fuel type FIAT PUNTO EVO 2009 1.G Owners Manual

INSTRUMENTS
Instrument background colour and type may vary ac-
cording to the version.
SPEEDOMETER fig. 14
This shows the speed of the vehicle.
REV COUNTER fig. 15
The rev counter shows the number of engine revolutions
per minute.
IMPORTANT The electronic injection control system
gradually shuts off the flow of fuel when the engine is over-
revving, resulting in a gradual loss of engine power.
When the engine is idling, the rev counter may indicate a
gradual or sudden increase of the rate.
This is normal and does not indicate a fault. It may becaused, for example, by the operation of the climate con-
trol system or fan. In these cases, a slow change in revs is
used to protect the battery charge.
FUEL GAUGE fig. 16
This shows the amount of fuel left in the tank.
E tank empty.
F tank full.
The reserve warning light A comes on to indicate that
approximately 7 litres of fuel are left in the tank.
Do not travel with the fuel tank almost empty: the gaps
in fuel delivery could damage the catalyst.
See the description in the “Refuelling” paragraph.
IMPORTANT The needle will point to E and warning light
A will blink to indicate a fault in the system. If this is the
case, go to a Fiat Dealership to have the system checked.
fig. 15F0U0015mfig. 14F0U0014m
CONTENTS TECHNICAL
SPECIFICATIONS SERVICING
AND CARE IN AN
EMERGENCY WARNING LIGHTS
AND MESSAGES STARTING
AND DRIVING SAFETY
KNOWING
YOUR
VEHICLE
15
001-036 PUNTO FL EN 3ed 10-12-2009 15:54 Pagina 15

Fiat Auto S.p.A. authorises the installation of transceiving
devices provided that they are installed by a specialised
centre according to rules of good engineering practice in
compliance with the manufacturer’s instructions.
IMPORTANT Traffic police may not allow the car on the
road if devices have been installed which modify the features
of the car. This may also cause invalidation of warranty in
relation to faults caused by the change or either directly
or indirectly related to it.
Fiat Auto S.p.A. shall not be liable for damage caused by
the installation of accessories either not supplied or rec-
ommended by Fiat Auto S.p.A. and/or not installed in com-
pliance with the provided instructions.
RADIOTRANSMITTERS AND MOBILE
PHONES
Radio transmitter equipment (vehicle mobile phones, CB
radios, amateur radio etc.) shall not be used inside the
car unless a separate aerial is mounted on the roof.
IMPORTANT The use of these devices inside the pas-
senger compartment (without a separate aerial) may cause
the vehicle electrical systems to malfunction. This could
compromise safety in addition to constituting a potential
hazard for passengers’ health.
In addition, transmission and reception of these devices
may be affected by the shielding effect of the car body.
As far as the use of EC-approved mobile phones is con-
cerned (GSM, GPRS, UMTS), follow the instructions for
use provided by the mobile phone manufacturer.
125
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
REFUELLING THE CAR
PETROL ENGINES
Use only unleaded petrol.
To avoid mistakes, the diameter of the fuel tank opening is
too small to insert the nozzle of a leaded petrol pump. The
petrol octane rating (RON) must not be lower than 95.
IMPORTANT An inefficient catalytic converter leads to
harmful exhaust emissions, thus contributing to air pol-
lution.
IMPORTANT Never use leaded petrol, even in small
amounts or in an emergency, as this would damage the
catalytic converter beyond repair.
DIESEL ENGINES
If the outside temperature is very low, the diesel thick-
ens due to the formation of paraffin clots and could clog
the diesel filter. In order to avoid these problems, differ-
ent types of diesel are distributed according to the season:
summer type, winter type and arctic type (cold, moun-
tainous areas).
If refuelling with diesel fuel whose specifications are not
suitable for the usage temperature, it is advisable to mix
TUTELA DIESEL ART additive in the proportions shown
on the container with the fuel. Pour the additive into the
tank before the fuel.
082-128 PUNTO FL EN 3ed 9-12-2009 13:43 Pagina 125

126F0U0111mfig. 128
FUEL TANK CAP fig. 128
To carry out refuelling, open lid A and unscrew cap B;
the cap is fitted with a device C which fastens it to the lid
so it cannot be mislaid.
In some versions, cap B have a lock and key: open lid A,
insert the ignition key then turn it anti-clockwise and un-
screw the cap itself.
The hermetic seal may cause a slight increase in pressure
in the tank. A suction noise when you release the cap is
therefore entirely normal.
When refuelling, attach the cap to the device inside the
flap as shown in fig. 128.KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
When using or parking the vehicle for a long time in the
mountains or cold areas, it is advisable to refuel using lo-
cally available diesel.
In this case, it is also advisable to keep the tank over
50% full.
For diesel engines, use only diesel fuel for
motor vehicles in accordance with EN590
European specifications. The use of other
products or mixtures may damage the engine be-
yond repair and consequently invalidate the war-
ranty, depending on the damage caused. If you ac-
cidentally introduce other types of fuel into the
tank, do not start the engine. Empty the tank. If the
engine has run, even for a very short time, you will
need to have the entire fuel system emptied in ad-
dition to the tank.
082-128 PUNTO FL EN 3ed 9-12-2009 13:43 Pagina 126

213
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
●● ●● ● ●
●
●
●● ●● ● ●
●● ●
●● ●
●● ●● ● ●
●● ●● ● ●
●● ●
●● ●● ● ●
Thousands of kilometres 30 60 90 120 150 180
Check engine management system operation (via diagnostic socket)
Replace accessory drive belt/s
Replace toothed timing belt (*)
Replace spark plugs (petrol versions) (1)
Replace fuel filter (diesel versions)
Replace air filter cartridge (petrol versions) (❏)
Change engine oil and replace oil filter (petrol versions)
(or every 24 months) (2)
Change engine oil and replace oil filter
(EURO 4 diesel versions without DPF) (or every 24 months)
Change engine oil and oil filter (diesel EURO 4 versions with DPF) (Õ) (3)
Change brake fluid (or every 24 months)
Replace pollen filter (or every 15 months)
(*) Regardless of the distance covered, the timing belt should be replaced every 4 years for particularly demanding use (cold climates, city dri-
ving, idling for a long time, dusty areas) or, in any case, every 5 years.
(❏) For Euro 4 diesel versions, the air filter cartridge should be replaced every 30,000 km.
(Õ) The engine oil and the filter must be replaced when the warning light on the dashboard comes on (see the “Warning lights and messages”
section) or at least every 24 months.
(1)For 1.4 Turbo Multi Air versions, in order to guarantee correct operation and prevent serious damage to
the engine, it is essential to observe the following:
– only use spark plugs specifically certified for 1.4 Turbo Multi Air engines; all spark plugs should be of the
same type and brand (see the “Engine” paragraph);
– adhere strictly to the spark plug replacement intervals detailed in the Scheduled Servicing Plan;
– it is advisable to have this performed at a Fiat Dealership.
(2)If the car is mainly used in towns and cities, change the engine oil and filter every 12 months.
(3)If the car is mainly used in cities or travels less than 10,000 km a year, change the engine oil and filter every 12 months.
211-234 PUNTO FL EN 3ed 9-12-2009 13:38 Pagina 213

KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
238
ENGINE
GENERAL INFORMATION
Type code
Cycle
Number and layout of cylinders
Piston bore
and stroke mm
Total capacity cm3
Compression ratio
Max.
power (EEC) kW
HP
corresponding speed rpm
Max.
torque (EEC) Nm
kgm
corresponding speed rpm
Spark plugs
Fuel
(*) For versions/markets where provided
1.2
199A4000
Otto
4 in line
70.8 x 78.86
1242
11.1 : 1
48
65
5500
102
10.4
3000
NGK
ZKR7A-10
1.4
350A1000
199A7000 (*)
Otto
4 in line
72 x 84
1368
11.1 : 1
57/55 (*)
77/75 (*)
6000
115
11.7
3250
NGK
ZKR7A-10
1.4 Multi Air
955A6000
Otto
4 in line
72 x 84
1368
10.8 : 1
77
105
6500
130
13.2
4000
NGK
DCPR7E-N10
1.4 Turbo
Multi Air
955A2000
Otto
4 in line
72 x 84
1368
9.8 : 1
99
135
5000
206
21
1750
NGK
IKR9F8
Unleaded petrol 95 RON (EN228 Specification)
235-258 PUNTO FL EN 3ed 9-12-2009 13:41 Pagina 238

KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
239
1.3 Multijet
90HP
199A3000
223A9000 (*) (Õ)
Diesel
4 in line
69.6 x 82
1248
17.6 : 1
66/62 (*)
90/85 (*)
4000
200
20.4
1750
1.3 Multijet
95HP
199B1000
Diesel
4 in line
69.6 x 82
1248
16.8 : 1
70
95
4000
200
20.4
1500
1.6 Multijet
120HP
955A3000
Diesel
4 in line
79.5 x 80.5
1598
16.5 : 1
88
120
3750
320
32.6
1750
Diesel for motor vehicles (EN590 Specification)
GENERAL INFORMATION
Type code
Cycle
Number and layout of cylinders
Piston bore and stroke mm
Total capacity cm3
Compression ratio
Max power (EEC) kW
HP
corresponding speed rpm
Max torque (EEC) Nm
kgm
corresponding speed rpm
Fuel
(*) For versions/markets where provided
(Õ) Euro 4
1.3 Multijet
75HP
199A9000
199B2000 (*) (Õ)
Diesel
4 in line
69.6 x 82
1248
16.8 : 1/17.6 : 1 (Õ)
55/51 (*)
75/70 (*)
4000
190
19.4
1750 (
Õ)/1500
235-258 PUNTO FL EN 3ed 9-12-2009 13:41 Pagina 239

KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
253
FUEL CONSUMPTION
The fuel consumption figures given in the table below are
determined on the basis of the homologation tests set
down by specific European Directives.
The procedures below are followed for measuring con-
sumption:
❒urban cycle: cold starting followed by driving that sim-
ulates urban use of the car;
❒extra-urban cycle: driving that simulates using the ve-
hicle out of town with frequent acceleration in all gears;
the speed varies from 0 to 120 km/h;
❒combined consumption: this is calculated with a weight-
ing of about 37% urban cycle consumption and about
63% extra-urban consumption.
IMPORTANT The type of route, traffic situations, weath-
er conditions, driving style, general state of the car, trim
level/equipment/accessories, load, climate control system,
roof rack, and other situations that affect how the car
moves through the air may lead to different fuel con-
sumption levels than those measured.
Fuel consumption according to the current European directive (litres x 100 km)
Versions Urban Extra-urban Combined
1.27,3 4,8 5,7
1.4 7,4 4,7 5,7
1.4 Multi Air 7,5 4,7 5,7
1.4 Turbo Multi Air 7,3 4,6 5,6
1.3 Multijet 70HP (❒)4,9 3,4 4,0
1.3 Multijet 75HP (❍)5,1 3,3 4,0
1.3 Multijet 75
HP5,2 3,5 4,1
1.3 Multijet 90
HP5,9 3,7 4,5
1.3 Multijet 95HP5,3 3,5 4,2
1.6 Multijet 120HP5,8 3,8 4,5
(❒) For versions/markets where provided(❍) ECO versions
235-258 PUNTO FL EN 3ed 9-12-2009 13:41 Pagina 253

261
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
– armrest .......................................... 76
– cleaning .......................................... 234
– headrests ....................................... 42
– heating ............................................ 41
Fuel
– fuel cut-off (system) .................... 73
– consumption ................................. 253
– fuel tank cap .................................. 126
– gauge and warning light .............. 15
– opening the flap ............................ 126
– refuelling the car .......................... 125
– specifications ......................238-239
Fuel cut-off system ............................. 73
Fuel economy ...................................... 154
Fuel flap ................................................. 126
Fuel gauge ............................................. 15
– type of fuel .........................125-238
Fuel reserve ......................................... 167
Fuel supply
(technical specifications) ................. 240
Fuel tank (capacity) ............................ 250
Fuel tank cap ........................................ 126
Fuse boxes (location) .. 200-201-202-268
Fuse list ...............................203-204-205
Fuse replacement
– list ..................................203-204-205
– general information and
warnings ......................................... 198
– location ..................200-201-202-268
Fuses ....................................203-204-205
– general information
and warnings ................................. 198
– location ..................200-201-202-268Gear lever ............................................ 153
Gearbox ............................................... 153
– technical specifications ............... 240
Glove compartment ........................... 74
Handbrake ........................................... 152
Hazard warning lights
– switching on .................................. 71
Headlamp alignment corrector ....... 101
Headlight alignment corrector ........ 101
Headlights
– alignment corrector .................... 101
– bulbs (type) ................................... 186
– bulb replacement ......................... 186
Headlights ............................................. 101
– alignment corrector .................... 101
– bulbs (type) ................................... 188
– light beam direction .................... 101
– adjusting headlights abroad ........ 102
– bulb replacement ......................... 186
Headrests
– front ................................................ 42
– rear ................................................. 43
Heated rear window ............51-55-72
Heating and ventilation ...................... 47
Heating and ventilation system ........ 47
Heavy-duty use of the car ................ 216
Hill Holder (system) .......................... 106
Ignition lock ......................................... 11
Ignition switch and steering
lock ..............................................11-12
Ignition .................................................. 11
In an emergency........................... 175 Environment
– devices for reducing emissions .. 127
EOBD system ...................................... 109
ESP system ........................................... 105
Extending the boot ........................... 94
Exterior lights (switching on) ........... 61
Fiat CODE system ............................. 4
Fiat CODE ........................................... 4
Fix&Go automatic
(quick tyre repair kit) ...................... 181
Flashing (main beams) ........................ 61
Fluids and lubricants
(specifications) .................................. 251
Fog lights
– bulb replacement ......................... 192
– switching on ................................. 71
Follow Me Home
(headlight device) ............................. 62
Front airbags ...................................... 141
– disabling ......................................... 143
– driver .............................................. 142
– passenger ....................................... 142
Front armrest ...................................... 76
Front ceiling light ................................ 68
– bulb replacement ......................... 195
Front fog lights
– bulb replacement ......................... 192
– switching on .................................. 71
Front light clusters
– bulb arrangement ......................... 189
Front seats ........................................... 39
– adjusting ......................................... 39
259-268 PUNTO FL EN 3ed 9-12-2009 13:42 Pagina 261