battery FIAT LINEA RHD 2010 1.G User Guide

74
TRANSCEIVERS
AND MOBILE PHONES
Radio transceiver equipment (e.g.: e-tacs
mobile phones, HAM radio systems and
the like) shall not be used inside the car
unless a separate aerial is mounted on the
roof.
IMPORTANT The use of similar devices
inside the passenger compartment (with-
out separated aerial) produces radio-fre-
quency electromagnetic fields which,
am-
plified by the resonance effects inside the
passenger compartment,
may cause elec-
trical systems equipping the car to mal-
function. This could compromise safety in
addition to constituting a potential hazard
for the passengers.
In addition, transmission and reception of
these devices may be affected by the
shielding effect of the car body.
As concerns EC-approved mobile phones
(GSM, GPRS, UMTS),
strictly comply with
the instructions for use provided by the
mobile phone’s manufacturer.
ACCESSORIES
PURCHASED BY THE
OWNER
If after buying the car, you decide to install
electrical accessories that require a per-
manent electric supply (alarm, satellite an-
titheft system, etc.) or accessories that in
any case burden the electric supply,
con-
tact Fiat Dealership,
whose qualified
perso nnel, beside s sugge sting the most suitable devices belonging to Linea access-
ories Fiat, will also evaluate the overall elect-
ric absorption,
checking whether the car’s
electric system is able to withstand the
load required, or whether it needs to be
integrated with a more powerful battery.
Be very careful when fitting
non-standard additional
spoilers , light alloy wheels or wheel
cups: they could reduce brake
venti-
lation and consequently brake effi-
ciency in the case of repeated, violent
braking or on long downhill roads.
Make sure that nothing obstructs the
pedal stroke (mats, etc.)
WARNING
ELECTRICAL/ELECTRONIC
DEVICE INSTALLATION
Electrical and electronic devices installed
after buying the car by after-market ser-
vice must carry the following label:
auth-
orises the installation of transceiving dev-
ices provided that they are installed accord-
ing to rules of good engineering practice
respecting the manufacturer’s indications
by a specialised centre.
IMPORTANT Traffic police may not allow
the car on the road in the event of
as-
sembly of devices which imply modifica-
tions to the features of the car. This may
also cause lapse of warranty in relation to
faults caused by the change or either di-
rectly or indirectly related to it.
shall
not be liable for damage caused by the
installation of accessories either not sup-
plied or recommended by
and/or installed
in compliance with the provided instruc-
tions.
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
Fiat Group Automobiles South Africa (Pty) Ltd
Fiat Group Automobiles South Africa (Pty) Ltd
Automobiles South Africa (Pty) Ltd
Fiat Group
LINEA Owner HAND BOOK RHD.pdf 74LINEA Owner HAND BOOK RHD.pdf 748/21/09 2:16:10 PM8/21/09 2:16:10 PM

ENGINE STARTING
The car is provided with an electronic en-
gine lock device: refer to “The Fiat CODE
system” paragraph in “Dashboard and
controls” if you cannot start the engine.
The engine may be noisier during the first
seconds of operation, particularly after a
long period of inactivity. This is charac-
teristic of hydraulic tappets, the timing sys-
tem chosen to reduce the number of ser-
vicing interventions and does effects nei-
ther functionality nor reliability.
It is advisable not to demand
maximum performance from
your car (e.g. excessive accel-
erations, long distances at top
rpm, excessive intense braking, etc.) as
soon as the engine is started.
Do not leave the key in the ig-
nition switch with the engine
off to avoid unnecessary con-
sumption of electricity which
could drain the battery. It is dangerous
to run the engin e in clo sed environ-
ments.
Running the engine in con-
fined areas is extremely dan-
gerous. The engine consumes oxygen
and produces carbo n monoxide
which is a highly toxic and lethal gas.
WARNING
Remember that the brake
booster and power steering
are not operational until the engine
has been started, therefore much ef-
for t than usual is required on the
brake pedal and steering wheel.
WARNING
STARTING PROCEDURE FOR
PETROL VERSIONS
Proceed as follows:
ensure that the handbrake is up;
put the gear lever into neutral;
press the clutch pedal down to the
floor without touching the accelerator;
turn the ignition key to AV Vand let
it go the moment the engine starts.
If the engine does not start at the first at-
tempt,
return the ignition key to STOP
before repeating starting.




93
CORRECT USE
OF THE CAR
WARNING
IN AN
CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
LIGHTS AND
EMERGENCY
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
MESSAGES
LINEA Owner HAND BOOK RHD.pdf 93LINEA Owner HAND BOOK RHD.pdf 938/21/09 2:16:13 PM8/21/09 2:16:13 PM

HANDBRAKE fig. 1
The handbrake lever is located between
the two front seats.
Pull the lever upwards to operate the
handbrake. Four or five notches are nor-
mally sufficient to lock the car on flat ter-
rain, while nine or ten may be necessary
on a steep slope with the car loaded.
IMPORTANT If this is not the case, con-
tact Fiat Dealership to have the hand-
brake adjusted.
When the handbrake lever is pulled up
and the ignition key is atMAR, the in-
strument panel warning light will turn
on.
PARKING THE CAR
Proceed as follows:
stop the engine and engage the hand-
brake;
engage a gear (on a slope, engage first
gear if the car is faced uphill or reverse
if it is faced downhill) and leave the
wheels steered.
If the car is parked on a steep slope, it is
further advisable to block the wheels with
a wedge or stone. Do not leave the key in
the ignition switch to prevent draining the
battery. Always remove the key when you
leave the car.
Never leave children unat-
tended in the car. Always re-
move the ignition key when leaving
the car and take it out with you.
WARNING
fig. 1F0R0103m
Proceed as followed to release the hand-
brake:

slightly lift the handbrake and press re-
lease button A;
hold button Apressed and lower the
lever. Warning light on the instru-
ment panel will go out.
Press the brake pedal when carrying out
this operation to prevent the car from
moving accidentally.


96
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
EMERGENCY
MAINTENANCE
SPECIFICATIONS
INDEX
MESSAGES
DASHBOARD
SAFETY
LIGHTS AND
IN AN
CAR
TECHNICAL
WARNING
LINEA Owner HAND BOOK RHD.pdf 96LINEA Owner HAND BOOK RHD.pdf 968/21/09 2:16:14 PM8/21/09 2:16:14 PM

CAR INACTIVITY
If the car is to be left inactive for longer
than a month, the following precautions
should be noted:
park the car in covered, dry and if pos-
sible well-ventilated premises;
engage a gear;
check that the handbrake is not en-
gaged;
disconnect the negative battery termi-
nal and check battery charge (see para-
graph “Charge level check”
in chapter
“Maintenance and care”). Repeat this
check once every three months dur-
ing storage. Recharge the battery if nec-
essary (see paragraph “If the battery is
flat” in chapter “In an emergency”);
clean and protect the painted parts us-
ing protective wax;
clean and protect the shiny metal parts
using special compounds readily avail-
able;
sprinkle talcum powder on the rubber
windscreen and rear window wiper
blades and lift them off the glass;
slightly open the windows;
cover the car with a fabric or perfo-
rated plastic terrapin. Do not use com-
pact plastic sheets which do
not allow
humidity to evaporate from the surface
of the car;
inflate tyres to +0.5 bar above the nor-
mal specified pressure and check it at
intervals;
if you don’t disconnect the battery from
the electric system, check its charge
every month (see paragraph “Charge
level check” in chapter “Maintenance
and care”);
recharge the battery if necessary (see
paragraph “If the battery is flat” in chap-
ter “In an emergency”);
do not drain the engine cooling system.
IMPORTANT Where relevant, switch off
the car alarm with the remote control.
CORRECT USE
OF THE CAR
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
WARNING
LIGHTS AND
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
MESSAGES
100
LINEA Owner HAND BOOK RHD.pdf 100LINEA Owner HAND BOOK RHD.pdf 1008/21/09 2:16:14 PM8/21/09 2:16:14 PM

GENERAL WARNINGS ..................................................... 102
LOW BRAKE FLUID ............................................................ 102
HANDBRAKE ON................................................................ 102
AIR BAG FAILURE ................................................................ 103
HOT
ENGINE COOLANT ........................................................... 103
LOW BATTERY CHARGE ................................................. 104
LOW ENGINE OIL PRESSURE .......................................... 104
INCOMPLETE DOOR LOCKING.................................... 105
SEAT BELTS NOT FASTENED .......................................... 105
EBD SYSTEM FAILURE ........................................................ 105
INJECTION SYSTEM FAILURE
(DIESEL VERSIONS) ............................................................ 106
EOBD SYSTEM FAILURE (PETROL VERSIONS) ......... 106
FRONT PASSENGER AIRBAG DEACTIVATED ........... 107
ABS SYSTEM FAILURE ......................................................... 107
FUEL RESERVE ....................................................................... 107
GLOW PLUG WARMING ................................................ 108
GLOW PLUG WARMING FAILURE ............................... 108
WATER IN DIESEL FUEL FILTER ..................................... 108FIAT CODE PROTECTION
SYSTEM FAILURE .................................................................. 108
EXTERNAL LIGHTS FAILURE........................................... 109
REAR FOG LIGHTS.............................................................. 109
GENERIC FAILURE INDICATION ................................. 109
SIDELIGHTS AND LOW BEAMS ..................................... 110
FOLLOW ME HOME ........................................................... 110
FRONT FOG LIGHTS ........................................................ 110
LEFT-HAND DIRECTION INDICATOR ........................ 110
RIGHT-HAND DIRECTION INDICATOR .................... 110
MAIN BEAM HEADLIGHTS............................................... 110
WW W
A A
R R
N N
I I
N N
G G
L L
I I
G G
H H
T T
S S
A A
N N
D D
M M
E E
S S
S S
A A
G G
E E
S S
101
CORRECT USE
OF THE CAR
CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 101LINEA Owner HAND BOOK RHD.pdf 1018/21/09 2:16:14 PM8/21/09 2:16:14 PM

LOW ENGINE OIL
PRESSURE (red)
Turning the ignition key to
MARthe warning light turns on, but it
should go out as soon as the engine is
started.
On certain versions the dedicated message
is displayed.
If the warning light
turns on when the car is trav-
elling (on cer tain versions together
with the message on the display) stop
the engine immediately and contact
a Fiat Dealership.
WARNING
In the case of demanding use (e.g.
towing traile rs uphill or car at full
load): slow down and stop the car if
the warning light stays on. Stand for
2 or 3 minutes with the engine running
and slightly accelerated to promote a
better circulation of coolant.
Then
stop the engine. Check correct liquid
level as described above.
IMPORTANT Under severe use of the
car, keep the engine on and slightly accel-
erated for few minutes before switching it
off.
On certain versions the dedicated message
is displayed.LOW BATTERY
CHARGE (red)
Turning the igni tion key to
MARthe warning light turns on, but it
should go out as soon as the engine is
started (with the engine running at idle
speed a brief delay in going out is allowed).
Go to a Fiat Dealership immediately
if the warning light stays on either ste-
ady or blinking.
CORRECT USE
OF THE CAR
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES
104
LINEA Owner HAND BOOK RHD.pdf 104LINEA Owner HAND BOOK RHD.pdf 1048/21/09 2:16:15 PM8/21/09 2:16:15 PM

111
STARTING THE ENGINE ................................................... 112
REPLACING A WHEEL ...................................................... 113
WHEN NEEDING TO CHANGE A BULB ..................... 119
IF AN EXTERIOR LIGHT BURNS OUT .......................... 121
IF AN INTERIOR LIGHT BURNS OUT .......................... 126
IF A FUSE BLOWS ................................................................ 128
IF THE BATTERY IS FLAT.................................................. 135
LIFTING THE CAR ............................................................... 135
TOWING THE CAR ........................................................... 135
II I
N N
A A
N N
E E
M M
E E
R R
G G
E E
N N
C C
Y Y
CORRECT USE
OF THE CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
LINEA Owner HAND BOOK RHD.pdf 111LINEA Owner HAND BOOK RHD.pdf 1118/21/09 2:16:16 PM8/21/09 2:16:16 PM

112
STARTING THE
ENGINE
EMERGENCY START-UP
Go to a Fiat Dealership immediately
if instrument panel warning light
comes
on steady.
JUMP STARTING fig. 1
If the battery is flat, the engine may be
started using an auxiliary battery with the
same capacity or a little
higher than the
flat one. Proceed as follows to start the engine:
connect positive terminals (+near the
terminal) of the two batteries with a
jump lead;
with a second lead, connect the nega-
tive terminal (–) of the auxiliary battery
to an earthing point on the engine or
the gearbox of the car to be
started;
start the engine;
when the engine has been started, re-
move the leads reversing the order
above.
If after a few attempts the engine does not
start, do not insist but contact the
near-
est Fiat Dealership.
This procedure must be per-
formed by expert personnel
because incorrect actions may cause
electrical
discharge of considerable in-
tensity. Furthermore, battery fluid is
poisonous
and corrosive: avoid contact
with your skin and eyes. Keep naked
flames away from the battery.
No
smoking. Do not cause sparks.
WARNING
fig. 1
CORRECT USE
OF THE CAR
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
F0R0242m
LINEA Owner HAND BOOK RHD.pdf 112LINEA Owner HAND BOOK RHD.pdf 1128/21/09 2:16:16 PM8/21/09 2:16:16 PM

113
IMPORTANT Never connect the negative
terminals of the two batteries directly:
sparks could ignite explosive gas released
from the battery. If the auxiliary battery is
installed on another car, prevent
acciden-
tal contact between metallic parts of the
two cars.JUMP STARTING
Never jump start the engine by pushing,
towing or driving downhill.
This could
cause a flow of fuel into the catalytic con-
verter and damage it beyond repair.
IMPORTANT Remember that the brake
booster and the power steering system
are not operating until
the engine is start-
ed, a greater effort will therefore be re-
quired to press the brake pedal or turn
the steering wheel.
REPLACING A WHEEL
GENERAL INSTRUCTIONS
Wheel changing and correct use of the
jack and spare wheel call for some pre-
cautions as listed below.
Indicate that the car is sta-
tionary according to the laws
in force: hazard lights, triangle, etc.
Passengers should leave the car, par-
ticularly if it is very loaded and
wait
for the wheel to be changed away
from on-coming traffic . Apply the
handbrake.
WARNING
CORRECT USE
OF THE CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
LINEA Owner HAND BOOK RHD.pdf 113LINEA Owner HAND BOOK RHD.pdf 1138/21/09 2:16:16 PM8/21/09 2:16:16 PM

FUSE LOCATION
The fuses are grouped in three units
on
the dashboard, in the engine compartment
and on the positive battery terminal.
Fuse box on the dashboard
To gain access to the fuses in the fuse box
on the dashboard,
remove the cover A
fig. 28.
fig. 29F0R0126m
F34 F48 F49 F35 F13
F46 F33 F37 F42 F12
F45 F47 F32 F50 F51
F52 F41 F43 F40 F44
F36 F39 F38 F53 F31
fig. 28F0R0125m
129
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 129LINEA Owner HAND BOOK RHD.pdf 1298/21/09 2:16:20 PM8/21/09 2:16:20 PM