stop start FIAT LINEA RHD 2010 1.G User Guide

Electric devices
Use electric devices only for the amount
of time needed. Rear heated window, ad-
ditional headlights, windscreen wipers and
heater fan need a considerable amount of
energy, therefore increasing the require-
ment of current increases fuel consump-
tion (up to +25% in the urban cycle).
Climate control
The climate control system requires high-
er fue l consumptio n (up to +20% in av-
erage): use the air vents when the exter-
nal temperature allows to.
Spoilers
The use of non-c erti fied aerodynamic
item s may advers ely affe ct air drag and
consumption levels.DRIVING STYLE
Starting
Do not warm the engine up with the car
standing: the engine warms up very slow-
ly in these condition s, increasing con-
sumption and emissions. It is advisable to
start off immediately and slowly keeping
the engine speed down: the engine will
warm up much faster this way.
Unnecessary actions
Avoid revving up when starting at traffic
lights or before stopping the engine. The
latter action, like doubling the clutch, is un-
necessary and causes increase of con-
sumption and pollution.
Gear selection
Use a higher gear as soon as traffic and
road conditions allow. Using a low gear
for faster acceleration will increase con-
sumption.
In the same way improper use of a high
gear increases consumption, emissions an
engine wear.CONTAINING
RUNNING COSTS
Here are some suggestions which may
help you to keep the running costs of your
car down and lower the amount of toxic
emissions released into the atmosphere.
GENERAL CONSIDERATIONS
Car maintenance
Have checks and adjustments carried out
in accordance with the “Service schedule”.
Ty r e s
Check tyre pressure regularly at least
once ever y four weeks: excessively low
pressure will increase consumption be-
cause rolling resistance will be higher.
Unnecessary loads
Do not travel with too much luggage
stowed in the boot. The weight of the car
(especially when driving in town) and its
trim greatly affects consumption and sta-
bility.
98
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
EMERGENCY
MAINTENANCE
SPECIFICATIONS
INDEX
MESSAGES
DASHBOARD
SAFETY
LIGHTS AND
IN AN
CAR
TECHNICAL
WARNING
LINEA Owner HAND BOOK RHD.pdf 98LINEA Owner HAND BOOK RHD.pdf 988/21/09 2:16:14 PM8/21/09 2:16:14 PM

103
AIR BAG FAILURE
(red)
Turn ing the ignit ion key to
MARthe warning ligh t turns on, but it
should go off after few seconds.
The warning light stays on steady if there
is a failure in the airbag system.
On certain versions the dedicated message
is displayed.
If when turning the key to
MAR the warning light
does not turn on or if it stays on when
travelling (together with the message
on the multifunctional display, where
provided) there could be a failure in
safety systems; in this event air bags
or pretensioners may not be deployed
in case of impact or, in a minor num-
ber of cases, they be deployed acci-
dentally. Contact Fiat Dealership
immediately to have the system checked.
WARNING
Failure of warning light
(warning light off) is indicat-
ed by warning light which will
blink for longer than the normal 4
seconds indicating that the front pas-
senger airbag is off.
WARNING
HOT ENGINE
COOLANT (red)
Turn ing the igni tion key to
MARthe warning light turns on, but it
should go off after few seconds.
The warning light turns on when the en-
gine is overheated.
If the warning light comes on, proceed as
follows:
during normal travel: s t o p t h e c a r,
stop the engine and check that the wa-
ter level in the vessel is not under the
MINline. In this case, wait for a few
minutes for the engine to cool down
when slowly and carefully open the
cap, top-u p with coolant and check
that the level is between the MINand
MAXreferences on the vessel itself.
Also check for leakages. Go to a Fiat
Dealership if the warning should
come on when the engine is started
again.CORRECT USE
OF THE CAR
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES WARNING
LIGHTS AND
MESSAGES
IN AN
LINEA Owner HAND BOOK RHD.pdf 103LINEA Owner HAND BOOK RHD.pdf 1038/21/09 2:16:15 PM8/21/09 2:16:15 PM

LOW ENGINE OIL
PRESSURE (red)
Turning the ignition key to
MARthe warning light turns on, but it
should go out as soon as the engine is
started.
On certain versions the dedicated message
is displayed.
If the warning light
turns on when the car is trav-
elling (on cer tain versions together
with the message on the display) stop
the engine immediately and contact
a Fiat Dealership.
WARNING
In the case of demanding use (e.g.
towing traile rs uphill or car at full
load): slow down and stop the car if
the warning light stays on. Stand for
2 or 3 minutes with the engine running
and slightly accelerated to promote a
better circulation of coolant.
Then
stop the engine. Check correct liquid
level as described above.
IMPORTANT Under severe use of the
car, keep the engine on and slightly accel-
erated for few minutes before switching it
off.
On certain versions the dedicated message
is displayed.LOW BATTERY
CHARGE (red)
Turning the igni tion key to
MARthe warning light turns on, but it
should go out as soon as the engine is
started (with the engine running at idle
speed a brief delay in going out is allowed).
Go to a Fiat Dealership immediately
if the warning light stays on either ste-
ady or blinking.
CORRECT USE
OF THE CAR
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES
104
LINEA Owner HAND BOOK RHD.pdf 104LINEA Owner HAND BOOK RHD.pdf 1048/21/09 2:16:15 PM8/21/09 2:16:15 PM

106
Go to a Fiat Dealership
as soon as possible if warning
light either does not light
up when the key is turned to
MAR to if while travelling the warning
lights comes on either steady or blink-
ing (along with a message on the dis-
play).
If the light flashes, release the accelerator
pedal to lower the speed of the engine un-
til the warning light stops flashing; contin-
ue the journey at moderate speed, trying
to avoid driving conditions that may cause
further flashing and contact Fiat
Dealership as soon as possible. EOBD ENGINE CONTROL
SYSTEM FAILURE
Under normal conditions, turning the ig-
nition key to MAR, the warning light turns
on
but it should go off after engine starting.
This indicates that the warning light is
working correctly. If the warning light
ei-
ther stays on or comes on while travelling:
steady light: a fault in the supply/ignition
system which could cause high emis-
sions at the exhaust, possible lack of
performance, poor handling and high
consumption levels.
On certain versions the dedicated mes-
sage is displayed.
In these conditions, you may continue
travelling at moderate speed without de-
manding excessive effort from the engine.
Prolonged use of the car with the warn-
ing light on may cause damage.
Go to a
Fiat Dealership as soon as possible.
if warning light will go out after the
fault goes away but it will be stored in the
system.
blinking: indicates the possibility of
damage to the catalyser (see “EOBD
system” in section “Dashboard
and
controls”). INJECTION SYSTEM
FA I L U R E
(Multijet versions -
amber)
EOBD SYSTEM
FAILURE (petrol
versions - amber)
Injection system failure
Under normal conditions, turning the
ig-
nition key to MAR, the warning light turns
on but it should go off after engine start-
ing.
If the warning light stays on or turns
on
when travelling, means a fault in the sup-
ply/ignition system which could cause high
emissions at the exhaust, possible lack of
performance, poor handling and high
con-
sumption levels.
On certain versions the dedicated message
is displayed.
In these conditions, you may continue
travelling at moderate speed without
de-
manding excessive effort from the engine.
Go to a Fiat Dealersh ip as so on as
possible.
CORRECT USE
OF THE CAR
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES
LINEA Owner HAND BOOK RHD.pdf 106LINEA Owner HAND BOOK RHD.pdf 1068/21/09 2:16:15 PM8/21/09 2:16:15 PM

108
GLOW PLUG
WA R M I N G
(Multijet versions - amber)
GLOW PLUG
WARMING FAILURE
(Multijet versions - amber)
Glow plug warming
The warning light will go on when the key
is turned to MAR. It will go out as soon
as the glow plugs have
reached a prede-
termined temperature. Start the engine as
soon as the warning light goes out.
IMPORTANT With hot ambient temper-
ature, warning light stays on for very short
time.
Glow plug warming failure
The warning light will blink in the event
of a failure to the glow plug heating sys-
tem. Go to a Fiat Dealership as soon
as possible.
On certain
versions the dedicated message
is displayed.
WATER IN DIESEL
FUEL FILTER
(Multijet versions - amber)
Turning the ignition key to MARthe
warning light turns on, but it should go off
after few seconds.
The warning light turns on when there is
water in the diesel fuel filter.
On certain
versions the dedicated message
is displayed.
The presence of water in the
feeding circuit may cause se-
vere damage to the injection
system and irregular engine
operation. If warning light lights up
(on some versions with the message on
the display), go to a Fiat Dealership
as soon as possi bl e to hav e the
system bled. Water may have been intro-
duced in the tank if this appears imme-
diate ly afte r refu ellin g: in this case ,
stop the engine immediately and cont-
act a Fiat Dealership.
CAR PROTECTION
SYSTEM FAILURE -
FIAT CODE (amber)
Turning the key to MARthe warning light
shall flash only once and then go off.
If with the ignition key at MAR, the warn-
ing light stays on, this indicates a possible
failure (see “Fiat Code system” in section
“Dashboard and controls”).
IMPORTANT Warning lights and
will come on at the same time to indicate
a Fiat CODE system failure.
If with the engine running the warning light
flashes, this means that the car is not
protected by the engine inhibitor device
(see “Fiat Code system” in section “Dash-
board and controls”).
Contact Fiat Dealership to have all the
key stored.
CORRECT USE
OF THE CAR
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES
LINEA Owner HAND BOOK RHD.pdf 108LINEA Owner HAND BOOK RHD.pdf 1088/21/09 2:16:15 PM8/21/09 2:16:15 PM

If the oil level is near or even under the
MINline, add oil through the filler Ato
reach the MAXline.
Oil level shall never exceed the MAXline.ENGINE OIL CONSUMPTION
The maximum
engine oil consumption is
usually 400 grams every 1,000 km.
When the car is new, the engine needs
to run in, therefore the engine oil con-
sumption
can only be considered stabilised
after the first 5,000 - 6,000 km.
IMPORTANT
The oil consumption de-
pends on driving style and the conditions
under which the car is used.
IMPORTANT
After adding or changing
the oil, let the engine turn over for a few
seconds
and wait a few minutes after turn-
ing it off before you check the level. ENGINE OIL fig. 3-4
Check the oil level a few minutes (about
5) after the engine has stopped, with the
car parked on level ground.
The oil level shall be included between the
MINand MAXmarks on the dipstick B.
The range between the MINand MAX
levels corresponds to approximately
one litre of oil.
fig. 3 - 1 .4 version F0R0134mfig. 4 - 1 .3 Multijet versionF0R0135m
Proceed very carefully inside
the engine compartment
when the engine is hot: risk of burns.
Remember that the fan may start up
if the engine is hot: risk of injury.
Pay
attention to scarves, ties and other
loose fitting garments: they could get
dragged by the moving parts.
WARNING
146
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 146LINEA Owner HAND BOOK RHD.pdf 1468/21/09 2:16:34 PM8/21/09 2:16:34 PM

WHEELS AND TYRES
Check the pressure of each tyre, includ-
ing the spare, approximately once every
two weeks and before starting a long jour-
ney: this check must be performed with
the tyre rested and cold.
It is normal for pressure to increase when
the car is used. For the correct tyre in-
flation pressure, see “Wheels” in “Tech-
nical specifications” section.
Incorrect pressure causes abnormal tyre
wearfig. 9:
Anormal pressure: evenly worn tread.
Blow pressure: tread particularly worn
on the edges.
Cexcessive pressure: tread particularly
worn in the middle.
The tyres must be replaced when the
tread is less than 1.6 mm thick. In all cas-
es, follow the laws in force in the coun-
try where you are driving.
fig. 9F0R0141m
IMPORTANT NOTES
Avoid braking suddenly, burning starts
and violent knocks against the curb,
potholes or other obstacles if possible.
Long dista nces on rough roads may
damage the tyres;
check the tyres regularly for cuts on the
sides, swelling or irregular tread wear.
Go to a Fiat Dealership if required.
 do not over load your car : this may
cause serious damage to wheels and
tyres;
if a tyre is punctured, stop immediate-
ly and charge it to avoid damage to the
tyre, the rim, suspensions and steering
system;
a tyre will age even if it is not used
much. Cracks in the tread and on the
sidewalls are a sign of ageing. Have the
tyres checked by specialised personnel
if they have been fitted for longer than
6 years. Remember to check the spare
wheel very carefully;
In the case of replacement, always fit
new tyres, avoiding those of dubious
origin;
If a tyre is changed, also change the in-
flation valve;
to allow even wear between the front
and rear tyres, it is advisable to change
them over every 20 thousand kilome-
tres, keeping them on the same side of
the car so as not to reverse the dire-
ction of rotation.
Remember that the road
holding qualities of your car
also depends on the correct inflation
pressure of the tyres.
WARNING
152
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 152LINEA Owner HAND BOOK RHD.pdf 1528/21/09 2:16:35 PM8/21/09 2:16:35 PM

178
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
SAFETY
Speedometer ..................................... 14
Starting and driving ..........................
93
Starting the engine
- bump starting ...............................
113
- diesel engines ............................... 94
- emergency start-up .................... 112
- ignition switch .............................. 12
- jump starting ................................ 112
- petrol engines ..............................
93
- stopping the engine .................... 95
- warm up the engine after
just started ...................................
95
Steering .............................................. 164
Steering column lock .......................
12
Steering wheel ...................................
35
Sun visors ........................................... 63
Suspensions ....................................... 164
Symbols ............................................... 6
Tailgate .............................................. 67
Technical specifications ................... 159
Third brake light ...............................
125
Top speeds .........................................
99
Towing the car .................................. 135
Transmission ......................................
162Ty r e s
- replacing a wheel ........................ 113
- maintenance .................................
152
- reading tyre markings ................ 165
- standard tyres ..............................
167
- cold tyre inflation pressure ....... 168
Using the manual gearbox ............ 97
Warning lights and messages ...... 101
Weights .............................................. 171
Wheel .................................................
165
- replacing a wheel ........................ 113
- spare wheel .................................. 165
- wheel geometry .......................... 165
Wheel rims
- understanding rim marking .......
166
Windscreen washing ........................ 53
Window winders .............................. 65
Windscreen washer
- control ........................................... 53
- fluid level ....................................... 147
Windscreen wiper
- blades .............................................
153
- control ........................................... 53
- spray nozzles ................................
154
LINEA Owner HAND BOOK RHD.pdf 178LINEA Owner HAND BOOK RHD.pdf 1788/21/09 2:16:38 PM8/21/09 2:16:38 PM