brake FIAT BRAVO 2012 2.G Service Manual

1.4 Turbo MultiAir version1. Engine oil 2. Battery 3. Brake fluid 4. washer fluid for windscreen/rear window/headlights 5. Engine coolant
fig. 200
F0Q0763
233GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCYSERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX

1.6 MultiJet version1. Engine oil 2. Battery 3. Brake fluid 4. washer fluid for windscreen/rear window/headlights 5. Engine coolant
fig. 201
F0Q0767
234GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCYSERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX

2.0 MultiJet version1. Engine oil 2. Battery 3. Brake fluid 4. washer fluid for windscreen/rear window/headlights 5. Engine coolant
fig. 202
F0Q0768
235GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCYSERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX

WARNING
Do not travel with the windscreen
washer reservoir empty: the windscreen
washer is essential for improving visibility.
Some commercial windscreen washer additives
are flammable.The engine compartment
contains hot components which may set it on
fire.
BRAKE FLUID
Undo the cap A shown in the figure: fig. 210check
that the fluid contained in the reservoir is at the
maximum level. The fluid level in the reservoir must
not exceed the MAX mark. If you need to top up,
you should use the brake fluid shown in the "Fluids
and lubricants" table (see chapter "Technical data").
When opening the cap A, make sure that no dirtgets into the reservoir. Always use a funnel with a
built-in filter with a mesh of 0.12 mm or less for
topping up.
IMPORTANT Brake fluid is hygroscopic (i.e. it
absorbs moisture). For this reason, if the car is
mainly used in areas with a high degree of
atmospheric humidity, the fluid should be replaced
at more frequent intervals than specified in the
“Scheduled Servicing Plan”.
Prevent brake fluid, which is highly
corrosive, from coming into contact with
painted parts. Should it happen,
immediately wash with water.
fig. 209
F0Q0666
fig. 210
F0Q0664
239GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCYSERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX

WARNING
Brake fluid is poisonous and highly
corrosive. If contact accidentally occurs,
immediately wash the affected areas with
water and a neutral detergent , and then rinse
thoroughly with water. Call a doctor
immediately if swallowed.
WARNING
The symbol
on the container
indicates a synthetic brake fluid, which
is different from a mineral fluid. Using a
mineral-type fluid will damage the special
rubber seals of the braking system beyond
repair.
AIR CLEANER/POLLEN
FILTER/DIESEL FILTERFor filter replacement, contact a Fiat Dealership.
240GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCYSERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX

PLASTIC AND COATED PARTS
Clean interior plastic parts with a damp cloth (if
possible made from microfibre), and a solution
of water and neutral, non-abrasive detergent. To
clean oily or persistent stains, use specific products
free from solvents and designed to maintain the
original appearance and colour of the components.
Remove any dust using a microfibre cloth, if
necessary moistened with water. The use of paper
tissues is not recommended as these may leave
residues.
IMPORTANT Never use alcohol or petroleum to
clean the instrument panel.LEATHER STEERING WHEEL/GEAR
KNOB/HANDBRAKE
These components must be cleaned with mild soap
and water only. Never use alcohol or alcohol-based
products.
Read the product label carefully before using
specific products for cleaning the interiors: make
sure the product does not contain alcohol or
alcohol-based substances.
If, when cleaning the windscreen with special
products, window cleaner accidentally drips onto
the leather of the steering wheel/gear lever
knob/hand brake, wipe away immediately and then
wash the affected area with mild soap and water.
IMPORTANT Be careful when using a steering
wheel lock device, where applicable, to avoid
damaging the leather upholstery by rubbing.
251GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCYSERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX

TRANSMISSIONVersions Gearbox Clutch Drive
1.4 16V - 1.4 T-JET - 1.4 Turbo MultiAir -
1.6 MultiJet - 2.0 MultiJetSix forward gears
plus reverse with
synchronisers for
forward gear
engagementSelf-adjusting with
pedal without idle
strokeFrontBRAKESVersionsFront service
brakesRear service
brakesParking brake
1.4 16V - 1.4 T-JET - 1.4 Turbo MultiAir -
1.6 MultiJet - 2.0 MultiJetSelf-ventilated disc DiscControlled by hand
lever, acting on the
rear brakesIMPORTANT Water, ice and salt spread on the roads may deposit on the brake discs reducing braking
efficiency the first time the brakes are applied.
258GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX

WEIGHTSWeights (kg) 1.4 16V 1.4 Turbo MultiAir 1.4 T-JET 120 HP
Unladen weight (with all fluids, fuel tank filled
to 90% and without optional equipment)1205 1275 1260
Payload:
(*)
including the driver (kg):
510 510 510
Maximum permitted loads:
(**)
– front axle: 1000 1000 1000
– rear axle: 860 860 860
– total: 1715 1785 1770
Towable loads
– trailer with brakes: 1000 1300 1300
– trailer without brakes: 500 500 500
Maximum load on the roof:
(***)
80 80 80
Maximum load on ball (trailer with brakes): 60 60 60
(*) If special equipment is fitted (sun roof, tow hook, etc.) the unladen car weight increases, thus reducing the specified payload with
respect to the maximum permitted loads.
(**) Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or load platform within
the maximum permitted loads.
(***) Lineaccessori Fiat roof rack bars, max capacity: 50 kg.
271GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONSINDEX

Weights (kg) 1.6 MultiJet 2.0 MultiJet
Unladen weight (with all fluids, fuel tank filled
to 90% and without optional equipment)1320 1360
Payload :
(*)
including the driver:
510 510
Maximum permitted loads :
(**)
– front axle: 1060 1060
– rear axle: 860 860
– total: 1830 1870
Towable loads
- braked trailer: 1300 1300
- non-braked trailer: 500 500
Maximum load on roof :
(***)
80 80
Maximum load on ball joint (braked trailer): 60 60
(*) If special equipment is fitted (sun roof, tow hook, etc.) the unladen car weight increases, thus reducing the specified payload with
respect to the maximum permitted loads.
(**) Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or load platform within
the maximum permitted loads.
(***) Lineaccessori Fiat roof rack bars, max capacity: 50 kg.
272GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX

REFUELLINGPetrol versions1.4 16V 1.4 T-Jet1.4 Turbo
MultiAirPrescribed fuels
Original products
litres kg litres kg litres kg
Fuel tank: 57 – 57 – 57 –Unleaded petrol not
less than 95 RON (EN
228 specification) including a reserve of: 8 – 10 – 8 – 10 – 8 – 10 –
Engine cooling system
– with climate control:5,2 4,6 6,0 5,3 6,0 5,350-50 mixture of
demineralised water and
PARAFLU
UP
(°°)
Engine sump: 2,75 2,3 2,75 2,3 3,1 2,6
SELENIA K P.E.
Engine sump and filter: 2,9 2,5 2,9 2,5 3,5 3,0
Gearbox casing/differential: 1.87 1.6 2.4 2.1 1.99 1.7TUTELA CAR
TECHNYX
TUTELA CAR MATRYX
(**)TUTELA
TRANSMISSION
GEARFORCE
(°)
Hydraulic brake circuit with
ABS anti-lock device:0,56 0,525 0,56 0,525 0,56 0,525 TUTELA TOP 4
Windscreen/rear
window/headlight washer
fluid reservoir:
(*)
3 (6) 2,7 (5,3) 3 (6) 2,7 (5,3) 3 (6) 2,7 (5,3)Mixture of water and
TUTELA
PROFESSIONAL SC 35
(°°) For particularly harsh climate conditions, a mixture of 60% PARAFLU
UP
and 40% demineralised water is recommended.
(**) 1.4 T-JET 150 HP versions
(°) 1.4 T-JET 120 HP and 1.4 Turbo MultiAir versions
(*) values in brackets refer to versions with headlight washers
273GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONSINDEX