oil FORD CONTOUR 2000 2.G User Guide

Maintenance and care
206The bulbs for the low beam, high
beam, turn signals and side lamps
are housed in the lamp assembly.
To replace a bulb, the complete
lamp assembly has to be removed
as follows:
1. Switch off the lamps.
2. Open the hood.
3. Remove the lower screw (2)
from the headlamp housing.
4. Remove the two upper screws
(1) from the headlamp housing.
5. Gently pull the headlamp
housing outward.
6. Replace the headlamp bulbs. BULB REPLACEMENT
Handle a halogen headlamp
bulb carefully and keep out
of children’s reach.Grasp the bulb
only by its plastic base and do not
touch the glass. The oil from your
hand could cause the bulb to
break the next time the
headlamps are operated.
1
1
2
Removing the headlamps
assembly
31CMCen 17.6.99 11:15 Uhr Seite 206

Maintenance and care
210
High-mounted brake lamp
Enter the rear seat compartment.
1. Remove the high-mounted stop
lamp assembly.
2. Remove the red bulb cover.
3. Remove inoperative stop lamp
bulb.
To install, fit the new bulb in
reverse sequence.
On vehicles equipped with a rear
spoiler, the high-mounted brake
lamp is included in the spoiler.
See your dealer for repair.
Luggage compartment lamp
Pry out the light assembly from the
holder with a flat screwdriver. Turn
the spherical bulb under slight
pressure counterclockwise and
remove.
31CMCen 17.6.99 11:15 Uhr Seite 210

223
Capacities and specifications
* Refer to Vehicle Emission Control Information (VECI) decal for spark plug and gap specifications.
** If a spark plug is removed for examination, it must be reinstalled in the same cylinder.
If a spark plug needs to be replaced, use only spark plugs with the service part number suffix
letter “FE” as shown on the engine decal.
Motorcraft parts
Component
Spark plug*
Air filter
Passenger compartment
air filter
Fuel filter
Oil filter
Battery
PCV valve
Crankcase ventilation
filter2.0 litre engine
AZFS-22F # 1+2**
AZFS-22FE# 3+4
FA-1612
FP4
FG-800A
FL-2005
BXT-40R
EV-224
FA-1621
2.5 litre engine
AWSF-32F
FA-1613
FP4
FG-800A
FL-820
BXT-40R
EV-152
—
Part number
32CCSen 17.6.99 11:31 Uhr Seite 223

Capacities and specifications
224
* Total capacity
** with automatic transaxle
Engine oil
- with filter
- without
Manual transaxle 1.9 l (2.0 qts)
Automatic transaxle
with oil cooler
Power steering
Cooling system with heating
Windshield washer fluid
Fuel tank
Braking system4.25 l (4.5 qts)
3.75 l (4.0 qts)
8.5 l (9.0 qts.)
6.6 l (7.0 qts)*
7.1 l (7.5 qts)**
Fill to MAX mark
Fill to top of reservoir
58.5 l (15.4 gallons)
Fill to MAX mark5.5 l (5.8 qts)
5.0 l (5.3 qts)
9.6 l (10.2 qts)
9.5 l (10.0 qts)*
9.7 l (10.2 qts)**
Capacities2.0 litre
engine2.5 litre
engine
32CCSen 17.6.99 11:31 Uhr Seite 224

ItemFord part name
or equivalent
High Performance
DOT 3 Motor
Vehicle Brake
Fluid, (North
America)
DOT 4 Brake
Fluid or Super
DOT 4 (Europe)
Premium engine
coolant
Super Premium
SAE 5W-30 Motor
Oil
Motorcraft
MERCON
®AT F
Motorcraft*
MERCON
®AT F
Ultra-Clear
Windshield Washer
Concentrate
Ford
part number
C6AZ-19542-AB
for DOT 3
E2FZ-19549-AA
CXC-8-B (Canada)
F5FZ-19549-CC
(Oregon)
XO-5W30-QSP
XT-2-QDX
XT-2-QDX
C9AZ-19550-AC
or
C9AZ-19550-BC
Ford
specification
ESA-M6C25-A
(DOT 3) (North
America
ESD-M6C57-A
(Super DOT 4)
(Europe)
ESE-M97B44-A
API Certification
Mark and
WSS-M2C153-G
MERCON®
MERCON®
ESR-M17P5-A Brake fluid
Engine coolant
Engine oil
Power steering
fluid
Transaxle fluid
automatic/
5-speed manual
Windshield
washer
fluid
* Use only MERCON®
approved transmission/transaxle fluid. Use of any fluid approved and/or labeled
for MERCON®
V may cause internal transaxle damage.
Capacities and specifications
225
Lubricant Specifications
32CCSen 17.6.99 11:31 Uhr Seite 225

Customer assistance
237 FORD CAR CARE PRODUCTS
FOR YOUR VEHICLE
Ford has many quality products
available from your dealer to
clean your vehicle and protect its
finishes. For best results, use the
following or products of
equivalent quality
Ford Custom Clearcoat Polish*
Ford Custom Silicone Gloss
Polish
Ford Custom Vinyl Protectant*
Ford Deluxe Leather and Vinyl
Cleaner
Ford Extra Strength Tar and
Road Oil Remover*
Ford Extra Strength Upholstery
Cleaner
Ford Metal Surface Cleaner
Ford Multi-Purpose Cleaner*
Motorcraft Car Wash Concentrate
Motorcraft Carlite Glass Cleaner
Ford Spot and Stain Remover*
Ford Super Premium Tire and
Trim DressingFord Triple Clean
Ford Ultra-Clear Spray Glass
Cleaner
* May be sold with the Motorcraft
name
FORD ACCESSORIES FOR
YOUR VEHICLE
A wide selection of accessories is
available through your local
authorized Ford, Lincoln-Mercury
or Ford of Canada dealer. These
quality accessories have been
specifically engineered to fulfill
your automotive needs; they are
custom designed to complement
the style and aerodynamic
appearance of your vehicle. In
addition, each accessory is made
from high quality materials and
meets or exceeds Ford's rigid
engineering and safety
specifications. Ford accessories are
warranted for up to 12 months or
20,000 km (12,000 miles) on all
cars and light trucks and 12
months with unlimited distance on
medium/heavy duty trucks unless
the accessory is installed on a new
vehicle, then the warranty becomes
the balance of the new vehicle's
warranty or the accessories
warranty, whichever is greater. See
your dealer for complete warranty
information and availability.
Not all accessories are
available for all models.
33CCAen 17.6.99 11:32 Uhr Seite 237

Customer assistance
239 Protection and appearance
equipment
Air bag anti-theft locks
Bed mat/bedliner tailgate covers
Bed mats
Bedliners
Car/truck covers
Cargo liners, interior
Carpet floor mats
Cleaners, waxes and polishes
Flat splash guards
Frond end covers (full and mini)
Hood deflectors
Locking gas cap
Lubricants and oils
Molded splash guards
Molded vinyl floor mats
Rallye bars
Rear air deflectors
Rear decklid spoilers
Side window air deflectors
Spare tire lock
Step bumpers
Step/sill plates
Tailgate covers
Tailgate lock
Tailgate protection
Tonneau covers
Touch-up paint
Universal floor matsFor maximum vehicle performance,
keep the following information in
mind when adding accessories or
equipment to your vehicle:
• When adding accessories,
equipment, passengers and luggage
to your vehicle, do not exceed the
total weight capacity of the vehicle
or of the front or rear axle (GVWR
or GAWR as indicated on the Safety
compliance certification label).
Consult your dealer for specific
weight information.
• The Federal Communications
Commission (FCC) and Canadian
Radio Telecommunications
Commission (CRTC) regulate the
use of mobile communications
systems - such as two-way radios,
telephones and theft alarms - that
are equipped with radio
transmitters. Any such equipment
installed in your vehicle should
comply with FCC or CRTC
regulations and should be installed
only by a qualified service
technician.
33CCAen 17.6.99 11:32 Uhr Seite 239

Index
242APage
Accessory position on
the ignition . . . . . . . . . . . . . . . . . .54
Additives, engine oil . . . . . . . . .169
Air bag supplemental
restraint system
and child safety seats . . . . . . . .87
description . . . . . . . . . . . . . . . . .87
disposal . . . . . . . . . . . . . . . . . . .92
indicator light . . . . . . . . . . .15, 91
operation . . . . . . . . . . . . . . . . . .89
wearing safety belts . . . . . . . . .87
Air conditioning
(see Climate control system)
Alarm, activating panic . . . . . . . .69
Antenna, radio
(see Audio system) . . . . . . . . . . .53
Anti-lock brake system (ABS) .116
Anti-theft system (see Passive
Anti-Theft System)
Antifreeze (see Engine coolant)
Audio system . . . . . . . . . . . . . . . .34
Automatic transaxle
driving with . . . . . . . . . . . . . . .121
fluid, adding . . . . . . . . . . . . . . .179
fluid, checking . . . . . . . . . . . . .179
fluid, refill capacities . . . . . . . .224
fluid, specification . . . . . . . . . .225
B
Backing up . . . . . . . . . . . . .123, 129
Battery
charging system warning light . .9
jumping a disabled battery . . .154
proper disposal, recycling . . . .184
replacement, specifications . .223
servicing . . . . . . . . . . . . . . . . . .182
Brake fluid
checking and adding . . . . . . . .172
specifications . . . . . . . . . . . . . .225
Brake-shift interlock . . . . . . . . .121
Brakelamps
(see Bulb replacement)BPage
Brakes
anti-lock brake system (ABS) 116
brake warning light . . . . . . . . . .14
fluid, checking and adding . . .172
fluid, refill capacities . . . . . . . .224
fluid, specification . . . . . . . . . .225
parking . . . . . . . . . . . . . . . . . . .116
Built-in child seat
folding up the seat . . . . . . . . .102
inspection after a collision . . .102
interlock safety feature . . . . . . .98
operation . . . . . . . . . . . . . . . . . .97
retractors . . . . . . . . . . . . . . . . . .98
Break-in period . . . . . . . . . . . . . . .2
Bulbs, replacing
foglamps . . . . . . . . . . . . . . . . .208
headlamps . . . . . . . . . . . . . . . .206
high-mounted brake lamp . . . .210
license plate lamp . . . . . . . . . .209
rear lamps . . . . . . . . . . . . . . . .209
specifications . . . . . . . . . . . . . .212
C
Cabin air filter . . . . . . . . . . .33, 186
Capacities for refilling fluids . . .224
Carbon monoxyde in exhaust . .110
Catalytic converter . . . . . . . . . .202
Chains, tires . . . . . . . . . . . . . . . .194
Changing a tire . . . . . . . . . . . . .150
Charging system warning light . . .9
Child safety restraints
built-in child seat . . . . . . . . . . .97
child safety seats . . . . . . . . . . .103
children and safety belts . . .93, 95
Child safety seats
and air bags . . . . . . . . . . . . . . . .88
attaching with tether straps . .104
automatic locking mode . . . . . .79
Childproof safety locks . . . . . . . .65
Chimes . . . . . . . . . . . . . . . . . . . . .19
Circuit breakers . . . . . . . . . . . . .143
4CInden 17.6.99 11:32 Uhr Seite 242

243
Index
CPage
Cleaning your vehicle
engine compartment . . . . . . . .219
exterior lamps . . . . . . . . . . . . .220
fabric . . . . . . . . . . . . . . . . . . . .221
instrument panel . . . . . . . . . . .221
plastic exterior parts . . . . . . . .220
safety belts . . . . . . . . . . . . . . .222
wheels . . . . . . . . . . . . . . . . . . .218
wiper blades . . . . . . . . . . . . . .220
Climate control system
air conditioning . . . . . . . . . . . . .29
controlling airflow . . . . . . . . . . .26
defrosting . . . . . . . . . . . . . . . . . .38
temperature . . . . . . . . . . . . . . . .27
vents . . . . . . . . . . . . . . . . . . . . . .26
Clock . . . . . . . . . . . . . . . . . . . . . .45
Clutch
operation . . . . . . . . . . . . . . . . .127
recommended shift speeds . . .128
Cold engine starting . . . . . . . . .114
Controls
instrument panel . . . . . . . . . . . .20
power seats . . . . . . . . . . . . . . . .75
steering column . . . . . . . . . . . . .55
Customer assistance . . . . . . . . .229
D
Daytime running lights . . . . . . . .23
Defects, reporting . . . . . . . . . . .241
Defrost
rear window . . . . . . . . . . . . . . . .24
windshield . . . . . . . . . . . . . . . . .32
Dipstick, engine oil . . . . . . . . . .167
Door mounted controls . . . . . . . .64
Driving under special conditions
heavy load . . . . . . . . . . . . . . . .133
towing a trailer . . . . . . . . . . . .134
E
Electrical system
fuses . . . . . . . . . . . . . . . . . . . . .143EPage
Emergencies, roadside
fuel pump shut-off switch . . . .141
jump starting . . . . . . . . . . . . . .154
towing . . . . . . . . . . . . . . . . . . .160
Emergency brake (see Parking
brake)
Emission control system . . . . . .202
Engine
check engine warning light . . . .12
fuel pump shut-off switch . . . .141
lubricant specifications . . . . . .225
preparing to start . . . . . . . . . .111
refill capacities . . . . . . . . . . . .224
starting . . . . . . . . . . . . . . . . . . .114
Engine block heater . . . . . . . . .115
Engine coolant
checking and adding . . . . . . . .174
disposal . . . . . . . . . . . . . . . . . .178
low coolant warning light . . . . .11
refilll capacities . . . . . . . . . . . .224
specifications . . . . . . . . . . . . . .225
Engine fan . . . . . . . . . . . . . . . . .163
Engine oil
changing oil and filter . . . . . . .170
checking and adding . . . . . . . .169
dipstick . . . . . . . . . .167, 168, 169
disposal . . . . . . . . . . . . . . . . . .171
engine oil pressure
warning light . . . . . . . . . . . . . . .18
filter specifications . . . . . . . . .223
refill capacities . . . . . . . . . . . .224
specifications . . . . . . . . . . . . . .225
Exhaust fumes . . . . . . . . . .110, 202
F
Fan (see Engine fan)
Flasher, hazard . . . . . . . . . .56, 141
Flashing the lights . . . . . . . . . . . .57
Floor mats . . . . . . . . . . . . . . . . . .67
Fluid refill capacities . . . . . . . . .224
Foglamps . . . . . . . . . . . . . . .23, 208
4CInden 17.6.99 11:32 Uhr Seite 243

Index
245 LPage
Lamps
bulb replacement specification
chart . . . . . . . . . . . . . . . . . . . . .212
daytime running light system . .23
flashing the lamps . . . . . . . . . . .57
foglamps . . . . . . . . . . . . . .23, 208
hazard flashers . . . . . . . . .56, 141
headlamps . . . . . . . . . . . . . . . . .22
high beams . . . . . . . . . . . . . . . . .57
high-mounted brake lamp . . . .210
instrument panel, dimming . . .25
interior lamps . . . . . . . . . . . . . .62
reading lamps . . . . . . . . . . . . . .62
replacing bulbs . . . . . . . . . . . .206
rear lamps . . . . . . . . . . . . . . . .209
Lights, warning and indicator
air bag . . . . . . . . . . . . . . . . . . . .15
anti-lock brakes (ABS) . . . . . . .17
brake . . . . . . . . . . . . . . . . . . . . .16
charging system . . . . . . . . . . . . .9
check engine . . . . . . . . . . . . . . .12
engine oil pressure . . . . . . . . . .18
high beam . . . . . . . . . . . . . . . . . .9
low coolant . . . . . . . . . . . . . . . .11
low fuel . . . . . . . . . . . . . . . . . . .15
overdrive off . . . . . . . . . . . . . . .11
safety belt . . . . . . . . . . . . . . . . . .9
testing the warning lights . . . . .19
turn signal indicator . . . . . . . . . .8
Load limits . . . . . . . . . . . . . . . . .130
Lubricant specifications . . . . . .225
Luggage compartment . . . . . . . .66
M
Maintenance (see Servicing)
Manual transaxle
backing up (reverse) . . . . . . . .129
clutch . . . . . . . . . . . . . . . . . . . .127
fluid, capacity . . . . . . . . . . . . .224
shift speeds . . . . . . . . . . . . . . .128MPage
Mileage, calculating fuel
economy . . . . . . . . . . . . . . . . . . .201
Mirrors
side view mirrors (power) . . . .25
Motorcraft parts . . . . . . . . . . . .223
N
National Highway Traffic Safety
Administration . . . . . . . . . . . . . .241
O
Octane rating . . . . . . . . . . . . . . .199
Odometer . . . . . . . . . . . . . . . . . . .20
Oil (see Engine oil)
Oil filter . . . . . . . . . . . . . . .170, 223
On-board diagnostic
(OBD II) system . . . . . . . . . . . .205
Overdrive . . . . . . . . . . . . . . .11, 124
Overhead controls . . . . . . . . . . . .62
P
Panel dimmer control . . . . . . . . .25
Panic alarm, remote entry sytem 69
Parking brake . . . . . . . . . . . . . .118
Parts (see Motorcraft parts) . . .223
Passenger compartment
air filter (see Cabin air filter)
Passive Anti-Theft
System (PATS) . . . . . . . . . . . . . .71
Power distribution box
(see Fuses)
Power door locks . . . . . . . . . . . . .64
Power features
mirrors . . . . . . . . . . . . . . . . . . . .25
seats . . . . . . . . . . . . . . . . . . . . . .75
sunroof . . . . . . . . . . . . . . . . . . . .63
windows . . . . . . . . . . . . . . . . . . .64
Power steering
fluid, checking and adding . . .178
fluid, refill capacity . . . . . . . . .224
fluid, specification . . . . . . . . . .225
4CInden 17.6.99 11:32 Uhr Seite 245