weight FORD BRONCO SPORT 2022 Warranty Guide

1. Introduction
Ford Motor Companyand your selling dealer thank you for
selecting one of our quality products. Our commitment to you
and your vehicle begins with quality protection and service.
When you need warranty repairs, your selling dealer would like
you to return to it for that service, but you may also take your
vehicle to another Ford Motor Company dealership authorized for
warranty repairs. Certain warranty repairs require special training
though, so not all dealers are authorized to perform all warranty
repairs. That means that, depending on the warranty repair
needed, the vehicle may need to be taken to another dealer. If a
particular dealership cannot assist you, then contact the
Customer Relationship Center at 1-800-392-3673.
This booklet explains in detail the warranty coverages that apply
to your 2022-model car or light truck. If you bought a previously
owned 2022-model vehicle, you are eligible for any remaining
warranty coverages.
Ford Motor Company provides the Emissions Defect Warranties
and Emissions Performance Warranties which cover your
emissions control systems, and Noise Emissions Warranty
which applies only to medium/heavy duty trucks over 10,000
pounds Gross Vehicle Weight Rating (pages 22-42).
1

6. California requirements for emissions warranties
QUICK REFERENCE: EMISSIONS WARRANTY COVERAGE
This chart shows the emission warranty that Ford Motor Company
provides for your vehicle under the emissions control warranty in
accordance with the regulations of the California Air Resources Board.
This coverage is in addition to Federal Emission warranties (Page 22).
* Gross Vehicle Weight Rating
** These specific parts were selected on the basis of their estimated replacement cost at the time the California Air Resources Board certified your vehicle for sale in California
(up through 14,000 pounds GVWR).
***
Refer to your Vehicle Emission Control Information label for emissions certification information.
**** Except for the high voltage battery, which is covered for 10 years or 150,000 miles (whichever occurs first).
NOTE: Fully-electric vehicles are not eligible for any emissions
warranties described in this booklet.
TRANSITIONAL ZERO EMISSION VEHICLES (TZEV)***
DEFECTS AND PERFORMANCE WARRANTY**** 15/150,000
EMISSIONS DEFECTS WARRANTY FOR
VEHICLE WITH GVWR OVER 14,000 LBS.***
(Gasoline engines)
(2021 and earlier engine
model year diesel engines)
(2022 and later engine
model year diesel engines)
EMISSIONS PERFORMANCE WARRANTY (Vehicles of 14,000 LBS.* & under)
EMISSIONS DEFECTS WARRANTY FOR
VEHICLES WITH GVWR*
OF 14,000 LBS. & UNDER
Short-Term Warranty
Long-Term Warranty**
3/50,000
3/50,000
7/70,000
5/50,000 5/100,000
5/110,000
Emissions Warranties for California Certified Vehicles
TYPE OF
COVERAGE YEARS IN
SERVICE/MILES DRIVEN
29

EXPLANATION OF CALIFORNIA EMISSIONS WARRANTIES
Your Warranty Rights and Obligations
The California Air Resources Board and Ford Motor Company are
pleased to explain the emission control system warranty on your
2022-model vehicle. In California, new motor vehicles must be
designed, built, and equipped to meet the State's stringent
anti-smog standards. Ford must warrant the emission control
system on your vehicle for the periods of time listed on pages 32-35,
provided there has been no abuse, neglect, or improper maintenance
of your vehicle.
Your emission control system may include parts such as the fuel
injection system, the ignition system, catalytic converter, and the
engine computer. Also included may be hoses, belts, connectors,
and other emissions-related assemblies.
Where a warrantable condition exists, Ford Motor Company will
repair your vehicle at no cost to you including diagnosis, parts,
and labor.
Manufacturer's Warranty Coverage
For Vehicles Eligible for California Emission Warranty Coverage
If Gross Vehicle Weight Rating is 14,000 lbs. or less:
For 3 years or 50,000 miles (whichever occurs first):
1. If your vehicle fails a Smog Check inspection, all necessary
repairs and adjustments will be made by Ford to ensure that your
vehicle passes the inspection. This is your emission control
system PERFORMANCE WARRANTY.
2. If any emissions-related part on your vehicle is defective, the
part will be repaired or replaced by Ford. This is your short-term
emission control system DEFECTS WARRANTY.
For 7 years or 70,000 miles (whichever occurs first):
If a high-priced emissions-related part is defective or if its failure
causes your vehicle to fail a Smog Check inspection, the part will
be repaired or replaced by Ford. This is your long-term emission
control system DEFECTS WARRANTY.
32

For a list of the high-priced emission-related parts that are
covered for 7 years or 70,000 miles, go to www.owner.ford.com /
Owner Manuals.
Select the list that corresponds to the model and the model year
of your vehicle. NOTE: This list is vehicle specific and may not be
the same for all vehicles. It is based on the replacement cost of
each specific part, which can vary between vehicle lines.
If Gross Vehicle Weight Rating is 8,501 lbs. through 14,000 lbs.:
• For 5 years or 50,000 miles (whichever occurs first) forcomponents whose failure would increase the vehicle’s
emissions of air conditioning refrigerants.
• Only for HDVs designated as "vocational vehicles" on the
underhood "VEHICLE EMISSION CONTROL INFORMATION"
label: Tire defects that affect compliance with greenhouse gas
requirements are covered for 2 years or 24,000 miles,
whichever comes first.
If Gross Vehicle Weight Rating is over 14,000 lbs.:
For 5 years or 50,000 miles (gasoline engines), 5 years or
100,000 miles (2021 and earlier engine model year diesel
engines), and 5 years or 110,000 miles (2022 and later engine
model year diesel engines) (whichever occurs first). Warranty
coverage of 5 years or 50,000 miles (whichever occurs first)
applies for components whose failure would increase the
vehicle’s emissions of air conditioning refrigerants. Only for HDVs
designated as "vocational vehicles" on the underhood
"VEHICLE EMISSION CONTROL INFORMATION" label: Tire
defects that affect compliance with greenhouse gas
requirements are covered for 2 years or 24,000 miles, whichever
comes first.
33

8. Noise emissions warranty
NOISE EMISSIONS WARRANTY FOR CERTAIN LIGHT TRUCKS
Ford Motor Company warrants to the first person who purchases
this vehicle for purposes other than resale and to each
subsequent purchaser that this vehicle as manufactured by Ford,
was designed, built and equipped to conform at the time it left
Ford's control with all applicable U.S. EPA Noise Control
Regulations.
This warranty covers this vehicle as designed, built and equipped
by Ford Motor Company, and is not limited to any particular part,
component or system of the vehicle as manufactured by Ford.
Defects in design, assembly or in any part, component or system
of the vehicle as manufactured by Ford, which, at the time it left
Ford's control, caused noise emissions to exceed Federal
standards, are covered by this warranty for the life of the vehicle.
THE NOISE EMISSIONS WARRANTY OBLIGATIONS DO NOT
APPLY TO:
• loss of time, inconvenience, loss of use of the vehicle,commercial loss or, other consequential damages.
• any vehicle which is not covered by the U.S. EPA Medium and Heavy Trucks Noise Emission Standards (40 C.F.R. Part 205,
Subpart B). Among the non-covered vehicles are those lacking
a partially or fully enclosed operator's compartment, such as a
basic stripped chassis, those having a Gross Vehicle Weight
Rating of 10,000 pounds or less, and those sold outside the
United States and its territories. To the extent permitted by
law, THIS WARRANTY IS EXPRESSLY INSTEAD of any express
or implied warranty, condition, or guarantee, agreement, or
representation, by any person with respect to conformity of
this vehicle with the U.S. EPA Noise Control Regulations,
including ANY IMPLIED WARRANTY OF MERCHANTABILITY
OR FITNESS.
42