headlight FIAT LINEA 2007 1.G Owner's Manual

172
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IINDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
20
30
40
20
40
30
15
10
7.5
7.5
10
10
7.5 F03
F04
F05
F06
F07
F08
F10
F11
F14
F15
F17
F18
F19
Fuse box in engine compartment
LOADS FUSE AMPERES
Ignition switch
Brake valves
Brake pump
Engine cooling fan (low speed)
Engine cooling fan (high speed)
Climate control fan
Horn
Engine control system secondary loads
Right main beam headlight
Left beam headlight
Engine control system primary loads
Engine control unit
Conditioner compressor

179
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
30 60 90 120 150 180
●●●●● ●
●●●●● ●
●●●●● ●
●●●●● ●
●●●●● ●
●● ●
●●●●● ●
●●●●● ●
●●
●●
●
●●●●● ●
●● ●
SERVICE SCHEDULE PETROL VERSIONS
Service coupons shall be performed every 30,000 km
Thousands of kilometres
Check tyre conditions/wear and adjust pressure if
required
Check light system operation (headlights, direction indicators,
hazard lights, boot lights, passenger compartment lights,
instrument panel warning lights, etc.)
Check windscreen wiper/washer operation
Check of conditions and wear of pads of front disk brakes
Check of conditions and wear of pads of rear disk brakes
(T-JET version)
Check rear drum brake linings and wear
Visually inspect conditions and integrity: bodywork,
underbody protection, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.)
Check cleanness of locks, bonnet and boot and lever
cleanness and lubrication
Check tension and adjust accessory drive belts
(1.4 with heater)
Visually inspect accessory drive belt conditions
Replace accessory drive belt/s
Check and adjust handbrake lever stroke, if required
Check and adjust tappet clearance, if required

181
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
30 60 90 120 150 180
●●●●● ●
●●●●● ●
●●●●● ●
●●●●● ●
●● ●
●●●●● ●
●●●●● ●
●●
●
●●●●● ●
SERVICE SCHEDULE DIESEL VERSIONS
Service coupons shall be performed every 30,000 km
Thousands of kilometres
Check tyre conditions/wear and adjust pressure if
required
Check light system operation (headlights, direction indicators,
hazard lights, boot lights, passenger compartment lights,
instrument panel warning lights, etc.)
Check windscreen wiper/washer operation
Check front and rear (where provided) disk brake pad
conditions and wear
Check rear drum brake linings and wear
Visually inspect conditions and integrity: bodywork,
underbody protection, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.)
Check cleanness of locks, bonnet and boot and lever
cleanness and lubrication
Visually inspect accessory drive belt conditions
Replace accessory drive belt/s
Check and adjust handbrake lever stroke, if required

183
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
DEMANDING USE
OF THE CAR
Should prevailing use of the car be under
one of the following specially heavy con-
ditions:
❒trailer or caravan towing;
❒dusty roads;
❒short distances (less than 7-8 km) re-
peated and with external temperatures
below zero;
❒frequently idling engines or long dis-
tance low speed driving (e.g. taxis or
door-to-door deliveries) or in case of
a long term inactivity;
❒in cities;
perform the following inspections more
frequently than shown on the Service
Schedule:
❒check front disk brake pad conditions
and wear;
❒check cleanness of locks, bonnet and
boot and lever cleanness and lubrica-
tion;
❒visually inspect the conditions of: en-
gine, gearbox, transmission, pipes and
hoses (exhaust - fuel - brakes), rubber
parts (boots, sleeves, bushes, etc.);
❒check battery charge and liquid level
(electrolyte) (see paragraph “Charge
level check” in chapter “Maintenance
and care”);
❒visually inspect the accessory drive belt
conditions;
❒check pollen filter and replace, if re-
quired;
❒check air cleaner and replace, if re-
quired.
REGULAR
INSPECTIONS
Every 1,000 km or before long journeys,
check and top up if required:
❒engine coolant fluid level;
❒brake fluid level;
❒brake fluid level;
❒tyre pressure and conditions.
❒operation of lights (headlights, direction
indicators, hazard lights, etc.);
❒operation of the windscreen wiper/
washer system, position and wear of
the windscreen and rear window wiper
blades;
Every 3,000 km check the following and
top-up, if required:engine oil level.
You are recommended to use FL
Seleniaproducts, designed and produced
specifically for Fiat cars (see table “Ca-
pacities” in section “Technical specifica-
tions”).

196
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
Normal maintenance of paintwork consists
in washing the car: the frequency depends
on the conditions and environment where
the car is used. For example, it is advisable
to wash the car more often in areas with
a high environmental pollution or on roads
sprinkled with salt.
To correctly wash the car:
❒remove the aerial from the roof to pre-
vent damage to it if the car is washed in
an automatic system;
❒wash the body using a low pressure jet
of water;
❒wipe a sponge with a slightly soapy so-
lution over the bodywork, frequently
rinsing with the sponge;
❒rinse well with water and dry with a jet
of air or a chamois leather.
Dry the parts less in sight particularly care-
fully, such as the door frames and the
headlight frames, where water may stag-
nate more easily. It is a good idea to leave
the car in the open for a while after wash-
ing it to give time for the water to evap-
orate.Do not wash the car after it has been
parked in the sun or when the engine is
bonnet is hot: this could take the shine off
the paint.
Exterior plastic parts must be cleaned in
the same way as the rest of the car.
Where possible, do not park under trees;
the resinous substance many species re-
lease give the paint a dull appearance and
increase the possibility of triggering rust
processes.
IMPORTANT Bird droppings must be
washed off immediately and thoroughly as
the acid they contain is particularly ag-
gressive.
Detergents cause water pollu-
tion. The car should be washed
in areas equipped for collect-
ing and purifying the liquid
used in the washing process.
Windows
Use specific window cleaner products.
Use also clean cloths to avoid scratching
the glass or damaging the transparency.
IMPORTANT The inside of the rear win-
dow should be wiped gently with a cloth
in the direction of the filaments to avoid
damaging the heating device.
Engine compartment
Wash the engine compartment carefully
after the end of the winter. Be careful not
to direct the jet of water onto electronic
control units. Adequately protect the up-
per air vents to prevent damage to the
windscreen wiper motor. Have this op-
eration performed at a specialised work-
shop.
IMPORTANT Perform this operation on
a cold engine and with the key at STOP.
After the washing operation, make sure
that the various protections (e.g. rubber
caps and guards) have not removed or
damaged.
Front headlights
IMPORTANT Never use aromatic sub-
stances (e.g.: petrol) or ketenes (e.g.: ace-
tone) for cleaning front headlight plastic
lens.

219
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
VEHICLE
IN AN
EMERGENCY
VEHICLE
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
EOBD system ...................................... 96
ESP system............................................ 93
External lights ...................................... 66
Fiat CODE system ............................. 6
Fix & Go automatic ............................ 153
Flashing the headlights ....................... 66
Fluid levels ............................................ 196
Fluids and lubricants ........................... 214
Follow me home (device) ................. 67
Front ceiling lights
– bulb replacement........................... 165
– control ............................................ 72
Front fog lights
– bulb replacement .......................... 162
– control button .............................. 75
Fuel
– consumption................................... 229
– cut-off switch.................................. 69
– level gauge....................................... 17
Fuel cut-off switch............................... 77
Fuel filler cap ....................................... 102
Fuel level gauge ................................... 17
Fuses (replacement) ........................... 167
Gearbox
– using manual gearbox .................. 132
Glass holder - can holder................... 72
Glove box/oddment compartment .. 70
Handbrake .......................................... 125
Hazard lights ........................................ 75
Head restraints
– front ................................................ 45
– rear................................................... 46
Headlight washer
– control ............................................ 61
– fluid level ........................................ 200
Headlights.............................................. 91
– beam adjustment .......................... 89
– headlight slant adjusting device ... 89
Heated rear window ......................52-57
Heating and ventilation ...................... 49
Identification data .............................. 200
Ignition device....................................... 13
In an emergency .................................. 145
Instrument panel ................................. 14
Instruments .......................................... 16
Interior fittings .................................... 78
Interiors ................................................ 197
Isofix (child restraint system) .......... 114
Jack ........................................................ 148
Jacking the car ..................................... 186
Key with remote control ................ 8
Key without remote control ........... 11
Dashboard........................................... 5
– Left hand drive version ............... 5
Dashboard and controls..................... 4
Dead lock device................................. 77
Digital display ....................................... 18
Dimensions .......................................... 210
Dipped beam headlights
– control ............................................ 66
– bulb replacement........................... 161
Direction indicators
– control ............................................ 67
– front bulb replacement ............... 161
– rear bulb replacement ................. 162
– side bulb replacement ................. 162
Doors..................................................... 82
Electrical socket ................................ 73
Engine
– identification code ........................ 200
– marking ........................................... 202
– technical data ................................ 203
Engine compartment
– washing ........................................... 197
Engine coolant...................................... 187
Engine coolant temperature gauge .. 17
Engine oil
– consumption .................................. 186
– level check....................................... 186
– specifications ................................. 227

220
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Prolonged car inactivity...................... 138
Protecting the environment ............. 102
Puddle lights.......................................... 74
– bulb replacement .......................... 174
Radio transmitters and cellular
telephones ......................................... 100
Radionavigator presetting system .... 104
Rain sensor............................................ 69
Rear ceiling lights
– bulb replacement........................... 165
– control ............................................ 72
Rear doors emergency
lock device.......................................... 79
Rear fog lights
– bulb replacement .......................... 162
– control button .............................. 75
Rear window washer
– control ............................................ 61
– fluid level ........................................ 200
Rear window wiper
– blades .............................................. 207
– control ............................................ 61
– nozzles ............................................ 208
Rearview mirrors
– door mirrors ................................. 47
– driving mirror ................................ 48
Reconfigurable
Multifunctional Display ................... 32Refuelling............................................... 106
Rev. counter......................................... 16
Reversing light ..................................... 171
Roof rack/ski rack .............................. 90
Rubber hoses ....................................... 193Safety ................................................... 103
Seat adjustment ................................... 44
Seat belts
– general instructions ..................... 107
– load limiters ................................... 106
– maintenance .................................. 109
– using the seat belts ........................ 104
Seats
– adjustment ..................................... 44
– cleaning ........................................... 197
– tilting (rear seats).......................... 87
Side/taillights
– control ............................................ 57
– front bulb replacement................. 168
– rear bulb replacement.................. 170
Smart washing ..................................... 60
Smoker’s kit ......................................... 72
Snow chains ......................................... 131
Sound system ...................................... 99
Spark plugs
– type ................................................. 215
Speedometer ....................................... 16
Starting and driving ............................ 121
Load limiters ...................................... 106
Main beam headlights
– bulb replacement .......................... 161
– control ............................................ 66
– flashing ............................................ 66
Manual climate control system ........ 53
Multifunctional display........................ 23
Number plate light ............................ 164
Oddment compartments.................. 70
Paint ..................................................... 208
Parking .................................................. 125
Parking sensors.................................... 97
Performance ........................................ 211
Plates
– bodywork paint
identification plate ....................... 213
– model plate .................................... 212
Pollen filter ........................................... 189
Power socket ...................................... 73
Power steering .................................... 96
Power windows .................................. 79
Presetting for mounting the
“Isofix Universal” child
restraint system................................. 120
Pretensioners ...................................... 106

221
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE
VEHICLE
IN AN
EMERGENCY
VEHICLE
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Tyres
– replacing a wheel ........................... 147
– maintenance .................................. 192
– reading tyre markings .................. 206
– standard tyres................................ 208
– cold tyre inflation pressure 209
Using the manual gearbox .............. 126
Ventilation .......................................... 51
Warning lights and messages ......... 133
Weights ................................................ 212
Wheel..................................................... 206
– replacing a wheel .......................... 147
– spare wheel ................................... 220
– wheel geometry ............................ 206
Wheel rims
– understanding rim marking ........ 219
Window washing................................. 68
Window winders................................. 83
Windscreen/rear window/
headlight washer fluid level ............ 200
Windscreen/rear window
wiper blades ...................................... 206
Windscreen washer
– control ............................................ 68
– fluid level ........................................ 187Windscreen wiper
– blades .............................................. 193
– control ............................................ 59
– spray nozzles ................................. 194 Starting the engine
– bump starting ................................ 147
– diesel engines ................................ 123
– emergency start-up ...................... 146
– ignition switch ............................... 13
– jump starting .................................. 146
– petrol engines ............................... 122
– stopping the engine....................... 124
– warm up the engine after
just started...................................... 124
Steering.................................................. 217
Steering column lock ......................... 13
Steering wheel ..................................... 47
Sunroof.................................................. 74
Sun visors ............................................. 81
Suspensions .......................................... 205
Symbols ................................................. 6
Tailgate ................................................ 82
Technical specifications ..................... 199
Third brake light ................................. 172
Top speeds ........................................... 223
Towing the car .................................... 175
Towing trailers
– tow hook installation ................... 129
Transmission ........................................ 204
Trip computer ..................................... 42