brake FIAT QUBO 2014 1.G Owner's Guide

RUBBER LINESFollow the requirements in “Scheduled Servicing
Plan” in this section carefully for brake and fuel
rubber lines.
Ozone, high temperatures and a prolonged lack of
fluid in the system may cause hardening and cracking
of the tubes, which could result in leaks. Careful
inspections are therefore necessary.
WINDSCREEN/REAR WINDOW
WIPERS(for versions/markets, where provided)
BLADES
Regularly clean the rubber part using appropriate
products; TUTELA PROFESSIONAL SC 35 is
recommended.
Replace the blades if the rubber edge is misshapen or
worn. In any event, it is advisable to replace them
approximately once a year.
A few simple precautions can reduce the possibility
of damage to the blades:
❒make sure that the rubber part is not stuck to the
windscreen at sub-zero temperatures. Use an
antifreeze product to release it if required;
❒remove any snow from the glass: in addition to
protecting the blades, this prevents the electric
motor from overheating;
❒do not operate the windscreen and rear window
wipers on dry glass.
WARNING
Driving with worn wiper blades is a
serious hazard, because visibility is
reduced in bad weather.
184KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX

SEATS AND FABRIC PARTS
Remove dust with a soft brush or a vacuum cleaner.
It is advisable to use a damp brush on velvet
upholstery.
Rub the seats with a sponge and a solution of water
and mild soap.
PLASTIC PARTS
It is advisable to clean interior plastic parts with a
damp cloth and a solution of water and non-abrasive
mild soap. To remove grease and tough stains, use
products designed specifically for cleaning plastics.
These have no solvents and have been designed
so that they do not alter the appearance and colour
of the components.
IMPORTANT Never use spirits or petroleum to
clean the instrument panel glass.REAL LEATHER STEERING WHEEL/GEAR
LEVER KNOB/HANDBRAKE
(for versions/markets, where provided)
These components must be cleaned with mild soap
and water only. Never use alcohol or alcohol-based
products.
Read the product label carefully before using specific
products for cleaning the interiors: make sure the
product does not contain spirits or alcohol-based
substances.
If, when cleaning the windscreen with special
products, window cleaner accidentally drips onto the
leather of the steering wheel/gear lever knob/hand
brake, wipe away immediately and then wash the
affected area with mild soap and water.
IMPORTANT Be careful when installing a steering
wheel locking device not to damage the leather
upholstery.
190KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX

BRAKESVersions Front service brakes Rear service brakes Parking brake
1.3 Multijet 75 HPdisk drumcontrolled by hand lever,
acting on rear brakesIMPORTANT Water, ice and salt sprinkled on the roads may deposit on the brake disks reducing braking
efficiency the first time the brakes are applied.SUSPENSIONVersions Front Rear
1.3 Multijet 75 HPMc Pherson independent wheels torsion beamSTEERINGVersions Turning circle (kerb to kerb) (m) Type
1.4
10.55rack and pinion with electric power
steering (for versions/markets, where
provided) 1.3 Multijet 75 HP
1.3 Multijet 95 HP
196KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX

WEIGHTSWeights (kg)1.3 Multijet 75 HP Euro 4 class 1
(o)
N1 "Mini-
mum" ver-
sions
(4 seats)N1 "Maximum" versions
(4 seats)M1 versions
Unladen weight (with all fluids, fuel tank filled to
90% and without optional equipment)1205 1300 1200
Payload
(*)
including the driver:
550 455 510
Payload
(*)
excluding the driver:
475 - 440
Maximum permitted loads
(**)
- front axle: 950 950 950
- rear axle: 950 950 950
- total: 1755 1755 1710
Towable loads
- trailer with brakes: 600 600 600
- trailer without brakes: 400 400 400
Max. load on the roof (with roof rack bars)
(***)
70 70 70
Max. load on ball joint (trailer with brake): 60 60 60
(o)For versions/markets, where provided
(*)N1 CATEGORY: for the full optional versions (110 kg) the payload is gradually reduced to 500 kg.
(**)Loads not to be exceeded. The user is responsible for arranging goods in the boot and/or on the load carrying platform within the
maximum permitted loads.
(***)Including weight of any carrying systems fitted (Lineaccessori Fiat bars/box).NoteTrekking versions have the same capacities as the other versions.CATEGORY M1: optional equipment is included in the capacity.
204KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX

Weights (kg)1.3 Multijet 75 HP Euro 4 class 2
N1 "Minimum"
versions (4 seats)N1 "Maximum" versions (4 seats)
Unladen weight (with all fluids, fuel
tank filled to 90% and without
optional equipment)1235 1355
Payload
(*)
including the driver:
565 445
Payload
(*)
excluding the driver:
490 370
Maximum permitted loads
(**)
- front axle: 950 950
- rear axle: 960 960
- total: 1800 1800
Towable loads
- trailer with brakes: 600 600
- trailer without brakes: 400 400
Maximum load on the roof (with roof
bars)
(***)
50 50
Maximum load on ball joint (trailer
with brake):60 60
(*)N1 CATEGORY: for the full optional versions (120 kg) the payload is gradually reduced to 445 kg.
(**)Loads not to be exceeded. The user is responsible for arranging goods in the boot and/or on the load carrying platform within the
maximum permitted loads.
(***)Including weight of any carrying systems fitted (Lineaccessori Fiat bars/box).NoteTrekking versions have the same capacities as the other versions.
205KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONSINDEX

CAPACITIES
1.3 Multijet 75 HP
Recommended fuels and original
lubricants
litres kg
Fuel tank: 45 -
Diesel for motor vehicles (EN590
specification)
including a reserve of: 6/7 -
Engine cooling system: 7.6 -50% mixture of distilled water and
PARAFLU
UP
(*)
Engine sump: 3.0 2.6
SELENIA WR P.E.
Engine sump and filter: 3.2 2.8
Gearbox/differential casing: 1.84 1.6TUTELA CAR TECHNYX
Hydraulic power steering 0.38 0.35TUTELA GI/E
Hydraulic brake circuit: - 0.5TUTELA TOP 4
Windscreen and rear window
washer fluid tank:3.0 -Water and liquid mixture
TUTELA PROFESSIONAL SC 35(*)When the vehicle is used in particularly harsh weather conditions, we recommend using a 60-40 mixture of PARAFLU
UP
and
distilled water.
206KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX

UseFluid and lubricant specifications for
correct operationGenuine fluids and
lubricantsApplications
Lubricants for
motion
transmissionSAE 75W-85 grade synthetic lubricant. Exceeds
API GL 4 PLUS specifications.
FIAT Qualification 9.55550-MX3TUTELA CAR
TECHNYX
Contractual Technical
Reference N. F010.B05Manual gearboxes and
differentials (diesel
versions)
Molybdenum disulphide grease, for use at high
temperatures.
Qualification FIAT 9.55580.Consistency
NL.G.I. 1-2TUTELA ALL STAR
Contractual Technical
Reference N. F702.G07Wheel side constant
velocity joints
Grease for constant velocity joints with low
friction coefficient.
Qualification FIAT 9.55580.Consistency
NL.G.I. 0-1TUTELA STAR 700
Contractual Technical
Reference N. F701.C07Differential-side
constant velocity
joints
Automatic transmission lubricant. Exceeding ATF
DEXRON III specificationsQualification FIAT
9.55550- AG2.TUTELA GI/E
Contractual Technical
Reference N. F001.C94Hydraulic power
steering
Brake fluidSynthetic fluid, NHTSA N. 116 DOT 4, ISO
4925, SAE J-1704, CUNA NC 956-01.
Qualification FIAT 9.55597.TUTELA TOP 4
Contractual Technical
Reference N. F001.A93Hydraulic brakes and
hydraulic clutch
controls
208KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX

INDEX
A
BS fault warning light ............ 121
ABS (fault warning light) .......... 121
ABS ................................................ 69
Air bag fault warning light ........ 119
Air bag (fault warning light) ..... 119
Airbags (general warnings) ...... 104
Air cleaner ................................... 180
Alarm fault warning light .......... 125
Alarm ............................................. 9
Alarm (warning light) ................ 125
Arrangements for dealing
with the vehicle at the end
of its life ..................................... 213
Ashtray .......................................... 50
ASR
– On/off message..................... 128
ASR system .................................. 73
– On/off message..................... 128
Battery
– Replacement .......................... 180
Battery (low charge warning
light) ............................................ 121
Battery (recharging) .................. 164Body
– Advice for preserving the
bodywork ............................... 187
– Protection from
atmospheric elements......... 186
– Vehicle body and
underbody guarantee .......... 187
Body paintwork
identification plate ................... 192
Bodywork versions.................... 193
Bonnet
– Closing ..................................... 66
– Opening ................................... 65
Boot ............................................... 56
Boot light ............................... 46-155
Brake fluid/handbrake
warning light.............................. 118
Brake fluid.................................... 178
Brake fluid (warning light)........ 118
Brake lights (changing a
bulb) ............................................ 149
Brake pad wear warning
light ............................................. 127
Brake pad wear (warning
light) ............................................ 127
Brakes
– characteristics ....................... 196Brakes (pad wear warning
light) ............................................ 127
Break-in attempt warning
light ............................................. 125
Bulbs
– types of bulbs ........................ 144
Bump starting ............................. 130
Capacities.................................... 206
Carrying children safely
– Child seat compliance .......... 95
– Child seats .............................. 90
– Safety rules ............................. 96
Ceiling lights................................. 44
Ceiling light with movable
lens (changing a bulb).............. 152
Central and side vents ............... 35
Changing a bulb .......................... 142
Changing an exterior
146-147-148-149-150-151
Changing an interior bulb ........ 152
Changing a tyre .................. 130-131
Changing battery - key with
remote control.......................... 8
Chassis marking.......................... 192
Checking fluid levels.................. 172
Cigar lighter ................................. 49
220KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
bulb ......

Front airbags ............................... 100
– Front airbag driver's side .... 102
– Front airbag passenger's
side .......................................... 102
– Manual deactivation of
passenger front airbag
and side bag ........................... 103
Front ceiling light ....................... 152
Front ceiling light with map
reading lights (changing a
bulb) ............................................ 153
Front light clusters
(changing a bulb) ...................... 146
Front light clusters .................... 146
Front power socket ................... 49
Fuel consumption ...................... 210
Fuel cut-off system ..................... 83
Fuel filter (water in fuel
warning light) ............................ 124
Fuel level gauge ........................... 13
Fuel reserve warning light........ 124
Fuel (reserve warning light) ..... 124
Fuel system.................................. 195
Fuses (replacement) .. 155-157-161G
ear lever................................... 112
Generic failure indication
warning light.............................. 127Generic failure indication
(warning light)........................... 127
Glove compartment................... 49
Glow plug preheating fault
warning light.............................. 124
Glow plugs (preheating/fault
warning light) ............................ 124
Glow plugs preheating
warning light.............................. 124
Handbrake ................................... 110
Handbrake lever ......................... 110
Handbrake (warning light) ....... 118
Hazard lights ................................ 47
Headlight alignment
corrector .................................... 68
Headlights
– Headlight alignment
corrector................................. 68
– Light beam direction ............ 68
Headrest
– Front ........................................ 29
– Rear .......................................... 30
Heating and ventilation ............. 35
Heating and ventilation
system; ........................................ 34
Heavy use of the vehicle .......... 171
Hill Holder (system) .................. 72How to warm up the engine
after it has just started ........... 108
Identification data ..................... 191
Ignition switch
– Ignition ..................................... 11
– Steering lock........................... 12
In an emergency ......................... 129
Inflation pressure ....................... 201
Inflation procedure .................... 139
Injection system/EOBD
engine control system fault
warning light.............................. 123
Injection system (warning
light) ............................................ 123
Installing
electrical/electronic devices ... 80
Instrument panel ......................... 4
Instruments .................................. 12
Interior fittings ............................ 48
Interiors ....................................... 189
Isofix child seat assembly
setup ............................................ 97
Isofix child seats (fitting
arrangement) ............................. 97
– Seat compliance with
child seat use.......................... 99Jack ............................................... 131
222KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX

– Wing mirrors ......................... 32
Rear window washer ................. 43
Rear window wiper ............. 43-184
Removable ceiling light ............. 154
Replacing the battery ................ 180
Replacing the rear window
wiper blade................................ 185
Replacing the windscreen
wiper blades .............................. 185
Rev counter.................................. 13
Right-hand indicator
warning light.............................. 128
Rim Protector............................. 199
Rims and tyres ............................ 197
Roof rack/ski rack ....................... 67
Roof rails....................................... 67
Rubber lines ................................ 184Saving fuel ................................... 113
Seat belt reminder ..................... 122
Seat belts
– Use ........................................... 85
Seats
– Accessing front seats............ 28
– Foldaway passenger seat...... 27
– Front seats .............................. 26Securing your load ...................... 64
Side bags .............................. 103-104
Side bags
– Side bag................................... 104
Side lights - tail lights
(changing a bulb) ...................... 146
Side lights - tail lights ................. 41
Side lights/tail lights ................... 146
– Warning light ......................... 127
Side/tail lights warning light ..... 127
Snow chains................................. 116
Snow tyres................................... 111
Spare wheel ................................. 197
Speedometer ............................... 12
Spray nozzles .............................. 186
Starting procedure for
diesel versions .......................... 107
Starting the engine.... 107-129-130
Steering ........................................ 196
Steering lock ................................ 12
Steering wheel ............................. 31
Stopping the engine ................... 109
Sun visors ..................................... 50
Suspension ................................... 196
Symbols ......................................... 5
Tail lights/rear fog light
(changing a bulb) ...................... 149
Third brake lights (changing
a bulb)......................................... 150
Third brake lights ....................... 150
Tool bag ....................................... 132
Towing the vehicle ..................... 165
Towing trailers ............................ 115
Traction Plus system .................. 75
Transmission ....................... 112-195
Trip Computer ............................ 23
Tyres ............................................. 197U
niversal Isofix seat
compliance with child seat
use................................................ 99
Useful advice for extending
the life of your battery ........... 181
Uzávěr palivové nádrže .............. 82
VIN plate .................................... 191W
arning lights and
messages .................................... 118
Washer fluid for
windscreen/rear window ....... 177
Water in diesel fuel filter
warning light.............................. 124
Weights ........................................ 204
Wheel geometry........................ 197
224KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX