steering FORD C MAX 2008 1.G Service Manual

Downloaded from www.Manualslib.com manuals search engine All vehicles
1.Fully tighten the wheel nuts in thepattern shown.
2.Press the hub cap firmly with theball of the hand.
3.Stow the locking nut and thewheel brace safely.
4.Stow the jack and defective wheelin reverse order and secure them.
Note:Have the tightening torque ofthe wheel nuts and the tyre pressurechecked as soon as possible.
TYRE REPAIR KIT
Your vehicle may not have a sparetyre. In this case it will have anemergency tyre repair kit that can beused to repair one flat tyre.
The tyre repair kit is located in thespare wheel well.
General information
WARNINGS
Depending on the type andextent of tyre damage, sometyres can only be partially sealed ornot sealed at all. Loss of tyrepressure can affect vehicle handling,leading to loss of vehicle control.
Do not use the tyre repair kit ifthe tyre has already beendamaged as a result of being drivenunder inflated.
Do not try to seal damage otherthan that located within thevisible tread of the tyre.
Do not try to seal damage to thetyre’s sidewall.
The tyre repair kit seals most tyrepunctures [with a diameter of up tosix millimetres (1/4 inch)] totemporarily restore mobility.
Observe the following rules whenusing the kit:
•Drive with caution and avoidmaking sudden steering ordriving manoeuvres,especially if the vehicle is heavilyloaded or you are towing a trailer.
•The kit will provide you with anemergency temporary repair,enabling you to continue yourjourney to the next vehicle or tyredealer, or to drive a maximumdistance of 200 kilometres(125 miles).
•Do not exceed a maximumspeed of 80 km/h (50 mph).
217
Wheels and tyresE72573

Downloaded from www.Manualslib.com manuals search engine 17.Immediately drive approximatelythree kilometres (two miles) sothat the sealant can seal thedamaged area.
Note:When pumping in the sealantthrough the tyre valve, the pressuremay rise up to 6 bar (87 psi) but willdrop again after about 30 seconds.
WARNING
If you experience heavyvibrations, unsteady steeringbehaviour or noises while driving,reduce your speed and drive withcaution to a place where it is safe foryou to stop the vehicle. Recheck thetyre and its pressure. If the tyrepressure is less than 1.3 bar (19 psi)or if there are any cracks, bumps orsimilar damage visible, do notcontinue driving with this tyre.
Checking the tyre pressure
1.Stop the vehicle after drivingapproximately three kilometres(two miles). Check, and wherenecessary, adjust the pressure ofthe damaged tyre.
2.Attach the kit and read the tyrepressure from the pressure gaugeF.
3.If the pressure of the sealant-filledtyre is 1.3 bar (19 psi) or more,adjust it to the specified pressure.See Technical specifications(page 224).
4.Follow the inflation procedureonce again to top up the tyre.
5.Check the tyre pressure againfrom the pressure gauge F. If thetyre pressure is too high, deflatethe tyre to the specified pressureusing the pressure relief valve B.
6.Once you have inflated the tyre toits correct tyre pressure, movethe compressor switch H toposition 0, remove the powerplug G from the socket, unscrewthe hose C, fasten the valve capand replace the protective cap A.
7.Leave the sealant bottle K in thebottle holder E and store the kitaway safely in its original location.
8.Drive to the nearest tyre specialistto get the damaged tyre replaced.Before the tyre is removed fromthe rim, inform your tyre dealerthat the tyre contains sealant.Renew the kit as soon as possibleafter it has been used once.
Note:Remember that emergencyroadside tyre repair kits only providetemporary mobility. Regulationsconcerning tyre repair after usage oftyre repair kit may differ from countryto country. You should consult a tyrespecialist for advice.
WARNING
Before driving, make sure thetyre is adjusted to therecommended inflation pressure.See Technical specifications(page 224). Monitor the tyre pressureuntil the sealed tyre is replaced.
222
Wheels and tyres

Downloaded from www.Manualslib.com manuals search engine Voice and accept/reject button
Voice button1
Accept/Reject button2
The VOICE button is used to activateor switch off the Voice control.
On vehicles with an accept/rejectbutton, phone calls can be acceptedand rejected by pressing theappropriate button.
Note:Some audio units have theaccept/reject buttons on the frontbezel. These operate in the sameway.
Mode button on the steeringwheel
Mode button only
On vehicles without a VOICE button,the MODE button on the remotecontrol is used to activate or switchoff the voice control.
Note:You will not be able to use theMODE button to activate the voicecontrol during an incoming or activecall.
You will not be able to use the MODEbutton to control the audio system.
USING THE TELEPHONE
- VEHICLES WITHOUT:
NAVIGATION SYSTEM
This chapter describes the phonefunctions of the audio unit.
Note:Refer to your audio guide fordetails of the controls.
An active phone must be present.
Even if connected to the audio unit,your phone can still be used in theusual way.
Note:You can exit the phone menuby pressing any source button CD,AM/FM or AUX.
235
Telephone12E87662 E87663 E87664

Downloaded from www.Manualslib.com manuals search engine A
A/CSee: Climate control..........................107
About this handbook........................7ABSSee: Brakes.........................................158
ABS driving hintsSee: Hints on driving with ABS.........158
AccessoriesSee: Parts and accessories..................7
Adaptive front lighting system(AFS)...............................................68Adjusting the pedals.......................58Adjusting the steering wheel.........55Adjusting the windscreen washerjets...................................................62AFSSee: Adaptive front lighting system(AFS)..................................................68
Air conditioningSee: Climate control..........................107
Air vents..........................................107Alarm.................................................53Appendices...................................255Arming the alarm.............................53Automatic arming delay.....................53Interior sensors....................................53
Arming the engine immobiliser.....52ASLSee: Automatic speed limiter(ASL).................................................166
Audible warnings andindicators........................................94Automatic transmission......................94Electronic parking brake (EPB).........94Frost.......................................................94Key-in-ignition......................................94Key outside car....................................94Lights on................................................94Low fuel.................................................94Seat belt reminder...............................95
Audio control...................................55Mode.....................................................56Seek.......................................................56Volume..................................................56
Audio unit commands.................242CD Player/CD Changer....................242Radio...................................................244
Autolamps........................................65Automatic climate control.............111Air distribution......................................112Blower...................................................112Mono mode.........................................112Recirculated air...................................113Setting the temperature.....................111Switching off the automatic climatecontrol...............................................113Switching the air conditioning on andoff.......................................................113To switch mono mode back on.......112To switch mono mode off.................112Windscreen defrosting anddemisting..........................................113
Automatic speed limiter(ASL)..............................................166Principle of operation........................166
Automatic transmission................154Drive modes.......................................156Emergency park position releaselever..................................................156General information...........................154Hints on driving with an automatictransmission....................................156Selector lever positions.....................155
Auxiliary heater...............................114Auxiliary heater....................................116Fuel operated heater.........................116Programmable auxiliary heater........114
Auxiliary input (AUX IN)socket...........................................140Type 1...................................................140Type 2..................................................140
265
Index

Downloaded from www.Manualslib.com manuals search engine Manual transmission.....................154Reverse gear − 5-speedtransmission....................................154Reverse gear − 6-speedtransmission....................................154
Message centreSee: Information displays...................96
MirrorsSee: Heated windows and mirrors...114See: Windows and mirrors.................84
N
Navigation systemcommands..................................252
O
Occupant protection......................27Principle of operation..........................27
Oil checkSee: Engine oil check.......................200
Opening and closing thebonnet..........................................189Closing the bonnet............................189Opening the bonnet..........................189
P
Parking aid......................................162Principle of operation........................162
Parking aidSee: Using the parking aid................162
Parking brake.................................159All vehicles...........................................159
Parts and accessories......................7Look for the Ford logo on thefollowing parts ....................................8Now you can be sure that your Fordparts are Ford parts...........................7
Pedals...............................................58
Personalised settings.....................99Auxiliary heater programming..........100Car Setup menu..................................99Chime deactivation............................102Clock setting.......................................100ESP.......................................................100Language setting...............................100Units of measure................................100
Power steering fluid check.........202Vehicles with 1.4L Duratec-16V(Sigma) or 1.6L Duratec-16V(Sigma) or 1.6L Duratec-16V Ti-VCT(Sigma) engine...............................202Vehicles with 1.8L Duratec-HE (MI4)or 2.0L Duratec-HE (MI4) or 2.5LDuratec-ST (VI5) or 1.6LDuratorq-TDCi (DV) Diesel or 1.8LDuratorq-TDCi (Kent) Diesel or 2.0LDuratorq-TDCi (Kent) Dieselengine.............................................203
Programming the remotecontrol............................................35Reprogramming the unlockingfunction..............................................36
Q
Quick start.........................................10
R
Rear fog lamps................................65Rear seats......................................124Comfort seat system........................124Folding the seatbacks forward........125Folding the seats forward.................127Installing the seats..............................131Removing the seats..........................130Returning the seatbacks to theupright position...............................126Returning the seats to the seatingposition............................................129
270
Index

Downloaded from www.Manualslib.com manuals search engine Rear under floor storage..............168Rear window wiper andwashers..........................................61Intermittent wipe..................................61Rear window washer..........................62Reverse gear wipe...............................61
Refuelling.........................................151Remote control batterySee: Changing the remote controlbattery...............................................36
Remote control programmingSee: Programming the remotecontrol................................................35
Repairing minor paintdamage.......................................208Running-in.......................................173Brakes and clutch..............................173Engine..................................................173Tyres.....................................................173
S
Safety precautions........................149Seat back trays..............................138Seat belt height adjustment..........33Seats...............................................120Sitting in the correct position.......120Snow chainsSee: Using snow chains...................223
Speed controlSee: Cruise control............................164
Stability control...............................160Principle of operation........................160
Stability controlSee: Using stability control................161
Starter switchSee: Ignition switch.............................141
Starting a diesel engine................144Cold/hot engine.................................144Vehicles with the key freesystem.............................................145
Starting a petrol engine................142All vehicles...........................................142Except vehicles with a Flexfuelengine..............................................143Vehicles with a Flexfuel engine........143Vehicles with the key freesystem.............................................144
Starting the engine.........................141General information............................141
Status after a collision...................175Steering wheel lock.......................142Vehicles with keyless starting..........142Vehicles without keyless starting.....142
Steering wheel................................55Storage compartments................137Driver’s seat storage bin...................138Front storage compartment............137Storage area under the rear centreseat...................................................138
Sun blinds.......................................133Panoramic roof...................................133Side windows.....................................133
SunroofSee: Electric sunroof..........................116
Sun visors.......................................133Switching off the engine...............148Vehicles with a turbocharger...........148
Symbols glossary..............................7Symbols in this handbook.....................7Symbols on your vehicle.......................7
T
Technical specifications...............228Technical specifications...................228
Telephone commands................247Create a phonebook........................248Main settings......................................251Phone..................................................247Phone functions................................249
271
Index

Downloaded from www.Manualslib.com manuals search engine VentilationSee: Climate control..........................107
VentsSee: Air vents......................................107
VINSee: Vehicle identification number(VIN).................................................226
Voice control............................57, 241Principle of operation........................241
W
Warning lamps and indicators......90ABS warning lamp...............................90Airbag warning lamp...........................90Brake system and ABS warninglamps..................................................91Brake system warning lamp..............90Cruise control indicator.......................91Direction indicator................................91Doors open warning lamp..................91Engine systems fault warninglamp....................................................91Engine warning lamp...........................91Front fog lamp indicator......................91Frost warning lamp..............................92Glow plug indicator.............................92Headlamp indicator.............................92Ignition warning lamp..........................92Low fuel level warning lamp...............92Main beam indicator...........................92Maximum engine RPM warninglamp...................................................92Message indicator...............................92Oil pressure warning lamp.................93Power steering warning lamp...........93Rear fog lamp indicator......................93Seat belt reminder...............................93Stability control (ESP) indicator..........93
Warning triangle.............................174Washer fluid check.......................203Washers
See: Wipers and washers..................59
WashingSee: Cleaning the exterior...............207
Wheels and tyres...........................211General information............................211Technical specifications...................224
Windows and mirrors.....................84Windscreen washers......................61Windscreen wipers.........................59Automatic wiper system.....................61Autowipers...........................................59Intermittent wipe..................................59
Winter tyresSee: Using winter tyres....................223
Wipers and washers.......................59
273
Index