... .108
Rear Liftgate (Sedan) ......................24
Rear Window Features ....................127
Reclining Rear Seats .......................82
Recreational Towing ..................... .272
Reformulated Gasoline ....................266
Refrigerant ............................ .306
Reminder, Seat Belt ........................27
Remote Sound System (Radio) Controls ........192
Remote Starting Uconnect Customer Programmable Features . . .185
Uconnect Settings ..................... .185
Replacement Bulbs .......................334
Replacement Keys ........................14
Replacement Parts ........................301 Replacement Tires
........................258
Reporting Safety Defects ...................353
Restraints, Child ..........................49
Rotation, Tires ..........................260
Safety Checks Inside Vehicle .................67
Safety Checks Outside Vehicle ................69
Safety Defects, Reporting ...................353
Safety, Exhaust Gas ........................67
Safety Information, Tire ....................239
Safety Tips ..............................66
Schedule, Maintenance ....................344
Seat Belt Automatic Locking Retractor (ALR) ..........34
Energy Management Feature ...............33
Lap/Shoulder Belts .....................29
Lap/Shoulder Belt Untwisting ..............32
Pregnant Women .......................33
Seat Belt Pretensioner ....................33
Seat Belt Reminder ......................27
Seat Belt Maintenance .....................327
Seat Belt

Reminder ........................27
Seat Belts ............................27, 67
Child Restraint .........................49
Front Seat .......................27, 29, 31
10
INDEX 363

Inspection............................67
Operating Instructions ...................31
Pregnant Women .......................33
Pretensioners ..........................33
Rear Seat .............................29
Reminder ............................139
Untwisting Procedure ....................32
Seats Fold And Tumble Rear ...................83
Reclining .............................79
Security Alarm ...........................14
Sentry Key (Immobilizer) ...................13
Service Assistance ........................350
Service Contract ........................ .352
Service Manuals ........................ .353
Shift Lever Override ..................... .290
Shoulder Belts ...........................29
Signals, Turn ........................ .70, 150
Snow Chains (Tire Chains) ..................259
Snow Tires ............................ .253
Spare Tire ....................253, 254, 255, 256
Spark Plugs ............................340
Speed Control Accel/Decel ..........................103
Speed Control (Cruise Control) ...............100Starting
...............................218
Automatic Transmission .................218
Cold Weather ........................ .218
Engine Fails To Start ....................219
Steering Tilt Column ...........................99
Wheel, Tilt ............................99
Steering Wheel Audio Controls ..............192
Steering Wheel Mounted Sound System Controls . .192
Storage ...............................334
Storage, Vehicle ........................ .205
Stuck, Freeing .......................... .289
Sun Roof ..............................117
Sun Visor Extension .......................77
Telescoping Steering Column .................99
Temperature Control, Automatic (ATC) .........204
Tilt Steering Column .......................99
Tire And Loading Information Placard ......245,246
T

ire Markings .......................... .239
Tires.................... .69, 249, 253, 254, 261
Aging (Life Of Tires) ....................257
Air Pressure .......................245, 249
Chains ............................. .259
Changing ............................280
364 INDEX