fuel cap FIAT ULYSSE 2008 2.G Owners Manual

GETTING TO KNOW YOUR CAR
11fig. 2
F0B0401b
THE FIAT CODE
SYSTEM
To further protect your vehicle from
attempted theft, it has been fitted with
an electronic engine immobiliser sys-
tem (called Fiat CODE) which is au-
tomatically activated when the ignition
key is removed. Each ignition key, in
fact, contains an electronic device,
which modulates a radio-frequency
signal emitted by a special aerial, built
into the ignition switch, during ignition.
The modulated signal is a “password”
with which the control unit recognis-
es the key. Engine ignition is enabled
only if the key is recognised by the sys-
tem.THE KEYS fig. 2
The following keys are supplied with
the car:
– two keys Aif the car is fitted with
remote central door locking system
and electronic alarm.
– two keys Bif the car is fitted with
remote central door locking system,
electronic alarm and powered side
sliding doors.The keys shall be used to:
– ignition switch;
– lock/unlock the driver and passen-
ger door
– operate remote door locking/un-
locking
– operate the alarm system (where
fitted)
– deactivate the passenger side airbag
– lock/unlock the fuel filler cap
– lock/unlock the glove compart-
ment.

GETTING TO KNOW YOUR CAR
134
REFUELLING
To guarantee full tank filling, carry
out two refuelling operations after the
first click of the fuel delivery gun.
Avoid further topping up operations
that could cause damages to the fuel
system.
FUEL FILLER CAP fig. 172
The fuel filler cap Ais locked; to ac-
cess it, open the fuel tank flap Bwith
the ignition key and turn it anticlock-
wise while releasing the cap.
During filling, hang the cap to the
hook inside the flap, as illustrated.
fig. 172
F0B0116b
The vehicle must only
be filled with diesel fuel
for motor vehicles, in
compliance with European Stan-
dard EN590. The use of other
products or mixtures may ir-
reparably damage the engine
with invalidation of the warran-
ty due to the damage caused. In
the event of accidentally filling
with another type of fuel, do not
start the engine and empty the
tank. If the engine has been run
even for only a very short time,
in addition to the tank, it is also
necessary to drain out the whole
fuel circuit.
If driving or parking the vehicle for
a long period in cold areas/mountains,
refuel with the diesel fuel available at
local filling stations.
In this situation you are also recom-
mended to have in the tank an amount
of fuel 50% higher than usable capac-
ity.AT THE FILLING
STATION
OPERATION AT LOW
TEMPERATURES
If the outside temperature is very
low, the diesel thickens due to the for-
mation of paraffin and could cause the
malfunctioning of the fuel system.
In order to avoid these problems, dif-
ferent types of diesel are distributed
according to the season: summer type,
winter type and arctic type (cold,
mountain areas). If refuelling with
diesel fuel not suitable for the current
temperature, mix diesel fuel with
TUTELA DIESEL ART additive in the
proportions stated on the can, putting
first the antifreeze in the tank and then
the diesel fuel.

GETTING TO KNOW YOUR CAR
135
PROTECTING THE
ENVIRONMENT
Protecting the environment has been
a constant guiding factor of the
Ulysse’s design and manufacture at
every stage. The result of this atten-
tion is to be seen in the choice of ma-
terials and installation of devices able
to drastically limit or reduce harmful
influences on the environment.
Devices for reducing emissions from
JTD engines are:
– oxidising catalytic converter;
– exhaust gas recirculation system
(E.G.R.);
– particulate filter (where fitted): its
purpose is to trap and burn particulate
(unburnt particles) to reduce harmful
exhaust emissions.
The vehicle, therefore, has great ad-
vantages with respect to the strictest
international anti-pollution directives. Do not put open flames
or lighted cigarettes near
the fuel filler hole as there
is a danger of fire. Do not lean out
too close to the hole either so as
not to breathe in harmful
vapours.
Where necessary, to
avoid compromising the
efficiency of the fuel
vapour recovery system, replace
the fuel cap with another genuine
spare part.
IMPORTANTThe waterproof fu-
el filler cap lock may be slightly pres-
surised. Therefore, do not worry if
some air comes out when the cap is
released.
After filling, drive in the cap by turn-
ing it clockwise until it clicks twice or
thrice, then turn the key clockwise and
remove it. Close the flap.

TECHNICAL SPECIFICATIONS
229
CAPACITIES
2.0 JTD
120 HP
litres
80
8
9
5.25
1.9
–
1.2
1.2
0.519
7.52.0 JTD
136 HP
litres
80
8
9
5.25
1.9
–
1.2
1.2
0.519
7.52.2 JTD
170 HP
litres
80
8
9
4.75
–
–
1.2
1.2
0.93
7.5
2.2 JTD
170 HP a.g.
litres
80
8
9
4.75
–
3/4
1.2
1.2
0.93
7.5
Fuel tank:
– including a reserve of:
Engine cooling system:
Engine sump and filter:
Transaxle:
Automatic gearbox
Hydraulic power steering:
Electro-hydraulic power steering
Hydraulic brake circuit with:
ABS (with ESP)
Windscreen, rear mirror and
headlight liquid reservoir:
Recommended fluids
and lubricants
Recommended products
Diesel for motor vehicles
(EN590 specifications)
Mixture of distilled water and
PARAFLU UP(red) at 50%
SELENIA WR
TUTELA CAR EXPERYA
TUTELA GI/E
TUTELA GI/E
TUTELA GI/R
TUTELA TOP 4
50-50 mixture of distilled
water and TUTELA
PROFESSIONAL SC 35

INDEX
242
- switching the alarm
system off.................................. 16
- when the alarm is triggered.. 16
Electronic automatic
transmission ............................... 90
- display ....................................... 91
- driving in automatic mode .... 94
- driving in sequence mode ..... 94
- failure indication ..................... 95
- lever position ........................... 91
- moving the car ......................... 93
- selection lever.......................... 91
- sound warnings (buzzers) .... 96
- starting the engine ................. 93
- stopping the engine ................ 96
- technical specifications ......... 221
- towing the car ........................ 180
Electronic braking force
distributor EBD ......................... 118
Electronic control units
(warnings) ................................... 204
Engine
- engine marking ....................... 218
- identification code ................. 219
- technical specifications ......... 219
Engine compartment
(washing) ..................................... 212Engine coolant level .................... 194
Engine coolant temperature
gauge ............................................ 53
Engine oil
- checking the level .................. 193
Engine oil consumption ............. 193
Engine oil level .............................. 193
EOBD system .............................. 122
ESP system .................................... 119
- ASR function ........................... 121
- ESP action ................................. 121
- failure indication ...................... 121
- MSR function ........................... 122
- operation ................................. 120
- TC function ............................. 121
Exterior lights (controls) ........... 79
Fiat CODE system ..................... 11
- CODE card ............................. 14
Flashing
(main beam headlights) ............ 81
Follow me home .......................... 79
Front and side airbags ................ 124
- deactivating the passenger’s
front air bag manually............. 127
- general notes .......................... 128
- passenger’s front airbag ........ 125- side airbags
(side bag -window bag) ......... 127
Front ceiling light ........................ 102
- bulb replacement ................... 168
Front doors
- autoclose ................................... 19
- opening/closing ........................ 19
- super lock ................................. 22
Front fog lights
- bulb replacement .................... 165
- control ...................................... 81
Front seats .................................... 24
- adjustment ....................... 24-25
- armrests ................................... 33
- head restraints ........................ 32
- heating ...................................... 25
- interior settings .............. 31-32
- storing the driver’s
seat position ............................ 25
- swivel ......................................... 26
Fuel
- consumption ........................... 232
- fuel cut off switch.................... 87
- fuel filler cap ............................ 134
- fuel level gauge ....................... 53
Fuel consumption ........................ 232
Fuel cut off switch ....................... 87

INDEX
243
Fuel filler cap ................................. 134
Fuel gauge....................................... 53
Fuel supply/ignition
- technical specifications ......... 220
Fuses (replacement) ................... 170
- fusebox in the engine
compartment ................... 173-176
- fusebox in the glove
compartment ..................... 172-174
- fuse list .............. 174-175-176-177
- fusebox next to
battery............................... 172-175
- general instructions ............... 170
Getting to know your car ....... 9
Glove compartment ................... 98
Glove compartment light
- bulb replacement .................... 169
Handbrake................................... 87
Hazard lights ......................... 85-86
HBA system ................................... 118
Headlight automatic
switching on ................................ 80
Headlamp washer
- control ...................................... 209
- liquid level ................................ 192Headlamps
- automatic switching on .......... 80
- headlamp beam
positioning .................................... 115
- slant compensation ................. 115
- Xenon lights ............................ 114
If a tyre is punctured
(changing the wheel) ................ 154
If an accident occurs .................. 182
- first-aid kit ............................... 183
- if anyone is injured ................ 182
Ignition switch .............................. 18
In an emergency ........................... 153
Infotelematic
CONNECT system ................... 56
Instrument panel .............. 50-51-52
- brightness adjustment ............ 50
Instruments .......................... 50-51-52
Interior equipment ..................... 96
Interiors (maintenance) ............. 212
- cleaning ...................................... 213
“Isofix Type” child's seat
(presetting for mounting) ........ 47
Jack .............................. 156-157-158
Jacking the car .............................. 179- with an arm hoist
or a shop jack................. 179-180
- with the jack ........................... 179
Keys ............................................ 11
- duplicate keys........................... 15
- remote control
functions ........................... 12-13
- replacing the battery ............. 14
- request for additional
remote controls .......................... 17
Litter container........................... 98
Load anchorage ........................... 110
Load limiting devices ................... 38
Lower glove compartment ....... 96
Lubricant and fluid
specifications ..................... 230-231
Luggage and ski racks .................. 113
Luggage compartment
- emergency opening................. 110
- opening/closing ........................ 109
Luggage compartment lights
- bulb replacement ................... 170
Luggage retaining net ................. 100

Fiat Group Automobiles S.p.A. - Customer Services - Technical Services - Service Engineering
Largo Senatore G. Agnelli, 5 - 10040 Volvera - Torino (Italia)
Print no. 603.81.363 - 02/2008 - 1
stedition
COLD TYRE INFLATION PRESSURE (bar)
ENGINE OIL CHANGE
FUEL CAPACITIES
2.0 JTD - 2.2 JTD
Tank capacity litres 80
Reserve litres 8
Refuel diesel engines with diesel fuel for motor vehicles (EN590 specifications) only.
Front
2.5
2.5 Tyre
215/60 R16
215/65 R15Rear
2.5
2.5Front
2.5
2.5Rear
3.4
3.0 Empty Full load
Add +0.3 bars to the prescribed inflation pressure when the tyres are warm. In any case. check the correct value again when the tyres are cold.
2.0 JTD 2.2 JTD
Engine sump and filter litres 5.25 4.75
#Dispose of waste oil properly.