window FIAT IDEA 2007 1.G Service Manual

Changing the windscreen wiper blades
Proceed as follows:
❒raise the windscreen wiper arm (A) and position the blade so that it
forms an angle of 90° with the arm;
❒press tab (B) of the coupling spring and remove the blade to be
replaced from the arm (A);
❒fit the new blade by inserting the tab into the special slot in the arm.
Make sure it is properly locked into place.
Changing the rear window blade
Proceed as follows:
❒raise the cover(A) and remove the arm from the car, slackening the
nut (B) that fastens it to the pivot pin;
❒fit the new arm, positioning it correctly, and fully tighten the nut;
❒lower the cover.
280
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
F0H0217m
F0H0218m

SPRAY NOZZLES
Windscreen wiper
If the jet of fluid is inadequate, firstly check that there is fluid in the
reservoir: see “Checking fluid levels” in this section).
Then check that the nozzle holes are not clogged, if necessary use a
needle.
Windscreen nozzles are fluid-dynamic and do not require adjustment;
windscreen fluid is atomized to cover a preset glass area.
Rear window wiper
The rear window nozzle like the windscreen nozzle is fluid-dynamic and
do not require adjustment; rear window fluid is atomized to cover a
preset glass area.
The nozzle holder is located at the top of the tailgate.
281
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
F0H0219m
F0H0220m

283
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
❒wipe a sponge with a slightly soapy solution over
the bodywork, frequently rinsing with the sponge;
❒rinse well with water and dry with a jet of air or a
chamois leather.
When drying, take particular care with the less visible
parts like door surrounds, bonnet and around the
headlights where water may stagnate. The car should
not be taken to a closed area immediately, but left in
the open so that residual water can evaporate.
Do not wash the car after it has been left in the sun or
with the bonnet hot: this may alter the shine of the
paintwork.
Exterior plastic parts must be cleaned in the same way
as the rest of the vehicle.
Where possible, do not park under trees; the resinous
substance many species release give the paint a dull
appearance and increase the possibility of triggering
rust processes.
IMPORTANT Bird droppings must be washed off
immediately and thoroughly as the acid they contain is
particularly aggressive.Windows
Use specific window cleaner products. Use also clean
cloths to avoid scratching the glass or damaging the
transparency.
IMPORTANT The inside of the rearscreen should be
wiped gently with a cloth in the direction of the
filaments to avoid damaging the heating device.
Front headlights
IMPORTANT When cleaning plastic lenses of front
headlights, never use aromatic substances (e.g. petrol)
or ketones (e.g.: acetone).
Detergents cause water pollution. Therefore the car should be washed in areas equipped for
collecting and purifying the liquid used in the washing process.

300
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
AND CONTROLS
TECHNICAL
SPECIFICATIONS
1.416V1.216V1.3 Multijet
kg
–
–
–
–
–
2.4
2.55
–
–
1.5
–
–kg
–
–
–
–
–
–
–
2.54
2.65
1.8
–
–litres
–
–
47
5 - 7
6.5
–
–
4.2
4.4
1.65
0.45
1.5kg
–
–
–
–
–
–
–
3.75
3.9
1.5
–
–litres
47
5 - 7
–
–
4.5
2.75
2.9
–
–
1.65
0.45
1.5 litres
47
5 - 7
–
–
4.5
2.5
2.7
–
–
1.65
0.45
1.5kg
–
–
–
–
–
2.2
2.35
–
–
1.5
–
–litres
–
–
47
5 - 7
6.0
–
–
2.85
3.0
1.98
0.45
1.51.9 Multijet1.48V (◊)
litres
47
5 - 7
–
–
4.5
2.4
2.6
–
–
1.65
0.45
1.5kg
–
–
–
–
–
2.1
2.25
–
–
1.5
–
–
CAPACITIES
Fuel tank:
including
a reserve of:
Fuel tank:
including
a reserve of:
Engine cooling
system:
Engine sump:
Engine sump
and filter:
Engine sump:
Engine sump
and filter:
Gearbox/
differential casing:
Hydraulic
brake circuit
Windscreen and
rear window washer
fluid reservoir
(❒) For use with very cold temperatures, we recommend using SELENIA PERFORMER MULTIPOWERSAE 5W-30.
(◊) Engine model provided for certain versions/markets onlySpecified fuels
Recommended products
Unleaded Premium petrol
with no less than 95 R.O.N
(EN228 Specifications)
Diesel fuel for motor
vehicles
(Specification EN590)
Mixture of distilled water
and PARAFLU UPat 50%
SELENIA 20K (❒)
SELENIA WR
TUTELA CAR
TECHNYX
TUTELA TOP 4
Mixture of water and
TUTELA
PROFESSIONAL SC 35

302
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
AND CONTROLS
TECHNICAL
SPECIFICATIONS
Use
Lubricants and greases for
transmission
Brake liquid
Protective agent
for radiator
Additive
for diesel fuel
Windscreen/
rear window
(●) IMPORTANT Do not add or mix with fluids with specifications other than the specified ones.Fluid and lubricant specifications
for correct car operation
Fully synthetic oil, grade SAE 75W-85 that passes API GL-4
PLUS, FIAT 9.55550 MIL-L- 2105 D LEV. Specifications
Specific transmission fluid with "ATF DEXTRON III"
type additives.
Lithium soap base grease. NLGI 0 consistency
Organic molibdenum disulphide, lithium soap based grease.
NLGI 2 consistency
Synthetic fluid FMVSS no. 116 DOT 4, ISO 4925,
SAE J1704, CUNA NC 956-01
Protective with antifreeze action (red colour) based on
inhibited monoethylen glycol, with O.A.T. formulation, that
passes CUNA NC 956-16, ASTM D 3306 specifications.
Additive for diesel fuels with protective action for
Multijet engines
Mixture of alcohol and surfactants CUNA NC 956-IIOriginal fluids
and lubrificants
TUTELA CAR
TECHNYX
TUTELA CAR
CS SPEED
TUTELA
MRM ZERO
TUTELA STAR 500
TUTELA TOP 4
PARAFLU UP (
●)
DIESEL MIX
TUTELA
PROFESSIONAL
SC 35Applications
Mechanical gearbox and
differential
Selespeed transmission
electrically-operated
electrohydraulic
actuator
CV joints on
differential side
CV joints on wheel side
Brake and clutch
hydraulic controls
Cooling circuits
Proportion: 50% down
to -35° C Not to be
mixed with products
having different formulas.
To be mixed with
the fuel oil
(25 cc per 10 litres)
To be used diluted or
undiluted

306
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
DASHBOARD
AND CONTROLS
INDEX
EBD (electronic brake force
distributor) ................................. 137
Emergency device for locking
doors from the outside 12-221
Engine
– fuel feed ................................. 292
– identification code ............... 289
– injection/ignition ................. 178
– technical data ....................... 290
Engine compartment ................ 265
Engine coolant gauge................. 26
Engine coolant level ................ 269
Engine oil
– checking level........................ 267
– consumption ......................... 268
– technical specifications ....... 301
Environment (protection)........ 150
EOBD (system) ......................... 140
External lights ............................. 100
Fiat CODE (system) ............... 5
Fix &Go (tyre repair kit) ......... 225
Flashing the headlights ............. 101
Fluids and lubricants ................ 301
Follow me home (device) ....... 102
FPS (fuel cut-off switch) .......... 116Front fog lights
– bulb replacement ................. 243
– control button ...................... 114
Fuel
– consumption ......................... 303
– fuel cut-off switch ................ 116
– level gauge ............................ 25
Fuel cut-off switch ..................... 116
Fuel filler cap............................... 149
Fuses ............................................. 248
Gearbox (use). .......................... 182
Glass/can holders ....................... 119
Handbrake ................................. 181
Hazard lights
– control .................................. 114
Head restraints ......................... 76
Headlights ................................... 136
(electric adjusting device) ..... 136
Heated rear window ............... 87
Heating and ventilation............. 82
Identification data .................... 287
Ignition switch ........................... 20
In an emergency ........................ 220
Instrument panel ....................... 24Instruments ................................. 25
Interior equipment ................... 117
Interior fittings
– current socket ...................... 121
– glass / can holder ................. 119
– magnetic card/ticket slots .. 120
– oddment compartments .... 118
– rear CD compartment
with glass/can holder .......... 120
– roof bracket .......................... 120
– roof console.......................... 119
– upper oddment
compartments ...................... 117
Interiors ...................................... 284
Isofix ............................................. 166
Jack .............................................. 232
Jacking the car ............................ 255
Key kit and door locking ........ 7
Light control buttons ............. 11
Load limiters ............................... 157
Lubricants (specifications)........ 301
Magnetic card/ticket slots ...... 120
Main beam headlights
– bulb replacement ................. 241

307
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
DASHBOARD
AND CONTROLS
INDEX
– control .................................. 101
– flashing .................................... 101
Manual climate control
system ......................................... 85
Multifunction display (on
comfort instrument panel) ..... 35
- controls ..................................... 36
Multifunction display (on
modal instrument panel) ......... 27
- controls ..................................... 28
Number plate light
– bulb replacement ................ 223
Oddment compartments ........ 118
- roof console ............................. 119
- upper.......................................... 117
Outlets ......................................... 121
Parking ....................................... 181
Parking sensors .......................... 146
Performance................................ 298
Plates ........................................... 287
Pollen filter ................................. 263
Power windows ......................... 125
Pretensioners.............................. 156
Prolonged car inactivity .......... 190
Protecting the environment .... 150
Radio transmitters and
cellular telephones..................... 141
Rain sensor ................................ 105
Rear fog lights
– bulb replacement ................. 244
– control button ...................... 115
Rear window washer
– control .................................. 104
– fluid level ............................... 270
Rear window wipers
– control .................................. 104
– smart washing ....................... 105
– blades .................................... 279
– nozzles.................................... 281
Rearview mirrors....................... 78
Rev counter ................................ 25
Reversing light
– bulb replacement ................. 244
Rims ............................................. 295
Roof racks ................................. 136
Rubber tubing ............................. 279
Safety devices ............................ 151
Seat belts
– general instructions ............ 152
– height adjustment ............... 154– maintenance ......................... 159
– S.B.R. system ......................... 153
– use .......................................... 152
Seats .............................................. 69
Side/taillights
– bulb replacement ........... 243-244
– control .................................. 100
Smart washing............................. 105
Snow chains ............................... 189
Sound system
– installation ............................ 141
– preset system ...................... 141
Spark plugs .................................. 290
Speedometer .............................. 25
Starting the engine
– bump starting ........................ 224
– emergency start-up ............. 222
– ignition switch ..................... 20
– jump starting ........................ 223
– Multijet engines .................... 179
– petrol engines ...................... 178
– stopping the engine ............. 180
– warming up the engine ...... 180
Steering . ...................................... 293
Steering lock .............................. 20
Steering wheel (adjustment) ... 68

308
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
DASHBOARD
AND CONTROLS
INDEX
Sunroof......................................... 123
Sun visors ................................... 122
Suspensions ................................. 293
Symbols ........................................ 5
Technical specifications........... 286
Third brake light
– bulb replacement ................ 245
Tools ........................................... 242
Towing the car ........................... 255
Towing trailers ........................... 185
Transmission ............................... 292
Transporting children
safely ........................................... 159
Tyres
– snow tyres ............................. 295
– standard ................................. 295
– correct tyre reading ............ 294
Warning lights and messages 191
Weights ........................................ 299
Wheel
– spare wheel ........................... 294
– changing ................................ 230
Wheel geometry ....................... 294
Windows (cleaning) .................. 284Windscreen washer
– control ................................. 104
– fluid level ................................ 270
Windscreen wiper
– blades .................................... 279
– control .................................. 104
– nozzles .................................. 281
– smart washing ...................... 105