engine FIAT LINEA RHD 2010 1.G Service Manual

GENERIC FAILURE
INDICATION
(amber)
The warning light turns on in the follow-
ing circumstances.
Engine oil pressure sensor failure
The warning light turns on when failure is
detected in Engine oil pressure sensor Go
to a Fiat Dealership to have the fault
fixed as soon as possible.
External light fault
(where provided)
See description of warning light .
Fuel cut-off switch tripped
The warning light comes on when the fu-
el cut-off switch trips.
The display will show the dedicated mes-
sage.EXTERNAL LIGHT
FAILURE (amber)
The warning light will come on
(some versions only) when a fault
to one of the following lights is detected:
– side/taillights
– brake lights
– rear fog lights
– direction indicators
– number plate lights.
The fault may be caused by: one or more
burnt lamps, a blow protection fuse or in-
terruption of the electrical connection.
On certain versions warning light
comes on instead.
On certain versions the dedicated message
is displayed.
REAR FOG LIGHTS
(amber)
The warning light comes on
when the rear fog lights are turned on.
Speed limit exceeded
(where provided)
The display will show the dedicated mes-
sage when the car exceeds the set speed
limit (see “Multifunctional Display” in sec-
tion “Dashboard and controls”).
Diesel filter failure
(where provided)
The warning light will come on when a
diesel filter system failure is detected. The
display will show the dedicated message
(where provided).
109
CORRECT USE
OF THE CAR
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES WARNING
LIGHTS AND
MESSAGES
IN AN
LINEA Owner HAND BOOK RHD.pdf 109LINEA Owner HAND BOOK RHD.pdf 1098/21/09 2:16:16 PM8/21/09 2:16:16 PM

111
STARTING THE ENGINE ................................................... 112
REPLACING A WHEEL ...................................................... 113
WHEN NEEDING TO CHANGE A BULB ..................... 119
IF AN EXTERIOR LIGHT BURNS OUT .......................... 121
IF AN INTERIOR LIGHT BURNS OUT .......................... 126
IF A FUSE BLOWS ................................................................ 128
IF THE BATTERY IS FLAT.................................................. 135
LIFTING THE CAR ............................................................... 135
TOWING THE CAR ........................................................... 135
II I
N N
A A
N N
E E
M M
E E
R R
G G
E E
N N
C C
Y Y
CORRECT USE
OF THE CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
LINEA Owner HAND BOOK RHD.pdf 111LINEA Owner HAND BOOK RHD.pdf 1118/21/09 2:16:16 PM8/21/09 2:16:16 PM

112
STARTING THE
ENGINE
EMERGENCY START-UP
Go to a Fiat Dealership immediately
if instrument panel warning light
comes
on steady.
JUMP STARTING fig. 1
If the battery is flat, the engine may be
started using an auxiliary battery with the
same capacity or a little
higher than the
flat one. Proceed as follows to start the engine:
connect positive terminals (+near the
terminal) of the two batteries with a
jump lead;
with a second lead, connect the nega-
tive terminal (–) of the auxiliary battery
to an earthing point on the engine or
the gearbox of the car to be
started;
start the engine;
when the engine has been started, re-
move the leads reversing the order
above.
If after a few attempts the engine does not
start, do not insist but contact the
near-
est Fiat Dealership.
This procedure must be per-
formed by expert personnel
because incorrect actions may cause
electrical
discharge of considerable in-
tensity. Furthermore, battery fluid is
poisonous
and corrosive: avoid contact
with your skin and eyes. Keep naked
flames away from the battery.
No
smoking. Do not cause sparks.
WARNING
fig. 1
CORRECT USE
OF THE CAR
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
F0R0242m
LINEA Owner HAND BOOK RHD.pdf 112LINEA Owner HAND BOOK RHD.pdf 1128/21/09 2:16:16 PM8/21/09 2:16:16 PM

113
IMPORTANT Never connect the negative
terminals of the two batteries directly:
sparks could ignite explosive gas released
from the battery. If the auxiliary battery is
installed on another car, prevent
acciden-
tal contact between metallic parts of the
two cars.JUMP STARTING
Never jump start the engine by pushing,
towing or driving downhill.
This could
cause a flow of fuel into the catalytic con-
verter and damage it beyond repair.
IMPORTANT Remember that the brake
booster and the power steering system
are not operating until
the engine is start-
ed, a greater effort will therefore be re-
quired to press the brake pedal or turn
the steering wheel.
REPLACING A WHEEL
GENERAL INSTRUCTIONS
Wheel changing and correct use of the
jack and spare wheel call for some pre-
cautions as listed below.
Indicate that the car is sta-
tionary according to the laws
in force: hazard lights, triangle, etc.
Passengers should leave the car, par-
ticularly if it is very loaded and
wait
for the wheel to be changed away
from on-coming traffic . Apply the
handbrake.
WARNING
CORRECT USE
OF THE CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
LINEA Owner HAND BOOK RHD.pdf 113LINEA Owner HAND BOOK RHD.pdf 1138/21/09 2:16:16 PM8/21/09 2:16:16 PM

115
To change a wheel proceed as
follows:
stop the car in a position so that it is
not a danger for on-coming traffic and
where you can replace the wheel safe-
ly. The ground must be flat and com-
pact;
stop the engine off and pull up the hand-
brake;
engage first gear or reverse;
wear the reflecting safety jacket (com-
pulsory by law in certain countries) be-
fore getting out of the car;
open the tailgate and lift the mat;
loosen the fastener A;

take out the tool box Cand take it near
to the wheel to be changed;

take the spare wheel B;
fig. 2F0R0107m
CORRECT USE
OF THE CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
LINEA Owner HAND BOOK RHD.pdf 115LINEA Owner HAND BOOK RHD.pdf 1158/21/09 2:16:16 PM8/21/09 2:16:16 PM

FUSE LOCATION
The fuses are grouped in three units
on
the dashboard, in the engine compartment
and on the positive battery terminal.
Fuse box on the dashboard
To gain access to the fuses in the fuse box
on the dashboard,
remove the cover A
fig. 28.
fig. 29F0R0126m
F34 F48 F49 F35 F13
F46 F33 F37 F42 F12
F45 F47 F32 F50 F51
F52 F41 F43 F40 F44
F36 F39 F38 F53 F31
fig. 28F0R0125m
129
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 129LINEA Owner HAND BOOK RHD.pdf 1298/21/09 2:16:20 PM8/21/09 2:16:20 PM

Fuse box in engine compartment
To gain access to the fuses in the fuse box
next to the battery,
remove the protec-
tion cover fig. 30.
fig. 30F0R0127m
fig. 31F0R0128m
130
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
MAINTENANCE
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
DASHBOARD
SAFETY
CAR
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 130LINEA Owner HAND BOOK RHD.pdf 1308/21/09 2:16:21 PM8/21/09 2:16:21 PM

7.5
7.5
7.5
15
20
20
7.5
7.5
7.5
20
10
30
7.5
20 F12
F13
F31
F32
F33
F34
F35
F36
F37
F38
F39
F40
F42
F43
FUSE TABLE
Fuse box on dashboard
LOADS FUSE AMPERES
Right dipped beam headlight
Left dipped beam headlight, headlight corrector
INT/A for relay coils (T08, T17) in engine compartment fuse box and body
computer node
Subwoofer
Power windows control unit (left rear window motor)
Power windows control unit (right rear window motor)
+15 reversing lights, brake lights control, air mass meter, glow plug pre-heating
unit, water in diesel fuel sensor, tachometer generator, level sensor 2
Power window unit (+30 for electronics)
+15 instrument panel, NA brake lights control
Body computer node
Radio node
Heated rear window
+15 brake system node
Windscreen wiper control (two-way pump)
131
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 131LINEA Owner HAND BOOK RHD.pdf 1318/21/09 2:16:21 PM8/21/09 2:16:21 PM

20 70
30
40
20/30
20/30/40
30
15
10
7.5
7.5
15 7.5
10
7.5 F03 F01
F04
F05
F06
F07
F08
F10
F11
F14
F15
F17 F16
F18
F19
Fuse box in engine compartment
LOADS FUSE AMPERES
Ignition switch Dashboard CPL1
Brake valves
Brake pump
Engine cooling fan (low speed)
Engine cooling fan (high speed)
Climate control fan
Horn
Engine control system secondary loads
Right main beam headlight
Left beam headlight
Engine control system primary loads EOBD
Engine control unit
Conditioner compressor
133
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 133LINEA Owner HAND BOOK RHD.pdf 1338/21/09 2:16:21 PM8/21/09 2:16:21 PM

15
15/20
20
–
50
15 F21
F22
F23
F24
F00
F30
LOADSFUSE AMPERES
Fuel pump
Engine control system primary loads (injectors, ignition coils)
Windscreen wiper motor
Spare
Glow plug pre-heating unit
Fog lights
134
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
MAINTENANCE
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
DASHBOARD
SAFETY
CAR
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 134LINEA Owner HAND BOOK RHD.pdf 1348/21/09 2:16:21 PM8/21/09 2:16:21 PM