Control FIAT PANDA 2007 169 / 2.G Owners Manual

DIMENSIONS
Dimensions are expressed in mm and re-
fer to the car fitted with standard tyres.
The height refers to the car unladen.
187
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
F0G0703m
fig. 6
Versions A B C D E F G H
Saloon 3538 713 2299 526 1578 (**) 1357 (*) 1578 1366 (*)
(*) Track measurements may vary according to rim size.
(**) Without longitudinal bars mm. 1540
177-196 Panda New GB 21-06-2007 13:53 Pagina 187

188
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
BOOT VOLUME
Unladen boot volume (V.D.A. Standards) in dm
3
Single and double Rear slidingrear seat seat
Under rear parcel shelf with rear seat
in normal position
At waist edge with rear seat back rest folded
Max. to roof with rear seat back rest folded
Max. to roof with rear seat back rest folded
(with sunroof)
(*) With seat completely backward
(**) With seat completely forward206
490
860
815176 (*) / 235 (**)
416
786
741
PERFORMANCE
Top admitted speed after initial car use in km/h.
1.1
Actual
Active
1.2
Dynamic
Emotion
1.3 Multijet 70CV
Dynamic
Emotion
1.3 Multijet 75CV
Dynamic
Emotion150
150
155
155
160
160
165
165
177-196 Panda New GB 21-06-2007 13:53 Pagina 188

189
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
1.3 Multijet
935
445
750
660
1380
900
400
50
60 1.2
860
445
730
660
1305
800
400
50
60 1.1
840
415
730
640
1255
800
350
50
60
WEIGHTS
Weights (kg)
Weight empty (including fluids,
90% fuel in the tank and no optional)
Payload (*) including the driver:
Maximum admitted loads (**)
– front axle:
– rear axle:
– total:
Towable loads
– trailer with brakes:
– trailer without brakes:
Maximum load on roof (***):
Maximum load on tow hitch
(trailer with brakes):
(*) If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases, thus reducing the specified payload.
(**) Loads not be exceeded. The driver is responsible for arranging the loads in the boot and/or on the roof so that they
comply with these limits.
(***) Lineaccessori Fiat roof rack, max capacity: 50 kg.
177-196 Panda New GB 21-06-2007 13:53 Pagina 189

190
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
1.3 Multijet
35 (▲)
5 (▲)
4.6
2.5 (●)
2.8 (●)
1.65
0.55
0.40
1.8 1.2
35
5
4.6
2.5
2.8
1.65
0.55
0.40
1.8 1.1
35
5
4.6
3.1
3.5
1.65
0.55
0.40
1.8
CAPACITIES
Fuel tank: litres
including a reserve of: litres
Engine cooling system:
litres
Engine sump: litres
Engine sump and filter: litres
Gearbox/differential casing:
litres
Hydraulic brake circuit:
- with ABS kg
- without ABS kg
Windscreen and rear window
washer fluid reservoir: litres
(❑) For particularly hard climate conditions, we recommend use of a 60% Paraflu UP and 40% demineralized water mixture.
Specified fuels and
recommended products
Unleaded petrol with no less
than 95 R.O.N.
(▲) Diesel fuel for motor vehi-
cles (Specification EN590)
Mixture of distilled water and
PARAFLU UPat 50%
(❑)
SELENIA 20K
(●) SELENIA WR
TUTELA CAR ZC 75 SYNTH
TUTELA TOP 4
Mixture of water and
TUTELA PROFESSIONAL
SC 35
177-196 Panda New GB 21-06-2007 13:53 Pagina 190

191
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
FLUIDS AND LUBRICANTS
RECOMMENDED PRODUCTS AND THEIR SPECIFICATIONS
Use Fluid and lubricant specifications Original fluids and Change
for correct car operation lubricants
Oils for
petrol engines
Oils for
diesel engines
(1.3 Multijet
versions)
For regular operation of Multijet versions with DPF, use only original oil. In an emergency (lacking the original product) only top up
with max. 0,5 l and then drive immediately to the nearest Fiat Dealership.
If using non original SAE 5W-40 products, oils with minimum ACEA A3 specifications for petrol engines and ACEA B4 specifica-
tions for Diesel engines are admitted; in this event top engine performance is not guaranteed.
Use of products with low-quality properties than ACEA A3 and ACEA B4 could cause damages to the engine that are not covered
by the warranty.
For very cold climate conditions, ask Fiat Dealership for the appropriateSeleniaproduct to use. Synthetic-based oils, grade
SAE 10W-40, that pass ACEA A3 and API SL
specifications.
Synthetic-based oils, grade
SAE 5W- 40, that pass
ACEA B4, API CF and FIAT 9.55535- M2
specifications. SELENIA 20K
SELENIA WRAccording to
Service Schedule
According to
Service Schedule
177-196 Panda New GB 21-06-2007 13:53 Pagina 191

192
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
Synthetic oil SAE 75W- 80 EP, that passes
API GL5, MIL - L - 2105 D LEV specifications.
Molibdenum organic disulphide, lithium soap based
grease. N.L.G.I. 2 consistency
Lithium soap based grease.
N.L.G.I.O. consistency
Synthetic fluid FMVSS no. 116 DOT 4, ISO 4925
SAE J1704, CUNA NC 956- 01
Red protective with antifreeze action, based on in-
hibited monoethylen glycol with organic formula
based on O.A.T,
That passes CUNA NC 956-16, ASTM D 3306
specifications
Mixture of alcohol, water and surfactants CUNA
NC 956-II
Additive for diesel fuels with protective action for
Diesel enginesTUTELA CAR ZC
75 SYNTH
TUTELA
STAR 500
TUTELA MRM
ZERO
TUTELA TOP 4
PARAFLU UP (*)
TUTELA
PROFESSIONAL
SC 35
DIESEL MIX
Use Fluid and lubricant specifications Recommended fluids Applicationsfor correct car operation and lubricants
Lubricants and greases
for transmission
Brake fluids
Protective agent
for radiators
Windscreen/
rear window
washer fluid
Diesel fuel
additive
(*) IMPORTANT Do not top up or mix with fluids having characteristics different from those specified.
(❑) For particularly hard climate conditions, we recommend use of a 60% Paraflu UP and 40% demineralized water mixture.
Mechanical gearbox
and differential
CV joints
on wheel side
CV joints
on differential side
Brake and clutch hy-
draulic controls
Radiator antifreeze
proportion: 50% dis-
tilled water and 50%
PARAFLU UP
(❑)
To be used diluted or
undiluted in wind-
screen/rear window
washer/wiper sys-
tems
To be mixed with the
fuel oil (25 cc per 10
litres)
177-196 Panda New GB 21-06-2007 13:53 Pagina 192

❒extra-urban cycle: frequent accelerat-
ing in all gears, simulating extraurban
use of the car: speed varies between 0
and 120 km/h;
❒combined consumption: is calculated
weighing about 37% of urban cycle con-
sumption and about 63% of extraurban
consumption.
FUEL CONSUMPTION
The fuel consumption figures given in the
table below are determined on the basis
of the homologation tests set down by
specific European Directives.
The procedures below are followed for
measuring consumption:
❒urban cycle: cold starting followed by
driving that simulates urban use of the
car;
193
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IMPORTANT The type of route, traffic
situations, weather conditions, driving
style, general conditions of the car, trim
level/equipment/accessories, load, climate
control system, roof rack, other situations
that affect air drag may lead to different
fuel consumption levels than those mea-
sured.
Fuel consumption according to 1999/100/EC Directive (litres x 100 km)
Versions Urban Extra-urban Combined
1.1
Actual - Active 7.2 4.8 5.7
1.2
Dynamic - Emotion 7.1 4.8 5.6
(*) Ecopack 7.0 4.6 5.5
1.3 Multijet 70HP
Dynamic - Emotion 5.4 3.7 4.3
1.3 Multijet 75HP
Dynamic - Emotion 5.3 3.7 4.3
(*) Extended ratios to reduce CO
2emissions
177-196 Panda New GB 21-06-2007 13:53 Pagina 193

194
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
CO2EMISSIONS
The CO2emission levels at the exhaust given in the following tables refer to combined consumption.
Versions CO
2emissions
according to 1999/100/CE Directive (g/km)
1.1
Actual - Active 135
1.2
Dynamic - Emotion 133
(*) Ecopack129
1.3 Multijet 70HP
Dynamic - Emotion 114
1.3 Multijet 75HP
Dynamic - Emotion 113
(*) Extended ratios to reduce CO
2emissions
177-196 Panda New GB 21-06-2007 13:53 Pagina 194

195
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
CZ
SK
RADIO FREQUENCY REMOTE CONTROL
Conformity certifications to EC and national requirements
EC and Countries applying these Directives
Czech Republic
Slovak Republic
Poland CLBT/C/120/2003 – CLBT/C/121/2003
South Africa TA-2003/050 – TA-2003/049
177-196 Panda New GB 21-06-2007 13:53 Pagina 195

Bonnet .................................................. 63
Boot ........................................................ 60
– extension......................................... 62
– opening/closing .........................60-61
– removing the rear parcel shelf .. 62
Boot light .............................................. 51
– bulb replacement........................... 145
Brakes..................................................... 183
– fluid level ........................................ 165
– technical data ................................ 183
Bulb (replacement) ............................. 136
– general instructions ..................... 136
– types of bulbs ................................ 137
Capacities ............................................ 190
Car inactivity ....................................... 112
Car maintenance ................................. 155
– additional checks .......................... 159
– Annual Inspection Schedule ....... 159
– climate control system ............ 43-47
– scheduled service ......................... 156
– Service Schedule ........................... 157
Carrying children safely ..................... 87
Ceiling lights ......................................... 50
– boot light ........................................ 51
– front ................................................ 50
Central door locking system ............ 57Chassis (marking) ............................... 179
Child lock.............................................. 58
Child restraint systems
– "Isofix type" .................................. 91
– Passenger’s seat compliance ..... 89
Cigar lighter.......................................... 53
Clutch..................................................... 182
CO
2emissions ..................................... 194
Code Card ........................................... 8
Consumption ....................................... 193
– engine oil ........................................ 163
– fuel ................................................... 293
Containing running costs .................. 106
Controls................................................ 52
Control buttons .................................. 52
Correct use of the car ...................... 101
Dashboard........................................... 5
Demisting the windows...........40-42-46
Digital clock ..............................18-20-25
Digital display ....................................... 18
Dimensions .......................................... 187
Dipped beam headlights .................... 48
– bulb replacement........................... 140
– control ............................................ 48
Direction indicators ........................... 48
– control ............................................ 48
ABS ...................................................... 67
Accessories purchased
by the owner .................................... 77
Air bag .................................................. 93
– front air bag driver’s side ........... 94
– front air bag passenger’s side ..... 95
– Side bags and
Window bags.................................. 96
Air filter ................................................ 166
Air recirculation .......................39-41-45
Air vents ............................................... 38
Ashtray................................................... 53
At the filling station ............................ 190
Automatic climate control system .. 44
Battery.................................................. 168
– checking the charge ..................... 168
– important notes ............................ 160
– jump starting .................................. 125
– recharging ...................................... 152
– replacing ......................................... 168
– useful advice.................................... 169
Bodywork.............................................. 173
– maintenance .................................. 174
– protection....................................... 173
– version codes ................................ 180
– warranty ......................................... 174
197
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
II I
N N
D D
E E
X X
197-204 Panda New GB 21-06-2007 13:54 Pagina 197