multijet FIAT DOBLO 2007 1.G User Guide

151VEHICLE MAINTENANCE
20 40 60 80 100 120 140 160 180
●●●●
●●●
●●●●●●●●●
●●
●
●●●●
●●●●
●●
●●●●●●●●●
(●)(●)(●)(●)(●)(●)(●)(●)(●)
●●●
●●●●●●●●●thousands of kilometres
Replace air cleaner cartridge (petrol versions)
Replace air cleaner cartridge (Multijet versions)
Top up fluids (engine coolant, brakes, windscreen washer, battery, etc.)
Check timing belt conditions (excluding 1.3 Multijet versions)
Replace timing belt (excluding 1.3 Multijet versions) (*)
Replace spark plugs (petrol versions)
Check engine control systems (via diagnostic socket)
Check mechanical transmission oil level
Change engine oil and oil filter (versions without DPF) (O)
Change engine oil and oil filter (Multijet versions with DPF)
(or every 2 years) (**)
Change brake fluid (or every 2 years)
Change pollen filter (or every 2 years)
(*) Or every 4 years for very demanding use (cold climate, idling in city traffic, dusty areas).
Or every 5 years, regardless from the distance travelled.
(
O) Every 30.000 km or 2 years for Multijet versions
(**)Engine oil and oil filter shall be changed according to their actual exhaust conditions, indicated by warning light/message (where provided) on the
instrument panel (see section “Warning lights and messages”).

Be careful not to mix up
the various types of fluids
when you are topping up:
they are all mutually incompati-
ble and could damage the vehicle.Do not smoke while
working in the engine
compartment: the pres-
ence of flammable gas and
vapour could cause a fire.
155VEHICLE MAINTENANCE
F0A0719b
fig. 2 - 1.9 Multijet versions
1.Engine oil - 2.Battery - 3.Brake flu-
id - 4.Windscreen washer fluid - 5.
Engine coolant - 6.Power steering flu-
id.

156VEHICLE MAINTENANCE
1.Engine oil - 2.Battery - 3.Brake flu-
id - 4.Windscreen washer fluid - 5.
Engine coolant - 6.Power steering flu-
id.
F0A0345b
fig. 3 - 1.3 Multijet versions
Do not smoke while
working in the engine
compartment: the pres-
ence of flammable gas and
vapour could cause a fire.
Be careful not to mix up
the various types of fluids
when you are topping up:
they are all mutually incompati-
ble and could damage the vehicle.

157VEHICLE MAINTENANCE
ENGINE OIL fig. 6, 7, 8
Check engine oil with the vehicle on
level ground and while the engine is
still warm (approximately 5 minutes
after stopping the engine.
The oil level should be included be-
tween the MINand MAXreference
marks on the dipstick.
The space between MINand MAX
equals about 1 litre of oil.If the oil level is near or actually be-
low the MINmark, add oil through
the filler until it reaches the MAX
mark.
Oil level shall never exceed the
MAXmark. Be very careful under
the bonnet: you risk burn-
ing yourself. Remember
that when the engine is hot, the
fan can start up and cause in-
juries.
Do not add oil with dif-
ferent specifications from
the oil already in the en-
gine.
fig. 6 - 1.4 8V versions
F0A0536bF0A0346b
fig. 7 - 1.3 Multijet versions

158VEHICLE MAINTENANCE
Used engine oil and re-
placed oil filters contain
substances which can
harm the environment. We rec-
ommend you have the vehicle
seen to at a Fiat Dealership for
the oil and filter change. It is suit-
ably equipped for disposing of
used oil and filters in an environ-
mentally-friendly way that com-
plies with the law.ENGINE OIL CONSUMPTION
Max engine oil consumption is usu-
ally 400 grams every 1000 km.
During the beginning of the vehicle’s
life the engine is be tuned in. Engine oil
consumption can only be considered
stabilised after the first 5000 ÷ 6000
km.
IMPORTANTOil consumption
depends on the driving style and the
conditions of use. IMPORTANTIf, following a check
the engine oil if move the MAXlev-
el, go to a Fiat Dealershipto have
the correct level restored.
IMPORTANT After topping up or
changing the oil, let the engine turn for
a few seconds and wait a few minutes
after stopping it before you check the
level.
fig. 8 - 1.9 Multijet versions
F0A0265b

162VEHICLE MAINTENANCE
REPLACING THE FILTER
fig. 16
Loosen the screws A, remove the
cover and remove the filtering ele-
ment to be replaced B.1.9 Multijet versions
Loosen the three screws A-fig. 18
on the air cleaner cover, remove the
cover B-fig. 19and remove the fil-
tering element C, to be replaced.
A
A
B
A
fig. 18
F0A0155b
B
C
fig. 19
F0A0156b
AIR CLEANER
REPLACEMENT
Petrol versions
Loosen the screws on the side and
on the air cleaner cover, remove the
cover A-fig. 17and remove the fil-
tering element to be replaced.
fig. 17
F0A0720b
A
B
fig. 16
F0A0150b

163VEHICLE MAINTENANCE
1.3 Multijet versions
Loosen the screws D-fig. 21, re-
move the cover Eand remove the fil-
tering element to be replaced.BATTERY
The battery is of the “Limited main-
tenance” type: under normal condi-
tions of use the electrolyte does not
need topping up with distilled water.CHECKING
THE CHARGE
fig. 22
The battery charge may be checked
satisfactorily through the inspection
slot using the indicator and acting ac-
cording to the colour the indicator
shows.
Refer to the table below or to the
plate (see figure) set on the battery.
fig. 21
F0A0347b
fig. 22
F0A0523b
Top up electrolyte
Low charge level
Electrolyte level and charge
sufficientContact Fiat Dealership
Charge the battery
(Contact Fiat Dealership)
No actionBright white
Dark colour
without green area
in the centre
Dark colour with
green area in the
centre

174TECHNICAL SPECIFICATIONS
VEHICLE IDENTIFICATION
DATA CHASSIS MARKING
fig. 1
It is printed on the passenger com-
partment floor, near the right-hand
front seat.
It can be reached by lifting the spe-
cial flap in the carpeting and includes
the following data:
– vehicle model ZFA 223000;
– chassis number.MODEL PLATE
The plate A-fig. 2-3, is applied to the
front engine crossmember.
T T
E E
C C
H H
N N
I I
C C
A A
L L
S S
P P
E E
C C
I I
F F
I I
C C
A A
T T
I I
O O
N N
S S
fig. 1
F0A0163b
fig. 2 - 1.4 8Vversions
F0A0537b
fig. 3 - Multijet versions
F0A0538b
ENGINE MARKING
The marking is stamped on the cylin-
der block and includes the model and
the serial number.

177TECHNICAL SPECIFICATIONS
EUROPEAN HOMOLOGATION
Engine Enginecode
1.3 Multijet 199 A 2000
Versions Bodywork
version code
Cargo 223ZXN1AAX
Cargo high roof 223ZXN1ABX
Cargo extra capacity 223WXN1AAX
Cargo high roof - extra capacity 223WXN1ABX
Cargo small capacity 223ZXN1AAY
Cargo high roof - small capacity 223ZXN1ABY
Cargo Maxi (long wheelbase) 223WXN1AAXL
Cargo Maxi (long wheelbase) - small capacity 223WXN1AAYL
5 seater combi N1 223WXN1AAZ
Engine Engine
code
1.3 Multijet 85 HP 223 A 9000
Versions Bodywork
version code
Cargo 223ZXM1AAX
Cargo high roof 223ZXM1ABX
5 seater combi N1 223ZXM1AAZ
Panorama 223AXM1A08D
Panorama high roof 223AXM1A08B
7 seater family 223AXM1A08E
HOMOLOGATION FOR SPECIFIC MARKETS
Engine Enginecode
1.3 Multijet 199 A 2000
Versions Bodywork
version code
Cargo 223ZXN1AXX
Cargo high roof 223ZXN1AXY
Cargo extra capacity 223WXN1AXX
Cargo high roof - extra capacity 223WXN1AXY
Cargo Maxi (long wheelbase) 223WXN1AXXL
5 seater combi N1 223WXN1AXZ

178TECHNICAL SPECIFICATIONS
EUROPEAN HOMOLOGATION
Engine Engine code
1.9 Multijet 105 HP 223 B 1000
Versions Bodywork
version code
Cargo 223ZXL1AAX
Cargo high roof 223ZXL1ABX
Cargo extra capacity 223WXL1AAX
Cargo high roof - extra capacity 223WXL1ABX
Cargo small capacity 223ZXL1AAY
Cargo high roof - small capacity 223ZXL1ABY
Cargo Maxi (long wheelbase) 223WXL1AAXL
Cargo Maxi (long wheelbase) - small capacity 223WXL1AAYL
5 seater combi N1 223WXL1AAZ
Panorama 223AXL1AA07
Engine Engine
code
1.9 Multijet 100 HP 223 B 2000
Versions Bodywork
version code
Cargo 223ZXR1AAX
Cargo high roof 223ZXR1ABX
Cargo extra capacity 223WXR1AAX
Cargo high roof - extra capacity 223WXR1ABX
Cargo Maxi (long wheelbase) 223WXR1AAXL
HOMOLOGATION FOR SPECIFIC MARKETS
Engine Engine code
1.9 Multijet 105 HP 223 B 1000
Versions Bodywork
version code
Cargo 223ZXL1AXX
Cargo high roof 223ZXL1AXY
Cargo extra capacity 223WXL1AXX
Cargo high roof - extra capacity 223WXL1AXY
Cargo Maxi (long wheelbase) 223WXL1AXXL
5 seater combi N1 223WXL1AXZ
Panorama 223AXL1AXX