2.8 FIAT DUCATO 244 2005 3.G Service Manual

232TECHNICAL SPECIFICATIONS
COMBI WEIGHTS
Weights (kg)
Short wheelbase version
Kerb weight
(including fuel,
spare wheel, tools
and accessories):
Payload including driver (1):
Maximum admitted
loads (2)
– front axle:
– rear axle:
– total:
Towable weight:
– trailer with brakes
– trailer without brakes
Maximum load on ball coupling
(trailer with brakes)
Maximum load on roof
(1) If special equipment is fitted (tow hitch, etc.), the unladen vehicle weight increases, thus reducing the specified payload.
(2) Loads not to be exceeded. The driver is responsible for arranging the loads so that they comply with these limits.2.8 JTD
1960 ÷ 2035
5P +600 ÷ 490 kg
1600
1600
2900
2000
750
80
100 2.0
1805
5P + 755 kg
1600
1600
2900
2000
750
80
1002.0 JTD
1865
5P + 695 Kg
1600
1600
2900
1600
750
80
1002.3 JTD
1935 ÷2010
5P +625 ÷ 515 kg
1600
1600
2900
2000
750
80
100

233TECHNICAL SPECIFICATIONS
Weights (kg)
Medium wheelbase version
Kerb weight
(including fuel,
spare wheel, tools
and accessories):
Payload including driver (1):
Maximum admitted
loads (2)
– front axle:
– rear axle:
– total:
Towable weight:
– trailer with brakes
– trailer without brakes
Maximum load on ball coupling
(trailer with brakes)
Maximum load on roof
(1) If special equipment is fitted (tow hitch, etc.), the unladen vehicle weight increases, thus reducing the specified payload.
(2) Loads not to be exceeded. The driver is responsible for arranging the loads so that they comply with these limits.2.0
1845
5P + 1115 kg
1750
1850
3300
2000
750
80
1002.0 JTD
1905
5P + 1055 kg
1750
1850
3300
1600
750
80
1002.3 JTD
1975 ÷ 2050
5P +985 ÷ 875 kg
1750
1850
3300
2000
750
80
1002.8 JTD
2000 ÷ 2075
5P +960 ÷ 850 kg
1750
1850
3300
2000
750
80
100

234TECHNICAL SPECIFICATIONS
Weights (kg)
GRAND VOLUME
Kerb weight
(including fuel,
spare wheel, tools
and accessories):
Payload including
driver (1):
Maximum admitted
loads (2)
– front axle:
– rear axle:
– total:
Towable weight:
– trailer with brakes
– trailer without brakes
Maximum load on ball coupling
(trailer with brakes)
Maximum load on roof
(1) If special equipment is fitted (tow hitch, etc.), the unladen vehicle weight increases, thus reducing the specified payload.
(2) Loads not to be exceeded. The driver is responsible for arranging the loads so that they comply with these limits.2.3 JTD
2075 ÷ 2150
5P + 885 ÷ 775 kg
1750
1850
3300
2000
750
80
100 2.0
1945
5P + 1015 kg
1750
1850
3300
2000
750
80
1002.8 JTD
2100 ÷ 2175
5P + 860 ÷ 750 kg
1750
1850
3300
2000
750
80
100

236TECHNICAL SPECIFICATIONS
Weights (kg)
Version 15
Kerb weight
(including fuel,
spare wheel, tools
and accessories):
Payload including driver (1):
Maximum admitted
loads (2)
– front axle:
– rear axle:
– total:
Towable weight:
– trailer with brakes
– trailer without brakes
Maximum load on ball coupling
(trailer with brakes)
(1) If special equipment is fitted (tow hitch, etc.), the unladen vehicle weight increases, thus reducing the specified payload.
(2) Loads not to be exceeded. The driver is responsible for arranging the loads so that they comply with these limits.2.0
1795
1505
1750
1850
3300
2000
750
802.0 JTD
1780 ÷ 1855
1375 ÷ 1445
1750
1850
3250 ÷ 3300
1600
750
802.3 JTD
1850 ÷ 1985
1315 ÷ 1415
1750
1850
3230 ÷ 3300
2000
750
80
2.8 JTD
2.8 JTD POWER
1875 ÷ 2010
1290 ÷ 1390
1750
1850
3260 ÷ 3300
2000
750
80

237TECHNICAL SPECIFICATIONS
Weights (kg)
Version MAXI
Kerb weight
(including fuel,
spare wheel, tools
and accessories):
Payload including driver (1):
Maximum admitted
loads (2)
– front axle:
– rear axle (3):
– total:
Towable weight:
– trailer with brakes
– trailer without brakes
Maximum load on ball coupling
(trailer with brakes)
(1) If special equipment is fitted (tow hitch, etc.), the unladen vehicle weight increases, thus reducing the specified payload.
(2) Loads not to be exceeded. The driver is responsible for arranging the loads so that they comply with these limits.
(3) See “Cold tyre inflation pressure”.2.0
1845
1655
1850
2120
3500
2000
750
802.3 JTD
1900 ÷ 2035
1465 ÷ 1600
1850
2120
3500
2000
750
80
2.8 JTD - 2.8 JTD POWER
1925 ÷ 2060
1440 ÷ 1575
1850
2120
3500
2000
750
80

238TECHNICAL SPECIFICATIONS
CREW CAB TRUCK WEIGHTS
Weights (kg)
Kerb weight (including fuel,
spare wheel, tools
and accessories):
Payload including driver (1):
Maximum admitted loads (2)
– front axle:
– rear axle:
– total:
Towable weight:
– trailer with brakes
– trailer without brakes
Maximum load on ball coupling
(trailer with brakes)
(1) If special equipment is fitted (tow hitch, etc.), the unladen vehicle weight increases, thus reducing the specified payload.
(2) Loads not to be exceeded. The driver is responsible for arranging the loads so that they comply with these limits.
(3) See “Cold tyre inflation pressure”.15
2.3 JTD
1990 ÷ 2055
970 ÷ 1310
1750
1850
3300
2000
750
8015
2.8 JTD
2015 ÷ 2080
945 ÷ 1285
1750
1850
3300
2000
750
80MAXI
2.0
1950
1250
1850
2120 (3)
3500
2000
750
80MAXI
2.3 JTD
2040 ÷ 2105
1120 ÷ 1460
1850
2120 (3)
3500
2000
750
80MAXI
2.8 JTD
2.8 JTD POWER
2065 ÷ 2130
1095 ÷ 1435
1850
2120 (3)
3500
2000
750
80

243TECHNICAL SPECIFICATIONS
FUEL CONSUMPTION - CO2EMISSIONS
RUNNING AND USE CONDITIONS AFFECTING FUEL CONSUMPTION
(examples and differences with respect to goods transportation vehicle data)
IMPORTANT
Although fuel consumption mea-
surements procedure aim at defining
realistic values, fuel consumption is in-
fluenced by factors such as:
Driving style and vehicle usehigh
speed, frequent acceleration, frequent
gear shifting, door-to-door deliveries,
etc.
Just for passenger transportation
versions with 2.3 and 2.8 JTD engines,
reduced consumption can be obtained
by starting (on level road) in 2nd gear
instead of 1st gear.
Traffic and road conditions
queues, bending roads, steep roads,
bad road surface, etc.Weather conditions and tem-
peratures
low temperatures, thinner air, wind,
rain etc…;
Vehicle conditions
Poor maintenance (tyre pressure, fil-
ters, spark plugs, etc.), damaged body-
work
Load conditions
Heavy weights, not optimal load dis-
tribution, large weights on roof rack,
etc.
Use of electric devices
Climate control, heater and electric
devices in general
Special conditions of use
Special vehicle conditions of use: roof
rack, trailer, open side windows, type
of tyres, etc.Special trim and adaptations
caravan, motor home, mega box, can-
vas cover, etc.
Some of these conditions are illus-
trated in these figures on the next
pages.
For more information, refer to the
advice in the chapter “Cheap running
that respects the environment.
The fuel consumption values shown
in the table in following pages were de-
fined according to the type-approval
specifications in European Directives.
Consumption values are defined by
means of the following procedures:
– an urban cycle: consisting of a
cold start and a simulated drive in city
streets;
– an extra-urban cycle: consisting
in frequent accelerations, in all gears,

244TECHNICAL SPECIFICATIONS
simulating normal conditions of use.
Speed ranges from 0 to 120 km/h;
– average combined cyclecon-
sisting of 37% urban cycle and 63% ex-
tra-urban cycle.
IMPORTANT Road and traffic
conditions, weather, general con-
ditions of the vehicle, drivingstyle, fittings and accessories, use
of the climate control system,
load, roof racks and other situa-
tions penalising aerodynamic
penetration and effecting rolling
resistance will influence fuel con-
sumption rates which can be dif-
ferent from the values shown inthe table (see “Cheap running
that respects the environment”
in “Driving your car” chapter).
CO
2EMISSIONS AT EXHAUST
The maximum CO
2emission values
shown in the following table refer to
the average combined cycle.
Consumption according to Directive Urban Extra-urban Combined CO
2emissions at exhaust
99/100/EC (litres/100 km)according to Directive
99/100/EC (g/km)
Engine 2.0
Version 11Panorama short wheelbase 16.1 11.2 13.0 306
Combi short wheelbase 15.9 11.0 12.8 301
Panorama short wheelbase 4x4 16,3 11.4 13.2 311
Version 15Combi medium wheelbase 15.911.012.8 301
Combi medium wheelbase
high sided 16
.111.213.0 306
Panorama medium wheelbase 16
.311.413.2 311
Combi short wheelbase 4x4 16
.111.213.0 306
Combi medium wheelbase 4x4 16.111.213.0 306
Engine 2.0 JTD
Version 11Panorama short wheelbase 10.6 8.1 9.0 239
Combi short wheelbase 10.2 7.8 8.7 230
Version 15Combi medium wheelbase 10.68.19.0 239

245TECHNICAL SPECIFICATIONS
Consumption according to Directive Urban Extra-urban Combined CO
2emissions at exhaust
99/100/EC (litres/100 km)according to Directive
99/100/EC (g/km)
Engine 2.3 JTD (*)
Version 11Panorama short wheelbase 9.0 7.7 8.1 216Combi short wheelbase 8.7 7.3 7.8 208
Version 15Combi medium wheelbase 8.7 7.3 7.8 208
Combi medium wheelbase high sided 9.0 7.7 8.1 216
Panorama medium wheelbase 9.2 8.0 8.4 223
Engine 2.8 JTD (*)
Version 11Panorama short wheelbase 10.9 8.8 9.6 234
Panorama short wheelbase
automatic gearbox 13.7 10.0 11.3 301
Combi short wheelbase 10.6 8.5 9.3 246
Panorama short wheelbase 4x4 11.1 9.0 9.8 261
Version 15Combi medium wheelbase 10.6 8.5 9.3 246
Combi medium wheelbase high sided10.9 8.8 9.6 234
Combi medium wheelbase
automatic gearbox 13.4 9.8 11.1 295
Combi medium wheelbase high sided
automatic gearbox13.7 10.0 11.3 301
Panorama medium wheelbase 11.1 9.0 9.8 261
Panorama medium wheelbase
automatic gearbox 13.9 10.2 11.5 307
Combi short wheelbase 4x4 10.9 8.8 9.6 234
Combi medium wheelbase 4x4 11.1 9.0 9.8 261
(*) Test was performed with start-up in second gear.

2.0 petrol
COLD TYRE INFLATION PRESSURE (bar)
ENGINE OIL CHANGE
FUEL CAPACITIES (litres)
For all engine types
Tank capacity ........................................................................ litres 80
Reserve .................................................................................. litres 8 ÷ 10
Refuel petrol engines with unleaded petrol with an octane rating (RON) no lower than 95 only.
Refuel diesel engines with diesel fuel for motor vehicles (EN590 specifications) only.
Version
11
15
MAXI
(*) 4.75 bar for vehicles with maximum admitted load on rear axle over 2000 kg. (**) 2.8 JTD POWER versions
For warm tyres the pressure should be +0.3 bar in relation to the prescribed value.
Check again the correct pressure when the tyres are cold.
Unladen and fully loaded
Rear
4.0
4.0
5.0
4.5
5.0
4.5 (*)
4.5
5.5 Front
4.0
4.0
5.0
4.1
5.0
4.5
4.5
5.5 All types
Camping Car
All types
Camping Car
All types
Camping CarTyre
195/70 R15C (103/101) Q
205/70 R15C (106/104) Q
215/70 R15C (109/107) Q Camping
205/70 R15C (106/104) Q/205/70 R15C (106/104) R (**)
215/70 R15C (109/107) Q Camping
205/75 R16C (110/108) Q/205/75 R16C (110/108) R (**)
215/75 R16C (113/111) Q/215/75 R16C (113/111) R (**)
215/75 R16C (113/111) Q Camping
2.8 JTD - 2.8 JTD
POWER
litres
5
–kg
4.5
–kg
–
5.6litres
5.0
5.7 kg
5.2
5.7kg
4.5
5.1 2.3 JTD
Fiat Auto S.p.A.
After Sales - Assistenza Tecnica - Ingegneria Assistenziale
Largo Senatore G. Agnelli, 5 - 10040 Volvera - Torino (Italia)
Print no. 603.45.862 - IV/2005 - 3
rdedition 2.0 JTD
litres
–
6.25litres
5.8
6.3
Engine sump
Engine sump and filter