key FIAT IDEA 2007 1.G Workshop Manual

175
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
GENERAL WARNINGS
WARNING
If warning light ¬does not come on when turning the key to MAR or if it stays on
when travelling it could indicate a failure in restraint systems; in this case air bags
or pretensioners could not trigger in the event of an accident, or in a restricted
numbers of cases they could trigger accidentally. Stop the car and contact Fiat
Dealership to have the system checked immediately.WARNING
WARNINGAlways keep your hands on the steering wheel rim when driving, so that if the air
bag is triggered, it can inflate without meeting any obstacles which could cause
serious harm to you. Do not drive with the body bent forwards, keep the seat back
rest in the erect position and lean your back well against it. Do not cover the back rest of front seats with trims or covers there are not set for
the use of side bags.
If the car has been stolen or an attempt to steal it has been made, if it has been
subjected to vandals or floods, have the air bag system checked by Fiat Dealership.WARNING
WARNINGRemember that with the key engaged and in the MAR position, even with the
engine not running, the air bags may be triggered on a stationary vehicle if it is
bumped by another moving car. Therefore, never seat children on the front seat
even when the vehicle is stationary. On the other hand remember that if the key is
at STOP, no safety system (air bags or pretensioners) is triggered in the event of an
impact; in these case, failure to come into action cannot be considered as a sign
that the system is not working properly.

176
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
WARNING
WARNINGWhen the ignition key is turned to the MAR position, the warning light F(with
passenger’s front air bag deactivation (where required) switch in the ON position)
turns on and flashes for few seconds to remind that passenger’s air bag will be
deployed in a crash, after which it should go off.
Do not wash the seat back rest with pressurised water or steam (by hand or at
automatic seat washing stations).
Never travel with objects on your lap, in front of your chest or with a pipe, pencil,
etc. between your lips; injury may result in the event of the air bag being triggered.WARNING
The front air bag is triggered for shocks greater in magnitude than the
pretensioners. For impacts between these two thresholds, it is therefore normal
that only the pretensioners are triggered.WARNING
WARNINGThe air bag does not substitute the seat belts, but only increases their
effectiveness. Moreover, since the front air bags do not come into operation in
the event of front impact at low speed, side collisions, bumps from behind or
overturning, in these circumstances the occupants would only be protected by
the seat belts which must therefore always be fastened.
WARNINGDo not hook rigid objects to the coat hooks and to the support handles.

ENGINE STARTING
The car is fitted with an electronic engine lock device.
If the engine fails to start, see paragraph “Fiat CODE
system” in section “Dashboard and controls”.
The engine may be noisier than usual during the first
seconds of operation, especially after it has not been
used for a while. This characteristic feature of the
hydraulic tappet system does not compromise
functionality or reliability. The system devised for the
Fiat Idea was designed to limit maintenance
interventions.STARTING PROCEDURE FOR PETROL
VERSIONS
Proceed as follows:
❒Ensure that the handbrake is up;
❒Put the gear lever into neutral;
❒Press the clutch pedal down to the floor without
touching the accelerator;
❒Turn the ignition key to AVV and let it go the
moment the engine starts.
If the engine does not start at the first attempt, return
the ignition key to STOP before repeating starting.
If, when the ignition key is on MAR, warning light
Y
remains lit together with warning light U, turn the
key to STOP and then back to MAR; if the warning
light remains on, try with the other keys provided with
the car.
178
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CORRECT USE
OF THE CAR
We recommend that during the initial period you do not drive to full vehicle performance (e.g.:
excessive acceleration, long journeys at top speed, sharp braking, etc.).
When the engine is switched off never leave the ignition key in the MAR position to prevent
pointless current absorption from draining the battery.
WARNINGRunning the engine in confined areas is extremely dangerous. The engine consumes
oxygen and produces carbon monoxide which is a highly toxic and lethal gas.

If you are still unable to start the engine, perform the
emergency start-up procedure (see “Emergency start-
up” in section “In an emergency”) and contact Fiat
Dealership.
IMPORTANT Never leave the ignition key at MAR
when the engine is off.
STARTING PROCEDURE FOR MULTIJET
VERSIONS
Proceed as follows:
❒Ensure that the handbrake is up;
❒Put the gear lever into neutral;
❒Turn the ignition key to MAR: the warning lights
m, Uand Ywill light up on the instrument
panel;
❒Wait for the warning lights
Yand m. The
hotter the engine is, the quicker this will happen;
❒Press the clutch pedal down to the floor without
touching the accelerator;❒Turn the ignition key to AVV as soon as warning
light
mgoes out. If you wait too long you will
lose the benefit of the work done by the glow
plugs. Release the key as soon as the engine starts.
IMPORTANT With cold engine, the accelerator pedal
shall be completely released while turning the ignition
key to AVV.
If the engine does not start at the first attempt, return
the ignition key to STOP before repeating starting.
If, when the ignition key is on MAR, warning light Y
remains lit, turn the key to STOP and then back to
MAR; if the warning light remains on, try with the
other keys provided with the car.
If you still cannot start the engine, contact Fiat
Dealership.
IMPORTANT Never leave the ignition key at MAR
when the engine is off.
179
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CORRECT USE
OF THE CAR
The warning light mwill flash for 60 seconds at start-up or during prolonged cranking to signal a
fault in the glow plug heating system. You can use the car as usual if the engine starts but you should
contact a Fiat Dealership as soon as possible.

PARKING
Proceed as follows:
❒stop the engine and engage the handbrake;
❒engage a gear (on a slope, engage first gear if the car is faced uphill or
reverse if it is faced downhill) and leave the wheels steered.
Block the wheels with a wedge or a stone if the car is parked on a steep
slope. Avoid leaving the car parked with a wheel on the sidewalk or
steered against the kerb. Do not leave the ignition key at MAR to
prevent draining the battery. Always remove the key when you leave
the car.
181
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CORRECT USE
OF THE CAR
HANDBRAKE
The handbrake lever is located between the two front seats.
Pull the handbrake lever upwards until the car cannot be moved.
Four or five clicks are generally enough when the car is on level ground while nine or ten may be required if the car
is on a steep slope or laden.
IMPORTANT If this is not the case, contact Fiat Dealership to have the handbrake adjusted.
When the handbrake lever is pulled up and the ignition key is at MAR the panel warning light xwill come on.
To release the handbrake:
❒slightly lift the handbrake and press release button (A);
❒keep button (A) pressed in and lower the lever. Warning light xwill go out.
Press the brake pedal when carrying out this operation to prevent the car from moving accidentally.
IMPORTANT If the handbrake lever tends to approach the end of stroke (slot on central console), contact Fiat
Dealership to have the handbrake adjusted.
WARNINGNever leave children unattended in the car. Always remove the ignition key when
leaving the car and take it out with you.
F0H0149m

192
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
WARNING
LIGHTS AND
MESSAGES
GENERAL WARNINGS
Failure indicationsshown on the reconfigurable
multifunction display together with buzzer sounding
(adjustable) and warning light (if any) coming on on the
cluster, are accompanied by specific warning
messages(e.g.: “Switch off engine”, etc...). These
indications are concise and cautionaryand are
aimed to suggest the prompt actionthe driver must
adopt when a car malfunctioning appears. These
indications, however, shall not be considered as
exhaustive and/or as an alternative to the
specifications contained in this “Owner Handbook”,
which shall always be read through carefully and
thoroughly. In case of failure indication always refer
to the specifications contained in this section.
IMPORTANT Failure indications displayed on the
reconfigurable multifunction display are divided into
two categories: very serious failures and
serious/minor failures.
The message and the warning indication corresponding
to very serious failures are displayed alternately for
few seconds. This “cycle” is repeated indefinitely and it
stops any previous indication on the display. It is
displayed every time the ignition key is turned to MAR,
until the cause of malfunctioning is removed. Should failure disappear, message and warning light will
however stay on for about 2 seconds. Eliminating the
failure, the warning light and the displayed message will
go off. It is possible to stop this “cycle” by pressing
button Q; in this case the screen active before the
failure will be resumed and the warning light will stay
on until eliminating the failure cause.
The message and the warning indication corresponding
to serious/minorfailures are displayed alternately for
few seconds. This “cycle” is repeated for about 20
seconds and then goes off, but it comes on again every
time the ignition key is turned to MAR.
Should failure disappear during the 20 seconds
displaying, message and warning light will stay on for
about 2 seconds. Eliminating the failure, the warning
light and the displayed message will go off.
At the end of the display cycle (which lasts approx. 20
seconds), or if button Qis pressed, the screen active
before the failure will be resumed and the warning
light will stay on until eliminating the failure cause.
Q= Press button “MODE” for less than two seconds
R= Press button “MODE” for over two seconds

193
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
WARNING
LIGHTS AND
MESSAGES
LOW BRAKE FLUID LEVEL
Turning the ignition key to MAR the warning light
on the dial turns on, but it should go off after few
seconds.
The warning light turns on (together with the
message on the display, on certain versions) when
the level of the brake fluid in the reservoir falls
below the minimum level, due to possible leak in
the circuit.x
HANDBRAKE ON
Turning the ignition key to MAR the warning light
on the dial turns on, but it should go off after few
seconds. The warning light turns on when the
handbrake is on.
IMPORTANT If the warning light
xturns on
when travelling
check that the handbrake is not engaged.
x
Warning
light on dialMessage on
multifunction display Message on reconfigurable
multifunction display
WARNINGIf the warning light xturns on when travelling (on certain versions together with the
message on the display) stop the car immediately and contact Fiat Dealership.red
red

194
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
WARNING
LIGHTS AND
MESSAGES
FRONT PASSENGER AIR BAG
DEACTIVATED (where required)
Dial warning light comes on when front
passenger air bag is deactivated. With front
passenger air bag on, turning the ignition key to
MAR, warning light
Fcomes on flashing on the
cluster for about 4 seconds, then it shall go off.
F
SEAT BELTS NOT FASTENED
The warning light will come on flashing, together
with the warning buzzer when, with the car
moving, the driver's seat belt is not correctly
fastened. The S.B.R. (Seat Belt Reminder) buzzer
can only be excluded by Fiat Dealership. On
versions fitted with reconfigurable multifunction
display (Comfort), the system can be reactivated
through the set-up menu (see diagram aside).
<
WARNINGWarning light Findicates also warning light ¬failure. This is indicated by
intermittent flashing, over 4 seconds, of warning light F. In this event, warning
light ¬could be not up to indicate restraint system failures, if any. Stop the car
and contact Fiat Dealership to have the system checked. amber
red
Warning
light on dialMessage on reconfigurable
multifunction displayMessage on
multifunction display

195
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
WARNING
LIGHTS AND
MESSAGES
red
red
w
v
LOW BATTERY CHARGE
Turning the key to MAR the warning light on the
dial turns on, but it should go out as soon as the
engine is started (with the engine running at idle
speed a brief delay in going out is allowed).
If it stays on contact immediately Fiat Dealership.
LOW ENGINE OIL PRESSURE
Turning the key to MAR the warning light on the
dial turns on, but it should go off as soon as the
engine is started.
If the vwarning light turns on when the car is travelling (on certain versions together with the
message on the display), stop the engine immediately and contact a Fiat Dealership.
Warning
light on dial Message on
multifunction displayMessage on reconfigurable
multifunction display

196
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
WARNING
LIGHTS AND
MESSAGES
ENGINE COOLANT FLUID HIGH
TEMPERATURE
Turning the ignition key to MAR the warning
light on the dial turns on, but it should go off
after few seconds.
The warning light turns on (on certain versions
together with the message on the display) when
the engine is overheated. If the warning light
comes on when driving, proceed as follows:
❒normal driving conditions: stop the car,
switch off the engine and check whether the
water level in the reservoir is not below the
MIN mark. Otherwise wait for few seconds
to allow engine cooling, then open slowly and
carefully the cap, top up coolant and check
whether its level is falling between MIN and
MAX marks in the reservoir. Check visually
any leak. If when restarting the warning light
comes on again, contact a Fiat Dealership;
ç
continues on next page
red
Warning
light on dialMessage on reconfigurable
multifunction displayMessage on
multifunction display