brake light FIAT BRAVO 2007 2.G Service Manual
[x] Cancel search | Manufacturer: FIAT, Model Year: 2007, Model line: BRAVO, Model: FIAT BRAVO 2007 2.GPages: 246, PDF Size: 3.75 MB
Page 201 of 246
200
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
WINDSCREEN/REAR
WINDOW/HEADLIGHT
WASHER FLUID fig. 11
To top up, open the cap Aand then pour
a mixture of water and TUTELA PRO-
FESSIONAL SC 35, in the following
concentrations:
❒30% TUTELA PROFESSIONAL
SC 35and 70% water in summer;
❒50% di TUTELA PROFESSIONAL
SC 35and 50% water in winter.
In case of temperatures below –20°C, use
undiluted TUTELA PROFESSIONAL
SC 35 fluid.
fig. 11F0Q0666mDo not travel with the wind-
screen washer reservoir emp-
ty. The windscreen washer is funda-
mental for improving visibility.
WARNING
Certain commercial addi-
tives for windscreen washers
are inflammable. The engine com-
partment contains hot components
which may set it on fire.
WARNING
BRAKE FLUID fig. 12
Unscrew cap Aand check that the fluid
level in the reservoir is at maximum.
Fluid level in the reservoir shall not exceed
the MAXmark.
If fluid has to be added, it is suggested to
use the brake fluid in table “Fluids and lu-
bricants” (see chapter “Technical specifi-
cations”). When opening cap Atake the
utmost care to prevent impurities enter-
ing the tank.
For topping up, always use a funnel with
integrated filter with mesh equal to or
lower than 0.12 mm.
fig. 12F0Q0664m
Check level through the reservoir.
For versions fitted with headlight wash-
er, remove the filter and the relevant dip-
stick. Use the dipstick to check the fluid
level inside the reservoir.
191-212 BRAVO GB 10-05-2007 9:21 Pagina 200
Page 202 of 246
Make sure that the highly cor-
rosive brake fluid does not drip
onto the paintwork; if it does,
wash it off immediately with
water.
201
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
Symbol π, on the container
indicates synthetic brake flu-
id, distinguishing it from the mineral
kind. Using mineral fluids irreversibly
damages the special braking system
rubber seals.
WARNING
Brake fluid is poisonous and
highly corrosive. In the event
of accidental contact, wash the parts
involved immediately with neutral
soap and water, then rinse thor-
oughly. Call the doctor immediately
if the fluid is swallowed.
WARNINGAIR CLEANER/
POLLEN FILTER
Air cleaner or pollen filter replacement
shall be carried out at Fiat Dealership. IMPORTANT Brake fluid absorbs mois-
ture. For this reason, if the car is mainly
used in areas with a high degree of at-
mospheric humidity, the fluid should be
replaced at more frequent intervals than
specified in the “Service schedule”.
191-212 BRAVO GB 10-05-2007 9:21 Pagina 201
Page 206 of 246
205
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
RUBBER HOSES
As far as the brake system and fuel rubber
hoses are concerned, carefully follow the
“Service schedule” in this section.
Indeed ozone, high temperatures and pro-
longed lack of fluid in the system may
cause hardening and cracking of the hoses,
with possible leaks. Careful control is
therefore necessary.Remember that road holding
depends also on the correct
tyre inflating pressure.
WARNING
If the pressure is too low the
tyre overheats and this can
cause it serious damage.
WARNING
Do not cross switch the
tyres, moving them from the
right of the car to the left and vice
versa.
WARNING
Never submit alloy rims to
repainting treatments re-
quiring to use temperatures exceed-
ing 150°C since the mechanical prop-
erties of the wheels could be im-
paired.
WARNING
191-212 BRAVO GB 10-05-2007 9:21 Pagina 205
Page 213 of 246
212
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
If drops of the special products used to
clean the windscreen should fall on the
leather steering wheel/gear lever/hand-
brake, remove it immediately and then
wash effected area with neutral soap and
water.
IMPORTANT Take the utmost care when
engaging the steering lock to prevent
scratching the leather covering.
Do not keep aerosol cans in
the car: they might explode.
Aerosol cans must never be exposed
to a temperature above 50°C. The
temperature inside the car exposed
to the sun may go well beyond that
figure.
WARNINGREAL LEATHER TRIMMED
STEERING WHEEL/
GEAR LEVER/HAND BRAKE
These components shall only be cleaned
with water and neutral soap. Never use
spirit or alcohol-based products.
Before using special products for clean-
ing interiors, read carefully label instruc-
tions and indications to make sure they
are free from spirit and/or alcohol-based
substances.
191-212 BRAVO GB 10-05-2007 9:21 Pagina 212
Page 214 of 246
213
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONS
IDENTIFICATION DATA ................................................... 214
ENGINE CODES - BODYWORK VERSIONS .............. 216
ENGINE .................................................................................... 217
FUEL FEED/IGNITION ........................................................ 218
TRANSMISSION .................................................................... 218
BRAKES ..................................................................................... 219
SUSPENSIONS......................................................................... 219
STEERING ................................................................................. 219
WHEELS .................................................................................... 220
DIMENSIONS .......................................................................... 224
PERFORMANCE ..................................................................... 225
WEIGHTS ................................................................................. 226
CAPACITIES ........................................................................... 227
FLUIDS AND LUBRICANTS ............................................... 228
FUEL CONSUMPTION ........................................................ 230
CO
2EMISSIONS .................................................................... 231
RADIO FREQUENCY REMOTE CONTROL:
MINISTERIAL HOMOLOGATION .................................. 232
T T
E E
C C
H H
N N
I I
C C
A A
L L
S S
P P
E E
C C
I I
F F
I I
C C
A A
T T
I I
O O
N N
S S
213-236 BRAVO GB 16-05-2007 10:11 Pagina 213
Page 220 of 246
219
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONS
SUSPENSIONS
1.4 16V- 1.4 T-JET 150 HP - 1.9 Multijet 8V- 1.9 Multijet 16V
Front
RearMcPherson independent wheels
Interconnected wheels with twisting axle
BRAKES
1.4 16V- 1.4 T-JET 150 HP - 1.9 Multijet 8V- 1.9 Multijet 16V
Service brakes:
– front
– rear
Parking brake
IMPORTANT Water, ice and antifreeze salt on roads may deposit on the brake discs thus reducing braking efficiency
at first braking.
STEERING
1.4 16V- 1.4 T-JET 150 HP - 1.9 Multijet 8V- 1.9 Multijet 16V
Type
Minimum steering cycle mDisc, self-ventilating
Disc
Controlled by hand lever, it works on the rear brakes
Rack and pinion with electric power steering
10.4 (11.0 with 18” alloy wheel option)
213-236 BRAVO GB 16-05-2007 10:11 Pagina 219
Page 227 of 246
1.4 T-JET 150 HP
1275
510
1000
860
1785
1300
500
80
60
226
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONSDASHBOARD
AND CONTROLS
1.4 16V1.9 Multijet 8V1.9 Multijet 16V
1205
510
1000
860
1715
1000
500
80
601320
510
1060
860
1830
1300
500
80
601360
510
1060
860
1870
1300
500
80
60
WEIGHTS
Weights (kg)
Kerb weight
(including all fluids, fuel tank
at 90% and with no optional)
Payload (*) including the driver:
Maximum admitted loads (**)
– front axle:
– rear axle:
– total:
Towable loads
– trailer with brakes:
– trailer without brakes:
Maximum load on roof (***):
Maximum load on tow hitch
(trailer with brakes):
(*) If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases, thus reducing the specified payload.
(**) Loads not to be exceeded. The driver is responsible for arranging the loads in the boot an/or on the roof so that they com-
ply with these limits.
(***) Lineaccessori Fiat roof rack, max capacity: 50 kg.
213-236 BRAVO GB 16-05-2007 10:11 Pagina 226
Page 228 of 246
CAPACITIES
1.4 16V - 1.4 T-JET 150 HP
227
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONS
1.9 Multijet
Fuel tank:
including a reserve of:
Engine cooling system– with climate control:
Engine sump:
Engine sump and filter:
Gearbox/differential casing:
Hydraulic brake circuitwith ABS:
Windscreen /
rear window / headlight
washer fluid reservoir: (*)
(*) The values in brackets refer to versions with headlight washers.
(
❏) Version 1.9 Multijet 8v
(
) Version 1.9 Multijet 16v
(
❍) Version 1.4 T-JET 150 HP
(▲) For particularly hard climate conditions, we recommend use of a 60% PARAFLUUPand 40% demineralized water mixture.
litres
57 ()
8-10 ()
–
4.4 ()
4.7 ()
1.76 (
❏)
1.87 ()
–
3 (6)kg
–
–
7.0
3.8 ()
4.0 ()
1.6 (❏)
1.7 ()
0.525
– kg
–
–
5.2
2.4
2.55
1.7
2.0 (❍)
0.525
–Recommended fuels and
genuine lubricants
Unleaded petrol
with no less than 95 R.O.N
(Specification EN228)
() Diesel fuel for motor vehicles
(Specification EN590)
Mixture of 50% demineralised water
and 50% PARAFLU
UP(▲)
SELENIA K P.E.
() SELENIA WR
TUTELA CAR TECHNYX
TUTELA CAR MATRYX (
❍)
TUTELA TOP 4
Mixture of water and
TUTELA
PROFESSIONAL SC 35 litres
57
8-10
–
2.75
2.9
1.87
2.4 (❍)
–
3 (6)
213-236 BRAVO GB 16-05-2007 10:11 Pagina 227
Page 230 of 246
Mechanical gearbox
and differential
Mechanical gearbox
and differential
CV joints
on differential side
CV joints on wheel side
Brake and clutch
hydraulic controls
Radiator antifreeze propor-
tion: 50% distilled water and
50% PARAFLU
UP(❑)
To be used diluted
or undiluted
To be mixed with diesel fuel
(25 cc per 10 litres) Lubricants
and greases for
transmissions
Protective
agent
for radiators
229
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONS
TUTELA CAR
TECHNYX
TUTELA CAR
MATRYX
TUTELA
STAR 700
TUTELA ALL STAR
TUTELA TOP 4
PARAFLU
UP(●)
TUTELA
DIESEL ART
TUTELA
PROFESSIONAL
SC 35 Windscreen/
rear window/
headlight
washer fluid Brake
fluid
Additive for
diesel fuelSynthetic-based oil, grade SAE 75W-85
that passes API GL-4 PLUS, FIAT 9.55550 specifications.
Synthetic-based oil, grade SAE 75W-85
that passes API GL-4 specifications
Specifc grease to be used for constant-velocity joints with
low friction coefficient. N.L.G.I. 0-1 consistency.
Grease containing Molybdenum bisulphide for high
temperature appliances. N.L.G.I. 1-2 consistency.
Synthetic fluid, FMVSS n° 116 DOT 4, ISO 4925
SAE J1704, CUNA NC 956-01
Protective with antifreeze action, red colour
based on inhibited monoethylen glycol and organic formula,
that passes CUNA NC 956-16, ASTM D 3306 specifications.
Additive for diesel fuels with protective action for Diesel engines
Mixture of alcohol and surfactants CUNA NC 956-11
Use Fluid and lubricant specifications Genuine fluids Applicationsfor correct car operation and lubricants
(●) IMPORTANT Do not add or mix fluids having different specifications from that already existing.
(❑) For particularly hard climate conditions, we recommend use of a 60% PARAFLUUPand 40% demineralized water mixture.
213-236 BRAVO GB 16-05-2007 10:11 Pagina 229
Page 238 of 246
237
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Car maintenance ............................ 191
– scheduled servicing ........................ 192
– service schedule ............................ 193
– heavy duty ....................................... 195
– routine maintenance .................... 195
Carrying children safely ..................... 112
Ceiling lights ......................................... 63
Central door locking system ............ 75
Checking fluid levels ............................ 196
Child locks ............................................ 75
Cigar lighter .......................................... 69
CO
2 emissions ..................................... 231
Code Card ............................................ 10
Containing running costs ................... 135
Controls ................................................ 65
Correct use of the car................. 129
Courtesy mirror light
(bulb replacement) ........................... 177
Cruise Control ................................... 61
Current outlet ..................................... 69
Dashboard ........................................... 5
Dashboard and controls .............. 4
Daylight sensor .................................... 56Diesel particulate filter (DPF) .......... 104
Dimensions ........................................... 224
Dipped beam headlights .................... 55
Direction indicators
– activation ......................................... 55
– bulbs replacement ................ 171-172
Doors
– child lock .......................................... 75
– rear doors emergency
lock device ...................................... 76
DPF (diesel particulate filter) ........... 104
Dualdrive
(electric power steering) ................ 94
Engine codes/Bodywork versions .. 216
Engine compartment (washing) ....... 210
Engine starting .............................. 130-156
EOBD system ....................................... 91
ESP system ............................................ 88
Exterior lights (replacement) ........... 170
External lights ....................................... 55
Fiat CODE system ............................. 8
Fix&Go automatic ............................... 163
Fluids and lubricants ........................... 228
ABS ........................................................ 86
Air bag
– front ................................................. 120
– side ................................................... 123
Air cleaner/Pollen filter ...................... 201
Alarm ...................................................... 16
Ashtray ................................................... 69
ASR system ........................................... 89
At the filling station ............................ 102
Automatic two-zone climate
control system .................................. 49
Battery ................................................... 79
– jump starting .................................. 156
– recharge .......................................... 188
– replacement .................................... 202
Bodywork .............................................. 208
– bodywork versions ....................... 216
Bonnet ..................................................... 83
Boot ........................................................ 79
Brake Assist ........................................... 87
Brakes ..................................................... 219
Capacities ............................................. 227
Car inactivity.......................................... 140
I I
N N
D D
E E
X X
237-244 BRAVO GB 10-05-2007 9:23 Pagina 237