window FIAT BRAVO 2013 2.G Service Manual

WINDSCREEN/REAR WINDOW
WIPERBLADES
Periodically clean the rubber part using special
products; TUTELA PROFESSIONAL SC 35 is
recommended.
Replace the blades if the rubber edge is deformed
or worn. In any case, it is advisable to replace them
approximately once a year. A few simple
precautions can reduce the possibility of damage to
the blades:
❒if the temperature falls below zero, make sure
that ice has not frozen the rubber against the
glass. Use an antifreeze product to release it
if required;
❒remove any snow from the glass: in addition to
protecting the blades, this prevents effort on
the motor and overheating;
❒do not operate the windscreen/rear window
wipers on dry glass.
WARNING
Driving with worn windscreen/rear
window wiper blades is a serious
hazard, because visibility is reduced in bad
weather.Replacing the wiper blades
Proceed as follows:
❒lift up the windscreen wiper arm and position the
blade so that it forms a 90° angle with the arm;
❒press tab A fig. 212 of the coupling spring and
remove the blade to be replaced from the arm;
❒fit the new blade by inserting the tab into the
special slot in the arm. Make sure that the new
blade is secured in position.
fig. 212
F0Q0662
245GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCYSERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX

Replacing the rear window wiper blade
Proceed as follows:
❒raise cover A fig. 213 and remove the arm from
the car undoing the nut B that fastens it to the
pivot pin;
❒correctly position the new arm and tighten the
nut fully;
❒lower the cover.
NOZZLES
Windscreen (washer)
If the jet is not coming out, firstly check that there
is fluid in the reservoir (see “Checking levels” in
this chapter). Then check that the nozzle holes,
marked by arrows in Fig. fig. 214, are not clogged; if
necessary use a needle. The window washer
nozzles are fixed.Rear window (washer)
The rear window washer nozzles are fixed.
The nozzle holder is on the rear window fig. 215.
fig. 213
F0Q0663
fig. 214
F0Q0661
fig. 215
F0Q0660
246GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCYSERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX

Glasses
To clean glasses, use specific window cleaner
products.
Also use clean cloths to avoid scratching the glass
or damaging the transparency.
IMPORTANT Wipe the rear window inside gently
with a cloth in the direction of the filaments to
avoid damaging the heating device.
Engine compartment
At the end of each winter, thoroughly wash the
engine compartment, taking care to avoid spraying
the water jet directly onto the electronic control
units and the relay/fuse control unit on the left side
of the engine compartment (as you look from
behind the wheel). Have this operation performed
at a specialised workshop.
IMPORTANT The washing should take place with
the engine cold and the ignition key in the STOP
position. After the washing operation, make sure
that the various protections (e.g. rubber caps
and guards) have not been removed or damaged.Front headlights
IMPORTANT Never use aromatic substances (e.g.
petrol) or ketenes (e.g. acetone) for cleaning the
plastic lenses of the front headlights.
249GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCYSERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX

PLASTIC AND COATED PARTS
Clean interior plastic parts with a damp cloth (if
possible made from microfibre), and a solution
of water and neutral, non-abrasive detergent. To
clean oily or persistent stains, use specific products
free from solvents and designed to maintain the
original appearance and colour of the components.
Remove any dust using a microfibre cloth, if
necessary moistened with water. The use of paper
tissues is not recommended as these may leave
residues.
IMPORTANT Never use alcohol or petroleum to
clean the instrument panel.LEATHER STEERING WHEEL/GEAR
KNOB/HANDBRAKE
These components must be cleaned with mild soap
and water only. Never use alcohol or alcohol-based
products.
Read the product label carefully before using
specific products for cleaning the interiors: make
sure the product does not contain alcohol or
alcohol-based substances.
If, when cleaning the windscreen with special
products, window cleaner accidentally drips onto
the leather of the steering wheel/gear lever
knob/hand brake, wipe away immediately and then
wash the affected area with mild soap and water.
IMPORTANT Be careful when using a steering
wheel lock device, where applicable, to avoid
damaging the leather upholstery by rubbing.
251GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCYSERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX

REFUELLINGPetrol versions1.4 16V 1.4 T-Jet1.4 Turbo
MultiAirPrescribed fuels
Original products
litres kg litres kg litres kg
Fuel tank: 57 – 57 – 57 –Unleaded petrol not
less than 95 RON (EN
228 specification) including a reserve of: 8 – 10 – 8 – 10 – 8 – 10 –
Engine cooling system
– with climate control:5,2 4,6 6,0 5,3 6,0 5,350-50 mixture of
demineralised water and
PARAFLU
UP
(°°)
Engine sump: 2,75 2,3 2,75 2,3 3,1 2,6
SELENIA K P.E.
Engine sump and filter: 2,9 2,5 2,9 2,5 3,5 3,0
Gearbox casing/differential: 1.87 1.6 2.4 2.1 1.99 1.7TUTELA CAR
TECHNYX
TUTELA CAR MATRYX
(**)TUTELA
TRANSMISSION
GEARFORCE
(°)
Hydraulic brake circuit with
ABS anti-lock device:0,56 0,525 0,56 0,525 0,56 0,525 TUTELA TOP 4
Windscreen/rear
window/headlight washer
fluid reservoir:
(*)
3 (6) 2,7 (5,3) 3 (6) 2,7 (5,3) 3 (6) 2,7 (5,3)Mixture of water and
TUTELA
PROFESSIONAL SC 35
(°°) For particularly harsh climate conditions, a mixture of 60% PARAFLU
UP
and 40% demineralised water is recommended.
(**) 1.4 T-JET 150 HP versions
(°) 1.4 T-JET 120 HP and 1.4 Turbo MultiAir versions
(*) values in brackets refer to versions with headlight washers
273GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONSINDEX

Diesel versions1.6 MultiJet 2.0 MultiJetPrescribed
fuels Original
products litres kg litres kg
Fuel tank: 57 – 57 –
Diesel for motor
vehicles (EN 590
Specification) including a
reserve of:8–10 – 8–10 –
Engine cooling
system
– with climate
control:7.1 6.3 7.1 6.3Mixture of 50%
demineralised
water and 50%
PARAFLU
UP
(°°)
Engine sump: 4.3 3.6 4.3 3.6
SELENIA W.R.
Engine sump and
filter:4.6 3.9 4.9 4.1
Gearbox
casing/differential:1.87 1.7 1.87 1.7TUTELA
TRANSMISSION
GEARFORCE
Hydraulic brake
circuit with ABS
anti-lock device:0.56 0.525 0.56 0.525 TUTELA TOP 4
Windscreen/rear
window/headlight
washer fluid
reservoir:
(*)
3 (6) 2.7 (5.3) 3 (6) 2.7 (5.3)Mixture of water
and TUTELA
PROFESSIONAL
SC 35
(°°) For particularly harsh climate conditions, a mixture of 60% PARAFLU
UP
and 40% demineralised water is recommended.
(*) values in brackets refer to versions with headlight washers
274GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX

UseFluid and lubricant specifications for a
correct use of the carGenuine fluids and
lubricantsApplications
Protective
agent for
radiatorsRed protective agent with antifreeze action,
based on inhibited monoethyl glycol with
organic formula. Exceeds CUNA NC 956-16,
ASTM D 3306 specifications. FIAT
Classification 9.55523PARAFLU
UP
(*)
Contractual Technical
Reference No.
F101.M01Cooling circuit usage
percentage: 50% water
50%PARAFLU
UP
(**)
Additive for
dieselAdditive for diesel with antifreeze and
protective action for diesel enginesTUTELA DIESEL
ART
Contractual Technical
Reference No. F601.L06To be mixed with diesel
(25 cc per 10 litres)
Windscreen/
rear window
washer fluidMixture of alcohols and surfactants. Exceeds
CUNA NC 956-11 specifications. FIAT
Classification 9.55522TUTELA
PROFESSIONAL SC
35
Contractual Technical
Reference No.
F201.D02To be used diluted or
undiluted in windscreen/
rear window washer/wiper
systems(*) IMPORTANT Do not use fluids with different specifications for topping up or mixing.
(**) For particularly harsh climate conditions, a mixture of 60%PARAFLU
UP
and 40% demineralised water is recommended.
277GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONSINDEX

285 2
RIGHT HAND DRIVE VERSIONS
DASHBOARDThe presence and the position of the instruments and warning lights may vary according to the versions.
1.Adjustable and swivel air vent - 2.Side window air vent - 3.Front passenger air bag - 4.Adjustable and swivel air vents - 5.Haz-
ard light switch - 6.External light stalk - 7.Instrument panel - 8.Windscreen/rear window wiper/trip computer stalk - 9.Bonnet
opening lever - 10.Glovebox - 11.Ignition key and ignition device - 12.Steering wheel locking/release stalk - 13.Driver’s air bag
- 14.Driver’s knees air bag (for versions/markets, where provided) - 15.Set of switches for front/rear fog lights and menu open-
ing/setting 16.Controls for heating/ventilation/climate control - 17.Sound system controls - 18.Set of ON/OFF switches for elec-
tric power steering and ASR system (for versions/markets, where provided) - 19.Oddment compartment
F0Q0005m
fig. 1
217-248 BRAVO GB.qxd:213-236 BRAVO GB 11-04-2011 12:04 Pagina 245

INDEX
A
BS (system) .............................. 106
Activation/Deactivation
(CITY function) ......................... 119
Activation of internal air
recirculation and
enablement of AQS
function (Air Quality
System)......................................... 68
Additional heater .............. 59-64-70
Adjustable side vents and
diffusers........................................ 54
Adjusting headlights
alignment .................................... 105
Air cleaner .................................... 240
Air distribution selection ........... 69
Alarm .............................................. 17
Anti-pinch safety device ............. 91
Ashtray ........................................... 88
ASR (system) ............................... 110
Automatic dual zone climate
control system ........................... 65
Automatic headlight sensor
(dusk sensor) .............................. 73
Automatic operation of the
climate control system
(AUTO function) ....................... 66
Battery ......................................... 241
Battery (recharging) ................... 219
Bodywork
– bodywork codes .................... 254
– maintenance ........................... 247
– protection against
atmospheric agents ............... 247
– warranty .................................. 247
Bodywork versions ..................... 254
Bonnet ........................................... 102
Brake Assist.................................. 108
Brake fluid..................................... 239
Brakes
– specifications .......................... 258
bulb replacement ................ 200-202
Bulb replacement
– exterior lights......................... 197
– interior lights .......................... 204
Bulbs
– bulbs (replacement) .............. 193
– general instructions .............. 193
– types of bulbs ......................... 195Car dimensions........................... 269
Cargo box..................................... 102
Carrying children safely ............. 138– child seats................................ 145
– "Universal Isofix" child
seat assembly setup .............. 144
Central diffusers .......................... 55
Central locking ............................. 92
Changing a wheel ........................ 182
Checking fluid levels ................... 230
Child lock device ......................... 93
Cigar lighter .................................. 87
Cleaning and maintenance
– bodywork ................................ 247
– car interior.............................. 250
– engine compartment ............ 249
– front headlights ...................... 249
– Plastic and coated parts....... 251
– seats ......................................... 250
– windows .................................. 249
Climate control/heating
system .......................................... 53
Climate control system
compressor
activation/deactivation.............. 69
Clutch ............................................ 258
CO2 emissions ............................ 279
Code card...................................... 9
289GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONSINDEX

Control panel and
instruments ................................. 4
Controls .................. 56-60-66-82-95
Courtesy mirror lights
– bulb replacement ................... 207
Cruise Control ............................. 78D
ashboard .................................... 3
Description ................................... 66
Diesel filter ................................... 240
Diffusers......................................... 54
Dipped headlights ........................ 71
– bulb replacement ................... 197
Direction indicators .................... 71
– bulb replacement ................... 199
Display functions (see
Multifunction display or
Reconfigurable
multifunction display)................ 36
Door mirrors ................................ 51
Doors ............................................. 92
DPF (Diesel Particulate
Filter) ........................................... 131
"Dualdrive" electric power
steering system ......................... 119EBD (system) .............................. 107
Electric windows.......................... 95Emergency manoeuvre ............... 92
Engine codes ................................ 254
Engine compartment
– opening/closing ...................... 102
– washing .................................... 249
Engine coolant ............................. 237
Engine coolant temperature
gauge............................................. 25
Engine
– identification codes ............... 254
– marking .................................... 253
– technical data ......................... 255
Engine oil
– Check ....................................... 236
– Consumption ......................... 237
– specifications .......................... 275
– Topping up .............................. 236
Environment protection ............ 130
EOBD system .............................. 116
ESP (system)................................. 108
Exterior lights ............................... 71
Failure indications ...................... 119
Fan speed adjustment ...... 58-63-67
Fast front window
demisting/defrosting ............. 57-62Fiat CODE (system) ................... 8
Fitting "Universal" child seat..... 145
Fix&Go Automatic Kit............... 188
Flashing ........................................... 71
Fluids and lubricants
(specifications) ........................... 275
Fog lights ................................. 82-200
"Follow me home" device ......... 72Front airbags ............................... 147
Front armrest with storage
compartments ............................ 84
Front roof light
– bulb replacement ................... 204
Front roof light with spot
lights.............................................. 80
Front seats with electric
adjustment................................... 47
Fuel cut-off switch ....................... 83
Fuel cut-off system ...................... 83
Fuel
– Fuel savings ............................. 159
Fuel level gauge ............................ 24
Fuel reserve.................................. 273
Fuel savings ................................... 159
Fuel supply .................................... 257
290GETTING TO KNOW
YOUR CAR
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX