battery FORD E SERIES 1996 4.G Owner's Manual

351 %
*
[SV51456( ALL)06/95]
Readiness for Inspection/Maintenance
Testing
*
[SV51457( ALL)06/95]
In some localities it may become a legal
requirement to pass an
Inspection/Maintenance (I/M) test of the
On-Board Diagnostic (OBD) II system. If the
vehicle's powertrain system or its battery has
just been serviced, the OBD II system is reset to
a not ready for I/M testing condition. To
prepare for I/M testing, the law specifies a
ªneed for additional mixed city and highway
driving to complete the checkº of the OBD II
system. As soon as all of the OBD II system
checks are successfully completed, the OBD II
system is set to the ready condition. The amount
of driving required to reach the ready condition
varies with individual driving patterns. To
complete this requirement in the minimum
amount of time, refer to the OBD II Drive Cycle
defined below. If the vehicle owner cannot or
does not want to do the additional driving
required by law, a service center can perform
this drive cycle as it would any other type of
repair work.
[SV51458( ALL)05/95]
OBD II Drive Cycle
*
[SV51459( ALL)05/95]
The engine must be warmed up and at
operating temperature before proceeding with
the drive modes of the following OBD II Drive
Cycle.
*
[SV51461( ALL)05/95]
1. Start the engine. Drive or idle (in neutral)
the vehicle for 4 minutes.
[SV51463( ALL)04/95]
2. Idle the vehicle in drive (neutral for manual
transmission) for 40 seconds.
*
[SV51465( ALL)06/95]
3. Accelerate the vehicle to 45 mph (70 km/h)
at 1/4 to 1/2 throttle for 10 seconds.
File:14ltsve.ex
Update:Wed Apr 17 08:40:13 1996

363 %
*
[SV58400( ALL)01/95]
Battery
*
[SV58500( ALL)01/95]
q
Check and recharge as necessary.
*
[SV58600( ALL)01/95]
q
Keep connections clean and covered with a
light coat of grease.
%*
[SV58700( ALL)01/95]
Brakes
*
[SV58800( ALL)01/95]
q
Make sure brakes and parking brake are fully
released.
%*
[SV58900( ALL)01/95]
Tires
[SV59000( ALL)10/95]
q
Maintain recommended air pressures.
*
[SV59100( ALL)01/95]
Miscellaneous
*
[SV59200( ALL)01/95]
q
Make sure all linkages, cables, levers and
clevis pins under vehicle are covered with
grease to prevent rust.
*
[SV59300( ALL)05/95]
q
Move vehicles at least 25 feet (10 m) every 15
days to lubricate working parts to prevent
corrosion.
File:14ltsve.ex
Update:Wed Apr 17 08:40:13 1996

378 Index
Anti-theft system
arming the system.......... 121
description.............. 121
disarming an untriggered system.... 122
disarming a triggered system...... 122
triggering............121±122
warning light.............. 75
Appeals (see Dispute settlement board) . . 262
Assistance (see Customer assistance).... 259
Audio system
(see Electronic sound system)..... 149
Automatic transaxle, fluid,
refill capacities............ 353
Automatic transmission
driving an automatic overdrive . 197, 199, 203
driving a regular automatic...... 195
fluid, adding............. 324
fluid, checking............ 323
fluid, refill capacities......... 353
fluid, specification........... 357
Axle
lubricant specifications......... 357
refill capacities............ 353
traction lok............216, 312
B
Backing up.............197, 202
Basic vehicle warranty........... 4
Battery
acid, treating emergencies . . . 244, 320±321
auxiliary battery........... 320
charging system warning light...... 74
disconnecting............. 247
how to service............ 319
jumping a disabled battery....... 243
maintenance-free........... 319
proper disposal, recycling....... 320
replacement, specifications....... 356
servicing............... 320
voltage gauge............74±75
when storing your vehicle....... 363
File:ltixe.ex
Update:Wed Apr 17 08:36:26 1996

Index 383
Electronic stereo radio
(see Electronic sound system)..... 178
Emergencies, roadside
assistance.............. 259
battery acid spills.........243, 321
jump-starting............. 243
towing................ 258
Emergency brake (parking brake)..... 212
Emission control system......... 346
catalytic converter.......... 346
emissions warranty....... 4,346, 349
Engine
check engine warning light....... 71
diesel................. 6
fuel injected engine, starting..... 57,59
fuel pump shut-off switch........ 63
preparing to start............ 58
refill capacities............ 353
service points............ 283
starting.............. 55,59
starting after a collision......... 63
storing your vehicle........361±362
Engine block heater............ 62
Engine coolant
checking and adding......... 301
checking hoses............ 305
disposal...........301, 304, 324
drain and flush............ 306
preparing for storage......... 362
proper solution............ 303
recovery reservoir........283, 302
refill capacities............ 353
refill procedure............ 306
specifications............. 304
temperature gauge........... 78
Engine coolant temperature gauge..... 78
File:ltixe.ex
Update:Wed Apr 17 08:36:26 1996

386 Index
Gauges, Mechanical
battery voltage gauge.......... 75
charging system gauge......... 75
engine coolant temperature gauge.... 78
engine oil pressure gauge........ 76
fuel gauge............... 77
speedometer.............. 79
GAWR (Gross Axle Weight Rating)
calculating.............. 225
definition.............218, 223
driving with a heavy load....... 218
Gearshift
automatic operation........195, 200
column-mounted.........195, 200
locking the gearshift........... 55
positions.............195, 200
shifting the gears.........195, 200
shift-lock........... 60,196, 202
Gearshift:shifting the gears......195, 200
GVWR (Gross Vehicle Weight Rating)
calculating.............. 225
definition.............218, 223
driving with a heavy load....... 218
H
Hazard flashers............. 103
Headlamps
aiming................ 340
checking alignment.......... 340
cleaning................ 93
daytime running lights......... 93
flashing............... 101
high beam.............. 100
replacing bulbs..........340±341
turning on and off........... 92
warning chime............. 77
Heating
heating and air conditioning system . . . 87
File:ltixe.ex
Update:Wed Apr 17 08:36:26 1996

Index 393
Shoulder and lap belts
(see Safety restraints).......... 14
Shoulder belts (see Safety restraints).... 14
Side mirrors, adjusting.......... 146
Snow tires and chains.......... 318
Spare tire
changing the tire.........247, 250
conventional spare.......... 247
finding the spare........... 248
removing the spare tire........ 248
Spark plugs, specifications........ 356
Special driving conditions........ 214
Special notice
ambulance conversions......... 5
diesel-powered vehicles......... 6
Specification chart, lubricants....... 357
Speed control
accelerating............. 108
canceling a set speed......... 111
resetting............... 108
resuming a set speed......... 111
tap up/tap down........... 108
when towing a trailer......... 239
Speedometer............... 79
Starting your vehicle
preparing to start your vehicle...... 58
starting a cold engine.......... 59
starting after a collision......... 63
starting a warm engine......... 60
starting your vehicle if the battery
is disabled............. 243
Steering, power............. 206
Steering wheel
horn................. 104
locking................ 55
speed controls............ 106
tilting................ 105
Storage compartments
center console............ 147
underseat storage drawer....... 142
File:ltixe.ex
Update:Wed Apr 17 08:36:26 1996

Index 395
Transmission (continued)
fluid, checking and adding (automatic) . 323
fluid, refill capacities......... 353
lubricant specifications........ 357
Transmission control switch.....197, 203
Transmitter (see Remote entry)...... 116
Tune-up specifications (VECI)...... 348
Turn signal
indicator lights............. 99
lever................. 99
U
Used engine oil, disposal....301, 304, 324
V
Vanity mirror.............. 143
Variable interval wipers......... 102
VECI (Vehicle Emission
Control Information) decal....... 348
Vehicle Identification Number (VIN).... 6
Vehicle loading............. 220
calculating the load.......... 225
Vehicle storage............. 361
Ventilating your vehicle
(see Climate control).......... 83
Viscosity (see Engine oil)........ 297
Voltmeter (see Battery voltage gauge).... 75
W
Warm engine, starting........... 60
Warning chimes
headlamps on............. 77
key in ignition............. 56
safety belt............... 71
Warning lights, testing........... 58
Warning lights (see Lights)......... 67
Warranties
basic.................. 4
Canada................ 4
File:ltixe.ex
Update:Wed Apr 17 08:36:26 1996