Electrical FORD ESCORT 1996 7.G Owners Manual

18 [SR05600(ALL)05/95]
RWARNING
The vehicle should not be driven unless
the doors are fully closed and the
shoulder belts are in the locked position.
[SR05700(ALL)10/89]
3. Unbuckle the shoulder belt by pressing the
red emergency release button on the buckle.
Then, reinsert the shoulder belt tongue into
the buckle until you hear a snap and feel the
latch engage.
[SR05800(ALL)02/95]
4. Turn the key to the ON position.
[SR05900(ALL)10/89]
5. If the shoulder belt doesn't move across you,
turn the ignition switch to the LOCK
position and then release the shoulder belt
from the buckle.
[SR06000(ALL)10/89]
6. Remove the access cap located in the lower
portion of the trim panel, rearward of the
front door opening.
[SR06100(ALL)12/89]
7. Pull the electrical wiring harness out through
the access hole and disconnect the connector.
The electrical wiring harness is located near
the internal hex nut. To disconnect the
connector, pull the left and right sides apart.
You may have to loosen the tape to
disconnect the electrical connector.
[SR06200(ALL)10/91]
8. Then, insert the emergency handle into the
hex nut inside the access hole. The
emergency handle is stored in the owner
portfolio in the glove compartment.
File:03ctsre.ex
Update:Tue Sep 19 15:05:35 1995

53
*
[SR13009(ALL)07/95]
RWARNING
Do not place objects or mount equipment
on or near the air bag cover on the
steering wheel or in front seat areas that
may come in contact with a deploying air
bag. Failure to follow this instruction may
increase the risk of personal injury in the
event of a collision.
%*
[SR13010(ALL)01/95]
How the Air Bag Supplemental Restraint
System Operates
*
[SR13020(ALL)09/95]
The Air Bag Supplemental Restraint System
consists of the Driver and Passenger air bags,
impact sensors, a system diagnostic module, a
readiness light and tone, and the electrical
wiring which connects the components. The
diagnostic module monitors its own internal
circuits and the supplemental air bag electrical
system readiness, including crash sensors, the
system wiring, the air bag readiness light, air
bag backup power, and the supplemental air bag
ignitors.
*
[SR13030(ALL)08/95]
The driver air bag is in the center of the steering
wheel. The front passenger seat air bag is
located in the center section of the instrument
panel ledge above the glove compartment. Both
air bags are designed to stay out of sight until
they are activated.
File:03ctsre.ex
Update:Tue Sep 19 15:05:35 1995

56 [SR13045(ALL)09/95]
half page art:0011064-AInflated passenger side air bag
*
[SR13047(ALL)07/95]
RWARNING
If the air bag is inflated, THE AIR BAG
WILL NOT FUNCTION AGAIN AND
MUST BE REPLACED IMMEDIATELY. If
the air bag is not replaced, the unrepaired
area will increase the risk of injury in a
collision.
*
[SR13048(ALL)07/95]
To ensure that the air bag system will operate as
intended in a crash, the system is equipped with
a diagnostic module, which controls a readiness
lamp and a warning tone. The diagnostic
module monitors its own circuits, the air bag
electrical system, the air bag readiness light, the
air bag power, and the air bag inflators.
*
[SR13049(ALL)06/95]
The air bag system uses a readiness light on the
instrument cluster or a tone to indicate the
condition of the system. When you turn the
ignition to the ON position, this light will
File:03ctsre.ex
Update:Tue Sep 19 15:05:35 1995

106 [ST03615(ALL)08/95]The automatic transaxle console-mounted
gearshift will lock only when you turn the key
to LOCK. When the gearshift is in any gear
position but P (Park), the ignition key cannot be
turned to LOCK or be removed from the
steering column.
[ST03620(ALL)02/95]
If you have a manual transaxle, you must push
the key in while turning to the LOCK position
in order to remove the key.
*
[ST03625(ALL)01/95]
LOCK is the only position that allows you to
remove the key. The LOCK feature helps to
protect your vehicle from theft.
[ST03635(ALL)09/95]
OFF (if equipped) allows you to shut off the
engine and all accessories without locking the
steering wheel.
*
[ST03650(ALL)07/95]
ACC (accessory) allows some of your vehicle's
electrical accessories such as the radio and the
windshield wipers to operate while the engine is
not running.
[ST03850(ALL)02/95]
ON allows you to test your vehicle's warning
lights (except the brake system warning light) to
make sure they work before you start the
engine. (The brake system warning light will
remain lit if the parking brake is set or if there
is a problem with the brake system.) The key
returns to the ON position once the engine is
started and remains in this position while the
engine runs.
[ST03900(ALL)02/95]
START cranks the engine. Release the key once
the engine starts so that you do not damage the
starter. The key should return to ON when you
release it. The START position also allows you
to test the brake system warning light.
File:04ctste.ex
Update:Tue Sep 19 14:42:54 1995

112
*
[ST10300(ALL)05/95]
RWARNING
Extended idling at high engine speeds can
produce very high temperatures in the
engine and exhaust system, creating the
risk of fire or other damage.
*
[ST10350(ALL)05/95]
RWARNING
Do not park, idle, or drive your vehicle in
dry grass or other dry ground cover. The
emission system heats up the engine
compartment and exhaust system, which
can start a fire.
%*
[ST10550(ALL)06/95]
Using the Engine Block Heater
(If equipped)
*
[ST10700(ALL)03/95]
Engine block heaters are strongly recommended
if you live in a region where temperatures reach
S20ÊF (S29ÊC) orbelow consistently during the
winter months. An engine block heater warms
the engine coolant, which improves starting,
warms up the engine faster, and allows the
heater-defrost system to respond quickly.
*
[ST10900(ALL)02/95]
To turn the heater on, simply plug it into a
grounded 110-volt outlet. Ford recommends that
you use a 110-volt circuit that is protected by a
ground fault circuit interrupter.
*
[ST11100(ALL)05/95]
RWARNING
To prevent electrical shock, do not use
your heater with ungrounded electrical
systems or two-pronged (cheater) adapters.
File:04ctste.ex
Update:Tue Sep 19 14:42:54 1995

121 [LG03550(ALL)08/95]
one inch art:0000837-A
The brake system and parking brake light
*
[LG03600(ALL)05/95]
RWARNING
The BRAKE light indicates that the brakes
may not be working properly. Have the
brakes checked immediately.
%*
[LG03800(ALL)01/95]
Charging System Light
*
[LG03900(ALL)03/95]
This light indicates that your battery is not being
charged and that you need to have the electrical
system checked.
*
[LG04300(ALL)07/95]
This light comes on every time you turn the
ignition to the ON or START position (engine
off). The light should go off when the engine
starts and the alternator begins to charge.
*
[LG04400(ALL)01/95]
If the light stays on or comes on when the
engine is running, have the electrical system
checked as soon as possible.
[LG04500(ALL)12/89]
one inch art:0000838-A
The charging system light
File:05ctlge.ex
Update:Tue Sep 19 14:44:43 1995

137
*
[IP00450(ALL)03/95]
If you have radio transmitting equipment in
your vehicle, be aware that it can interfere with
your vehicle's electrical system and may cause
the instrumentation and/or convenience
products to have temporary, abnormal operation.
%*
[IP00475(ALL)06/95]
NOTE: Any cleaner or polish that increases the
gloss (shine) of the upper part of the
instrument panel should be avoided.
The dull finish in this area is to help
protect the driver from undesirable
windshield reflection.
%
*
[IP00500(ALL)06/95]
The Climate Control Systems
*
[IP00510(ALL)06/95]
Your vehicle has one of the following climate
control systems:
[IP00520(ALL)08/95]
q
Heating Only System
[IP00530(ALL)08/95]
q
Heating and Air Conditioning System
*
[IP00540(ALL)06/95]
If you are not sure which system your vehicle
has, see the diagrams on the following pages.
[IP00550(ALL)08/95]
The Controls
[IP00560(ALL)08/95]
The fan speed knob controls the volume of air
circulated in the vehicle. There are four fan
settings numbered 1 (low) through 4 (high) and
on OFF position.
[IP00570(ALL)08/95]
Pushing the A/C button (in the center of the fan
speed knob) turns on the air conditioning
system, if equipped. The fan must be on for the
air conditioning compressor to operate. The
indicator light, to the left of the fan speed knob,
will glow when the A/C system is on.
[IP00580(ALL)08/95]
The temperature control lever may be adjusted
from cool air in the blue range to warm air in
the red range.
File:06ctipe.ex
Update:Tue Sep 19 14:46:28 1995

225 [DR05020(ALL)07/93]
Your vehicle has a special shift-lock safety
feature which prevents you from shifting out of
P (Park) without the brake pedal depressed. To
shift the transaxle out of the P (Park) position,
the ignition must be in the ON position, the
battery must be supplying electrical power, and
your foot must be pressing on the brake pedal.
[DR05030(ALL)01/92]
In the unlikely event that you cannot move the
selector lever from the P (Park) position with the
brake pedal depressed, continue depressing the
brake. Then:
*
[DR05035(ALL)06/95]
1. Remove the shift-lock override cap with a 1ª
or longer screwdriver.
[DR05038(ALL)02/94]
half page art:0070192-B
Shift-lock override
*
[DR05040(ALL)03/93]
2. Insert the screwdriver into the shift-lock
override opening and push the screwdriver
handle down.
File:10ctdre.ex
Update:Tue Sep 19 14:53:34 1995

243
Roadside Emergencies
%*
[RE00380(ALL)03/95]
Jump-Starting Your Vehicle
[RE00390(ALL)01/92]
Your vehicle's battery may die if you leave the
lights or any electrical equipment on after you
turn the engine off. If this happens, you may be
able to jump-start from a booster battery to start
your vehicle.
*
[RE00400(ALL)02/95]
RWARNING
The gases around the battery can explode
if exposed to flames, sparks, or lit
cigarettes. An explosion could result in
injury or vehicle damage.
*
[RE00500(ALL)02/95]
RWARNING
To protect yourself when charging a
battery, always shield your face and eyes.
Make sure that you can breathe fresh air.
%*
[RE00600(ALL)06/95]
RWARNING
Applying too much pressure on the ends
when lifting a battery could cause acid to
spill. Lift the battery with a carrier or
with your hands on the opposite corners.
%*
[RE00700(ALL)07/95]
RWARNING
Batteries contain sulfuric acid which burns
skin, eyes, and clothing.
File:12ctree.ex
Update:Tue Sep 19 14:55:16 1995

244
*
[RE00710(ALL)07/95]
If the acid touches someone's skin, eyes, or
clothing, immediately flush the area with water
for at least 15 minutes. If someone swallows the
acid, have him or her drink lots of milk or water
first, then Milk of Magnesia, a beaten egg, or
vegetable oil. Call a doctor immediately.
*
[RE00900(ALL)05/95]
RWARNING
To avoid damage or injury, follow these
directions in the order they are given. If
in doubt, call for road service.
*
[RE01000(ALL)03/95]
Preparing Your Vehicle
*
[RE01100(ALL)03/95]
1. Your vehicle has a 12-volt starting system, so
you need to use a 12-volt jumper system.
You will damage your starting motor,
ignition system, and other electrical parts if
you connect them to a 24-volt power supply
(either two 12-volt batteries in series or a
24-volt generator set).
*
[RE01200(ALL)03/95]
2. Do not disconnect the battery of the disabled
vehicle. You could damage the vehicle's
electrical system.
*
[RE01300(ALL)04/95]
3. Park the booster vehicle close to the hood of
the disabled vehicle.Make sure the vehicles
do not touch each other.Set the parking
brake on both vehicles and stay clear of the
engine cooling fan and other moving parts.
*
[RE01400(ALL)03/95]
4. Check all battery terminals and remove any
excessive corrosion before you attach the
jumper cables.
*
[RE01600(ALL)02/95]
5. Turn on the heater fan in both vehicles.
Turning on the fan helps protect the
electrical system from voltage surges. Turn
off all other switches and lights in both
vehicles to prevent possible damage to either
vehicle's electrical systems.
File:12ctree.ex
Update:Tue Sep 19 14:55:16 1995