clock FORD E SERIES 2009 4.G Owner's Manual

3. Recheck the engine oil level. Make sure the oil level is not above the
normal operating range on the engine oil level dipstick.
4. Install the dipstick and ensure it is fully seated.
5. Fully install the engine oil filler cap by turning the filler cap clockwise
1/4 of a turn until three clicks are heard or until the cap is fully seated.
To avoid possible oil loss, DO NOT operate the vehicle with the
engine oil level dipstick and/or the engine oil filler cap removed.
Engine oil and filter recommendations
Look for this certification
trademark.
Use SAE 5W-20 engine oil
Only use oils “Certified For Gasoline Engines” by the American
Petroleum Institute (API). An oil with this trademark symbol conforms
to the current engine and emission system protection standards and fuel
economy requirements of the International Lubricant Standardization and
Approval Committee (ILSAC), comprised of U.S. and Japanese
automobile manufacturers.
To protect your engine and engine’s warranty, use Motorcraft SAE 5W-20
or an equivalent SAE 5W-20 oil meeting Ford specification
WSS-M2C930-A.SAE 5W-20 oil provides optimum fuel economy and
durability performance meeting all requirements for your
vehicle’s engine.
Do not use supplemental engine oil additives, cleaners or other engine
treatments. They are unnecessary and could lead to engine damage that
is not covered by Ford warranty.
Change your engine oil and filter according to the appropriate schedule
listed in thescheduled maintenance information.
Ford production and Motorcraft replacement oil filters are designed for
added engine protection and long life. If a replacement oil filter is used
2009 Econoline(eco)
Owners Guide, 1st Printing
USA(fus)
Maintenance and Specifications
271

Battery relearn
Because your vehicle’s engine is electronically controlled by a computer,
some control conditions are maintained by power from the battery. When
the battery is disconnected or a new battery is installed, the engine must
relearn its idle and fuel trim strategy for optimum driveability and
performance. Flexible fuel vehicles (FFV) must also relearn the ethanol
content of the fuel for optimum driveability and performance. To begin
this process:
1. With the vehicle at a complete stop, set the parking brake.
2. Put the gearshift in P (Park), turn off all accessories and start the
engine.
3. Run the engine until it reaches normal operating temperature.
4. Allow the engine to idle for at least one minute.
5. Turn the A/C on and allow the engine to idle for at least one minute.
6. Release the parking brake. With your foot on the brake pedal and with
the A/C on, put the vehicle in D (Drive) and allow the engine to idle for
at least one minute.
7. Drive the vehicle to complete the relearning process.
•The vehicle may need to be driven 10 miles (16 km) or more to
relearn the idle and fuel trim strategy along with the ethanol content
for flexible fuel vehicles.
•If you do not allow the engine to relearn its idle trim, the idle quality
of your vehicle may be adversely affected until the idle trim is
eventually relearned.
•For flexible fuel vehicles, if you are operating on E85, you may
experience poor starts or an inability to start the engine and
driveability problems until the fuel trim and ethanol content have been
relearned.
If the battery has been disconnected or a new battery has been installed,
the clock and radio settings must be reset once the battery is
reconnected.
2009 Econoline(eco)
Owners Guide, 1st Printing
USA(fus)
Maintenance and Specifications
274

For vehicles with overflow coolant systems with a non-pressurized cap
on the coolant recovery system, add coolant to the coolant recovery
reservoir when the engine is cool. Add the proper mixture of coolant and
water to the “FULL COLD” level. For all other vehicles which have a
coolant degas system with a pressurized cap, or if it is necessary to
remove the coolant pressure relief cap on the radiator of a vehicle with
an overflow system, follow these steps to add engine coolant.
WARNING:To reduce the risk of personal injury, make sure the
engine is cool before unscrewing the coolant pressure relief cap.
The cooling system is under pressure; steam and hot liquid can come
out forcefully when the cap is loosened slightly.
Add the proper mixture of coolant and water to the cooling system by
following these steps:
1. Before you begin, turn the engine off and let it cool.
2. When the engine is cool, wrap a thick cloth around the coolant
pressure relief cap on the coolant reservoir (a translucent plastic bottle).
Slowly turn cap counterclockwise (left) until pressure begins to release.
3. Step back while the pressure releases.
4. When you are sure that all the pressure has been released, use the
cloth to turn it counterclockwise and remove the cap.
5. Fill the coolant reservoir slowly with the proper coolant mixture, to
within the “COLD FILL RANGE” or the “FULL COLD” level on the
reservoir. If you removed the radiator cap in an overflow system, fill the
radiator until the coolant is visible and radiator is almost full.
6. Replace the cap. Turn until tightly installed. Cap must be tightly
installed to prevent coolant loss.
After any coolant has been added, check the coolant concentration (refer
toChecking engine coolant). If the concentration is not 50/50
(protection to –34°F/–36°C), drain some coolant and adjust the
concentration. It may take several drains and additions to obtain a 50/50
coolant concentration.
Whenever coolant has been added, the coolant level in the coolant
reservoir should be checked the next few times you drive the vehicle. If
necessary, add enough 50/50 concentration of engine coolant and
distilled water to bring the liquid level to the proper level.
If you have to add more than 1.0 quart (1.0 liter) of engine coolant per
month, have your authorized dealer check the engine cooling system.
2009 Econoline(eco)
Owners Guide, 1st Printing
USA(fus)
Maintenance and Specifications
278

Refueling
WARNING:Fuel vapor burns violently and a fuel fire can cause
severe injuries. To help avoid injuries to you and others:
•Read and follow all the instructions on the pump island;
•Turn off your engine when you are refueling;
•Do not smoke if you are near fuel or refueling your vehicle;
•Keep sparks, flames and smoking materials away from fuel;
•Stay outside your vehicle and do not leave the fuel pump unattended
when refueling your vehicle — this is against the law in some places;
•Keep children away from the fuel pump; never let children pump
fuel.
Use the following guidelines to avoid electrostatic charge build-up when
filling an ungrounded fuel container:
•Place approved fuel container on the ground.
•DO NOT fill a fuel container while it is in the vehicle (including the
cargo area).
•Keep the fuel pump nozzle in contact with the fuel container while
filling.
•DO NOT use a device that would hold the fuel pump handle in the fill
position.
Fuel filler cap
Your fuel tank filler cap has an indexed design with a 1/4 turn on/off
feature.
When fueling your vehicle:
1. Turn the engine off.
2. Carefully turn the filler cap counterclockwise until it spins off.
3. Pull to remove the cap from the fuel filler pipe.
4. To install the cap, align the tabs on the cap with the notches on the
filler pipe.
5. Turn the filler cap clockwise 1/4 of a turn until it clicks at least once.
If the check fuel cap light
or a “check fuel cap” message comes on,
the fuel filler cap may not be properly installed. The light or message can
come on after several driving events after you’ve refueled your vehicle.
2009 Econoline(eco)
Owners Guide, 1st Printing
USA(fus)
Maintenance and Specifications
284

instrument panel ....................262
interior .....................................262
plastic parts ............................261
safety belts ..............................262
washing ....................................258
waxing .....................................259
wheels ......................................259
wiper blades ............................261
Climate control (see Air
conditioning or Heating) ......42–44
Clock adjust
6-CD in dash .............................28
AM/FM Stereo ...........................21
AM/FM/CD .................................23
Compass, electronic ....................60
calibration .................................61
set zone adjustment .................60
Console
overhead ..............................58–59
Controls
power seat .................................92
Coolant
checking and adding ..............275
refill capacities ................279, 303
specifications ..........................303
Cruise control
(see Speed control) ....................66
Customer Assistance ................221
Ford Extended Service
Plan ..........................................255
Getting assistance outside the
U.S. and Canada .....................255
Getting roadside assistance ...221
Getting the service you
need .........................................250
Ordering additional owner’s
literature .................................256
Utilizing the
Mediation/Arbitration
Program ...................................254D
Daytime running lamps
(see Lamps) ................................45
Dipstick
automatic transmission
fluid ..........................................296
engine oil .................................269
Driveline universal joint and
slip yoke ....................................296
Driving under special
conditions
through water .........................220
E
Electronic message center .........69
Emergencies, roadside
jump-starting ..........................242
Emergency Flashers .................222
Emission control system ..........291
Engine ........................................310
cleaning ...................................260
coolant .....................................275
diesel ...........................................7
fail-safe cooling .......................280
idle speed control ...................272
lubrication specifications .......303
refill capacities ........................303
service points ..........................267
starting after a collision .........223
Engine block heater .................193
Engine oil ..................................269
checking and adding ..............269
dipstick ....................................269
filter, specifications ........271, 302
recommendations ...................271
refill capacities ........................303
specifications ..........................303
2009 Econoline(eco)
Owners Guide, 1st Printing
USA(fus)
Index
317

locking/unlocking
doors ..............................78, 83–84
panic alarm ...............................84
replacement/additional
transmitters ...............................85
replacing the batteries .............84
Reverse camera .........................217
Reverse sensing system ...........214
Roadside assistance ..................221
Roll stability control .................198
S
Safety belts
(see Safety restraints) .......98–102
Safety defects, reporting ..........257
Safety restraints ..................98–102
Belt-Minder...........................103
extension assembly ................107
for adults ...........................99–101
for children .............................117
warning light and chime ........103
Safety restraints - LATCH
anchors ......................................124
Safety seats for children ..........121
Safety Compliance
Certification Label ....................311
Satellite Radio Information ........38
Seats ............................................90
child safety seats ....................121
front seats .................................91
SecuriLock passive anti-theft
system ....................................86, 88
Servicing your vehicle ..............265
Setting the clock
AM/FM single CD .....................23
AM/FM stereo ...........................21AM/FM/In-dash 6 CD ................28
Spare tire
(see Changing the Tire) ...........235
Spark plugs,
specifications .....................302, 310
Special notice ................................8
ambulance conversions ..............8
diesel-powered vehicles .............7
utility-type vehicles ....................7
Specification chart,
lubricants ...................................303
Speed control ..............................66
Stability system .........................198
Starting a flex fuel vehicle .......192
Starting your vehicle ........190–192
jump starting ..........................242
Steering wheel
tilting .........................................58
T
Temperature control
(see Climate control) ...........42, 44
Tilt steering wheel ......................58
Tire Pressure Monitoring
System (TPMS)
Tires, Wheels and Loading ....156
Tires ...........................138–139, 232
alignment ................................148
care ..........................................144
changing ..................232, 235–237
checking the pressure ............143
inflating ...................................140
label .........................................155
replacing ..........................146, 237
rotating ....................................148
safety practices .......................147
sidewall information ...............150
2009 Econoline(eco)
Owners Guide, 1st Printing
USA(fus)
Index
320