check engine FORD C MAX 2008 1.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine Introduction
About this handbook........................7
Symbols glossary..............................7
Parts and accessories......................7
Quick start
Quick start.........................................10
Child safety
Child seats........................................20
Child seat positioning......................21
Booster cushions............................23
ISOFIX anchor points......................24
Child safety locks............................26
Occupant protection
Principle of operation......................27
Fastening the seat belts.................31
Seat belt height adjustment..........33
Using seat belts duringpregnancy....................................33
Disabling the passengerairbag............................................33
Keys and remote
controls
General information on radiofrequencies..................................35
Programming the remotecontrol...........................................35
Changing the remote controlbattery...........................................36
Locks
Locking and unlocking...................40
Keyless entry...................................44
Global opening and closing...........50
Engine immobiliser
Principle of operation.....................52
Coded keys.....................................52
Arming the engine immobiliser.....52
Disarming the engineimmobiliser...................................52
Alarm
Arming the alarm.............................53
Disarming the alarm........................54
Steering wheel
Adjusting the steering wheel.........55
Horn..................................................55
Audio control...................................55
Voice control....................................57
Pedals
Adjusting the pedals.......................58
Wipers and washers
Windscreen wipers.........................59
Windscreen washers......................61
Rear window wiper andwashers.........................................61
Adjusting the windscreen washerjets.................................................62
Headlamp washers........................62
Checking the wiper blades...........63
Changing the wiper blades...........63
Lighting
Lighting control................................64
1
Table of contents

Downloaded from www.Manualslib.com manuals search engine Maintenance
General information......................188
Opening and closing thebonnet.........................................189
Engine compartment overview -1.6L Duratec-16V (Sigma)/1.6LDuratec-16V Ti-VCT (Sigma).....190
Engine compartment overview -1.8L Duratec-HE (MI4)/2.0LDuratec-HE (MI4).......................192
Engine compartment overview -1.6L Duratorq-TDCi (DV)Diesel...........................................194
Engine compartment overview -1.8L Duratorq-TDCi (Lynx)Diesel...........................................196
Engine compartment overview -2.0L Duratorq-TDCi (Puma)Diesel...........................................198
Engine oil dipstick - 1.6LDuratec-16V (Sigma)/1.6LDuratec-16V Ti-VCT (Sigma).....199
Engine oil dipstick - 1.8LDuratec-HE (MI4)/2.0LDuratec-HE (MI4).......................199
Engine oil dipstick - 1.6LDuratorq-TDCi (DV) Diesel......200
Engine oil dipstick - 1.8LDuratorq-TDCi (Lynx) Diesel....200
Engine oil dipstick - 2.0LDuratorq-TDCi (DW) Diesel.....200
Engine oil check............................200
Engine coolant check...................201
Brake and clutch fluid check......202
Power steering fluid check.........202
Washer fluid check.......................203
Technical specifications...............204
Vehicle care
Cleaning the exterior....................207
Cleaning the interior.....................208
Repairing minor paint damage....208
Vehicle battery
Battery care...................................209
Using booster cables...................209
Changing the vehicle battery......210
Wheels and tyres
General information.......................211
Changing a road wheel.................211
Tyre repair kit..................................217
Tyre care........................................223
Using winter tyres.........................223
Using snow chains.......................223
Technical specifications...............224
Vehicle identification
Vehicle identification plate...........226
Vehicle identification number(VIN).............................................226
Engine number - 1.6L Duratec-16V(Sigma)/1.6L Duratec-16V Ti-VCT(Sigma).......................................226
Engine number - 1.8L Duratec-HE(MI4)/2.0L Duratec-HE(MI4)............................................226
Engine number - 1.6LDuratorq-TDCi (DV) Diesel/2.0LDuratorq-TDCi (Puma)Diesel...........................................227
Engine number - 1.8LDuratorq-TDCi (Lynx) Diesel.....227
4
Table of contents

Downloaded from www.Manualslib.com manuals search engine CHILD SEATS
WARNINGS
Secure children that are lessthan 150 centimetres tall or lessthan 12 years of age in a suitable,approved child restraint, in the rearseat.
Original text according to ECER94.01: Extreme Hazard! Do notuse a rearward facing child restrainton a seat protected by an air bag infront of it!
Read and follow themanufacturer’s instructionswhen you are fitting a child restraint.
Do not modify child restraints inany way.
Do not hold a child on your lapwhen the vehicle is moving.
Do not leave unattendedchildren in your vehicle.
WARNINGS
If your vehicle has been involvedin an accident, have the childrestraints checked by properlytrained technicians.
Note:Mandatory use of childrestraints varies from country tocountry.
A choice of ECE approved childrestraints which have beenspecifically tested and approved foryour vehicle are available from yourDealer.
Child restraints for differentmass groups
Use the correct child restraint asfollows:
Baby safety seat
Secure children that weigh less than13 kilogrammes in a rearward facingbaby safety seat in the rear seat.
20
Child safetyE68916 E68918

Downloaded from www.Manualslib.com manuals search engine Fitting the passengerairbag deactivation switch
WARNING
If you need to fit a child restrainton a seat protected by anoperational airbag in front of it, havea passenger airbag deactivationswitch fitted. Ask your dealer forfurther information.
Note:The key switch is located inthe glove compartment with anairbag deactivation lamp in theinstrument panel.
If the airbag warning lamp illuminatesor flashes when you are driving, thisindicates a malfunction. SeeWarning lamps and indicators(page 90). Remove the child restraintand have the system checkedimmediately.
Disabling the passengerairbag
DisabledA
EnabledB
Turn the switch to position A.
When you switch the ignition on,check that the passenger airbagdeactivation warning lamp illuminates.
Enabling the passengerairbag
WARNING
Make sure that the passengerairbag is enabled when you arenot using a child restraint on the frontpassenger seat.
Turn the switch to position B.
34
Occupant protectionABE71312

Downloaded from www.Manualslib.com manuals search engine Locking the vehicle
WARNING
The vehicle does not lock itselfautomatically. If no lockingbutton is pressed, the vehicle willremain unlocked.
Note:Before leaving the vehicle,ensure that the ignition switch ispulled out. See Ignition switch(page 141).
Note:A valid passive key must belocated within the detection range ofthe respective door. If locking fromthe tailgate, the passive key must bewithin the tailgate detection range.
Note:Once activated, the vehiclewill remain locked for approximatelythree seconds, even if the passivekey is within the detection rangeduring this delay period. This is toallow you to pull a door handle andcheck if the vehicle is locked. Whenthe delay period is over, the doorscan be opened again, provided thepassive key is within the respectivedetection range. The delay periodcan be set to zero by an expert.
Note:If a passive key is left insidethe vehicle PASSIVE KEY LEFTINSIDE appears in the informationdisplay. Remove the passive keyfrom the vehicle interior. All passivekeys left inside the vehicle when it islocked will be disabled.
To activate central locking and armthe alarm:
•Press the locking button on oneof the front doors or the tailgateonce.
•On vehicles without doublelocking, the direction indicatorswill flash twice as confirmation.
To activate double locking, to armthe alarm and the interior sensors:
•Press the locking button on oneof the front doors or the tailgatetwice within three seconds.
•The direction indicators will flashtwice as confirmation.
Deactivating the key freefunction
The key free function can bedeactivated using the informationdisplay. See Information displays(page 96).
Once it is deactivated:
•the vehicle can only be lockedand unlocked using the spare keyin the lock cylinder on the driver’sdoor or using the buttons on thepassive key.
•the engine can only be startedwith the spare key.
49
LocksE78282

Downloaded from www.Manualslib.com manuals search engine PRINCIPLE OF
OPERATION
The engine immobiliser is a theftprotection system that preventssomeone from starting the enginewith an incorrectly coded key.
CODED KEYS
Note:Do not shield your keys withmetal objects. This may prevent thereceiver from recognising your keyas a valid one.
Note:Have all of your remainingkeys erased and recoded if you losea key. Ask your dealer for furtherinformation. Have replacement keysrecoded together with your existingkeys.
If you lose a key, you can obtain areplacement from your Ford Dealer.If possible, provide them with the keynumber from the tag provided withthe original keys. You can also obtainadditional keys from your FordDealer.
ARMING THE ENGINE
IMMOBILISER
The engine immobiliser is armedautomatically a short time after youhave switched the ignition off.
The indicator in the instrument clusterwill flash to confirm that the systemis operating.
DISARMING THE ENGINE
IMMOBILISER
The engine immobiliser is disarmedautomatically when you switch theignition on with a correctly coded key.
The indicator in the instrument clusterwill come on for approximately threeseconds and then go out. If theindicator stays on for one minute orflashes for approximately one minuteand then repeatedly at irregularintervals, your key has not beenrecognised. Remove the key and tryagain.
If you attempt to start the engine withan incorrectly coded key, you willneed to wait for approximately 20seconds before attempting to startthe engine again with a correctlycoded key.
If you are unable to start the enginewith a correctly coded key, thisindicates a malfunction. Have theimmobiliser checked immediately.
52
Engine immobiliser

Downloaded from www.Manualslib.com manuals search engine WARNING
Do not operate the washer formore than 10 seconds at a time,and never when the reservoir isempty.
Note:On some models, to preventthe washer fluid reservoir frombecoming empty too quickly, theheadlamp washer will not beactivated with every press of thebutton. For a period of ten minutesafter activation, the washer will onlybe activated again with every fourthpress of the button.
The headlamp washers operatewhen the exterior lights are switchedon and the windscreen washer isused. The system is supplied fromthe washer fluid reservoir.
CHECKING THE WIPER
BLADES
Run the tip of your fingers over theedge of the blade to check forroughness.
Clean the wiper blade lips with waterapplied with a soft sponge.
CHANGING THE WIPER
BLADES
Windscreen wiper blades
Lift the wiper arm. Position the wiperblade at a right angle to the wiperarm. Remove the blade from the armand replace it.
Rear window wiper blades
Lift the wiper arm and position thewiper blade at a right angle to thewiper arm. To remove, press theretaining clip, disengage the wiperblade and pull it off the arm in theopposite direction.
63
Wipers and washersE66644 E78156

Downloaded from www.Manualslib.com manuals search engine A message will appear in theinformation display and the headlampindicator flashes if the systemmalfunctions. See Informationmessages (page 103). Theheadlamps will move to a fixedcentral or dipped position. Have thesystem checked as soon as possible.
69
Lighting

Downloaded from www.Manualslib.com manuals search engine CHANGING A BULB
WARNINGS
On vehicles fitted with Xenonheadlamps, have the headlampbulbs changed by an expert. Thereis a risk of injury due to high voltage.
During operation, the bulbs andtheir surroundings get hot.Switch off the lights and let the bulbscool down before replacing them.
Always switch off lights and ignitionbefore replacing any bulb.
Never touch the glass of the bulbs.Fit only bulbs having a UV filter.Always replace a faulty bulb with anew one of the same type. Afterreplacing a bulb, check that the lightsoperate correctly.
Headlamps, side lamps,direction indicators
Note:It is necessary to remove theheadlamp assembly to remove anyof the bulbs.
Removing the headlampassembly
Open the bonnet.
Remove the screw.
WARNING
When re-installing the lampassembly, make sure that thewiring connectors and retaining clipsare engaged properly.
Press down the retaining clips at therear of the lamp assembly using ascrewdriver and carefully pull out thelamp assembly.
74
LightingE78106 E78107

Downloaded from www.Manualslib.com manuals search engine Brake lamp P21 wattA
Direction indicator PY21 watt(orange)B
Reversing lamp P21 wattC
Rear fog lamp/tail lampP21/4 WattD
Note:Vehicles may not have a taillamp if an LED board is fitted. TheLED board is not a serviceable item,please consult your dealer if this fails.
Turn the bulb anticlockwise underslight pressure and remove it.Replace the bulb.
Install in the reverse order. Afterinstallation, check that the lightsoperate correctly.
Central brake lamp
Consult an expert.
Number plate lamp
5 watt festoon
Loosen the two screws, and removethe lamp assembly.
Install in the reverse order.
Interior and reading lamps
Switch off the lights.
Insert a flat-bladed screwdriver intothe recess between the body of theunit and the lens at the opposite sideto the switches. Gently prise out thelens a short way. Take hold of theside of the lens and lift it off the unit.
81
LightingE78126 E72556 E7812812