ignition FORD ESCORT 1996 7.G Owner's Guide

234with your anti-lock brake system, you may not
have total control of your vehicle when braking
on roads with loose surfaces such as snow or
gravel, holes in the pavement, or alternating
patches of slippery and dry surfaces.
[DR17350(ALL)04/94]
Each time you turn the ignition key to the ON
position, the anti-lock brake system will function
through one test cycle. When this happens, the
anti-lock light (ABS) will come on for up to six
seconds. If the light stays on longer than six
seconds, shut off the engine and restart. If it
remains on, it means the anti-lock brake system
is disabled and should be serviced immediately
to restore the benefits of the anti-lock feature.
Normal braking is not affected unless the red
brake warning light is also lit.
[DR17400(ALL)02/94]
The anti-lock brake system has self-check
capabilities. As described above, the system
turns on the anti-lock light each time you start
your engine. After the engine is started and the
anti-lock light turns off, the system performs
another test the first time the vehicle reaches
7 mph (11 km/h). The system turns on the ABS
pump motor for approximately 1/2 second. At
this time, a mechanical noise may be heard. This
is a normal part of the self-check feature. If a
malfunction is found during this check the
anti-lock light will come on.
*
[DR17500(ALL)08/95]
Ford Motor Company has not found any
negative effects of mobile radio transmitting
equipment installed on vehicles with the ABS
system providing that the radio is installed
according to the radio manufacturer's
instructions. However, if you have had a mobile
radio transmitter installed and the ABS light
comes on (at any time other than immediately
File:10ctdre.ex
Update:Tue Sep 19 14:53:34 1995

244
*
[RE00710(ALL)07/95]
If the acid touches someone's skin, eyes, or
clothing, immediately flush the area with water
for at least 15 minutes. If someone swallows the
acid, have him or her drink lots of milk or water
first, then Milk of Magnesia, a beaten egg, or
vegetable oil. Call a doctor immediately.
*
[RE00900(ALL)05/95]
RWARNING
To avoid damage or injury, follow these
directions in the order they are given. If
in doubt, call for road service.
*
[RE01000(ALL)03/95]
Preparing Your Vehicle
*
[RE01100(ALL)03/95]
1. Your vehicle has a 12-volt starting system, so
you need to use a 12-volt jumper system.
You will damage your starting motor,
ignition system, and other electrical parts if
you connect them to a 24-volt power supply
(either two 12-volt batteries in series or a
24-volt generator set).
*
[RE01200(ALL)03/95]
2. Do not disconnect the battery of the disabled
vehicle. You could damage the vehicle's
electrical system.
*
[RE01300(ALL)04/95]
3. Park the booster vehicle close to the hood of
the disabled vehicle.Make sure the vehicles
do not touch each other.Set the parking
brake on both vehicles and stay clear of the
engine cooling fan and other moving parts.
*
[RE01400(ALL)03/95]
4. Check all battery terminals and remove any
excessive corrosion before you attach the
jumper cables.
*
[RE01600(ALL)02/95]
5. Turn on the heater fan in both vehicles.
Turning on the fan helps protect the
electrical system from voltage surges. Turn
off all other switches and lights in both
vehicles to prevent possible damage to either
vehicle's electrical systems.
File:12ctree.ex
Update:Tue Sep 19 14:55:16 1995

249
%*
[RE04500(ALL)03/95]
Changing a Tire
*
[RE04600(ALL)01/95]
If you get a flat tire while you are driving, do
not apply the brake heavily. Instead, gradually
decrease the speed. Hold the steering wheel
firmly and slowly move to a safe place on the
side of the road. Park on a level spot, turn off
the ignition, set the parking brake, and turn on
the hazard flashers.
%*
[RE04700(ALL)03/95]
The Temporary Spare Tire
*
[RE04800(ALL)03/95]
You may have a high pressure temporary spare
tire. This spare tire is smaller than a regular tire
and is designed for emergency use only. Use it
only when you get a flat tire and replace it as
soon as you can. This spare tire is marked with
the words ªTEMPORARY USE ONLYº so that
you can easily identify it.
*
[RE04900(ALL)01/93]
RWARNING
If you use the temporary spare tire
continuously or do not follow these
precautions, the tire could fail, causing
you to lose control of the vehicle, possibly
injuring yourself or others.
*
[RE05000(ALL)01/95]
When you drive with the temporary spare tire,
DO NOT:
*
[RE05100(ALL)01/95]
q
exceed 50 mph (80 km/h) under any
circumstances.
*
[RE05200(ALL)01/95]
q
load your vehicle so that it is heavier than
the maximum vehicle load rating listed on
the tire decal.
*
[RE05400(ALL)01/95]
q
use tire chains on this tire.
File:12ctree.ex
Update:Tue Sep 19 14:55:16 1995

281
*
[SV01900(ALL)06/95]
q
If you must work with the engine running,
avoid wearing loose clothing or jewelry that
could get caught in moving parts. Take
appropriate precautions with long hair.
*
[SV02000(ALL)06/95]
q
Do not work on a vehicle in an enclosed
space with the engine running, unless you are
sure you have enough ventilation.
*
[SV02100(ALL)08/95]
q
Never get under a vehicle while it is
supported only by a jack. If you must work
under a vehicle, use safety stands.
*
[SV02200(ALL)06/95]
q
Keep all lit cigarettes and other smoking
materials away from the battery and all
fuel-related parts.
[SV02250(ALL)03/95]
If you disconnect the battery, the engine must
ªrelearnº its idle conditions before your vehicle
will drive properly. To find out how the engine
does this, seeStarting your vehicle's fuel-injected
enginein the Index.
*
[SV02525(ALL)03/95]
Working with the engine off:
[SV02550(ALL)03/95]
1. Set the parking brake fully and make sure
that the gearshift is securely latched in Park
(automatic transaxle) or First (manual
transaxle).
*
[SV02650(ALL)06/95]
2. Remove the key from the ignition after you
turn the engine off.
*
[SV02675(ALL)06/95]
3. Block the wheels. This will prevent your
vehicle from moving unexpectedly.
File:15ctsve.ex
Update:Tue Sep 19 14:37:50 1995

287 %
*
[SV05840(ALL)04/95]
Cleaning the Engine
*
[SV05850(ALL)04/95]
A clean engine is more efficient because a
buildup of grease and dirt acts as an insulator,
keeping the engine warmer than normal.
*
[SV05860(ALL)07/95]
q
Extreme care must be used if a power washer
is used to clean the engine. The high pressure
fluid could penetrate sealed parts and
assemblies causing damage or malfunctions.
*
[SV05870(ALL)08/95]
q
In order to avoid possible cracking of the
engine block or fuel injection pump, do not
spray a hot engine or injection pump with
cold water.
*
[SV05880(ALL)07/95]
q
The alternator, distributor and air intake must
be covered. Covering these components will
help prevent water damage.
*
[SV05890(ALL)04/95]
q
Never wash or rinse the engine while it is
running. Water getting into the engine may
cause internal damage.
%
*
[SV06100(ALL)03/95]
Filling the Fuel Tank
[SV06110(ALL)01/92]
The fuel filler door can be opened by pulling on
the finger hold located on the rear edge of the
fuel filler door.
[SV06235(ALL)07/93]
For your convenience, a fuel filler door location
indicator is included in your instrument cluster.
It indicates which side of your vehicle contains
the fuel filler door.
[SV06275(ALL)08/95]
The fuel filler door is outside the vehicle on the
driver side near the back.
[SV06300(ALL)03/95]
1. Turn the ignition switch to the OFF position
and remove the key. To remove the fuel cap,
turn it counterclockwise.
File:15ctsve.ex
Update:Tue Sep 19 14:37:50 1995

303
*
[SV23400(ALL)09/95]
If the blades do not wipe properly, clean both
the windshield and the wiper blades. Use
undiluted windshield washer solution or a mild
detergent. Rinse thoroughly with clear water. Do
not use fuel, kerosene, paint thinner, or other
solvents to clean your wiper blades. These will
damage your blades.
[SV23450(ALL)07/93]
Inspect the wiper arm pivots on a regular basis
to ensure that the wiper arms move freely.
Lubricate the pivot points if necessary.
[SV23475(ALL)08/93]
half page art:0070198-A
Wiper arm pivot points
[SV23500(ALL)03/95]
To make reaching the wiper blades easy, simply
turn the ignition switch to the ON position and
turn the wipers on. Wait for them to reach a
vertical position and turn the ignition to OFF.
Do not move the wipers manually. Manually
moving the wipers across the windshield may
damage them.
File:15ctsve.ex
Update:Tue Sep 19 14:37:50 1995

341
*
[SV41300(ALL)05/95]
To make sure that the catalytic converter and the
other emission control parts continue to work
properly:
*
[SV41400(ALL)01/95]
q
Use only unleaded fuel.
*
[SV41500(ALL)01/95]
q
Avoid running out of fuel.
*
[SV41600(ALL)01/95]
q
Do not turn off the ignition while your
vehicle is moving, especially at high speeds.
*
[SV41700(ALL)03/95]
q
Have the services listed in theMaintenance
Schedule and Recordbooklet performed
according to the specified schedule. The
scheduled maintenance services are required
because they are considered essential to the
life and performance of your vehicle and to
its emissions system.
*
[SV41720(ALL)03/95]
In general, maintenance, replacement, or service
of the emissions control devices or systems in
your new Ford Motor Company vehicle or
engine may be performed at your expense by
any automotive repair establishment or
individual using automotive parts equivalent to
those which your vehicle or engine was
originally equipped.
*
[SV41750(ALL)05/95]
If other than Ford or Motorcraft or Ford
authorized remanufactured parts are used for
maintenance, replacement, or for the service of
components affecting emissions control, the
owner should be assured that such parts are
warranted by their manufacturer to be
equivalent to genuine Ford Motor Company
parts in performance and durability. Please
consult your warranty information booklet for
complete warranty information.
File:15ctsve.ex
Update:Tue Sep 19 14:37:50 1995

Index 371
Index
A
ABS warning light
(see Anti-lock brake system)...... 127
Accessory position on the ignition.... 106
Additives, engine oil.......... 294
Air bag Supplemental
Restraint System
and child safety seats.......... 52
description............... 50
disposal................ 57
driver air bag............. 50
indicator light............ 123
operation............... 53
passenger air bag............ 50
proper seating............. 51
service and information labels...... 57
tone generator............. 56
wearing safety belts........... 50
Air cleaner filter
location............... 285
specifications............. 347
Antenna, radio
(see Electronic sound system) . . . 157, 220
Antifreeze (see Engine coolant)...... 297
Anti-lock brake system (ABS)
description.............. 233
warning light............. 127
Anti-theft lug nuts and key....... 255
Assistance (see Customer assistance) . . . 259
Audio system
(see Electronic sound system)..... 197
Autolamp system (see Headlamps).... 152
File:ctixe.ex
Update:Tue Sep 19 15:00:54 1995

Index 379
GVWR (Gross Vehicle Weight Rating)
(continued)
location............... 240
H
Hazard flashers............. 162
Headlamps
aiming................ 333
checking alignment.......... 333
cleaning............... 153
daytime running lights........ 152
replacing bulbs............ 333
turning on and off.......... 151
Head restraints............. 177
High beams
indicator light............ 122
operation.............. 151
Hood
latch location............. 282
lubrication specifications........ 348
release lever............. 282
working under the hood....... 280
Horn.................. 163
Hoses, checking............. 301
I
Identification Number, Vehicle (VIN) . . . 267
Idle, relearning...........248, 280
Ignition
positions of the ignition........ 105
removing the key........... 107
Indicator lights and chimes (see Lights) . . 119
Infant seats (see Safety seats)........ 58
Instrument cluster............ 117
Instrument panel
cleaning............... 158
lighting up panel and interior..... 153
location of components........ 135
File:ctixe.ex
Update:Tue Sep 19 15:00:54 1995

380 Index
J
Jack
operation............... 251
positioning.............. 251
storage................ 250
Jump-starting your vehicle
attaching cables............ 243
disconnecting cables.......... 248
K
Keys
positions of the ignition........ 105
removing from the ignition...... 107
stuck in lock position.......105, 107
L
Lamps
checking............... 333
daytime running light system..... 152
dome lamps............. 154
hazard flashers............ 162
headlamps.............. 151
instrument panel, dimming...... 153
interior lamps............. 153
replacing bulbs............ 333
Lane change indicator (see Turn signal) . . 159
Lights, warning and indicator
airbag................ 123
anti-lock brakes (ABS)......... 127
charging system............ 121
check engine............. 124
engine oil pressure.......... 128
hazard warning light......... 162
high beam.............. 122
turn signal indicator........127, 159
Load limits
GAWR................ 240
GVWR................ 240
trailer towing............. 241
File:ctixe.ex
Update:Tue Sep 19 15:00:54 1995