handbrake FIAT LINEA 2007 1.G User Guide

155
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
INFLATION PROCEDURE
The cylinder contains ethyl
glycol. Contains latex: may
cause an allergic reaction. Harmful if
swallowed. Irritant for the eye. May
cause sensitization by inhalation or
contact. Avoid contact with your eyes,
skin and clothes. In the event of con-
tact, wash immediately with plenty of
water. Do not induce vomit if swal-
lowed. Rinse your mouth and drink
plenty of water. Call a doctor imme-
diately. Keep away from children. The
product must not be used by asth-
matics. Do not breath in the vapours
during insertion and suction. Call a
doctor immediately if allergic reactions
are noted. Store the cylinder in the
specific compartment, away from
sources of heat. The sealing fluid will
expire.
WARNINGReplace the cylinder contain-
ing the sealant after the ex-
piration date. Dispose of the
cylinder and the sealant liq-
uid properly. Dispose according to the
national and local laws in force.
Put on the protection gloves
provided together with quick
tyre repair kit.
WARNING
❒Apply the handbrake. Remove the
tyre valve cap, extract the flexible filler
tube A-fig. 9and fasten the ring Bon-
to the tyre valve;
fig. 9F0R0109m

156
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IINDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
❒make sure that switch D-fig. 10of the
compressor is in position 0(off), start
the engine, plug into the nearest sock-
et E-fig. 11and operate the compres-
sor turning switch D-fig. 10to position
I(on). Inflate the tyre to the pressure
specified in the “Inflation pressure”
paragraph, “Technical Specifications”
chapter. For a more accurate reading, check
pressure gauge F-fig. 10with the
compressor off;
❒if after 5 minutes it is still impossible
to reach at least 1.5 bar, disengage com-
pressor from valve and current outlet,
then move the car forth for approx. ten
metres in order to distribute the seal-
ing fluid inside the tyre evenly, then re-
peat the inflation operation;
❒If after this operation it is still impossi-
ble after 5 minutes to reach at least 1.8
bar, do not start driving since the tyre
is excessively damaged and the quick
tyre repair kit cannot guarantee suit-
able sealing, contact Fiat Dealership;
❒if reaching the tyre pressure specified
in paragraph “Inflation pressure” in sec-
tion “Technical Specifications”, start
driving immediately;
fig. 10F0R0160m
fig. 11F0R0113m
fig. 12F0R0110m
Apply the adhesive label in a
position clearly visible by the
driver as a reminder that the tyre has
been treated with the quick repair kit.
Drive carefully, particularly on bends.
Do not exceed 80 km/h. Do not ac-
celerate or brake suddenly.
WARNING
❒after driving for about 10 minutes stop
and check again the tyre pressure; pull
up the handbrake;
Stop if the pressure has
dropped to less than 1.8
bars: the Fix & Go automatic quick
repair kit cannot work properly be-
cause the tyre is excessively damaged.
Go to a Fiat Dealership.
WARNING

157
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
❒if at least 1.8 bar pressure is read, re-
store proper pressure (with engine
running and handbrake on) and restart;
❒drive with the utmost care to the near-
est Fiat Dealership.
FOR CHECKING AND
RESTORING PRESSURE ONLY
The compressor may also be used for
restoring pressure only. Release coupling
A-fig. 14and connect directly to the tyre
valve fig. 13. In this way, the cylinder will
not be connected to the compressor and
no sealant will be injected. CYLINDER REPLACEMENT
PROCEDURE
To replace the cylinder proceed as fol-
lows:
❒release connection A-fig. 14;
❒turn anticlockwise the cylinder to re-
place and raise it;
❒fit the new cylinder and turn it clock-
wise;
❒connect connection Ato the cylinder
and fit the transparent tube Binto the
proper space.
Remember to inform the
workshop that the tyre has
been treated with a quick repair kit.
Give the instruction booklet to the
tyre repair workshop personnel.
WARNING
fig. 13F0R0111mfig. 14F0R0161m

179
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
30 60 90 120 150 180
●●●●● ●
●●●●● ●
●●●●● ●
●●●●● ●
●●●●● ●
●● ●
●●●●● ●
●●●●● ●
●●
●●
●
●●●●● ●
●● ●
SERVICE SCHEDULE PETROL VERSIONS
Service coupons shall be performed every 30,000 km
Thousands of kilometres
Check tyre conditions/wear and adjust pressure if
required
Check light system operation (headlights, direction indicators,
hazard lights, boot lights, passenger compartment lights,
instrument panel warning lights, etc.)
Check windscreen wiper/washer operation
Check of conditions and wear of pads of front disk brakes
Check of conditions and wear of pads of rear disk brakes
(T-JET version)
Check rear drum brake linings and wear
Visually inspect conditions and integrity: bodywork,
underbody protection, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.)
Check cleanness of locks, bonnet and boot and lever
cleanness and lubrication
Check tension and adjust accessory drive belts
(1.4 with heater)
Visually inspect accessory drive belt conditions
Replace accessory drive belt/s
Check and adjust handbrake lever stroke, if required
Check and adjust tappet clearance, if required

181
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
30 60 90 120 150 180
●●●●● ●
●●●●● ●
●●●●● ●
●●●●● ●
●● ●
●●●●● ●
●●●●● ●
●●
●
●●●●● ●
SERVICE SCHEDULE DIESEL VERSIONS
Service coupons shall be performed every 30,000 km
Thousands of kilometres
Check tyre conditions/wear and adjust pressure if
required
Check light system operation (headlights, direction indicators,
hazard lights, boot lights, passenger compartment lights,
instrument panel warning lights, etc.)
Check windscreen wiper/washer operation
Check front and rear (where provided) disk brake pad
conditions and wear
Check rear drum brake linings and wear
Visually inspect conditions and integrity: bodywork,
underbody protection, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.)
Check cleanness of locks, bonnet and boot and lever
cleanness and lubrication
Visually inspect accessory drive belt conditions
Replace accessory drive belt/s
Check and adjust handbrake lever stroke, if required

219
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
VEHICLE
IN AN
EMERGENCY
VEHICLE
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
EOBD system ...................................... 96
ESP system............................................ 93
External lights ...................................... 66
Fiat CODE system ............................. 6
Fix & Go automatic ............................ 153
Flashing the headlights ....................... 66
Fluid levels ............................................ 196
Fluids and lubricants ........................... 214
Follow me home (device) ................. 67
Front ceiling lights
– bulb replacement........................... 165
– control ............................................ 72
Front fog lights
– bulb replacement .......................... 162
– control button .............................. 75
Fuel
– consumption................................... 229
– cut-off switch.................................. 69
– level gauge....................................... 17
Fuel cut-off switch............................... 77
Fuel filler cap ....................................... 102
Fuel level gauge ................................... 17
Fuses (replacement) ........................... 167
Gearbox
– using manual gearbox .................. 132
Glass holder - can holder................... 72
Glove box/oddment compartment .. 70
Handbrake .......................................... 125
Hazard lights ........................................ 75
Head restraints
– front ................................................ 45
– rear................................................... 46
Headlight washer
– control ............................................ 61
– fluid level ........................................ 200
Headlights.............................................. 91
– beam adjustment .......................... 89
– headlight slant adjusting device ... 89
Heated rear window ......................52-57
Heating and ventilation ...................... 49
Identification data .............................. 200
Ignition device....................................... 13
In an emergency .................................. 145
Instrument panel ................................. 14
Instruments .......................................... 16
Interior fittings .................................... 78
Interiors ................................................ 197
Isofix (child restraint system) .......... 114
Jack ........................................................ 148
Jacking the car ..................................... 186
Key with remote control ................ 8
Key without remote control ........... 11
Dashboard........................................... 5
– Left hand drive version ............... 5
Dashboard and controls..................... 4
Dead lock device................................. 77
Digital display ....................................... 18
Dimensions .......................................... 210
Dipped beam headlights
– control ............................................ 66
– bulb replacement........................... 161
Direction indicators
– control ............................................ 67
– front bulb replacement ............... 161
– rear bulb replacement ................. 162
– side bulb replacement ................. 162
Doors..................................................... 82
Electrical socket ................................ 73
Engine
– identification code ........................ 200
– marking ........................................... 202
– technical data ................................ 203
Engine compartment
– washing ........................................... 197
Engine coolant...................................... 187
Engine coolant temperature gauge .. 17
Engine oil
– consumption .................................. 186
– level check....................................... 186
– specifications ................................. 227