ABS FIAT IDEA 2007 1.G Owner's Manual

252
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
Fuse box in engine compartment
USERFUSE AMPERE
Dashboard control unit 1F1 70
Power steering control unitF2 70
Ignition switchF3 20
Dashboard control unit 2F4 50
ABS / ESP control unitF5 60
Radiator electric fan (low speed) (all versions)F6 30
Radiator electric fan (high speed) (all versions excluded 1.2 16V, 1.4 16V heated) F7 40
Climate control electric fanF8 30
Headlight washerF9 20
HornF10 15
Electronic injection secondary servicesF11 15
Right main beam headlightF14 10
Left main beam headlightF15 10
+15 Electronic injection system / Dualogic gearbox (*)F16 7,5
Electronic injection primary servicesF17 10
+30 Engine control unit / Radiator electric fan remote control switch (1.9 Multijet) (*) F18 7.5
CompressorF19 7.5
Heated diesel oil filter (Multijet)F20 30
Fuel pumpF21 15
Electronic injection primary services (1.2 16V, 1.4 16V)F22 15
Electronic injection primary services (Multijet)F22 20
+30 Dualogic gearbox (*)F23 15
+15 Electric power steering (*)F24 7,5
Front fog lightsF30 15
(*) +30 = battery directive positive terminal (not under key)
+15 = positive terminal under key

IMPORTANT - Battery
The charge in the battery should be checked at the
start of winter to limit the risk of electrolyte freezing.This check should be carried out more frequently if
the car is used mainly for short trips, or if it is fitted
with accessories that permanently absorb electricity
even with the ignition key removed, especially in the
case of after market accessories. If the car is used in
hot climates or particularly harsh conditions it is wise
to check the level of the battery fluid (electrolyte)
more frequently than specified in the “Service
schedule” in this section.
264
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
Car maintenance should be entrusted to Fiat Dealership. For routine and minor maintenance
operations you wish to carry out yourself, always make sure you have the proper equipment,
genuine Fiat spare parts and the necessary fluids; do not however carry out these operations if you
have no experience.

BRAKE FLUID
Unscrew cap: check that the fluid level in the reservoir is at maximum.
Fluid level in the reservoir shall not exceed the MAXmark.
If fluid has to be added, it is suggested to use the brake fluid in table
"Fluids and lubricants" (see chapter "Technical characteristics").
NOTE Clean accurately the tank cap and the surrounding surface.
At plug opening, pay maximum attention in order to prevent any
impurities from entering the tank.
For topping up, always use a funnel with integrated filter with mesh equal to or lower than 0.12 mm.
IMPORTANT Brake fluid absorbs moisture, for this reason, if the vehicle is mainly used in areas with a high degree
of atmospheric humidity, the fluid should be replaced at more frequent intervals than specified in the “Service
schedule”.
271
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
F0H0213m
Make sure that the highly corrosive brake fluid does not drip onto the paintwork. If it does, wash it
off immediately with water.
Symbol πon the container indicates synthetic brake fluid, distinguishing it from
the mineral kind. Using mineral fluids irreversibly damages the special braking
system rubber seals.WARNING
WARNINGBrake fluid is poisonous and highly corrosive. In the event of accidental contact,
wash the parts involved immediately with neutral soap and water, then rinse
thoroughly. Call the doctor immediately if the fluid is swallowed.

CHANGING THE BATTERY
If required, replace the battery with a genuine spare
part having the same specifications.If a battery with different specifications is fitted, the
service intervals given in the “Service schedule” in this
section will no longer be valid. Refer to the
instructions provided by the battery manufacturer.
274
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
WARNING
If the car is left inactive for long periods at cold, remove the battery and store it in
a warm place to prevent freezing.WARNING
When working on the battery or near it, always wear the proper goggles. Batteries contain substances that are very harmful for the environment. You are advised to have the
battery changed at a Fiat Dealership, which is properly equipped for disposing of used batteries
respecting nature and the law.
Incorrect fitting of electrical and electronic accessories can seriously damage the car.
If after buying the car, you want to install electric accessories which require permanent electric
supply (alarm, free-hand phone kit, etc.) contact Fiat Dealership whose qualified personnel, in
addition to suggesting the most suitable devices, will evaluate the overall electric absorption,
checking whether the car’s electric system is capable of withstanding the load required, or whether
it should be integrated with a more powerful battery.

USEFUL ADVICE FOR
LENGTHENING THE LIFE OF YOUR
BATTERY
To avoid draining your battery and lengthen its life,
observe the following indications:
❒when you park the car, ensure the doors, tailgate
and bonnet are closed properly;
❒the ceiling lights must be off. The car is however
provided with an automatic system for switching off
internal lights;
❒do not keep accessories (e.g.: sound system, hazard
lights, etc.) switched on for a long time when the
engine is not running;
❒before performing any operation on the electrical
system, disconnect the battery negative cable;
❒battery terminals shall always be perfectly
tightened.IMPORTANT A battery which is kept at a charge of
less than 50% (optical indicator with dark colour
without green area in the middle) for any length of
time will be damaged by sulphation leading to a
reduction in cranking power. Moreover, this might
lead to a higher risk of the battery electrolyte freezing
(this may even occur at -10°C).
If the car is left inactive for a long period of time, refer
to “Car inactivity”, in section “Correct use of the car”.
If after buying the car, you want to install electric
accessories which require permanent electric supply
(alarm, free-hands set, etc.) contact Fiat Dealership
whose qualified personnel, in addition to suggesting
the most suitable devices of the Lineaccessori Fiat, will
evaluate the overall electric absorption, checking
whether the car’s electric system is capable of
withstanding the load required, or whether it should
be integrated with a more powerful battery.
275
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE

In fact, since these devices continue absorbing energy
even when the ignition key is off, they gradually run
down the battery.The total intake of these systems (factory and after-
market) must be less than 0.6 mA x Ah (of the
battery) as shown in the following table:
276
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
Battery Maximum admitted stand-by intake
40 Ah 24 mA
44 Ah 27 mA
50 Ah 30 mA

284
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
Engine compartment
At the end of the winter the engine compartment
should be carefully washed, without directing the jet
against electronic control units. Contact a specialised
workshop to have this done.
IMPORTANT Washing should be carried out with the
engine cold and the ignition key at STOP. After
washing make sure that the various protections (e.g.:
rubber caps and various covers) have not been
damaged or removed.INTERIORS
Periodically check that water is not trapped under the
mats (due to water dripping off shoes, umbrellas, etc.)
which could cause oxidisation of the sheet metal.
CLEANING SEATS AND FABRIC AND
VELVET PARTS
Use a soft brush or vacuum cleaner to remove dust.
Velvet is cleaned better if the brush is moistened.
Rub the seats with a sponge moistened with a solution
of water and neutral detergent.
CLEANING LEATHER SEATS
Remove dried on dirt with lightly moistened chamois
leather or cloth without pressing too hard.
Remove liquid or grease stains with a dry absorbent
cloth without rubbing. Then wipe with a soft cloth or
chamois leather with water and neutral soap.
If the stain persists, use specific products, carefully
following the instructions for use.
IMPORTANT Never use spirit or alcohol-based
products.
WARNINGNever use flammable
products like oil ether or
rectified petrol for
cleaning car interiors.
Electrostatic discharges
generated by rubbing
during cleaning
operations could cause
fire.

305
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
DASHBOARD
AND CONTROLS
INDEX
I I
N N
D D
E E
X X
ABS (system) ............................. 138
Accessories purchased by the
user ............................................... 143
Air bags (front)........................... 166
– driver's air bag ...................... 168
– passenger's front air bag .... 168
– passenger's front air bag
manual deactivation ........... 169
- Side bags .................................. 170
Air cleaner................................... 263
Air vents ..................................... 80-81
Ashtray (Smokers' kit) ............ 122
At the filling station ................... 148
Automatic two-zone climate
control system............................ 89
Battery
– checking the charge............. 273
– jump starting ......................... 223
– recharging .............................. 254
– replacing ............................... 274
Bodywork
– maintenance ......................... 282
– version codes........................ 289
Bonnet ......................................... 134Boot ............................................. 128
– extension ............................... 131
– light ......................................... 256
Brake lights
– bulb replacement ................. 244
Brakes
– fluid level ............................... 271
– handbrake ............................. 181
– service and emergency ....... 293
Bulb (replacement) ................... 237
Capacities ................................... 300
Car inactivity ............................. 190
Car maintenance ........................ 258
– additional checks.................. 262
– Annual Inspection Schedule 262
– scheduled service................. 259
– Service Schedule .................. 260
Cargo box ................................... 119
Carrying children safely ............ 159
Ceiling lights ................................ 111
– bulb replacement ................. 246
Cellular telephones
– presetting............................... 141Checking fluid levels ............... 265
Child lock ................................... 11
Cigar lighter (Smokers' kit) ..... 122
Clutch .......................................... 292
CO
2emissions .......................... 304
Containing running costs ......... 183
Correct use of the car ............ 177
Cruise Control .......................... 108
Current sockets ......................... 121
Dashboard and controls ......... 4-21
Diesel fuel filter ......................... 272
Dimensions ............................... 297
Dipped beam headlights
– bulb replacement ................. 241
– control .................................. 100
Direction indicators ................. 101
– bulb replacement ................. 242
– control .................................. 101
Door pockets ............................. 117
Doors ........................................... 7-221
Emergency device for locking
doors from the outside ......... 12
Dualdrive
(electric power steering) ...... 144