transmission FIAT BRAVO 2007 2.G Owners Manual
[x] Cancel search | Manufacturer: FIAT, Model Year: 2007, Model line: BRAVO, Model: FIAT BRAVO 2007 2.GPages: 246, PDF Size: 3.75 MB
Page 94 of 246
93
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
INSTALLATION OF
ELECTRIC/ELECTRONIC
DEVICES
Electric/electronic devices installed after
buying the car and in after-market shall
bear the following marking:IMPORTANT The installation of devices
involving modifications of car character-
istics may determine the withdrawal of the
driving licence by the appointed public au-
thorities and the forfeiture of the warranty
as concerns defects/failures due to said
modification or leading directly or indi-
rectly to it.
Fiat Auto S.p.A. declines all responsibility
due to damages connected with the in-
stallation of accessories/devices not sup-
plied by or recommended by Fiat Auto
S.p.A. and installed not in compliance with
the specified prescriptions.RADIO TRANSMITTERS AND
CELLULAR TELEPHONES
Radio transceiver equipment (e.g.: e-tacs
mobile phones, HAM radio systems and
the like) shall not be used inside the car
unless a separate aerial is mounted on the
roof.
IMPORTANT The use of similar devices
inside the passenger compartment (with-
out separated aerial) produces radio-fre-
quency electromagnetic fields which, am-
plified by the resonance effects inside the
passenger compartment, may cause elec-
trical systems equipping the car to mal-
function. This could compromise safety in
addition to constituting a potential hazard
for the passengers.
In addition, transmission and reception of
these devices may be affected by the
shielding effect of the car body.
As concerns -approved mobile phones
(GSM, GPRS, UMTS), strictly comply with
the instructions for use provided by the
mobile phone’s manufacturer.
Fiat Auto S.p.A. authorizes the installation
of transceivers, provided that installation
is workmanlike performed in compliance
with Manufacturer’s specifications at a spe-
cialised service centre.
083-104 BRAVO GB 10-05-2007 9:10 Pagina 93
Page 196 of 246
195
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
ROUTINE
MAINTENANCE
Every 1,000 km or before long journeys,
check and top up if required:
❒engine coolant fluid level;
❒brake fluid level;
❒windscreen washer fluid level;
❒tyre pressure and conditions;
❒light system operation (headlights, di-
rection indicators, hazard lights, etc.);
❒windscreen wiper/washer operation
and windscreen/rear window blade
position/wear;
Every 3,000 km check and top up if re-
quired: engine oil level.
You are recommended to use FL Sele-
nia, products, designed and produced
specifically for Fiat cars (see table “Ca-
pacities” in section “Technical specifica-
tions”).
HEAVY-DUTY
Should prevailing use of the car be under
one of the following specially heavy con-
ditions:
❒trailer or caravan towing;
❒dusty roads;
❒short distances (less than 7-8 km) re-
peated and with external tempera-
tures below zero;
❒frequently idling engines or long dis-
tance low speed driving (e.g. door-to-
door deliveries) or in case of a long
term inactivity;
❒driving in the city;
carry out the following checks more fre-
quently than required in the Service
Schedule:
❒check front disk brake pad conditions
and wear;
❒check cleanness of locks, bonnet and
boot and lever cleanness and lubrica-
tion;
❒sight inspect the conditions of: engine,
gearbox, transmission, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.);
❒check battery charge and fluid level
(electrolyte) (only to be carried out by
skilled personnel or at Fiat Dealership
– see also paragraph “Battery” in this
section);
❒visual check on various drive belt con-
ditions;
❒check and replace pollen filter, if re-
quired;
❒check and replace air cleaner, if re-
quired.
191-212 BRAVO GB 10-05-2007 9:21 Pagina 195
Page 214 of 246
213
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONS
IDENTIFICATION DATA ................................................... 214
ENGINE CODES - BODYWORK VERSIONS .............. 216
ENGINE .................................................................................... 217
FUEL FEED/IGNITION ........................................................ 218
TRANSMISSION .................................................................... 218
BRAKES ..................................................................................... 219
SUSPENSIONS......................................................................... 219
STEERING ................................................................................. 219
WHEELS .................................................................................... 220
DIMENSIONS .......................................................................... 224
PERFORMANCE ..................................................................... 225
WEIGHTS ................................................................................. 226
CAPACITIES ........................................................................... 227
FLUIDS AND LUBRICANTS ............................................... 228
FUEL CONSUMPTION ........................................................ 230
CO
2EMISSIONS .................................................................... 231
RADIO FREQUENCY REMOTE CONTROL:
MINISTERIAL HOMOLOGATION .................................. 232
T T
E E
C C
H H
N N
I I
C C
A A
L L
S S
P P
E E
C C
I I
F F
I I
C C
A A
T T
I I
O O
N N
S S
213-236 BRAVO GB 16-05-2007 10:11 Pagina 213
Page 219 of 246
218
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONSDASHBOARD
AND CONTROLSModifications or repairs to the fuel system that are not carried out properly or do not take the system’s techni-
cal specifications into account can cause malfunctions leading to the risk of fire.
Six forward gears
and reverse
with synchromesh for
forward gear
engagement
Self-adjusting pedal
without idle
stroke
FrontFive forward gears
and reverse
with synchromesh for
forward gear
engagement
Self-adjusting pedal
without idle
stroke
Front
FUEL FEED/IGNITION
1.4 16V1.4 T-JET 150 HP 1.9 Multijet 8V1.9 Multijet 16V
Fuel feed Multipoint sequential Multipoint sequential phased Direct injection with
phased electronic injection electronic injection with electronically controlled
returnless system turbosupercharger Multijet “Common Rail”
and intercooler turbosupercharger
and intercooler
TRANSMISSION
1.4 16V- 1.4 T-JET 150 HP - 1.9 Multijet 16V1.9 Multijet 8V
Gearbox
Clutch
Drive
213-236 BRAVO GB 16-05-2007 10:11 Pagina 218
Page 230 of 246
Mechanical gearbox
and differential
Mechanical gearbox
and differential
CV joints
on differential side
CV joints on wheel side
Brake and clutch
hydraulic controls
Radiator antifreeze propor-
tion: 50% distilled water and
50% PARAFLU
UP(❑)
To be used diluted
or undiluted
To be mixed with diesel fuel
(25 cc per 10 litres) Lubricants
and greases for
transmissions
Protective
agent
for radiators
229
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONS
TUTELA CAR
TECHNYX
TUTELA CAR
MATRYX
TUTELA
STAR 700
TUTELA ALL STAR
TUTELA TOP 4
PARAFLU
UP(●)
TUTELA
DIESEL ART
TUTELA
PROFESSIONAL
SC 35 Windscreen/
rear window/
headlight
washer fluid Brake
fluid
Additive for
diesel fuelSynthetic-based oil, grade SAE 75W-85
that passes API GL-4 PLUS, FIAT 9.55550 specifications.
Synthetic-based oil, grade SAE 75W-85
that passes API GL-4 specifications
Specifc grease to be used for constant-velocity joints with
low friction coefficient. N.L.G.I. 0-1 consistency.
Grease containing Molybdenum bisulphide for high
temperature appliances. N.L.G.I. 1-2 consistency.
Synthetic fluid, FMVSS n° 116 DOT 4, ISO 4925
SAE J1704, CUNA NC 956-01
Protective with antifreeze action, red colour
based on inhibited monoethylen glycol and organic formula,
that passes CUNA NC 956-16, ASTM D 3306 specifications.
Additive for diesel fuels with protective action for Diesel engines
Mixture of alcohol and surfactants CUNA NC 956-11
Use Fluid and lubricant specifications Genuine fluids Applicationsfor correct car operation and lubricants
(●) IMPORTANT Do not add or mix fluids having different specifications from that already existing.
(❑) For particularly hard climate conditions, we recommend use of a 60% PARAFLUUPand 40% demineralized water mixture.
213-236 BRAVO GB 16-05-2007 10:11 Pagina 229
Page 240 of 246
239
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Steering wheel ...................................... 40
Sun roof ................................................. 72
Sun visors .............................................. 71
Suspensions ........................................... 219
Symbols .................................................. 8
T.P.M.S. system .................................... 96
Technical specifications .............. 213
Third brake light
(bulb replacement) ........................... 174
Towing the car ..................................... 189
Towing trailers ..................................... 137
Transmission ........................................ 218
Trip Computer ................................... 35
Tyres
– replacement .................................... 157
– snow tyres ...................................... 139
– standard tyres ................................ 222
– tyre marking ................................... 220
– pressure ............................................ 223
Using the gearbox ............................. 134
Isofix child restraint system .............. 117
Warning lights and messages... 141
Weights ................................................. 226Wheel geometry ................................. 220
Wheels and tyres ....................... 204-220
When needing to change a bulb ...... 167
Window washing ................................. 57
Windows (cleaning) ............................ 210 Remote control: ministerial
homologations ................................... 232
Right hand drive versions............ 234
Rim marking .......................................... 221
Roof rack/ski rack ............................... 84
Rubber hoses ....................................... 205
Safe lock device .................................. 14
S.B.R system ......................................... 108
Safety devices................................... 105
Seat belts ............................................... 106
Seats ........................................................ 37
– cleaning ............................................ 210
– manual adjustment ........................ 37
– electrical adjustment .................... 38
– seat warming .................................. 38
Side lights
– activation ......................................... 55
– bulbs replacement ................ 171-172
Smart washing function ...................... 58
Snow chains .......................................... 139
Sound System ....................................... 92
Spark plugs ............................................ 217
Sport function ...................................... 95
Spray nozzles ........................................ 207
Steering .................................................. 219
Steering column lock .......................... 19
237-244 BRAVO GB 10-05-2007 9:23 Pagina 239