automatic transmission fluid FORD AEROSTAR 1997 1.G Owners Manual
[x] Cancel search | Manufacturer: FORD, Model Year: 1997, Model line: AEROSTAR, Model: FORD AEROSTAR 1997 1.GPages: 347, PDF Size: 1.79 MB
Page 170 of 347
170
*
[GF10400(ALL)05/96]
Power Braking
*
[GF10410(ALL)05/96]
Increasing the engine speed above idle without
vehicle movement (such as holding the brake) in
a forward or reverse gear causes transmission
stall.
*
[GF10450(ALL)05/96]
NOTE: Continued operation in the stall
condition can result in transmission
overheat, malfunction or fluid
expulsion.
*
[GF10500(ALL)05/96]
Automatic Overdrive
Transmission
%*
[GF10750(ALL)05/96]
Putting Your Vehicle in Gear
[GF10800(ALL)05/96]
Your vehicle's gearshift is on the steering
column. The transmission control switch is
located on the end of the gearshift lever. You
can put the gearshift in any one of several
positions.
[GF10900(ALL)01/96]
one third page art:0095027-A
The positions of the column-mounted gearshift
File:09cpgfa.ex
Update:Wed Jun 5 12:04:06 1996
Page 245 of 347
246
*
[MC09200(ALL)01/96]
5. If the power steering fluid is low, add fluid
in small amounts, continuously checking the
level, until you reach the FULL HOT range.
Do not overfill.
*
[MC09210(ALL)03/96]
6. When you are finished, put the dipstick back
in and make sure that it fits snugly.
[MC09220(ALL)01/96]
Use only a power steering fluid such as Ford
Power Steering Fluid Motorcraft MERCONH
ATF.
*
[MC09230(ALL)01/96]
If the power steering fluid is low, do not drive
your vehicle for a long period of time before
adding fluid. This can damage the power
steering pump.
*
[MC09240(ALL)03/96]
If you check the power steering fluid when it is
cold, make sure that the fluid reaches the FULL
COLD range on the dipstick. The reading will
only be accurate if the fluid temperature is
approximately 50 to85ÊF (10 to 30ÊC).
*
[MC09250(ALL)01/96]
NOTE: Do not turn the steering wheel of your
vehicle with the engine off. It could
force power steering fluid out from the
reservoir cap or in extreme cases, it
could unseat the cap.
%
*
[MC10000(ALL)01/96]
Automatic Transmission Fluid
*
[MC10100(ALL)05/96]
Under normal driving conditions automatic
transmission fluid should be changed every
30,000 miles (48,000 km) or 21,000 miles
(34,000 km) if under severe duty conditions.
However, if the transmission is not working
properly, for instance, the transmission may slip
or shift slowly, or you may notice some sign of
fluid leakage, the fluid level should be checked.
*
[MC10110(ALL)01/96]
It is preferable to check the transmission fluid
level at normal operating temperature, after
approximately 20 miles (30 km) of driving.
However, if necessary, you can check the fluid
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996
Page 246 of 347
247
level without having to drive 20 miles to obtain
a normal operating temperature if outside
temperatures are above50ÊF (10ÊC).
*
[MC10120(ALL)01/96]
NOTE: If the vehicle has been operated for an
extended period at high speeds or in
city traffic during hot weather, or
pulling a trailer, the vehicle should be
turned off for about 30 minutes to
allow the fluid to cool before checking.
%*
[MC10130(ALL)01/96]
Checking the Automatic Transmission
Fluid
[MC10140(ALL)05/96]
With the vehicle on a level surface, start the
engine and move the gearshift lever through all
of the gear ranges allowing sufficiant time for
each position to engage. Securely latch the
gearshift lever in the P (Park) position, fully set
the parking brake and leave the engine running.
*
[MC10150(ALL)01/96]
RWARNING
Your vehicle should not be driven if the
fluid level is below the bottom hole on
the dipstick and outside temperatures are
above50ÊF (10ÊC).
[MC10160(ALL)01/96]
Wipe off the dipstick cap (located toward the
passenger's side of the engine), pull the dipstick
out and wipe the indicator end clean. Put the
dipstick back into the filler tube and make sure
it is fully seated. Pull the dipstick out and read
the fluid level.
*
[MC10170(ALL)01/96]
When checking fluid at normal operating
temperature, the fluid level should be within the
crosshatched area on the dipstick. When the
vehicle has not been driven, and outside
temperature is above50ÊF (10ÊC), thefluid level
should be between the holes on the dipstick.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996
Page 247 of 347
248 %
*
[MC10180(ALL)01/96]
Adding Automatic Transmission Fluid
*
[MC10190(ALL)01/96]
The fluid type is stamped on the dipstick.
Before adding any fluid, be sure that the
correct type will be used.
*
[MC10200(ALL)01/96]
Add fluid in 1/2 pint (.25L) increments through
the filler tube to bring the level to the correct
area on the dipstick. If an overfill occurs, excess
fluid should be removed by a qualified
technician.
%*
[MC10220(ALL)05/96]
NOTE: Always dispose of used automotive
fluids in a responsible manner. Follow
your community's standards for
disposing of these types of fluids. Call
your local recycling center to find out
about recycling automotive fluids.
[MC10230(ALL)04/96]
quarter page art:0020372-E
Automatic transmission dipstick
%*
[MC10500(ALL)01/96]
Driveline Universal Joint and Slip
Yoke
*
[MC10520(ALL)03/96]
The universal joints that come standard with
your vehicle do not require lubrication. If your
original equipment universal joints are replaced
with universal joints equipped with grease
fittings, lubrication will be necessary at the
intervals shown in theMaintenance Schedule
booklet.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996
Page 327 of 347
336 Index
Autolamp system (see Headlamps)..... 72
Automatic transmission
fluid, adding............. 248
fluid, checking............ 247
fluid, refill capacities......... 294
fluid, specification........... 296
Axle
lubricant specifications......... 296
refill capacities............ 294
traction lok............177, 254
B
Basic vehicle warranty........... 3
Battery
acid, treating emergencies.....223, 250
charging system warning light...... 13
disconnecting............. 226
how to service............ 249
jumping a disabled battery....... 222
maintenance-free........... 249
proper disposal, recycling....... 250
replacement, specifications....... 293
servicing............... 249
voltage gauge............ 13,15
when storing your vehicle....... 285
Brake fluid
brake warning light........... 9
checking and adding......... 236
description.............. 236
specifications...........237, 296
Brakelamp, high-mount brakelamp..... 72
Brakes
adjustment.............. 163
anti-lock............... 163
applying the brakes.......... 166
brake warning light........... 9
fluid, checking and adding....... 236
fluid, refill capacities.......236, 294
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996
Page 331 of 347
340 Index
D
Daytime running light system....... 72
Defects, reporting............ 301
Defrost, rear window........... 69
Dipstick
automatic transmission fluid....246, 248
engine oil.............. 234
power steering fluid.......... 244
Disabled vehicle (see Towing)...... 226
Dispute Settlement Board........ 306
Doors
door ajar warning light......... 11
lubricant specifications......... 296
Driveline universal joint and slip yoke . . 248
Driving under special conditions,
heavy load.............. 179
E
Electrical system
circuit breakers............ 209
fuses................. 200
operating when the engine is off..... 74
Electronic radio with cassette
(see Electronic sound system)...... 49
Electronic sound system
accessory delay............. 74
tuning the radio........ 23,37,49
warranty and service information..... 58
Electronic stereo cassette radio
(see Electronic sound system)...... 49
Electronic stereo radio (see Electronic
sound system)............. 49
Emergencies, roadside
assistance............... 303
battery acid spills.........223, 251
fuel................. 265
jump-starting............. 222
towing................ 226
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996
Page 344 of 347
Index 353
Transmission
automatic operation.......... 170
fluid, checking and adding
(automatic)............ 247
fluid, refill capacities......... 294
lubricant specifications........ 296
Trip odometer.............. 20
Tune-up specifications (VECI)...... 271
Turn signal
indicator lights............. 75
lever................. 75
U
Used engine oil, disposal......230, 248
V
Variable interval wipers.......... 76
VECI (Vehicle Emission Control Information)
decal................ 271
Vehicle Identification Number (VIN) . . . 300
Vehicle loading............. 181
calculating the load.......... 187
understanding loading information . . . 179
Vehicle storage............. 283
Ventilating your vehicle
(see Climate control).......... 61
Viscosity (see Engine oil)........ 233
Voltmeter (see Battery voltage gauge) . . 13, 15
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996