headlight FIAT LINEA RHD 2010 1.G User Guide
[x] Cancel search | Manufacturer: FIAT, Model Year: 2010, Model line: LINEA RHD, Model: FIAT LINEA RHD 2010 1.GPages: 184, PDF Size: 4.12 MB
Page 121 of 184
Bulb Ref. figure Type Power
Main beam headlights
Dipped beam headlights
Front sidelights
Front fog lights (where provided)
Front direction indicators
Side direction indicators
Rear direction indicators
Side/taillights (Parking lights)
Brake lights
Third brake light (additional brake light)
Reversing light
Rear fog lights
Number plate light
Front ceiling light with spot lights
Rear ceiling light with movable lens
Boot light H1U55W
H755W
W5W
H1U55W
PY21W
WY5W
PY21W
R5W
P21W
W5W
P21W
P21W
W5W
10W x 2
10W
W5W D
D
A
–
B
A
B
B
B
B
–
–
A
C
C
A55W
55W
5W
55W
21W
5W
21W
5W
21W
5W
21W
21W
5W
10W
10W
5W
120
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
MAINTENANCE
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
DASHBOARD
SAFETY
CAR
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 120LINEA Owner HAND BOOK RHD.pdf 1208/21/09 2:16:19 PM8/21/09 2:16:19 PM
Page 123 of 184
DIPPED BEAM HEADLIGHTS
fig. 10
To change the bulb, proceed as follows:
remove the clipped-on cover;
disconnect the central electric connec-
tor and release the bulb holder catch;
remove the bulb Band replace it;
fit the new bulb, making the outlines of
the metallic part coincide with the
grooves on the reflector;
refit the bulb holder catch and reconnect
the electrical connector;
refit the protection and check that it
is correctly locked.MAIN BEAM HEADLIGHTS
fig. 11
To change the bulb, proceed as follows:
remove the clipped-on cover;
disconnect the central electric connec-
tor and release the bulb holder catch;
remove the bulb Band replace it;
refit the new bulb;
refit the bulb holder catch and reconnect
the electrical connector;
refit the protection and check that it
is correctly locked.DIRECTION INDICATORS
Front fig. 11/a
To change the bulb, proceed as follows:
steer the right/left wheel outwards as
shown in the figure;
turn the catch as shown by the arrow,
then use the lid;
remove the bulb holder cover by turn-
ing it anticlockwise;
fig. 10F0R0222mfig. 11/aF0R0224mfig. 11F0R0223m
122
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
MAINTENANCE
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
DASHBOARD
SAFETY
CAR
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 122LINEA Owner HAND BOOK RHD.pdf 1228/21/09 2:16:19 PM8/21/09 2:16:19 PM
Page 132 of 184
7.5
7.5
7.5
15
20
20
7.5
7.5
7.5
20
10
30
7.5
20 F12
F13
F31
F32
F33
F34
F35
F36
F37
F38
F39
F40
F42
F43
FUSE TABLE
Fuse box on dashboard
LOADS FUSE AMPERES
Right dipped beam headlight
Left dipped beam headlight, headlight corrector
INT/A for relay coils (T08, T17) in engine compartment fuse box and body
computer node
Subwoofer
Power windows control unit (left rear window motor)
Power windows control unit (right rear window motor)
+15 reversing lights, brake lights control, air mass meter, glow plug pre-heating
unit, water in diesel fuel sensor, tachometer generator, level sensor 2
Power window unit (+30 for electronics)
+15 instrument panel, NA brake lights control
Body computer node
Radio node
Heated rear window
+15 brake system node
Windscreen wiper control (two-way pump)
131
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 131LINEA Owner HAND BOOK RHD.pdf 1318/21/09 2:16:21 PM8/21/09 2:16:21 PM
Page 134 of 184
20 70
30
40
20/30
20/30/40
30
15
10
7.5
7.5
15 7.5
10
7.5 F03 F01
F04
F05
F06
F07
F08
F10
F11
F14
F15
F17 F16
F18
F19
Fuse box in engine compartment
LOADS FUSE AMPERES
Ignition switch Dashboard CPL1
Brake valves
Brake pump
Engine cooling fan (low speed)
Engine cooling fan (high speed)
Climate control fan
Horn
Engine control system secondary loads
Right main beam headlight
Left beam headlight
Engine control system primary loads EOBD
Engine control unit
Conditioner compressor
133
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 133LINEA Owner HAND BOOK RHD.pdf 1338/21/09 2:16:21 PM8/21/09 2:16:21 PM
Page 144 of 184
DEMANDING USE
OF THE CAR
Should prevailing use of the car be under
one of the following specially heavy con-
ditions:
trailer or caravan towing;
dusty roads;
short distances (less than 7-8 km) re-
peated and with external temperatures
below zero;
frequently idling engines or long dis-
tance low speed driving (e.g . taxis or
door-to-door deliveries) or in case of
a long term inactivity;
in cities;
perform the following inspections and
shown on the Service Schedule:
check cleanness of locks, bonnet and
boot and lever cleanness and lubrica-
tion;
visually inspect the conditions of: en-
gine, gearbox, transmission, pipes and
hoses (exhaust - fuel - brakes), rubber
parts (boots, sleeves, bushes, etc.);
check battery charge and liquid level
(electrolyte) (see paragraph “Charge
level check” in chapter “Maintenance
and care”);
visually inspect the accessory drive belt
conditions;
check pollen filter
check air cleaner and replace, if re-
quired.
REGULAR
INSPECTIONS
Every 1,000 km or before long journeys,
check and top up if required:
engine coolant fluid level; Engine Oil level, every 3,000 km and
brake - clutch fluid level and type;
power steering fluid level;
tyre pressure and conditions;
operation of lights (headlights, direction
indicators, hazard lights, etc.);
143
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
. If the vehicle is
replacements more frequently than
check front disk brake pad conditions
and wear; frequently than required; replace engine oil and oil filter more
frequently
than required on the service replace spark plugs more
schedules, in particular contact a Fiat
Dealership if a reduction in the
vehicle engine performance is noted;used frequently in dusty or heavily
polluted environments it is
advisable to replace the filtering
elementts more frequently, in
particular it should be replaced if a
reduction of the amount of air
admitted to the passenger
compartment is noted; top up if required;
LINEA Owner HAND BOOK RHD.pdf 143LINEA Owner HAND BOOK RHD.pdf 1438/21/09 2:16:22 PM8/21/09 2:16:22 PM
Page 157 of 184
Normal maintenance of paintwork consists
in washing the car: the frequency depends
on the conditions and environment where
the car is used. For example, it is advisable
to wash the car more often in areas with
a high environmental pollution or on roads
sprinkled with salt.
To correctly wash the car:
remove the aerial from the roof to pre-
vent damage to it if the car is washed in
an automatic system;
wash the body using a low pressure jet
of water;
wipe a sponge with a slightly soapy so-
lution over the bodywork, frequently
rinsing with the sponge;
rinse well with water and dry with a jet
of air or a chamois leather.
Dry the parts less in sight particularly care-
ful ly, such as the door fram es and the
headlight frames, where water may stag-
nate more easily. It is a good idea to leave
the car in the open for a while after wash-
ing it to give time for the water to evap-
orate.Do not wash the car after it has been
parked in the sun or when the engine is
bonnet is hot: this could take the shine off
the paint.
Exterior plastic parts must be cleaned in
the same way as the rest of the car.
Where possible, do not park under trees;
the resinous substance many species re-
lease give the paint a dull appearance and
increase the possibility of triggering rust
processes.
IMPORTANT Bir d droppings must be
washed off immediately and thoroughly as
the acid they contain is partic ularly ag-
gressive.
Detergents cause water pollu-
tion. The car should be washed
in areas equipped for collect-
ing and purifying the liquid
used in the washing process.
Windows
Use specific window cleaner products.
Use also clean cloths to avoid scratching
the glass or damaging the transparency.
IMPORTANT The inside of the rear win-
dow should be wiped gently with a cloth
in the direction of the filaments to avoid
damaging the heating device.
Engine compartment
Wash the engine compartment carefully
after the end of the winter. Be careful not
to direct the jet of water onto electronic
control units. Adequately protect the up-
per air vents to prevent damage to the
windscreen wiper motor. Have this op-
eration performed at a specialised work-
shop.
IMPORTANT Perform this operation on
a cold engine and with the key at STOP.
After the washing operation, make sure
that the various protections (e.g. rubber
caps and guards) have not removed or
damaged.
Front headlights
IMPORTANT Never use aromatic sub-
stances (e.g.: petrol) or ketenes (e.g.: ace-
tone) for cleaning front headlight plastic
lens.
156
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 156LINEA Owner HAND BOOK RHD.pdf 1568/21/09 2:16:36 PM8/21/09 2:16:36 PM
Page 177 of 184
176
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
SAFETY
Dimensions ........................................ 169
Dipped beam headlights
- control ........................................... 51
- bulb replacement ........................ 122
Direction indicators
- control ........................................... 52
- front bulb replacement ..............
122
- rear bulb replacement ............... 123
- side bulb replacement ................
123
Doors .................................................. 64
Engine
- identification code ...................... 161
- marking ..........................................
160
- technical data ............................... 162
Engine compartment
- washing ..........................................
156
Engine coolant ...................................
147
Engine coolant temperature gauge .. 15
Engine oil
- consumption ................................ 146
- level check .................................... 146
- specifications ................................
173
EOBD system .................................... 72
External lights .................................... 51
Fiat CODE system .......................... 6
Flashing the headlights ..................... 51
Fluid levels ..........................................
146
Fluids and lubricants ........................ 173
Follow me home (device) ............... 52
Front ceiling lights
- bulb replacement ........................ 126
- control ........................................... 54
Front fog lights
- bulb replacement ........................ 123
- control button ............................. 57
Fuel
- level gauge .................................... 15
Fuel cut-off switch ............................ 59
Fuel filler cap ..................................... 76
Fuel level gauge ................................. 15
Fuses (replacement) ........................ 128
Gearbox
- using manual gearbox .................
97
Glass holder - can holder ............... 62
Glove box/oddment compartment .. 60
Handbrake ........................................ 96
Hazard lights ...................................... 57
Head restraints
- front ............................................... 33
- rear .................................................
34
Headlights
- beam adjustment ......................... 70
Heated rear window ....................... 42
Heating and ventilation ................... 37
Identification data ............................ 160
Ignition device ................................... 12
In an emergency ............................... 111
Instrument panel .............................. 13
Instruments ....................................... 14
Interior fittings .................................. 60
Interiors ............................................. 157
Jack ..................................................... 114
jacking the car ...................................
116
LINEA Owner HAND BOOK RHD.pdf 176LINEA Owner HAND BOOK RHD.pdf 1768/21/09 2:16:38 PM8/21/09 2:16:38 PM
Page 178 of 184
177
TECHNICAL
SPECIFICATIONS
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY INDEX
AND CONTROLS
DEVICES
Key with remote control .............. 8
Key without remote control ......... 10
Load limiters .................................... 80
Main beam headlights
- bulb replacement ........................ 122
- control ........................................... 51
- flashing ........................................... 51
Multi functional display ....................
21
Number plate light ......................... 125
Oddment compartments .............. 60
Paint ................................................... 155
Parking ................................................ 96
Performance ...................................... 170
Plates
- model plate ...................................
171
Pollen filter .........................................
149
Power steering fluid .........................149Power windows ................................ 65
Pretensioners .................................... 80
Prolonged car inactivity .................. 100
Protecting the environment ........... 76
Radio transmitters and cellular
telephones .................................... 74
Radio navigation presetting system.. 73
Rear ceiling lights
- bulb replacement ........................ 126
- control ........................................... 54
Rear door emergency
lock device .................................... 64
Rear fog lights
- bulb replacement ........................ 123
- control button ............................. 57
Rearview mirrors
- door mirrors ................................ 35
- driving mirror ...............................
36Refueling ............................................. 75
Rev. counter ....................................... 14
Reversing light ...................................
123
Rubber hoses .................................... 153
Safety ................................................. 77
Seat adjustment ................................ 32
Seat belts
- general instructions .................... 81
- load limiters ................................. 80
- maintenance ................................. 83
- using the seat belts .....................
78
Seats
- adjustment .................................... 32
- cleaning ......................................... 157
- tilting (rear seats) ........................ 68
Side lights
- control ...........................................
42
bulb replacement ........................... 121
Smart washing ................................... 53
Smoker’s kit ....................................... 62
Sound system .................................... 73
Spark plugs
- type ................................................ 162
LINEA Owner HAND BOOK RHD.pdf 177LINEA Owner HAND BOOK RHD.pdf 1778/21/09 2:16:38 PM8/21/09 2:16:38 PM