fuel pressure FORD ESCAPE 2018 Warranty Guide
[x] Cancel search | Manufacturer: FORD, Model Year: 2018, Model line: ESCAPE, Model: FORD ESCAPE 2018Pages: 41, PDF Size: 2.27 MB
Page 16 of 41
Transmission:all internal parts, clutch cover, seals and gaskets, torque
converter, transfer case (including all internal parts), transmission case,
transmission mounts; Front-Wheel Drive: axle shafts, front bearings,
seals and gaskets, universal and constant velocity joints; Rear-Wheel
Drive:axle shafts, rear bearings, center support bearing, drive axle
housing (including all internal parts), drive shaft, retainers, supports,
seals and gaskets, universal and constant velocity joints.
Four-Wheel/All-Wheel Drive: axle shafts, bearings (front and rear),
center support bearing, drive shafts, final drive housing (including all
internal parts), hubs-automatic front locking (four-wheel drive), locking
rings (four-wheel drive), seals and gaskets, universal and constant
velocity joints.
(2) Your vehicle’s safety belts and air bag Supplemental Restraint System
(SRS) are covered for an extended Safety Restraint Coverage Period,
which lasts for five years or 60,000 miles, whichever occurs first.
(3) Your vehicle’s body sheet metal panels are covered for an extended
Corrosion Coverage Period, which lasts for five years, regardless of miles
driven. The extended warranty coverage only applies if a body sheet
metal panel becomes perforated due to corrosion during normal use due
to a manufacturing defect in factory-supplied materials or factory
workmanship. If aluminum body panels have corrosion or rust damage,
and the damage is not the result of abnormal usage, vehicle accident,
customer actions and/or extreme environmental conditions, the corrosion
or rust damage repairs are covered for 5 years, unlimited miles. For
damage caused by airborne material (environmental fallout) where there
is no factory-related defect involved and therefore no warranty our
policy is to provide free repair of paint damage due to the airborne
material for 12 months or 12,000 miles, whichever occurs first.
(4) Your vehicle’s direct injection diesel engine and certain engine
components are covered during the PowerStroke Diesel Engine Coverage
Period, which lasts for five years or 100,000 miles, whichever occurs
first. The following parts are covered during this extended coverage
period: the engine, cylinder block, heads and all internal parts, intake
and exhaust manifolds, timing gear, harmonic balancer, valve covers, oil
pan and pump, water pump, fuel system (excluding fuel lines, fuel tank
and frame mounted fuel conditioning module sometimes referred to as
the frame mounted pump/filter/water separator or frame mounted fuel
filter/water separator), high pressure lines, gaskets and seals, glow plugs,
turbocharger, two-stage turbocharger assembly, turbocharger actuator,
11
Page 17 of 41
powertrain control module, high pressure fuel injection pump assembly,
injectors, injection pressure sensor, fuel rail pressure sensor, exhaust
back pressure regulator and sensor, exhaust pressure sensor, manifold
pressure sensor, intake air temperature sensor, crankshaft position
sensor, camshaft position sensor, accelerator switch.
NOTE:Some components may also be covered by the Emissions
Warranties. For more information, see pages 17-31.
If you own or lease a 2018-model Next Generation Police Interceptor
Vehicle (NGPI), refer to the Warranty Addendum Card that was given to
you when you took delivery of your vehicle for further explanation of
Amendments to the New Vehicle Limited Warranty. The Warranty
Addendum applies only the NGPI vehicles delivered in the State of Florida
and New York.
WHAT IS NOT COVERED UNDER THE NEW VEHICLE LIMITED
WARRANTY?
Damage Caused By:
• accidents, collision or objects striking the vehicle (including driving
through a car wash)
• theft, vandalism, or riot
• fire or explosion
• using contaminated or improper fuel/fluids
• customer-applied chemicals or accidental spills
• driving through water deep enough to cause water to be ingested into
the engine
• misuse of the vehicle, such a driving over curbs, overloading, racing or
using the vehicle as a permanent stationary power source
Damage Caused by Alteration or Modification
The New Vehicle Limited Warranty does not cover any damage caused by:
•alterations or modifications of the vehicle, including the body, chassis,
electronics or their components, after the vehicle leaves the control of
Ford Motor Company
• tampering with the vehicle, tampering with the emissions systems or
with the other parts that affect these systems (for example, but not
limited to exhaust and intake systems)
12
Page 25 of 41
WHAT IS COVERED?
For your vehicle if these parts contain an emissions-related defect, they
are covered by both the Emissions Defect Warranty and the Emissions
Performance Warranty.
•Air Flow Sensor
• Air/Fuel Feedback Control
System and Sensors
• Air Induction System
• Catalytic Converters (including
Selective Catalytic Reduction
and Diesel Oxidation Catalysts)
• Cold Start Enrichment System
(diesel only)
• Controls for Deceleration
(diesel only)
• Diesel Exhaust Fluid System
• Diesel Particulate Filter
• Electronic Ignition System
(diesel only)
• Electronic Engine Control
Sensors and Switches
• Powertrain Control Module
(PCM)/Engine Control Module
(ECM)*
• Evaporative Emission Control
System
• Exhaust Gas Recirculation
(EGR) System
• Exhaust Manifold
• Exhaust Pipe
(Manifold to Catalyst)
• Fuel Filler Tube and Seal
(non-diesel only) •
Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank (non-diesel only)
• Fuel Tank Pressure Control
Valve
• Heating Elements of Side
Mirrors and Back Windows
(3.0L Diesel F-150 only)
• Ignition Coil and/or Control
Module
• Intake Manifold
• Intercooler Assembly -
Engine Charger
• Malfunction Indicator Lamp
(MIL)/On-Board Diagnostic
(OBD) System
• PCV system and Oil Filler Cap
• Secondary Air Injection System
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Control Module
(TCM) and Solenoids
• Turbocharger Assembly
• Vacuum Distribution System
* Includes hardware and emissions related software changes only
20
Page 31 of 41
WHAT IS COVERED?
If the parts on the following list contains a defect that affects emissions,
they are covered by the Defects Warranties.
•Air Flow Sensor
• Air/Fuel Feedback Control
System and Sensors
• Air Induction System
• Catalytic Converters (including
Selective Catalytic Reduction
and Diesel Oxidation Catalysts)
• Cold Start Enrichment System
(diesel only)
• Controls for Deceleration
(diesel only)
• Diesel Exhaust Fluid System
• Diesel Particulate Filter
• Electronic Ignition System
(diesel only)
• Electronic Engine Control
Sensors and Switches
• Powertrain Control Module
(PCM)/Engine Control Module
(ECM)*
• Evaporative Emission Control
System
• Exhaust Gas Recirculation
(EGR) System
• Exhaust Manifold
• Exhaust Pipe (Manifold to
Catalyst)
• Fuel Filler Tube and Seal
(non-diesel only) •
Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank (non-diesel only)
• Fuel Tank Pressure Control
Valve
• Heating Elements of Side
Mirrors and Back Windows
(3.0L Diesel F-150 only)
• Ignition Coil and/or Control
Module
• Intake Manifold
• Intercooler Assembly - Engine
Charger
• Malfunction Indicator Lamp
(MIL)/On-Board Diagnostic
(OBD) System
• PCV System and Oil Filler Cap
• Secondary Air Injection System
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Control Module
(TCM) and Solenoids
• Turbocharger Assembly
• Vacuum Distribution System
* Includes hardware and emissions related software changes only
26
Page 33 of 41
COVERAGE FOR 2018 MODEL VEHICLES (GVWR OF 14,000 LBS. OR LESS) UNDER LONG TERM DEFECTS WARRANTY(Coverage for up to 7 years/70,000 miles, whichever first occurs)
Part Name
1.0L Fiesta
1.0L Focus
1.0L Ecosport
1.5 Fusion
1.5L Escape
1.6L Fiesta
2.0L Fusion
2.0L Focus
2.0L Ecosport
2.0L Taurus
2.0L Escape
2.0L Edge
2.3L Focus
2.3L Mustang
2.3L Explorer
2.5L Fusion
2.5L Escape
2.5L Transit Connect
2.7L Fusion
2.7L Edge
2.7L F-150
3.0L F-150 Diesel
3.2L Transit Diesel
3.3L F-150
3.5L Taurus
3.5L Edge
3.5L Flex
3.5L Explorer
3.5L Expedition
3.5L F-150
3.5L Transit
3.7L Taurus
3.7L Explorer
3.7L Transit
5.0L Mustang
5.0L F-150
5.2L Mustang
6.2L Econoline
6.2L F-Superduty
6.7L F-Superduty Diesel
6.8L Econoline
6.8L F-Superduty
6.8L Strip Chassis
EGR Cooler Bypass Control Solenoid XX X X X X X X X X
EGR Valve, EGR System Module XX
EGR Valve Gasket, EGR inlet tube to joint XX
Turbo Charger Actuator X
Exhaust Adapter XXX
Fuel Injector Kit X
High Pressure Fuel Injector Pump XXX
Engine Air Shutoff Control Assembly X
Fuel Injector Manifold Return Line XXX
Fuel Injector XXX XX
Injection Pressure Sensor XXXXXX XX
Air Intake Throttle Body XX X XXX
Fuel Injector Wiring Harness XXXX
Instrument Cluster (1) X X X X X X XXXXXX XXXXX XX XXX XX XX XXX XX X
Glow Plug XX
Powertrain Control Wiring Harness (2) X X X X X XXX X X X XX X X X X X X
Engine Control Sensor & Fuel Charge Wrng Assy (2) X
Engine Electronic Control Coolant Sensor XXX
Powertrain Control Module (PCM)/
Engine Control Module (ECM) XXXXXXXX XXXXXX XXXXXXXXXX XX XXXXXXXXXXXXXXX
Engine Control Sensor Ext. Wire Assembly (2) XXX
Knock Sensor XXX
Main Body Wiring Harness (2) X X X X X X X X X X X XXXX XX XXX XX XX XXX XX X
Dash Panel & Headlamp Junction Wiring Assembly (2) X X X X X X X X X X X XX X X X X X
Battery Cable (2) X XX X X
Wiring Assembly - Interior (2) XX X X X XX XX
Roof Wiring Harness (2) X
Main Wiring Assembly (2) XXXXXXXX XXXXXXXXXXXXXXXXX XXX XXXXXXXXXXXXXXX
Rear Lamp Wiring Assembly (2) XX XXXX XXXXXX
Fuel Sender Wiring Assembly (2) X XXXXXXXXX X XX X X XXXXX
Jumper Harness (2) XXX
Heating Elements of Back Window Glass Assembly X
(1) for Service Engine Soon/Malfunction Indicator Lamp (MIL) functionality concerns only
(2) for MIL illumination only
(3) for EcoBoost Engine only
28