power steering FORD CONTOUR 1998 2.G Owners Manual

4
Instrumentation
Page 30
Turn signal/high beam
Page 6
Instrument clusterPage 29
Hazard flasher
control
Page 31
Windshield
wiper/washer
control
Page 132
Hood release
Page 17
Headlamp control/
Foglamp control*Page 28
Tilt steering
wheel leverPage 27
Ignition switch
Page 32
Speed control*
Page 29
Horn Page 19
Rear window
defroster control*
Page 20
Power mirrors*
CHECK
ENGINE TRACTION
CONTROLO/D
OFF
Res
Set
Acc
CoastOff
On
NORMALEF 1
/
2
UNLEADED FUEL ONLY
BRAKE000123
000010 20 3040506070
80
90
100
110
120
130MPH
20 406055
80120 100
140
160
180
20012
03
x 1000
4
5
6
7
8
MIRRORS
CDW IIA2Instrum_en C 5/15/97 8:42 PM Page 4

Controls and features
28Tilt steering
Pull the locking lever on the
steering column cover up to adjust
the steering column position.
Secure the wheel by pushing the
locking lever down.
Never adjust the steering
wheel while the vehicle is
moving.
HM:
I0 20
OFF LOPNL/FLR
PANEL
A/CFLOOR
DEF FLR
DEF
MAX
A/C HI/
POWERAUDIOAM/FM
SCAN
SEEK 312645ANSSIDE1-2EJECTVOLUME
000123
000010 20 3040506070
80
90
100
110
120
130MPH20 406055
80120 100
140
160
180
200EF 1
/
2UNLEADED FUEL ONLY
12
03
x 1000
4
5
6
7
8
NORMALBRAKE
CHECK
ENGINE TRACTION
CONTROLO/D
OFF
MIRRORS
CDW IIIC3Controls en C 5/15/97 8:44 PM Page 28

Driving
105 Preparing to tow
Use the proper equipment for
towing a trailer and make sure that
it is properly attached to your
vehicle. See your dealer or a
reliable trailer retailer if you
require assistance.
Auxiliary coolers are recommended
for the power steering system and
automatic transaxle system if you
are planning on:
•Traveling farther than 80 km
(50miles).
•Towing in hilly terrain.
•Towing frequently.
Towing trailers beyond the
maximum recommended
gross trailer weight exceeds the
limit of the vehicle and could
result in engine damage, transaxle
damage, structural damage, loss of
control, and personal injury.
Do not exceed the maximum loads
listed on the Safety Compliance
Certification Label. For load
specification terms found on the
label, refer to Loading your
vehiclein this chapter. Remember
to figure in the tongue load of your
loaded vehicle when figuring the
total weight.
CDW IVB1-10Driving en C 5/15/97 8:52 PM Page 105

Maintenance and care
133 For ease of identification, all filler caps and the engine oil dipstick are
marked yellow/black. 2.0 litre EFI-engine compartment
Power
steering
reservoirEngine
coolant
reservoirAutomatic
transaxle
dipstick
(if equipped)Brake fluid
reservoir
BatteryWindshield
washer fluid
reservoirEngine oil
dipstickPower
distribution
box
Air
cleaner
Engine oil
filler cap
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 133

Maintenance and care
134
Power
steering
reservoirEngine
coolant
reservoir 2.5 litre EFI-engine compartment
For ease of identification, all filler caps and the engine oil dipstick are
marked yellow/black.Air
cleanerBrake fluid
reservoirAutomatic
transaxle
dipstick
(if equipped)
BatteryWindshield
washer fluid
reservoirEngine oil
dipstickPower
distribution
boxEngine oil
filler cap
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 134

Maintenance and care
143
Checking and adding power
steering fluid
Switch off the engine. With the
steering system at normal
operating temperature, the fluid
level should come up to the MAX
mark.
If the fluid level drops below the
MIN mark, add the specified fluid.
Refer to the Capacities and
specificationschapter.
Severe winter climate
If you drive in extremely cold
climates (less than -36°C [-34°F]),
it may be necessary to increase the
coolant concentration above 50%.
Refer to the chart on the coolant
container to ensure the coolant
concentration in your vehicle is
such that the coolant will not
freeze at the temperature level in
which you drive during the winter
months. Never increase the engine
coolant concentration above 60%.
Leave a 50/50 mixture of engine
coolant and water in your vehicle
year-round in non-extreme
climates.
MAX
MIN
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 143

Capacities and specifications
187
* Total capacity
** with automatic transaxle
Engine oil
- with filter
- without
Manual transaxle2.6 l (2.7 qts)
Automatic transaxle
with oil cooler
Power steering
Cooling system with heating
Windshield washer fluid
Fuel tank
Braking system4.25 l (4.5 qts)
3.75 l (4.0 qts)
8.5 l (9.0 qts.)
6.6 l (7.0 qts)*
7.1 l (7.5 qts)**
Fill to MAX mark
Fill to top of reservoir
61.5 l (16.2 gallons)
Fill to MAX mark5.5 l (5.8 qts)
5.0 l (5.3 qts)
9.6 l (10.2 qts)
9.5 l (10.0 qts)*
9.7 l (10.2 qts)**
Capacities2.0 litre
engine2.5 litre
engine
CDW_VB1-5_Caps_en_C 5/15/97 8:58 PM Page 187

Capacities and specifications
188
ItemFord part name
or equivalent
High performance
DOT 3 brake fluid
Premium engine
coolant
Motorcraft motor
oil 5W-30 super
premium
MERCON
®
power steering
fluid
Motorcraft
MERCON
®ATF
Ultra-clear
windshield washer
concentrate
Ford
part number
C6AZ-19542-AB
E2FZ-19549-AA
CXC-8-B*
XO-5W30-QSP
E6AZ-19582-AA
XT-2-QDX
C9AZ-19550-AA
or
C9AZ-19550-BA
Ford
specification
ESA-M6C25-A
WSE-97B44-A
American Petroleum
Institute Certification
Mark and
WSS-M2C153-G
MERCON®
MERCON®
ESR-M17P5-A Brake fluid
Engine coolant
Engine oil
Power steering
fluid
Transaxle fluid
automatic/
5-speed manual
Windshield
washer
fluid
Lubricant Specifications
CDW_VB1-5_Caps_en_C 5/15/97 8:58 PM Page 188

CPage
Child safety restraints
built-in child seat . . . . . . . . . . .68
child safety seats . . . . . . . . . . . .74
children and safety belts . . .64, 66
Child safety seats
and air bags . . . . . . . . . . . . . . . .59
attaching with tether straps . . .77
automatic locking mode . . . . . .52
Childproof safety locks . . . . . . . .38
Chimes . . . . . . . . . . . . . . . . . . . . .13
Circuit breakers . . . . . . . . . . . . .112
Cleaning your vehicle
engine compartment . . . . . . . .182
exterior lamps . . . . . . . . . . . . .183
fabric . . . . . . . . . . . . . . . . . . . .184
instrument panel . . . . . . . . . . .184
plastic exterior parts . . . . . . . .183
safety belts . . . . . . . . . . . . . . .185
wheels . . . . . . . . . . . . . . . . . . .181
wiper blades . . . . . . . . . . . . . .183
Climate control system
air conditioning . . . . . . . . . . . . .24
controlling airflow . . . . . . . . . . .23
defrosting . . . . . . . . . . . . . . . . . .26
temperature . . . . . . . . . . . . . . . .23
vents . . . . . . . . . . . . . . . . . . . . . .22
Clock . . . . . . . . . . . . . . . . . . . . . .21
Clutch
operation . . . . . . . . . . . . . . . . . .96
recommended shift speeds . . . .97
Cold engine starting . . . . . . . . . .85
Controls
instrument panel . . . . . . . . . . . .17
mirrors . . . . . . . . . . . . . . . . . . . .20
power seats . . . . . . . . . . . . . . . .48
steering column . . . . . . . . . . . . .27DPage
Daytime running lights . . . . . . . .18
Defects, reporting . . . . . . . . . . .192
Defrost
rear window . . . . . . . . . . . . . . . .19
windshield . . . . . . . . . . . . . . . . .26
Dipstick, engine oil . . . . . . . . . .133
Door mounted controls . . . . . . . .37
Driving under special conditions
heavy load . . . . . . . . . . . . . . . .102
towing a trailer . . . . . . . . . . . .103
E
Electrical system
fuses . . . . . . . . . . . . . . . . . . . . .112
Emergencies, roadside
fuel pump shut-off switch . . . .110
jump starting . . . . . . . . . . . . . .124
towing . . . . . . . . . . . . . . . . . . .127
Emergency brake (see Parking
brake)
Emission control system . . . . . .166
Engine
check engine warning light . . . . .9
fuel pump shut-off switch . . . .110
lubricant specifications . . . . . .188
preparing to start . . . . . . . . . . .82
refill capacities . . . . . . . . . . . .187
starting . . . . . . . . . . . . . . . . . . . .85
Engine block heater . . . . . . . . . .86
Engine coolant
checking and adding . . . . . . . .139
disposal . . . . . . . . . . . . . . . . . .141
low coolant warning light . . . . . .8
refilll capacities . . . . . . . . . . . .187
specifications . . . . . . . . . . . . . .188
Engine fan . . . . . . . . . . . . . . . . .129
Index
194
CDW_Index_en_C 5/15/97 8:59 PM Page 194

Index
197 MPage
Maintenance (see Servicing)
Manual transaxle
backing up (reverse) . . . . . . . . .98
clutch . . . . . . . . . . . . . . . . . . . . .96
fluid, capacity . . . . . . . . . . . . .187
fluid, checking and adding . . .138
shift speeds . . . . . . . . . . . . . . . .97
Mileage, calculating fuel
economy . . . . . . . . . . . . . . . . . . .165
Mirrors
side view mirrors (power) . . . .20
Motorcraft parts . . . . . . . . . . . .186
N
National Highway Traffic Safety
Administration . . . . . . . . . . . . . .192
O
Octane rating . . . . . . . . . . . . . . .163
Odometer . . . . . . . . . . . . . . . . . . .15
Oil (see Engine oil)
Oil filter . . . . . . . . . . . . . . .136, 187
On-board diagnostic (OBDII)
system . . . . . . . . . . . . . . . . . . . .169
Overdrive . . . . . . . . . . . . . . . . .9, 93
Overhead controls . . . . . . . . . . . .36
P
Panel dimmer control . . . . . . . . .19
Panic alarm, remote entry sytem42
Parking brake . . . . . . . . . . . . . . .89
Parts (see Motorcraft parts) . . .186
Passenger compartment
air filter (see Cabin air filter) . .150
Passive Anti-Theft
System (PATS) . . . . . . . . . . . . . .44PPage
Power distribution box
(see Fuses)
Power door locks . . . . . . . . . . . . .37
Power features
mirrors . . . . . . . . . . . . . . . . . . . .20
seats . . . . . . . . . . . . . . . . . . . . . .48
sunroof . . . . . . . . . . . . . . . . . . . .36
windows . . . . . . . . . . . . . . . . . . .37
Power steering
fluid, checking and adding . . .143
fluid, refill capacity . . . . . . . . .187
fluid, specification . . . . . . . . . .188
R
Radio (see Audio system) . . . . . .21
Rear window defroster . . . . . . . .19
Refill capacities for fluids . . . . .187
Relays . . . . . . . . . . . . . . . . . . . . .112
Remote control
luggage compartment . . . . . . . .39
Remote entry system
locking/unlocking doors . . . . . .41
opening the trunk . . . . . . . . . . .42
panic alarm . . . . . . . . . . . . . . . .42
replacing the batteries . . . . . . .42
replacement/additional
transmitters . . . . . . . . . . . . . . . .43
Repairing paint chips . . . . . . . .181
Reporting safety defects . . . . . .192
Restraints, safety . . . . . . . . . . . . .50
Rotating the tires . . . . . . . . . . . .155
CDW_Index_en_C 5/15/97 8:59 PM Page 197