engine coolant FORD CONTOUR 2000 2.G User Guide

Maintenance and care
175 • A large amount of water without
engine coolant may be added, in
case of emergency, to reach a
vehicle service location. In this
instance, the cooling system must
be drained and refilled with a 50/50
mixture of engine coolant and
distilled water as soon as possible.
Water alone (without engine
coolant) can cause engine damage
from corrosion, overheating or
freezing.
•Do not use alcohol or
methanol or any engine
coolants mixed with alcohol or
methanol antifreeze (coolant).
Alcohol and other liquids can cause
engine damage from overheating or
freezing.
•Do not add extra inhibitors
or additives to the coolant.
These can be harmful and
compromise the corrosion
protection of the engine coolant.
•Do not mix with recycled
coolant unless the bottle label
states compliance with Ford
specification ESE-M97B44-A.
31CMCen 17.6.99 11:15 Uhr Seite 175

Maintenance and care
1761. Before you begin, turn the
engine off and let it cool.
2. When the engine is cool, wrap a
thick cloth around the coolant
pressure relief cap on the coolant
reservoir (an opaque plastic
bottle). Slowly turn the cap
counterclockwise (left) until the
pressure begins to release.
3. Step back while the pressure
releases (you may hear a hissing
sound).
4. When you are sure that all the
pressure has been released from
the cooling system, use the cloth to
turn the cap counterclockwise and
remove it.
5. Fill the coolant reservoir slowly
with the proper coolant mixture
(see above) to within the “cold full“
or the “cold fill range“ level on the
reservoir.
6. Replace the cap. Turn until
tightly installed. (Cap must be
tightly installed to prevent coolant
loss.)
To avoid personal injury,
make sure the engine is cool
before unscrewing the coolant
pressure relief cap. The cooling
system is under pressure; steam
and hot liquid can come out
forcefully when the cap is
loosened slightly.
MAX
MIN
31CMCen 17.6.99 11:15 Uhr Seite 176

Maintenance and care
177 After any coolant has been added,
check the coolant concentration
(see Checking engine coolant
section). If the concentration is not
50/50 (protection to -34°F /-36°C),
drain some coolant and adjust the
concentration. It may take several
drains and additions to obtain a
50/50 coolant concentration.
Whenever coolant has been added,
the coolant level in the coolant
reservoir should be checked the
next few times you drive the
vehicle. If necessary, add enough
50/50 concentration of engine
coolant and distilled water to bring
the liquid level to the proper level.
If you have to add more than
1.0 liter (1.0 quart) of engine
coolant per month, have your
dealer check the engine cooling
system. Your cooling system may
have a leak. Operating an engine
with a low level of coolant can
result in engine overheating and
possible engine damage.
Changing engine coolant
Change your engine coolant
according to the appropriate
schedule listed in the “Scheduled
Maintenance Guide“. It is important
that the engine coolant be changed
at the specified intervals. The
corrosion protection of engine
coolant is depleted with time and
usage. Use of engine coolant with
depleted corrosion protection may
result in damage to the coolant
system. Color, specific gravity and
freeze point of the coolant are not indicators of depletion.
To find out how much fluid your
vehicle’s cooling system can hold,
refer to the Refill capacities in the
Capacities and Specifications
chapter. Fill your coolant reservoir
following the directions given in
the Adding engine coolant
section.
Coolant usage in severe winter
climate
If you drive in extremely cold
climates less than -34°F (-36°C), it
may be necessary to increase the
coolant concentration above 50 %.
Refer to the chart on the coolant
container to ensure the coolant
concentration in your vehicle will
provide adequate freeze protection.
Never increase the engine
coolant concentration above
60 %(protection to -60°F). At a
level over 60 %, your engine could
overheat and become damaged.
Coolant usage in hot climate
If you drive in hot climates, it is still
necessary to maintain the coolant
concentration at 50/50 coolant and
water. Do not allow the
concentration to fall below
40 % coolant.At a concentration
less than 40 %, the corrosion
protection to your engine and
cooling components may be
compromised and permanent
damage may result.
31CMCen 17.6.99 11:15 Uhr Seite 177

Disposal of used engine coolant
Used engine coolant should be
disposed of in an appropriate
manner. Follow your community’s
regulations and standards for
recycling and/or disposal of
automotive fluids.
Checking and adding power
steering fluid
Switch off the engine. With the
steering system at normal
operating temperature, the fluid
level should come up to the MAX
mark.
If the fluid level drops below the
MIN mark, add the specified fluid.
Refer to the Capacities and
specificationschapter.
Use of recycled engine coolant
Ford Motor Company recommends
the use of recycled engine coolant
produced by Ford-approved
processes. However, not all coolant
recycling processes produce
coolant that meets Ford
specification ESE-M97B44A. Use of
such coolant may harm the engine
and coolant system components.
Maintenance and care
178MAX
MIN
31CMCen 17.6.99 11:15 Uhr Seite 178

ItemFord part name
or equivalent
High Performance
DOT 3 Motor
Vehicle Brake
Fluid, (North
America)
DOT 4 Brake
Fluid or Super
DOT 4 (Europe)
Premium engine
coolant
Super Premium
SAE 5W-30 Motor
Oil
Motorcraft
MERCON
®AT F
Motorcraft*
MERCON
®AT F
Ultra-Clear
Windshield Washer
Concentrate
Ford
part number
C6AZ-19542-AB
for DOT 3
E2FZ-19549-AA
CXC-8-B (Canada)
F5FZ-19549-CC
(Oregon)
XO-5W30-QSP
XT-2-QDX
XT-2-QDX
C9AZ-19550-AC
or
C9AZ-19550-BC
Ford
specification
ESA-M6C25-A
(DOT 3) (North
America
ESD-M6C57-A
(Super DOT 4)
(Europe)
ESE-M97B44-A
API Certification
Mark and
WSS-M2C153-G
MERCON®
MERCON®
ESR-M17P5-A Brake fluid
Engine coolant
Engine oil
Power steering
fluid
Transaxle fluid
automatic/
5-speed manual
Windshield
washer
fluid
* Use only MERCON®
approved transmission/transaxle fluid. Use of any fluid approved and/or labeled
for MERCON®
V may cause internal transaxle damage.
Capacities and specifications
225
Lubricant Specifications
32CCSen 17.6.99 11:31 Uhr Seite 225

Index
242APage
Accessory position on
the ignition . . . . . . . . . . . . . . . . . .54
Additives, engine oil . . . . . . . . .169
Air bag supplemental
restraint system
and child safety seats . . . . . . . .87
description . . . . . . . . . . . . . . . . .87
disposal . . . . . . . . . . . . . . . . . . .92
indicator light . . . . . . . . . . .15, 91
operation . . . . . . . . . . . . . . . . . .89
wearing safety belts . . . . . . . . .87
Air conditioning
(see Climate control system)
Alarm, activating panic . . . . . . . .69
Antenna, radio
(see Audio system) . . . . . . . . . . .53
Anti-lock brake system (ABS) .116
Anti-theft system (see Passive
Anti-Theft System)
Antifreeze (see Engine coolant)
Audio system . . . . . . . . . . . . . . . .34
Automatic transaxle
driving with . . . . . . . . . . . . . . .121
fluid, adding . . . . . . . . . . . . . . .179
fluid, checking . . . . . . . . . . . . .179
fluid, refill capacities . . . . . . . .224
fluid, specification . . . . . . . . . .225
B
Backing up . . . . . . . . . . . . .123, 129
Battery
charging system warning light . .9
jumping a disabled battery . . .154
proper disposal, recycling . . . .184
replacement, specifications . .223
servicing . . . . . . . . . . . . . . . . . .182
Brake fluid
checking and adding . . . . . . . .172
specifications . . . . . . . . . . . . . .225
Brake-shift interlock . . . . . . . . .121
Brakelamps
(see Bulb replacement)BPage
Brakes
anti-lock brake system (ABS) 116
brake warning light . . . . . . . . . .14
fluid, checking and adding . . .172
fluid, refill capacities . . . . . . . .224
fluid, specification . . . . . . . . . .225
parking . . . . . . . . . . . . . . . . . . .116
Built-in child seat
folding up the seat . . . . . . . . .102
inspection after a collision . . .102
interlock safety feature . . . . . . .98
operation . . . . . . . . . . . . . . . . . .97
retractors . . . . . . . . . . . . . . . . . .98
Break-in period . . . . . . . . . . . . . . .2
Bulbs, replacing
foglamps . . . . . . . . . . . . . . . . .208
headlamps . . . . . . . . . . . . . . . .206
high-mounted brake lamp . . . .210
license plate lamp . . . . . . . . . .209
rear lamps . . . . . . . . . . . . . . . .209
specifications . . . . . . . . . . . . . .212
C
Cabin air filter . . . . . . . . . . .33, 186
Capacities for refilling fluids . . .224
Carbon monoxyde in exhaust . .110
Catalytic converter . . . . . . . . . .202
Chains, tires . . . . . . . . . . . . . . . .194
Changing a tire . . . . . . . . . . . . .150
Charging system warning light . . .9
Child safety restraints
built-in child seat . . . . . . . . . . .97
child safety seats . . . . . . . . . . .103
children and safety belts . . .93, 95
Child safety seats
and air bags . . . . . . . . . . . . . . . .88
attaching with tether straps . .104
automatic locking mode . . . . . .79
Childproof safety locks . . . . . . . .65
Chimes . . . . . . . . . . . . . . . . . . . . .19
Circuit breakers . . . . . . . . . . . . .143
4CInden 17.6.99 11:32 Uhr Seite 242

243
Index
CPage
Cleaning your vehicle
engine compartment . . . . . . . .219
exterior lamps . . . . . . . . . . . . .220
fabric . . . . . . . . . . . . . . . . . . . .221
instrument panel . . . . . . . . . . .221
plastic exterior parts . . . . . . . .220
safety belts . . . . . . . . . . . . . . .222
wheels . . . . . . . . . . . . . . . . . . .218
wiper blades . . . . . . . . . . . . . .220
Climate control system
air conditioning . . . . . . . . . . . . .29
controlling airflow . . . . . . . . . . .26
defrosting . . . . . . . . . . . . . . . . . .38
temperature . . . . . . . . . . . . . . . .27
vents . . . . . . . . . . . . . . . . . . . . . .26
Clock . . . . . . . . . . . . . . . . . . . . . .45
Clutch
operation . . . . . . . . . . . . . . . . .127
recommended shift speeds . . .128
Cold engine starting . . . . . . . . .114
Controls
instrument panel . . . . . . . . . . . .20
power seats . . . . . . . . . . . . . . . .75
steering column . . . . . . . . . . . . .55
Customer assistance . . . . . . . . .229
D
Daytime running lights . . . . . . . .23
Defects, reporting . . . . . . . . . . .241
Defrost
rear window . . . . . . . . . . . . . . . .24
windshield . . . . . . . . . . . . . . . . .32
Dipstick, engine oil . . . . . . . . . .167
Door mounted controls . . . . . . . .64
Driving under special conditions
heavy load . . . . . . . . . . . . . . . .133
towing a trailer . . . . . . . . . . . .134
E
Electrical system
fuses . . . . . . . . . . . . . . . . . . . . .143EPage
Emergencies, roadside
fuel pump shut-off switch . . . .141
jump starting . . . . . . . . . . . . . .154
towing . . . . . . . . . . . . . . . . . . .160
Emergency brake (see Parking
brake)
Emission control system . . . . . .202
Engine
check engine warning light . . . .12
fuel pump shut-off switch . . . .141
lubricant specifications . . . . . .225
preparing to start . . . . . . . . . .111
refill capacities . . . . . . . . . . . .224
starting . . . . . . . . . . . . . . . . . . .114
Engine block heater . . . . . . . . .115
Engine coolant
checking and adding . . . . . . . .174
disposal . . . . . . . . . . . . . . . . . .178
low coolant warning light . . . . .11
refilll capacities . . . . . . . . . . . .224
specifications . . . . . . . . . . . . . .225
Engine fan . . . . . . . . . . . . . . . . .163
Engine oil
changing oil and filter . . . . . . .170
checking and adding . . . . . . . .169
dipstick . . . . . . . . . .167, 168, 169
disposal . . . . . . . . . . . . . . . . . .171
engine oil pressure
warning light . . . . . . . . . . . . . . .18
filter specifications . . . . . . . . .223
refill capacities . . . . . . . . . . . .224
specifications . . . . . . . . . . . . . .225
Exhaust fumes . . . . . . . . . .110, 202
F
Fan (see Engine fan)
Flasher, hazard . . . . . . . . . .56, 141
Flashing the lights . . . . . . . . . . . .57
Floor mats . . . . . . . . . . . . . . . . . .67
Fluid refill capacities . . . . . . . . .224
Foglamps . . . . . . . . . . . . . . .23, 208
4CInden 17.6.99 11:32 Uhr Seite 243

Index
244FPage
Fuel
calculating fuel economy . . . .201
capacity . . . . . . . . . . . . . . . . . .224
choosing the right fuel . . . . . .198
consumption . . . . . . . . . . . . . .140
fuel gauge . . . . . . . . . . . . . . . . .21
low fuel warning light . . . . . . . .15
octane rating . . . . . . . . . . . . . .199
quality . . . . . . . . . . . . . . . . . . .199
running out of fuel . . . . . . . . .202
safety information relating
to automotive fuels . . . . . . . . .196
Fuel pump shut-off switch . . . .141
Fuse panels
engine compartment . . . . . . . .144
instrument panel . . . . . . . . . . .146
Fuses
charts . . . . . . . . . . . . . . . .145, 148
checking and replacing . . . . . .143
G
Gas mileage (see Fuel)
Gauges
engine coolant temperature . . .20
fuel . . . . . . . . . . . . . . . . . . . . . . .21
odometer . . . . . . . . . . . . . . . . . .20
speedometer . . . . . . . . . . . . . . .20
trip odometer . . . . . . . . . . . . . .20
GAWR
(Gross Axle Weight Rating) . . .131
Gearshift . . . . . . . . . . . . . .123, 128
GVWR
(Gross Vehicle Weight Rating) .131
H
Hazard flashers . . . . . . . . . .56, 141
Head restraints . . . . . . . . . . . . . .74
Headlamps
aiming . . . . . . . . . . . . . . . . . . .213
bulb specifications . . . . . . . . .212
daytime running light . . . . . . . .23
flashing . . . . . . . . . . . . . . . . . . .57HPage
high beam . . . . . . . . . . . . . . . . .57
replacing bulbs . . . . . . . . . . . .206
turning on and off . . . . . . . . . . .22
warning chime . . . . . . . . . . . . . .19
High beams
indicator light . . . . . . . . . . . . . . .9
operation . . . . . . . . . . . . . . . . . .57
High-mount brakelamp . . . . . . .210
Hood
latch location . . . . . . . . . . . . . .166
release lever . . . . . . . . . . . . . .166
Horn . . . . . . . . . . . . . . . . . . . . . . .56
I
Identification Number, Vehicle
(VIN) . . . . . . . . . . . . . . . . . . . . .228
Idle, relearning . . . . . . . . . . . . .185
Idle, speed . . . . . . . . . . . . . . . . .185
Ignition
chime . . . . . . . . . . . . . . . . . . . . .19
positions on the ignition . . . . . .54
Instrument cluster . . . . . . . . . . . . .8
Instrument panel
cleaning . . . . . . . . . . . . . . . . . .221
lighting up the panel . . . . . . . . .25
Integrated child seat (see Built-in
child seat)
Intermittent wipers . . . . . . . . . . .58
Introduction . . . . . . . . . . . . . . . . . .2
J
Jack
positioning . . . . . . . . . . . . . . . .152
storage . . . . . . . . . . . . . . . . . . .151
Jump starting your vehicle
attaching cables . . . . . . . . . . . .155
disconnecting cables . . . . . . . .158
K
Keys
key in ignition warning chime .19
positions of the ignition . . . . . .54
4CInden 17.6.99 11:32 Uhr Seite 244

Index
245 LPage
Lamps
bulb replacement specification
chart . . . . . . . . . . . . . . . . . . . . .212
daytime running light system . .23
flashing the lamps . . . . . . . . . . .57
foglamps . . . . . . . . . . . . . .23, 208
hazard flashers . . . . . . . . .56, 141
headlamps . . . . . . . . . . . . . . . . .22
high beams . . . . . . . . . . . . . . . . .57
high-mounted brake lamp . . . .210
instrument panel, dimming . . .25
interior lamps . . . . . . . . . . . . . .62
reading lamps . . . . . . . . . . . . . .62
replacing bulbs . . . . . . . . . . . .206
rear lamps . . . . . . . . . . . . . . . .209
Lights, warning and indicator
air bag . . . . . . . . . . . . . . . . . . . .15
anti-lock brakes (ABS) . . . . . . .17
brake . . . . . . . . . . . . . . . . . . . . .16
charging system . . . . . . . . . . . . .9
check engine . . . . . . . . . . . . . . .12
engine oil pressure . . . . . . . . . .18
high beam . . . . . . . . . . . . . . . . . .9
low coolant . . . . . . . . . . . . . . . .11
low fuel . . . . . . . . . . . . . . . . . . .15
overdrive off . . . . . . . . . . . . . . .11
safety belt . . . . . . . . . . . . . . . . . .9
testing the warning lights . . . . .19
turn signal indicator . . . . . . . . . .8
Load limits . . . . . . . . . . . . . . . . .130
Lubricant specifications . . . . . .225
Luggage compartment . . . . . . . .66
M
Maintenance (see Servicing)
Manual transaxle
backing up (reverse) . . . . . . . .129
clutch . . . . . . . . . . . . . . . . . . . .127
fluid, capacity . . . . . . . . . . . . .224
shift speeds . . . . . . . . . . . . . . .128MPage
Mileage, calculating fuel
economy . . . . . . . . . . . . . . . . . . .201
Mirrors
side view mirrors (power) . . . .25
Motorcraft parts . . . . . . . . . . . .223
N
National Highway Traffic Safety
Administration . . . . . . . . . . . . . .241
O
Octane rating . . . . . . . . . . . . . . .199
Odometer . . . . . . . . . . . . . . . . . . .20
Oil (see Engine oil)
Oil filter . . . . . . . . . . . . . . .170, 223
On-board diagnostic
(OBD II) system . . . . . . . . . . . .205
Overdrive . . . . . . . . . . . . . . .11, 124
Overhead controls . . . . . . . . . . . .62
P
Panel dimmer control . . . . . . . . .25
Panic alarm, remote entry sytem 69
Parking brake . . . . . . . . . . . . . .118
Parts (see Motorcraft parts) . . .223
Passenger compartment
air filter (see Cabin air filter)
Passive Anti-Theft
System (PATS) . . . . . . . . . . . . . .71
Power distribution box
(see Fuses)
Power door locks . . . . . . . . . . . . .64
Power features
mirrors . . . . . . . . . . . . . . . . . . . .25
seats . . . . . . . . . . . . . . . . . . . . . .75
sunroof . . . . . . . . . . . . . . . . . . . .63
windows . . . . . . . . . . . . . . . . . . .64
Power steering
fluid, checking and adding . . .178
fluid, refill capacity . . . . . . . . .224
fluid, specification . . . . . . . . . .225
4CInden 17.6.99 11:32 Uhr Seite 245