fuel cap FORD CONTOUR 1998 2.G Owners Manual

Instrumentation
9 O/D Off indicator
(Automatic transaxle only)
Illuminates and remains
illuminated when the transaxle
control switch (TCS) on the end of
the gearshift lever is pressed and
overdrive is turned off.
Indicates the status of the
transaxle and will flash steadily if a
malfunction is detected. If the
flashing persists, have your
transaxle serviced by your dealer
or a qualified service technician as
soon as possible.
If the condition persists, your
transaxle may be damaged.
TRACTION
CONTROLO/D
OFF
Check engine
Illuminates when the ignition is
turned on and the engine is off.
Also illuminates when the engine’s
emission control system requires
service or if the fuel filler cap is
not fitted correctly.CHECK
ENGINE
CHECK
ENGINELow fuel
Illuminates when the fuel level is
low.
CDW IIA2Instrum_en C 5/15/97 8:42 PM Page 9

Maintenance and care
160
Automotive fuels can cause
serious injury or death if
misused or mishandled.
IMPORTANT FUEL
INFORMATON
Important safety precautions
Do not overfill the fuel tank.
The pressure in an overfilled
tank may cause leakage and lead
to fuel spray and fire.
If you do not use the proper
fuel cap, the pressure in the
fuel tank can damage the fuel
system or cause it to work
improperly in a collision.
The fuel system may be
under pressure. If the fuel
cap is venting vapor or if you hear
a hissing sound, wait until it stops
before completely removing the
cap.
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 160

Maintenance and care
161 Observe the following guidelines
when handling automotive fuel:
•Extinguish all smoking materials
and any open flames before
fueling your vehicle.
•Always turn off the vehicle
before fueling.
•Make sure the fuel cap is
correctly fitted after fueling.
Failure to do so may cause the on
board diagnostic system to
illuminate the CHECK ENGINE
light.
•Automotive fuels can be harmful
or fatal if swallowed. If fuel is
swallowed, call a physician
immediately, even if no
symptoms are immediately
apparent. The toxic effects of
fuel may not be visible for hours.
•Fuels can also be harmful if
absorbed through the skin. If fuel
is splashed on the skin, promptly
remove contaminated clothing
and wash skin thoroughly with
soap and water.
•If fuel is splashed in the eyes,
remove contact lenses (if worn),
flush with water for 15 minutes
and seek medical attention.
•Be particularly careful if you are
taking “Antabuse” or other forms
of disulfiram for the treatment of
alcoholism. Breathing gasoline
vapors or skin contact could
cause an adverse reaction.
Consult a physician immediately.
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 161

Capacities and specifications
186
*Refer to Vehicle Emission Control Information (VECI) decal for spark plug and gap specifications.
**If a spark plug is removed for examination, it must be reinstalled in the same cylinder.
If a spark plug needs to be replaced, use only spark plugs with the service part number suffix
letter “FE” as shown on the engine decal.
Motorcraft parts
Component
Spark plug*
Air filter
Passenger compartment
air filter
Fuel filter
Oil filter
Battery
PCVvalve
Crankcase ventilation
filter2.0 litre engine
AZFS-22F # 1+2**
AZFS-22FE# 3+4
FA-1612
FP4
FG-800A
FL-2005
BXT-40R
EV-224
FA-1621
2.5 litre engine
AWSF-32F
FA-1613
FP4
FG-800A
FL-820
BXT-40R
EV-152
—
Part number
CDW_VB1-5_Caps_en_C 5/15/97 8:58 PM Page 186

Capacities and specifications
187
* Total capacity
** with automatic transaxle
Engine oil
- with filter
- without
Manual transaxle2.6 l (2.7 qts)
Automatic transaxle
with oil cooler
Power steering
Cooling system with heating
Windshield washer fluid
Fuel tank
Braking system4.25 l (4.5 qts)
3.75 l (4.0 qts)
8.5 l (9.0 qts.)
6.6 l (7.0 qts)*
7.1 l (7.5 qts)**
Fill to MAX mark
Fill to top of reservoir
61.5 l (16.2 gallons)
Fill to MAX mark5.5 l (5.8 qts)
5.0 l (5.3 qts)
9.6 l (10.2 qts)
9.5 l (10.0 qts)*
9.7 l (10.2 qts)**
Capacities2.0 litre
engine2.5 litre
engine
CDW_VB1-5_Caps_en_C 5/15/97 8:58 PM Page 187

Capacities and specifications
189 Engine data
* Mechanical valve adjuster
2.0 litre
Engine2.5 litre
Engine
19882544
96 (125)
5500125 (170)
6250
176 (130)
4000220 (162)
4250
61506700
63756925
800±50
(880±50)725±50
(725±50)
1-3-4-21-4-2-5-3-6
1.3
Electronically controlled Idle speed
(manual transaxle)Engine
cm
3Capacity
kW(HP)
at rpm Power output
Nm (lb-ft)
at rpm Max. torque
Fuel required87 Octane
rpm Continuous engine
speed
rpm Max. intermittent
engine speed
rpm
Mixture preparation
Injection system
Firing order
mm
Spark plug gap
Ignition system
0.14 mm
0.30 mm Valve Inlet
clearancesExhaustHydraulic valve
adjusters 0.11-0.18*
0.27-0.34*
CDW_VB1-5_Caps_en_C 5/15/97 8:58 PM Page 189

CPage
Child safety restraints
built-in child seat . . . . . . . . . . .68
child safety seats . . . . . . . . . . . .74
children and safety belts . . .64, 66
Child safety seats
and air bags . . . . . . . . . . . . . . . .59
attaching with tether straps . . .77
automatic locking mode . . . . . .52
Childproof safety locks . . . . . . . .38
Chimes . . . . . . . . . . . . . . . . . . . . .13
Circuit breakers . . . . . . . . . . . . .112
Cleaning your vehicle
engine compartment . . . . . . . .182
exterior lamps . . . . . . . . . . . . .183
fabric . . . . . . . . . . . . . . . . . . . .184
instrument panel . . . . . . . . . . .184
plastic exterior parts . . . . . . . .183
safety belts . . . . . . . . . . . . . . .185
wheels . . . . . . . . . . . . . . . . . . .181
wiper blades . . . . . . . . . . . . . .183
Climate control system
air conditioning . . . . . . . . . . . . .24
controlling airflow . . . . . . . . . . .23
defrosting . . . . . . . . . . . . . . . . . .26
temperature . . . . . . . . . . . . . . . .23
vents . . . . . . . . . . . . . . . . . . . . . .22
Clock . . . . . . . . . . . . . . . . . . . . . .21
Clutch
operation . . . . . . . . . . . . . . . . . .96
recommended shift speeds . . . .97
Cold engine starting . . . . . . . . . .85
Controls
instrument panel . . . . . . . . . . . .17
mirrors . . . . . . . . . . . . . . . . . . . .20
power seats . . . . . . . . . . . . . . . .48
steering column . . . . . . . . . . . . .27DPage
Daytime running lights . . . . . . . .18
Defects, reporting . . . . . . . . . . .192
Defrost
rear window . . . . . . . . . . . . . . . .19
windshield . . . . . . . . . . . . . . . . .26
Dipstick, engine oil . . . . . . . . . .133
Door mounted controls . . . . . . . .37
Driving under special conditions
heavy load . . . . . . . . . . . . . . . .102
towing a trailer . . . . . . . . . . . .103
E
Electrical system
fuses . . . . . . . . . . . . . . . . . . . . .112
Emergencies, roadside
fuel pump shut-off switch . . . .110
jump starting . . . . . . . . . . . . . .124
towing . . . . . . . . . . . . . . . . . . .127
Emergency brake (see Parking
brake)
Emission control system . . . . . .166
Engine
check engine warning light . . . . .9
fuel pump shut-off switch . . . .110
lubricant specifications . . . . . .188
preparing to start . . . . . . . . . . .82
refill capacities . . . . . . . . . . . .187
starting . . . . . . . . . . . . . . . . . . . .85
Engine block heater . . . . . . . . . .86
Engine coolant
checking and adding . . . . . . . .139
disposal . . . . . . . . . . . . . . . . . .141
low coolant warning light . . . . . .8
refilll capacities . . . . . . . . . . . .187
specifications . . . . . . . . . . . . . .188
Engine fan . . . . . . . . . . . . . . . . .129
Index
194
CDW_Index_en_C 5/15/97 8:59 PM Page 194

Index
195 EPage
Engine oil
changing oil and filter . . . . . . .136
checking and adding . . . . . . . .135
dipstick . . . . . . . . . . . . . . . . . .133
disposal . . . . . . . . . . . . . . . . . .137
engine oil pressure
warning light . . . . . . . . . . . . . . .11
filter specifications . . . . . . . . .186
refill capacities . . . . . . . . . . . .187
specifications . . . . . . . . . . . . . .188
Exhaust fumes . . . . . . . . . . .81, 166
F
Fan (see Engine fan)
Flasher, hazard . . . . . . . . . .29, 110
Flashing the lights . . . . . . . . . . . .30
Floor mats . . . . . . . . . . . . . . . . . .40
Fluid refill capacities . . . . . . . . .187
Foglamps . . . . . . . . . . . . . . .18, 172
Fuel
calculating fuel economy . . . .165
capacity . . . . . . . . . . . . . . . . . .187
choosing the right fuel . . . . . .162
consumption . . . . . . . . . . . . . .109
fuel gauge . . . . . . . . . . . . . . . . .16
low fuel warning light . . . . . . . . .9
octane rating . . . . . . . . . . . . . .163
quality . . . . . . . . . . . . . . . . . . .164
running out of fuel . . . . . . . . .166
safety information relating
to automotive fuels . . . . . . . . .160
Fuel pump shut-off switch . . . .110
Fuse panels
engine compartment . . . . . . . .113
instrument panel . . . . . . . . . . .115FPage
Fuses
charts . . . . . . . . . . . . . . . .114, 117
checking and replacing . . . . . .112
G
Gas mileage (see Fuel economy)
Gauges
engine coolant temperature . . .15
fuel . . . . . . . . . . . . . . . . . . . . . . .16
odometer . . . . . . . . . . . . . . . . . .15
speedometer . . . . . . . . . . . . . . .15
trip odometer . . . . . . . . . . . . . .15
GAWR
(Gross Axle Weight Rating) . . .100
Gearshift . . . . . . . . . . . . . . . .90, 96
GVWR
(Gross Vehicle Weight Rating) .100
H
Hazard flashers . . . . . . . . . .29, 110
Head restraints . . . . . . . . . . . . . .47
Headlamps
aiming . . . . . . . . . . . . . . . . . . .176
bulb specifications . . . . . . . . .175
daytime running light . . . . . . . .18
flashing . . . . . . . . . . . . . . . . . . .30
high beam . . . . . . . . . . . . . . . . .30
replacing bulbs . . . . . . . . . . . .171
turning on and off . . . . . . . . . . .17
warning chime . . . . . . . . . . . . . .13
High beams
indicator light . . . . . . . . . . . . . . .7
operation . . . . . . . . . . . . . . . . . .30
CDW_Index_en_C 5/15/97 8:59 PM Page 195

Index
197 MPage
Maintenance (see Servicing)
Manual transaxle
backing up (reverse) . . . . . . . . .98
clutch . . . . . . . . . . . . . . . . . . . . .96
fluid, capacity . . . . . . . . . . . . .187
fluid, checking and adding . . .138
shift speeds . . . . . . . . . . . . . . . .97
Mileage, calculating fuel
economy . . . . . . . . . . . . . . . . . . .165
Mirrors
side view mirrors (power) . . . .20
Motorcraft parts . . . . . . . . . . . .186
N
National Highway Traffic Safety
Administration . . . . . . . . . . . . . .192
O
Octane rating . . . . . . . . . . . . . . .163
Odometer . . . . . . . . . . . . . . . . . . .15
Oil (see Engine oil)
Oil filter . . . . . . . . . . . . . . .136, 187
On-board diagnostic (OBDII)
system . . . . . . . . . . . . . . . . . . . .169
Overdrive . . . . . . . . . . . . . . . . .9, 93
Overhead controls . . . . . . . . . . . .36
P
Panel dimmer control . . . . . . . . .19
Panic alarm, remote entry sytem42
Parking brake . . . . . . . . . . . . . . .89
Parts (see Motorcraft parts) . . .186
Passenger compartment
air filter (see Cabin air filter) . .150
Passive Anti-Theft
System (PATS) . . . . . . . . . . . . . .44PPage
Power distribution box
(see Fuses)
Power door locks . . . . . . . . . . . . .37
Power features
mirrors . . . . . . . . . . . . . . . . . . . .20
seats . . . . . . . . . . . . . . . . . . . . . .48
sunroof . . . . . . . . . . . . . . . . . . . .36
windows . . . . . . . . . . . . . . . . . . .37
Power steering
fluid, checking and adding . . .143
fluid, refill capacity . . . . . . . . .187
fluid, specification . . . . . . . . . .188
R
Radio (see Audio system) . . . . . .21
Rear window defroster . . . . . . . .19
Refill capacities for fluids . . . . .187
Relays . . . . . . . . . . . . . . . . . . . . .112
Remote control
luggage compartment . . . . . . . .39
Remote entry system
locking/unlocking doors . . . . . .41
opening the trunk . . . . . . . . . . .42
panic alarm . . . . . . . . . . . . . . . .42
replacing the batteries . . . . . . .42
replacement/additional
transmitters . . . . . . . . . . . . . . . .43
Repairing paint chips . . . . . . . .181
Reporting safety defects . . . . . .192
Restraints, safety . . . . . . . . . . . . .50
Rotating the tires . . . . . . . . . . . .155
CDW_Index_en_C 5/15/97 8:59 PM Page 197

Filling station information
UNLEADEDFUELONLY
Octane 87
61.5 litres (16.3 gallons)
Use Motorcraft 5W-30 Formula E
Fuel Economy Motor Oil, Ford
specification WSS-M2C153-G.
Refer to Safety Compliance
Certification label on driver’s door
pillar
Pull handle under the left side of
the instrument panel
Left rear of vehicle FuelFuel tank capacity
Engine oil
Tire size and pressure
Hood release location
Fuel filler location
CDW_Info_Fill_en_C 5/15/97 9:00 PM Page 2