key FIAT LINEA RHD 2010 1.G Owner's Guide

79
CORRECT USE
OF THE
CAR
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
IMPORTANT Make sure the backrest is
correctly fastened when returning it to the
position of normal use after folding it. S.B.R. SYSTEM
The car is fitted with the S.B.R. system
(Seat Belt Reminder), consisting of a
buzzer which,
together with the turning
on of warning light on the instrument
panel, warns the driver to fasten the seat
belt.
The buzzer can be deactivated (until the
next engine stop) as follows:
fasten the driver’s seat belt;
turn the ignition key to MAR;
wait for over 20 seconds and then re-
lease one of the seat belts.
For permanent deactivation, contact Fiat
Dealership.
With digital display, the S.B.R. system can
only be reset at Fiat Dealership.
Remember that in the event
of a violent collision, back
seat passengers not wearing seat belts
also represent a serious danger for
the front seat passengers.
WARNING
Make sure the backrest is
properly secured at both
sides to prevent it moves forward in
the event of sharp braking causing in-
juries to passengers.
WARNING


LINEA Owner HAND BOOK RHD.pdf 79LINEA Owner HAND BOOK RHD.pdf 798/21/09 2:16:11 PM8/21/09 2:16:11 PM

IMPORTANT The front air bags may be
deployed if the car is subject to heavy kno-
cks or accidents involving the underbody
area, such as for example violent shocks,
against steps, kerbs of low obstacles, fall-
ing of the car in big holes or sags in the
road.
IMPORTANT A small amount of dust will
be rele ase d when the airb ags are de-
ployed. The dust is not harmful and does
not indicate the beginning of a fire. Fur-
thermore, the surface of the deployed bag
and the interior of the car may be covered
in a dusty residue: this dust may irritate
the skin and the eyes. Wash with mild
soap and water in the event of exposure.
The expiration date of the explosive
charge and the clock wire are shown on a
specific label contained in the oddment
compartment. Go to a Fiat Dealership
to have the devices replaced when
the expiration date approaches.
IMPORTANT Should an accident occur in
which any of the safety devices is activat-
ed, take the car to a Fiat Dealership
to have the devices activated replaced
and to have the system checked.
All inspection, repair and replacement op-
erations concerning the air bags must on-
ly be carried out c/o Fiat Dealership.If you are having the car scrapped, have
the air bag system deactivated at a Fiat
Deal ers hi p firs t. If the car chang es
ownership, the new owner must be info-
rmed of the meth od of us e of ai r ba gs
and the above warnings and also be gi-
ven this “Owner’s Handbook”.
IMPORTANT Pretensioners, front airbags
are deployed according to different logics
on the basic of the type of collision. Non
depl oym ent of one of the de vi ces does
not therefore indicate a system fault.
Never rest head, arms and
elbows on the door, on the
windows area to prevent possible in-
juries during inflation phase.
WARNING
Never lean head, arms and
elbows out of window.
WARNING
GENERAL WARNINGS
If when turning the key to
MAR the warning light
does not turn on or if it stays on when
travelling (together with the message
on the multifunctional display, where
provided) there could be a failure in
safety systems; in this event air bags
or pretensioners could not trigger in
case of impact or, in a minor number
of cases, they could trigger acciden-
tally. Contact Fiat Dealership im-
mediately to have the system checked.
WARNING
Do not cover the backrest of
front and rear sea ts with
trims or covers that are not suitable
to be used with side bags.
WARNING
Never travel with objects on
your lap , in front of your
chest or with a pipe, pencil, etc. be-
tween your lips; injury may result in
the event of the air bag being trig -
gered.
WARNING
90
AND CONTROLS
DEVICES
CORRECT USE
OF THE
CAR
MESSAGES
EMERGENCY
MAINTENANCE
SPECIFICATIONS
INDEX
DASHBOARD
SAFETY
LIGHTS AND
CAR
IN AN
TECHNICAL
WARNING
LINEA Owner HAND BOOK RHD.pdf 90LINEA Owner HAND BOOK RHD.pdf 908/21/09 2:16:13 PM8/21/09 2:16:13 PM

Always drive holding your
hands on the steering wheel
rim so that the airbag can inflate
freely in the case of need. Do not dri-
ve with your body bent forward. Keep
your back straight against the back
rest.
WARNING
Airbags may be deployed if
another vehicle crashes if the
key is inserted and at MAR also if the
engine is not running and the car is
stationary. For this reason, children
must never sit on the front seat, even
if the car is not moving. On the oth-
er hand, if the key is inserted and at
STOP, none of the saf ety devi ces
(airbag or pretensioners) will be de-
ployed in a collision. Non deployment
of the devices in this case does not in-
dicate a system fault.
WARNING
Do not wash the seats with
press urised water or ste am
(by hand or in automatic seat wash-
ing stations).
WARNING
The airb ag deployment
threshold is higher than that
of the pretensioners. For collisions in
the range between the two thresh-
olds, it is normal for only the preten-
sioners to be activated.
WARNING
Do not hook rigid objects to
the coat hooks and to the
support handles.
WARNING
Airbags do not replace seat
belts but increase their effi-
cien cy. Fur the rmore , since front
airbags are not deployed in low speed
collisi ons, side collisi ons, rear-e nd
shunts or roll-overs, the occupants are
only protected by the seat belts which
must be fastened at all times.
WARNING
When the key is turn ed to
MAR warning light (with
passenger front airbag activate) will
blink for a few seconds to remind you
that the airbag will be deployed in the
event of a collision after which it
should go out.
WARNING
Have the airbag system
checked by a Fiat Dealership
if the car was sto len , if theft was
attempted, or if the car was subjec-
ted to vandalism or flooding.
WARNING
91
CORRECT USE
OF THE
CAR
WARNING
IN AN
CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
LIGHTS AND
EMERGENCY
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
MESSAGES
LINEA Owner HAND BOOK RHD.pdf 91LINEA Owner HAND BOOK RHD.pdf 918/21/09 2:16:13 PM8/21/09 2:16:13 PM

ENGINE STARTING
The car is provided with an electronic en-
gine lock device: refer to “The Fiat CODE
system” paragraph in “Dashboard and
controls” if you cannot start the engine.
The engine may be noisier during the first
seconds of operation, particularly after a
long period of inactivity. This is charac-
teristic of hydraulic tappets, the timing sys-
tem chosen to reduce the number of ser-
vicing interventions and does effects nei-
ther functionality nor reliability.
It is advisable not to demand
maximum performance from
your car (e.g. excessive accel-
erations, long distances at top
rpm, excessive intense braking, etc.) as
soon as the engine is started.
Do not leave the key in the ig-
nition switch with the engine
off to avoid unnecessary con-
sumption of electricity which
could drain the battery. It is dangerous
to run the engin e in clo sed environ-
ments.
Running the engine in con-
fined areas is extremely dan-
gerous. The engine consumes oxygen
and produces carbo n monoxide
which is a highly toxic and lethal gas.
WARNING
Remember that the brake
booster and power steering
are not operational until the engine
has been started, therefore much ef-
for t than usual is required on the
brake pedal and steering wheel.
WARNING
STARTING PROCEDURE FOR
PETROL VERSIONS
Proceed as follows:
ensure that the handbrake is up;
put the gear lever into neutral;
press the clutch pedal down to the
floor without touching the accelerator;
turn the ignition key to AV Vand let
it go the moment the engine starts.
If the engine does not start at the first at-
tempt,
return the ignition key to STOP
before repeating starting.




93
CORRECT USE
OF THE CAR
WARNING
IN AN
CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
LIGHTS AND
EMERGENCY
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
MESSAGES
LINEA Owner HAND BOOK RHD.pdf 93LINEA Owner HAND BOOK RHD.pdf 938/21/09 2:16:13 PM8/21/09 2:16:13 PM

If, when the ignition key is at MAR, the in-
strument panel warning light remains
lit together with warning light turn the
key to STOPand then back to MAR; r e -
main on, try with the other keys provid-
ed with the car.
IMPORTANT if on the instrument
panel remains on and steady,
go to a Fiat
Dealership immediately.
IMPORTANT
Never leave the ignition key
to MARwhen the engine is off.STARTING PROCEDURE FOR
DIESEL VERSIONS
Proceed as follows:
ensure that the handbrake is up;
put the gear lever into neutral;
turn the ignition key to MAR; instru-
ment panel warning lights and
will light up;
wait for the warning light e to
turn off. The hotter the engine is, the
quicker this will happen;
press the clutch pedal down to the
floor without touching the accelerator;
turn the ignition key to AV Vas soon
as warning light goes out. Waiting
too long will waste the work done by
the glow plugs. Release the key as soon
as the engine starts.If the engine does not start at the first at-
tempt, return the ignition key to STOP
before repeating starting.
If, when the ignition key is at MAR, the
instrument panel warning light re-
mains lit together with warning light
turn the key to STOPand then back to
MAR; if the warning lights remain on, try
with the other keys provided with the car.
IMPORTANT If the instrument panel
warning light
stays on glowing
steadily, contact immediately Fiat
Dealership.
IMPORTANT Never leave the ignition key
to MARwhen the engine is off.
Warning light will blink
for 60 seconds after starting
or during prolonged cranking
to indicate a fault to the glow
plug heating system.
Use the car nor-
mally if the engine starts and go to a
Fiat Dealership as soon as possible.
  
 

94
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
EMERGENCY
MAINTENANCE
SPECIFICATIONS
INDEX
MESSAGES
DASHBOARD
SAFETY
LIGHTS AND
IN AN
CAR
TECHNICAL
WARNING
LINEA Owner HAND BOOK RHD.pdf 94LINEA Owner HAND BOOK RHD.pdf 948/21/09 2:16:13 PM8/21/09 2:16:13 PM

HANDBRAKE fig. 1
The handbrake lever is located between
the two front seats.
Pull the lever upwards to operate the
handbrake. Four or five notches are nor-
mally sufficient to lock the car on flat ter-
rain, while nine or ten may be necessary
on a steep slope with the car loaded.
IMPORTANT If this is not the case, con-
tact Fiat Dealership to have the hand-
brake adjusted.
When the handbrake lever is pulled up
and the ignition key is atMAR, the in-
strument panel warning light will turn
on.
PARKING THE CAR
Proceed as follows:
stop the engine and engage the hand-
brake;
engage a gear (on a slope, engage first
gear if the car is faced uphill or reverse
if it is faced downhill) and leave the
wheels steered.
If the car is parked on a steep slope, it is
further advisable to block the wheels with
a wedge or stone. Do not leave the key in
the ignition switch to prevent draining the
battery. Always remove the key when you
leave the car.
Never leave children unat-
tended in the car. Always re-
move the ignition key when leaving
the car and take it out with you.
WARNING
fig. 1F0R0103m
Proceed as followed to release the hand-
brake:

slightly lift the handbrake and press re-
lease button A;
hold button Apressed and lower the
lever. Warning light on the instru-
ment panel will go out.
Press the brake pedal when carrying out
this operation to prevent the car from
moving accidentally.


96
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
EMERGENCY
MAINTENANCE
SPECIFICATIONS
INDEX
MESSAGES
DASHBOARD
SAFETY
LIGHTS AND
IN AN
CAR
TECHNICAL
WARNING
LINEA Owner HAND BOOK RHD.pdf 96LINEA Owner HAND BOOK RHD.pdf 968/21/09 2:16:14 PM8/21/09 2:16:14 PM

WARNING LIGHTS
AND MESSAGES
GENERAL WARNINGS
Lighting of a warning light is associated to
a specific message and/or buzzer when ap-
plicable. These indications are brief and
precautionary and as such must not be
considered as exhaustive and/or alterna-
tive to the information contained in
the
Owner’s Handbook, which you are rec-
ommended to read carefully in all
cases.
Refer to the information in this chap-
ter in the event of a failure indication.
IMPORTANT Failure indications
on the
display fall into either of two categories:
seriousfaults and less seriousfaults.
Very seriousfailures are indicated by a
repeated and prolonged warning
“cycle”.
Less seriousfailures are indicated by a lim-
ited warning “cycle”.
Press MENU ESCto stop the warning
cycle in both cases. The warning light on
the instrument panel will stay on until the
cause of the fault is eliminated.LOW BRAKE FLUID
LEVEL (red)
HANDBRAKE ON (red)
Turning the ignition key to MARthe
warning light turns on, but it should go off
after few seconds.
Low brake fluid level
The warning light turns on when the lev-
el of the brake fluid in the reservoir falls
below the minim um level, due to possi-
ble leak in the circuit.
On certain versions the dedicated message
is displayed.
If the warning light turns
on when travelling (on cer-
tain versions together with the mes-
sage on the display) stop the car im-
mediately and contact Fiat Dealer-
ship.
WARNING
Handbrake on
The warning light turns on when the hand-
brake is on.
IMPORTANT If the warning light turns on
when travelling, check that the handbrake
is not engaged.
102
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
EMERGENCY
MAINTENANCE
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
SAFETY
CAR
IN AN
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 102LINEA Owner HAND BOOK RHD.pdf 1028/21/09 2:16:15 PM8/21/09 2:16:15 PM

103
AIR BAG FAILURE
(red)
Turn ing the ignit ion key to
MARthe warning ligh t turns on, but it
should go off after few seconds.
The warning light stays on steady if there
is a failure in the airbag system.
On certain versions the dedicated message
is displayed.
If when turning the key to
MAR the warning light
does not turn on or if it stays on when
travelling (together with the message
on the multifunctional display, where
provided) there could be a failure in
safety systems; in this event air bags
or pretensioners may not be deployed
in case of impact or, in a minor num-
ber of cases, they be deployed acci-
dentally. Contact Fiat Dealership
immediately to have the system checked.
WARNING
Failure of warning light
(warning light off) is indicat-
ed by warning light which will
blink for longer than the normal 4
seconds indicating that the front pas-
senger airbag is off.
WARNING
HOT ENGINE
COOLANT (red)
Turn ing the igni tion key to
MARthe warning light turns on, but it
should go off after few seconds.
The warning light turns on when the en-
gine is overheated.
If the warning light comes on, proceed as
follows:
during normal travel: s t o p t h e c a r,
stop the engine and check that the wa-
ter level in the vessel is not under the
MINline. In this case, wait for a few
minutes for the engine to cool down
when slowly and carefully open the
cap, top-u p with coolant and check
that the level is between the MINand
MAXreferences on the vessel itself.
Also check for leakages. Go to a Fiat
Dealership if the warning should
come on when the engine is started
again.CORRECT USE
OF THE CAR
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES WARNING
LIGHTS AND
MESSAGES
IN AN
LINEA Owner HAND BOOK RHD.pdf 103LINEA Owner HAND BOOK RHD.pdf 1038/21/09 2:16:15 PM8/21/09 2:16:15 PM

LOW ENGINE OIL
PRESSURE (red)
Turning the ignition key to
MARthe warning light turns on, but it
should go out as soon as the engine is
started.
On certain versions the dedicated message
is displayed.
If the warning light
turns on when the car is trav-
elling (on cer tain versions together
with the message on the display) stop
the engine immediately and contact
a Fiat Dealership.
WARNING
In the case of demanding use (e.g.
towing traile rs uphill or car at full
load): slow down and stop the car if
the warning light stays on. Stand for
2 or 3 minutes with the engine running
and slightly accelerated to promote a
better circulation of coolant.
Then
stop the engine. Check correct liquid
level as described above.
IMPORTANT Under severe use of the
car, keep the engine on and slightly accel-
erated for few minutes before switching it
off.
On certain versions the dedicated message
is displayed.LOW BATTERY
CHARGE (red)
Turning the igni tion key to
MARthe warning light turns on, but it
should go out as soon as the engine is
started (with the engine running at idle
speed a brief delay in going out is allowed).
Go to a Fiat Dealership immediately
if the warning light stays on either ste-
ady or blinking.
CORRECT USE
OF THE CAR
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES
104
LINEA Owner HAND BOOK RHD.pdf 104LINEA Owner HAND BOOK RHD.pdf 1048/21/09 2:16:15 PM8/21/09 2:16:15 PM

106
Go to a Fiat Dealership
as soon as possible if warning
light either does not light
up when the key is turned to
MAR to if while travelling the warning
lights comes on either steady or blink-
ing (along with a message on the dis-
play).
If the light flashes, release the accelerator
pedal to lower the speed of the engine un-
til the warning light stops flashing; contin-
ue the journey at moderate speed, trying
to avoid driving conditions that may cause
further flashing and contact Fiat
Dealership as soon as possible. EOBD ENGINE CONTROL
SYSTEM FAILURE
Under normal conditions, turning the ig-
nition key to MAR, the warning light turns
on
but it should go off after engine starting.
This indicates that the warning light is
working correctly. If the warning light
ei-
ther stays on or comes on while travelling:
steady light: a fault in the supply/ignition
system which could cause high emis-
sions at the exhaust, possible lack of
performance, poor handling and high
consumption levels.
On certain versions the dedicated mes-
sage is displayed.
In these conditions, you may continue
travelling at moderate speed without de-
manding excessive effort from the engine.
Prolonged use of the car with the warn-
ing light on may cause damage.
Go to a
Fiat Dealership as soon as possible.
if warning light will go out after the
fault goes away but it will be stored in the
system.
blinking: indicates the possibility of
damage to the catalyser (see “EOBD
system” in section “Dashboard
and
controls”). INJECTION SYSTEM
FA I L U R E
(Multijet versions -
amber)
EOBD SYSTEM
FAILURE (petrol
versions - amber)
Injection system failure
Under normal conditions, turning the
ig-
nition key to MAR, the warning light turns
on but it should go off after engine start-
ing.
If the warning light stays on or turns
on
when travelling, means a fault in the sup-
ply/ignition system which could cause high
emissions at the exhaust, possible lack of
performance, poor handling and high
con-
sumption levels.
On certain versions the dedicated message
is displayed.
In these conditions, you may continue
travelling at moderate speed without
de-
manding excessive effort from the engine.
Go to a Fiat Dealersh ip as so on as
possible.
CORRECT USE
OF THE CAR
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES
LINEA Owner HAND BOOK RHD.pdf 106LINEA Owner HAND BOOK RHD.pdf 1068/21/09 2:16:15 PM8/21/09 2:16:15 PM